IllustrationBRAKING ISSUE; ABS LIGHT ON; INTERMITTENT BRAKE FAILURE; FRONT UPPER MOTOR MOUNT AS WELL AS MOTOR MOUNT BY RADIATOR; (FRONT LEFT CV AXLE RECENTLY REPAIRED) BRAKING PROBLEM PERSIST 2005 CHRYSLER PACIFICA JUST TODAY, HAVE A $706.00 REPAIR QUOTE: JUST PAID 207.18 2 DAYS AGO TO REPLACE LEFT FRONT CV AXEL !
2005 Chrysler Pacifica
Owner reports · Recalls · Investigations
More warning signs than most Pacifica years
Owner complaints for the 2005 Chrysler Pacifica are substantially higher than the model-year median of 189.
About this comparison →How this year compares
Owner complaints by model year
Compare all Pacifica years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1420–25K
10425–50K
12450–75K
16575–100K
369100–150K
141150K+
1,045 reports with mileage · 199 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 413 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 224 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 211 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
25 crash reports13 fire reports17 injury reports
Service Brakes complaints
22 reportsSINCE I PURCHASED THIS IN 2008, I HAVE REPLACED THE AXLE, 2 WHEEL BEARINGS A FEW MONTHS AGO, A FEW YEARS AGO 1 ABS SENSOR WAS REPLACED VIA WARRANTY BUT THEY WOULDN'T REPLACE THE OTHER - WHICH WENT OUT 2 MONTHS LATER. THEY KNEW IT WAS GOING TO. I REPLACED THE TRANSMISSION 2 YEARS, THE FUEL PUMP & CATALYTIC CONVERTER LAST YEAR, …
Read full complaint
SINCE I PURCHASED THIS IN 2008, I HAVE REPLACED THE AXLE, 2 WHEEL BEARINGS A FEW MONTHS AGO, A FEW YEARS AGO 1 ABS SENSOR WAS REPLACED VIA WARRANTY BUT THEY WOULDN'T REPLACE THE OTHER - WHICH WENT OUT 2 MONTHS LATER. THEY KNEW IT WAS GOING TO. I REPLACED THE TRANSMISSION 2 YEARS, THE FUEL PUMP & CATALYTIC CONVERTER LAST YEAR, JUST REPLACED THE OIL PAN GASKET 2 MONTHS AGO, THE RADIATOR 2 WEEKS AGO DUE TO COOLANT LEAD, AND NOW THE WATER PUMP IS LEAKING COOLANT. THIS IS JUST WHAT I CAN THINK OF OFF THE TOP OF MY HEAD. IT HAS BEEN ONE PROBLEM AFTER THE OTHER WITH THIS VEHICLE AND I HAVE SPENT A FORTUNE ON IT. I CAN'T AFFORD TO REPLACE IT & MY VIN DOESN'T SHOW UP ON THE RECALLS. *TR
WHEN I DRIVE MY CAR I CAN HEAR MY ENGINE HITTING THE WALLS OF MY CAR. IT IS LOOSE AND ALSO THE BREAKS ABS LIGHT IS ON THROUGHOUT MY DRIVE. IF IT IS NOT ON THAN THE BREAKS SLIDE.
ABS LIGHT CAME ONWHILE TRAVELING IN FLORIDA. CAR MAKES GRINDING SOUND. LIGHT GOES ON AFTER DRIVING AWHILE. DOES NOT BRAKE PROPERLY IF LIGHT COMES ON WHILE COMING TO A STOP. REPLACE ALL BRAKES AND SENSORS AND STILL NO HELP. CHRYSLER KNOWS THEY HAVE A PROBLEM AND IT IS GOING TO TAKE SOMEONE DYING BEFORE THIS GETS FIXED. THERE…
Read full complaint
ABS LIGHT CAME ONWHILE TRAVELING IN FLORIDA. CAR MAKES GRINDING SOUND. LIGHT GOES ON AFTER DRIVING AWHILE. DOES NOT BRAKE PROPERLY IF LIGHT COMES ON WHILE COMING TO A STOP. REPLACE ALL BRAKES AND SENSORS AND STILL NO HELP. CHRYSLER KNOWS THEY HAVE A PROBLEM AND IT IS GOING TO TAKE SOMEONE DYING BEFORE THIS GETS FIXED. THERE HAVE BEEN THOUSANDS OF COMPLAINTS ON THIS AT MUCH LOWER MILEAGES THAN MY CAR. PLEASE DO SOMETHING. EITHER CHRYLER KNOWS WHAT THE FIX IS AND DOES NOT CARE OR AT THIS POINT THEY REALLY DO NOT KNOW WHAT TO DO AND WILL NOT TAKE RESPONSIBILITY.
I WAS DRIVING AT LOWER SPEEDS, APPROACHING A STOP SIGN; DRIVING DOWN A HILLY ROAD IN DOWNTOWN NASHVILLE, TN. MY ABS LIGHT SUDDENLY CAME ON AS I PRESSED THE BRAKE IT TEMPORARY MADE A GRINDING NOISE AND BRAKES TEMPORARY FAILED THEN AS SUDDENLY AS IT HAPPENED THE BRAKES STOPPED GRINDING AND THEN STOPPED. THIS IS A BRAKING ISSUE TH…
Read full complaint
I WAS DRIVING AT LOWER SPEEDS, APPROACHING A STOP SIGN; DRIVING DOWN A HILLY ROAD IN DOWNTOWN NASHVILLE, TN. MY ABS LIGHT SUDDENLY CAME ON AS I PRESSED THE BRAKE IT TEMPORARY MADE A GRINDING NOISE AND BRAKES TEMPORARY FAILED THEN AS SUDDENLY AS IT HAPPENED THE BRAKES STOPPED GRINDING AND THEN STOPPED. THIS IS A BRAKING ISSUE THAT CAME HAPPEN SUDDENLY WITH NO SIGN OR WARNING BEFORE IT HAPPENED!!!!!!!! THE ABS BRAKE SENSORS OR SOME MYSTERIOUS OTHER ABS RELATED ISSUE THAT IS STOMPING MECHANICS.I TOOK MY VEHICLE IN THE NEXT DAY AND HAD BRAKES REPLACED BUT THE PROBLEM CONTINUES. MY BRAKES WORK FINE BUT AT TIMES I WOULD GET THE ABS LIGHT SIGNAL COMING ON THEN LIKE A SCRUBBING NOISE SEEM TO BE COMING FROM THE FRONT WHEELS WELL BRAKES CAUSING DIFFICULTY IN STOPPING. BUT NOT AT ALL TIMES. SOMETIMES THIS HAPPENS WITH NO ABS LIGHT COMING ON! AND THIS USUALLY HAPPENS AT LOWER SPEEDS 30 AND UNDER EVEN AT 15-20 MPH WHEN I AM BREAKING FOR A RED LIGHT OR STOP SIGN. I SAW ON SITES WHERE THOUSANDS OF PEOPLE HARE HAVING THE SAME PROBLEM AND WERE TOLD BY DEALERSHIPS AND MECHANICS THAT EVEN AFTER THOSE ARE REPLACED THE PROBLEM CONTINUES, NO ONE SEEMS TO BE ABLE TO FIND OUT WHAT THE REAL PROBLEM IS AND CHRYSLER WON'T EVEN TRY TO FIX MY VEHICLE WAS WORKING FINE THE ALL OF A SUDDEN, THE ISSUE. I THINK THIS IS A DANGEROUS SITUATION.I THINK THERE SHOULD BE A RECALL ON THE ABS WHEEL SENSORS AND THE MODULE CONTROL OR WHATEVER THE REAL PROBLEM IS? ONLY CHRYSLER KNOWS BUTR THEY ARE NOT TELLING!!! I THINK IF THEY WON'T ADDRESS THEN THE GOVERNMENT SHOULD MAKE THEM PLEASE INCLUDE THIS INT HE CURRENT RECALL LET'S GET THESE UNSAFE VEHICLES OFF THE ROADWAYS!!! NOW IS A GOOD TIME TO DOIT, WITH THE RECALL OF OTHER LIKE VECHILES FROM CHRYSLER ARE ALREADY IN RECALLN
TL* THE CONTACT OWNS A 2005 CHRYSLER PACIFICA. WHILE DRIVING AT 65 MPH, THE BRAKE PEDAL WAS DEPRESSED BUT THE VEHICLE FAILED TO STOP. THE CONTACT FELT A VIBRATION COMING FROM THE BRAKE PEDAL. THE CONTACT HAD TO SHIFT THE GEAR INTO NEUTRAL IN ORDER TO STOP THE VEHICLE. THE ABS AND ENGINE WARNING LIGHTS ILLUMINATED. IN ADDITION, "…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHRYSLER PACIFICA. WHILE DRIVING AT 65 MPH, THE BRAKE PEDAL WAS DEPRESSED BUT THE VEHICLE FAILED TO STOP. THE CONTACT FELT A VIBRATION COMING FROM THE BRAKE PEDAL. THE CONTACT HAD TO SHIFT THE GEAR INTO NEUTRAL IN ORDER TO STOP THE VEHICLE. THE ABS AND ENGINE WARNING LIGHTS ILLUMINATED. IN ADDITION, "NEW FUEL CAP" WAS DISPLAYED ACROSS THE MESSAGE BOARD. THE VEHICLE WAS TAKEN TO THE DEALER MULTIPLE TIMES AND THE FUEL CAP WAS REPLACED. THE DEALER WAS UNABLE TO DIAGNOSE OR REPAIR THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE ROTORS NEEDED TO BE RESURFACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO THE MECHANIC WHO WAS UNABLE TO DIAGNOSE OR REPAIR THE VEHICLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 80,000.
ABS AND TRACTION LIGHT COMES ON INTERMITTENTLY. *TR
I HAVE HAD MY CAR FROM 2011 TILL CURRENT AND REPLACED THE FRONT AXLES/TIE RODS AT LEAST 3 TO 4 TIMES A YEAR. LAST INCIDENT IT BROKE WHILE PULLING OUT OF DRIVE WAY AND I LOST CONTROL AND ROLLED DOWN A HILL INTO 4 LANES OF TRAFFIC NARROWLY MISSING THE GAS PUMPS AT THE STATION ACROSS THE 4 LANE THANK GOODNESS NO ONE HIT ME WITH MY …
Read full complaint
I HAVE HAD MY CAR FROM 2011 TILL CURRENT AND REPLACED THE FRONT AXLES/TIE RODS AT LEAST 3 TO 4 TIMES A YEAR. LAST INCIDENT IT BROKE WHILE PULLING OUT OF DRIVE WAY AND I LOST CONTROL AND ROLLED DOWN A HILL INTO 4 LANES OF TRAFFIC NARROWLY MISSING THE GAS PUMPS AT THE STATION ACROSS THE 4 LANE THANK GOODNESS NO ONE HIT ME WITH MY YOUNG CHILD IN THE CAR. WHEN I FIRST HAD TO TAKE IT TO A DEALER TO GET THEM CHANGED 2 OTHER CARS IN THIS SMALL TOWN I LIVE IN WERE THERE ALSO HAVING THERE'S REPLACED. THIS SHOULD BE A RECALL EVERY PERSON I TALK TO STATES THIS IS A PROBLEM THAT IS ARISING FROM A RUSTED CRADLE PROBLEM WHEN MANUFACTURING THE CAR. I WOULD LIKE MY CAR REPAIRED WHERE THIS WILL NO LONGER HAPPEN AND IT IS TOO EXPENSIVE FOR ME TO FIX. I HAVE DECIDED TO LOOK FURTHER INTO THIS ISSUE AND MAYBE COME TOGETHER WITH OTHER WITH THIS ISSUE. THERE SHOULD OF BEEN A RECALL BY NOW. I HAD MY OIL CHANGED AND WAS TOLD THAT MY BOOT IS BUSTED AND THAT I NEEDED TO REPLACE THE DRIVERS SIDE YET AGAIN AND I DO NOT HAVE 119.00 TO PAY MY LOCAL DODGE FOR THIS YET AGAIN! *TR
MY WIFE WAS GOING 35MPH IN TOWN. COMING TO AN INTERSECTION SHE NEEDED TO TURN. NO BRAKES OR STEERING, BOTH STOPPED WORKING. LUCKILY NO ONE HIT HER AND SHE WAS ABLE TO STOP BEFORE HITTING THE TELEPHONE POLE. I HAVE SEEN A NUMBER OF PEOPLE ONLINE WITH SIMILAR ISSUES. *TR
TL* THE CONTACT OWNS A 2005 CHRYSLER PACIFICA. THE CONTACT STATED THAT WHILE AT A STOP LIGHT, THE BRAKE PEDAL STARTED TO VIBRATE AS IT WAS BEING DEPRESSED. THE CONTACT ADDED MORE PRESSURE AND THE ABS WARNING LIGHT ILLUMINATED. THE DEALER DIAGNOSED THAT BRAKES NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE PERSIS…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHRYSLER PACIFICA. THE CONTACT STATED THAT WHILE AT A STOP LIGHT, THE BRAKE PEDAL STARTED TO VIBRATE AS IT WAS BEING DEPRESSED. THE CONTACT ADDED MORE PRESSURE AND THE ABS WARNING LIGHT ILLUMINATED. THE DEALER DIAGNOSED THAT BRAKES NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE PERSISTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE MASTER CYLINDER BUT FAILED TO REMEDY THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE.
Official recalls
206V432000 · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Nov 9, 2006
ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP MODULE AND THE POWER TRAIN CONTROL MODULE (PCM) SOFTWARE MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN OPERATING CONDITIONS.
Consequence & remedy
Consequence: THIS COULD CAUSE A CRASH TO OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPROGRAM THE POWER TRAIN CONTROL MODULE. THE FUEL PUMP MODULE WILL ALSO BE REPLACED ON VEHICLES BUILT FROM AUGUST 1, 2004 THROUGH SEPTEMBER 30, 2004. THE RECALL BEGAN ON NOVEMBER 21, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
05V066000 · Exterior Lighting:headlights
Mar 1, 2005
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH HALOGEN HEADLAMPS MAY EXPERIENCE AN INTERMITTENT AND EVENTUAL TOTAL LOSS OF HEADLAMP FUNCTION.
Consequence & remedy
Consequence: THE HEAD LIGHTS MAY NOT OPERATE PROPERLY WHICH COULD RESULT IN INTERMITTENT OR NO HEADLIGHT FUNCTION. THIS COULD IMPAIR A DRIVER'S VISIBILITY, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT, AND REPLACE IF NECESSARY, THE WIRING HARNESS AND LOW BEAM BULB ON BOTH HEADLAMP ASSEMBLIES FREE OF CHARGE. THE RECALL BEGAN ON MARCH 28, 2005. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
EA06013 · Engine Stalling
Opened Jun 22, 2006 · Closed Nov 29, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling; Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:fuel Pump; Power Train; Power Train:automatic Transmission:control Module (tcm/pcm/tecm); Vehicle Speed Control
IN A NOVEMBER 8, 2006 LETTER, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING TWO SEPARATE DEFECT CONDITIONS THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2005-2006 CHRYSLER PACIFICA VEHICLES (NHTSA RECALL NO. 06V-432).MY 2005 VEHICLES BUILT IN AUGUST AND SEPTEMBER OF 2004 ARE BEING RECALLED TO CORRECT A DEFECT IN THE SECONDARY FUEL PUMP MODULES, WHICH MAY HAVE AN IMPROPER PRESS FITTING ON THE INLET THAT CAN BECOME DISLODGED AND SHUT-OFF FUEL FLOW.ALL MY 2005-2006 VEHICLES BUILT BETWEEN JULY 8, 2004 AND NOVEMBER 11, 2005 ARE BEING RECALLED TO CORRECT A POWERTRAIN CONTROL MODULE (PCM) SOFTWARE ISSUE WITH THE EVAPORATIVE EMISSIONS SYSTEM WHICH CAN ALSO CAUSE STALLING.FOR BOTH CONDITIONS, ENGINE STALL INCIDENTS TEND TO OCCUR DURING LEFT TURNS. THERE WERE 17,375 VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004 THAT WERE AFFECTED BY BOTH THE FUEL PUMP MODULE AND PCM SOFTWARE CONDITIONS.THERE WERE 30 VOQS SUBMITTED TO ODI, 58 CONSUMER COMPLAINTS TO DCC AND 829 FIELD REPORTS RELATING TO VEHICLES PRODUCED DURING THIS PERIOD.WHILE THESE ARE MOSTLY RELATED TO THE FUEL PUMP CONDITION, SOME MAY HAVE BEEN CAUSED BY THE SOFTWARE FAULT.THE RESULTING STALL WHILE DRIVING FAILURE RATE FOR THIS PERIOD IS 5,278 INCIDENTS PER 100,000 VEHICLES.THERE WERE TWO CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 1,021 WARRANTY CLAIMS FOR FUEL PUMP MODULE REPLACEMENT THAT APPEAR RELATED TO ENGINE STALL (5.9% CLAIM RATE). THE POPULATION FOR THE REMAINING VEHICLES INCLUDED IN 06V-432 (I.E., THOSE ONLY AFFECTED BY THE SOFTWARE CONDITION) IS 114,523.THERE WERE 97 VOQS, 124 CONSUMER COMPLAINTS TO DCC AND 454 DCC FIELD REPORTS RELATING TO THESE VEHICLES.THE RESULTING STALL WHILE DRIVING FAILURE RATE IS 589 PER 100,000 VEHICLES.THERE WERE SEVEN CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 3,211 WARRANTY CLAIMS FOR PCM REFLASH THAT APPEAR RELATED TO ENGINE STALL IN THE TOTAL POPULATION OF 131,898 VEHICLES (2.4% CLAIM RATE). ALL CALCULATIONS ARE BASED ON UNIQUE VINS (MULTIPLE/REPEAT FAILURES NOT INCLUDED IN THESE CALCULATIONS) WITH NO DUPLICATION ACROSS CATEGORIES.DCC'S RECALL WILL REPROGRAM THE PCM SOFTWARE AND REPLACE THE FUEL PUMP MODULES IN ALL AFFECTED VEHICLES.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
Additional source detail variants (7)
Engine And Engine Cooling
IN A NOVEMBER 8, 2006 LETTER, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING TWO SEPARATE DEFECT CONDITIONS THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2005-2006 CHRYSLER PACIFICA VEHICLES (NHTSA RECALL NO. 06V-432).MY 2005 VEHICLES BUILT IN AUGUST AND SEPTEMBER OF 2004 ARE BEING RECALLED TO CORRECT A DEFECT IN THE SECONDARY FUEL PUMP MODULES, WHICH MAY HAVE AN IMPROPER PRESS FITTING ON THE INLET THAT CAN BECOME DISLODGED AND SHUT-OFF FUEL FLOW.ALL MY 2005-2006 VEHICLES BUILT BETWEEN JULY 8, 2004 AND NOVEMBER 11, 2005 ARE BEING RECALLED TO CORRECT A POWERTRAIN CONTROL MODULE (PCM) SOFTWARE ISSUE WITH THE EVAPORATIVE EMISSIONS SYSTEM WHICH CAN ALSO CAUSE STALLING.FOR BOTH CONDITIONS, ENGINE STALL INCIDENTS TEND TO OCCUR DURING LEFT TURNS. THERE WERE 17,375 VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004 THAT WERE AFFECTED BY BOTH THE FUEL PUMP MODULE AND PCM SOFTWARE CONDITIONS.THERE WERE 30 VOQS SUBMITTED TO ODI, 58 CONSUMER COMPLAINTS TO DCC AND 829 FIELD REPORTS RELATING TO VEHICLES PRODUCED DURING THIS PERIOD.WHILE THESE ARE MOSTLY RELATED TO THE FUEL PUMP CONDITION, SOME MAY HAVE BEEN CAUSED BY THE SOFTWARE FAULT.THE RESULTING STALL WHILE DRIVING FAILURE RATE FOR THIS PERIOD IS 5,278 INCIDENTS PER 100,000 VEHICLES.THERE WERE TWO CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 1,021 WARRANTY CLAIMS FOR FUEL PUMP MODULE REPLACEMENT THAT APPEAR RELATED TO ENGINE STALL (5.9% CLAIM RATE). THE POPULATION FOR THE REMAINING VEHICLES INCLUDED IN 06V-432 (I.E., THOSE ONLY AFFECTED BY THE SOFTWARE CONDITION) IS 114,523.THERE WERE 97 VOQS, 124 CONSUMER COMPLAINTS TO DCC AND 454 DCC FIELD REPORTS RELATING TO THESE VEHICLES.THE RESULTING STALL WHILE DRIVING FAILURE RATE IS 589 PER 100,000 VEHICLES.THERE WERE SEVEN CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 3,211 WARRANTY CLAIMS FOR PCM REFLASH THAT APPEAR RELATED TO ENGINE STALL IN THE TOTAL POPULATION OF 131,898 VEHICLES (2.4% CLAIM RATE). ALL CALCULATIONS ARE BASED ON UNIQUE VINS (MULTIPLE/REPEAT FAILURES NOT INCLUDED IN THESE CALCULATIONS) WITH NO DUPLICATION ACROSS CATEGORIES.DCC'S RECALL WILL REPROGRAM THE PCM SOFTWARE AND REPLACE THE FUEL PUMP MODULES IN ALL AFFECTED VEHICLES.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
Fuel System, Gasoline
IN A NOVEMBER 8, 2006 LETTER, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING TWO SEPARATE DEFECT CONDITIONS THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2005-2006 CHRYSLER PACIFICA VEHICLES (NHTSA RECALL NO. 06V-432).MY 2005 VEHICLES BUILT IN AUGUST AND SEPTEMBER OF 2004 ARE BEING RECALLED TO CORRECT A DEFECT IN THE SECONDARY FUEL PUMP MODULES, WHICH MAY HAVE AN IMPROPER PRESS FITTING ON THE INLET THAT CAN BECOME DISLODGED AND SHUT-OFF FUEL FLOW.ALL MY 2005-2006 VEHICLES BUILT BETWEEN JULY 8, 2004 AND NOVEMBER 11, 2005 ARE BEING RECALLED TO CORRECT A POWERTRAIN CONTROL MODULE (PCM) SOFTWARE ISSUE WITH THE EVAPORATIVE EMISSIONS SYSTEM WHICH CAN ALSO CAUSE STALLING.FOR BOTH CONDITIONS, ENGINE STALL INCIDENTS TEND TO OCCUR DURING LEFT TURNS. THERE WERE 17,375 VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004 THAT WERE AFFECTED BY BOTH THE FUEL PUMP MODULE AND PCM SOFTWARE CONDITIONS.THERE WERE 30 VOQS SUBMITTED TO ODI, 58 CONSUMER COMPLAINTS TO DCC AND 829 FIELD REPORTS RELATING TO VEHICLES PRODUCED DURING THIS PERIOD.WHILE THESE ARE MOSTLY RELATED TO THE FUEL PUMP CONDITION, SOME MAY HAVE BEEN CAUSED BY THE SOFTWARE FAULT.THE RESULTING STALL WHILE DRIVING FAILURE RATE FOR THIS PERIOD IS 5,278 INCIDENTS PER 100,000 VEHICLES.THERE WERE TWO CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 1,021 WARRANTY CLAIMS FOR FUEL PUMP MODULE REPLACEMENT THAT APPEAR RELATED TO ENGINE STALL (5.9% CLAIM RATE). THE POPULATION FOR THE REMAINING VEHICLES INCLUDED IN 06V-432 (I.E., THOSE ONLY AFFECTED BY THE SOFTWARE CONDITION) IS 114,523.THERE WERE 97 VOQS, 124 CONSUMER COMPLAINTS TO DCC AND 454 DCC FIELD REPORTS RELATING TO THESE VEHICLES.THE RESULTING STALL WHILE DRIVING FAILURE RATE IS 589 PER 100,000 VEHICLES.THERE WERE SEVEN CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 3,211 WARRANTY CLAIMS FOR PCM REFLASH THAT APPEAR RELATED TO ENGINE STALL IN THE TOTAL POPULATION OF 131,898 VEHICLES (2.4% CLAIM RATE). ALL CALCULATIONS ARE BASED ON UNIQUE VINS (MULTIPLE/REPEAT FAILURES NOT INCLUDED IN THESE CALCULATIONS) WITH NO DUPLICATION ACROSS CATEGORIES.DCC'S RECALL WILL REPROGRAM THE PCM SOFTWARE AND REPLACE THE FUEL PUMP MODULES IN ALL AFFECTED VEHICLES.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
Fuel System, Gasoline:delivery
IN A NOVEMBER 8, 2006 LETTER, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING TWO SEPARATE DEFECT CONDITIONS THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2005-2006 CHRYSLER PACIFICA VEHICLES (NHTSA RECALL NO. 06V-432).MY 2005 VEHICLES BUILT IN AUGUST AND SEPTEMBER OF 2004 ARE BEING RECALLED TO CORRECT A DEFECT IN THE SECONDARY FUEL PUMP MODULES, WHICH MAY HAVE AN IMPROPER PRESS FITTING ON THE INLET THAT CAN BECOME DISLODGED AND SHUT-OFF FUEL FLOW.ALL MY 2005-2006 VEHICLES BUILT BETWEEN JULY 8, 2004 AND NOVEMBER 11, 2005 ARE BEING RECALLED TO CORRECT A POWERTRAIN CONTROL MODULE (PCM) SOFTWARE ISSUE WITH THE EVAPORATIVE EMISSIONS SYSTEM WHICH CAN ALSO CAUSE STALLING.FOR BOTH CONDITIONS, ENGINE STALL INCIDENTS TEND TO OCCUR DURING LEFT TURNS. THERE WERE 17,375 VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004 THAT WERE AFFECTED BY BOTH THE FUEL PUMP MODULE AND PCM SOFTWARE CONDITIONS.THERE WERE 30 VOQS SUBMITTED TO ODI, 58 CONSUMER COMPLAINTS TO DCC AND 829 FIELD REPORTS RELATING TO VEHICLES PRODUCED DURING THIS PERIOD.WHILE THESE ARE MOSTLY RELATED TO THE FUEL PUMP CONDITION, SOME MAY HAVE BEEN CAUSED BY THE SOFTWARE FAULT.THE RESULTING STALL WHILE DRIVING FAILURE RATE FOR THIS PERIOD IS 5,278 INCIDENTS PER 100,000 VEHICLES.THERE WERE TWO CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 1,021 WARRANTY CLAIMS FOR FUEL PUMP MODULE REPLACEMENT THAT APPEAR RELATED TO ENGINE STALL (5.9% CLAIM RATE). THE POPULATION FOR THE REMAINING VEHICLES INCLUDED IN 06V-432 (I.E., THOSE ONLY AFFECTED BY THE SOFTWARE CONDITION) IS 114,523.THERE WERE 97 VOQS, 124 CONSUMER COMPLAINTS TO DCC AND 454 DCC FIELD REPORTS RELATING TO THESE VEHICLES.THE RESULTING STALL WHILE DRIVING FAILURE RATE IS 589 PER 100,000 VEHICLES.THERE WERE SEVEN CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 3,211 WARRANTY CLAIMS FOR PCM REFLASH THAT APPEAR RELATED TO ENGINE STALL IN THE TOTAL POPULATION OF 131,898 VEHICLES (2.4% CLAIM RATE). ALL CALCULATIONS ARE BASED ON UNIQUE VINS (MULTIPLE/REPEAT FAILURES NOT INCLUDED IN THESE CALCULATIONS) WITH NO DUPLICATION ACROSS CATEGORIES.DCC'S RECALL WILL REPROGRAM THE PCM SOFTWARE AND REPLACE THE FUEL PUMP MODULES IN ALL AFFECTED VEHICLES.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
Fuel System, Gasoline:delivery:fuel Pump
IN A NOVEMBER 8, 2006 LETTER, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING TWO SEPARATE DEFECT CONDITIONS THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2005-2006 CHRYSLER PACIFICA VEHICLES (NHTSA RECALL NO. 06V-432).MY 2005 VEHICLES BUILT IN AUGUST AND SEPTEMBER OF 2004 ARE BEING RECALLED TO CORRECT A DEFECT IN THE SECONDARY FUEL PUMP MODULES, WHICH MAY HAVE AN IMPROPER PRESS FITTING ON THE INLET THAT CAN BECOME DISLODGED AND SHUT-OFF FUEL FLOW.ALL MY 2005-2006 VEHICLES BUILT BETWEEN JULY 8, 2004 AND NOVEMBER 11, 2005 ARE BEING RECALLED TO CORRECT A POWERTRAIN CONTROL MODULE (PCM) SOFTWARE ISSUE WITH THE EVAPORATIVE EMISSIONS SYSTEM WHICH CAN ALSO CAUSE STALLING.FOR BOTH CONDITIONS, ENGINE STALL INCIDENTS TEND TO OCCUR DURING LEFT TURNS. THERE WERE 17,375 VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004 THAT WERE AFFECTED BY BOTH THE FUEL PUMP MODULE AND PCM SOFTWARE CONDITIONS.THERE WERE 30 VOQS SUBMITTED TO ODI, 58 CONSUMER COMPLAINTS TO DCC AND 829 FIELD REPORTS RELATING TO VEHICLES PRODUCED DURING THIS PERIOD.WHILE THESE ARE MOSTLY RELATED TO THE FUEL PUMP CONDITION, SOME MAY HAVE BEEN CAUSED BY THE SOFTWARE FAULT.THE RESULTING STALL WHILE DRIVING FAILURE RATE FOR THIS PERIOD IS 5,278 INCIDENTS PER 100,000 VEHICLES.THERE WERE TWO CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 1,021 WARRANTY CLAIMS FOR FUEL PUMP MODULE REPLACEMENT THAT APPEAR RELATED TO ENGINE STALL (5.9% CLAIM RATE). THE POPULATION FOR THE REMAINING VEHICLES INCLUDED IN 06V-432 (I.E., THOSE ONLY AFFECTED BY THE SOFTWARE CONDITION) IS 114,523.THERE WERE 97 VOQS, 124 CONSUMER COMPLAINTS TO DCC AND 454 DCC FIELD REPORTS RELATING TO THESE VEHICLES.THE RESULTING STALL WHILE DRIVING FAILURE RATE IS 589 PER 100,000 VEHICLES.THERE WERE SEVEN CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 3,211 WARRANTY CLAIMS FOR PCM REFLASH THAT APPEAR RELATED TO ENGINE STALL IN THE TOTAL POPULATION OF 131,898 VEHICLES (2.4% CLAIM RATE). ALL CALCULATIONS ARE BASED ON UNIQUE VINS (MULTIPLE/REPEAT FAILURES NOT INCLUDED IN THESE CALCULATIONS) WITH NO DUPLICATION ACROSS CATEGORIES.DCC'S RECALL WILL REPROGRAM THE PCM SOFTWARE AND REPLACE THE FUEL PUMP MODULES IN ALL AFFECTED VEHICLES.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
IN A NOVEMBER 8, 2006 LETTER, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING TWO SEPARATE DEFECT CONDITIONS THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2005-2006 CHRYSLER PACIFICA VEHICLES (NHTSA RECALL NO. 06V-432).MY 2005 VEHICLES BUILT IN AUGUST AND SEPTEMBER OF 2004 ARE BEING RECALLED TO CORRECT A DEFECT IN THE SECONDARY FUEL PUMP MODULES, WHICH MAY HAVE AN IMPROPER PRESS FITTING ON THE INLET THAT CAN BECOME DISLODGED AND SHUT-OFF FUEL FLOW.ALL MY 2005-2006 VEHICLES BUILT BETWEEN JULY 8, 2004 AND NOVEMBER 11, 2005 ARE BEING RECALLED TO CORRECT A POWERTRAIN CONTROL MODULE (PCM) SOFTWARE ISSUE WITH THE EVAPORATIVE EMISSIONS SYSTEM WHICH CAN ALSO CAUSE STALLING.FOR BOTH CONDITIONS, ENGINE STALL INCIDENTS TEND TO OCCUR DURING LEFT TURNS. THERE WERE 17,375 VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004 THAT WERE AFFECTED BY BOTH THE FUEL PUMP MODULE AND PCM SOFTWARE CONDITIONS.THERE WERE 30 VOQS SUBMITTED TO ODI, 58 CONSUMER COMPLAINTS TO DCC AND 829 FIELD REPORTS RELATING TO VEHICLES PRODUCED DURING THIS PERIOD.WHILE THESE ARE MOSTLY RELATED TO THE FUEL PUMP CONDITION, SOME MAY HAVE BEEN CAUSED BY THE SOFTWARE FAULT.THE RESULTING STALL WHILE DRIVING FAILURE RATE FOR THIS PERIOD IS 5,278 INCIDENTS PER 100,000 VEHICLES.THERE WERE TWO CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 1,021 WARRANTY CLAIMS FOR FUEL PUMP MODULE REPLACEMENT THAT APPEAR RELATED TO ENGINE STALL (5.9% CLAIM RATE). THE POPULATION FOR THE REMAINING VEHICLES INCLUDED IN 06V-432 (I.E., THOSE ONLY AFFECTED BY THE SOFTWARE CONDITION) IS 114,523.THERE WERE 97 VOQS, 124 CONSUMER COMPLAINTS TO DCC AND 454 DCC FIELD REPORTS RELATING TO THESE VEHICLES.THE RESULTING STALL WHILE DRIVING FAILURE RATE IS 589 PER 100,000 VEHICLES.THERE WERE SEVEN CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 3,211 WARRANTY CLAIMS FOR PCM REFLASH THAT APPEAR RELATED TO ENGINE STALL IN THE TOTAL POPULATION OF 131,898 VEHICLES (2.4% CLAIM RATE). ALL CALCULATIONS ARE BASED ON UNIQUE VINS (MULTIPLE/REPEAT FAILURES NOT INCLUDED IN THESE CALCULATIONS) WITH NO DUPLICATION ACROSS CATEGORIES.DCC'S RECALL WILL REPROGRAM THE PCM SOFTWARE AND REPLACE THE FUEL PUMP MODULES IN ALL AFFECTED VEHICLES.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
Power Train
IN A NOVEMBER 8, 2006 LETTER, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING TWO SEPARATE DEFECT CONDITIONS THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2005-2006 CHRYSLER PACIFICA VEHICLES (NHTSA RECALL NO. 06V-432).MY 2005 VEHICLES BUILT IN AUGUST AND SEPTEMBER OF 2004 ARE BEING RECALLED TO CORRECT A DEFECT IN THE SECONDARY FUEL PUMP MODULES, WHICH MAY HAVE AN IMPROPER PRESS FITTING ON THE INLET THAT CAN BECOME DISLODGED AND SHUT-OFF FUEL FLOW.ALL MY 2005-2006 VEHICLES BUILT BETWEEN JULY 8, 2004 AND NOVEMBER 11, 2005 ARE BEING RECALLED TO CORRECT A POWERTRAIN CONTROL MODULE (PCM) SOFTWARE ISSUE WITH THE EVAPORATIVE EMISSIONS SYSTEM WHICH CAN ALSO CAUSE STALLING.FOR BOTH CONDITIONS, ENGINE STALL INCIDENTS TEND TO OCCUR DURING LEFT TURNS. THERE WERE 17,375 VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004 THAT WERE AFFECTED BY BOTH THE FUEL PUMP MODULE AND PCM SOFTWARE CONDITIONS.THERE WERE 30 VOQS SUBMITTED TO ODI, 58 CONSUMER COMPLAINTS TO DCC AND 829 FIELD REPORTS RELATING TO VEHICLES PRODUCED DURING THIS PERIOD.WHILE THESE ARE MOSTLY RELATED TO THE FUEL PUMP CONDITION, SOME MAY HAVE BEEN CAUSED BY THE SOFTWARE FAULT.THE RESULTING STALL WHILE DRIVING FAILURE RATE FOR THIS PERIOD IS 5,278 INCIDENTS PER 100,000 VEHICLES.THERE WERE TWO CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 1,021 WARRANTY CLAIMS FOR FUEL PUMP MODULE REPLACEMENT THAT APPEAR RELATED TO ENGINE STALL (5.9% CLAIM RATE). THE POPULATION FOR THE REMAINING VEHICLES INCLUDED IN 06V-432 (I.E., THOSE ONLY AFFECTED BY THE SOFTWARE CONDITION) IS 114,523.THERE WERE 97 VOQS, 124 CONSUMER COMPLAINTS TO DCC AND 454 DCC FIELD REPORTS RELATING TO THESE VEHICLES.THE RESULTING STALL WHILE DRIVING FAILURE RATE IS 589 PER 100,000 VEHICLES.THERE WERE SEVEN CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 3,211 WARRANTY CLAIMS FOR PCM REFLASH THAT APPEAR RELATED TO ENGINE STALL IN THE TOTAL POPULATION OF 131,898 VEHICLES (2.4% CLAIM RATE). ALL CALCULATIONS ARE BASED ON UNIQUE VINS (MULTIPLE/REPEAT FAILURES NOT INCLUDED IN THESE CALCULATIONS) WITH NO DUPLICATION ACROSS CATEGORIES.DCC'S RECALL WILL REPROGRAM THE PCM SOFTWARE AND REPLACE THE FUEL PUMP MODULES IN ALL AFFECTED VEHICLES.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
Vehicle Speed Control
IN A NOVEMBER 8, 2006 LETTER, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING TWO SEPARATE DEFECT CONDITIONS THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2005-2006 CHRYSLER PACIFICA VEHICLES (NHTSA RECALL NO. 06V-432).MY 2005 VEHICLES BUILT IN AUGUST AND SEPTEMBER OF 2004 ARE BEING RECALLED TO CORRECT A DEFECT IN THE SECONDARY FUEL PUMP MODULES, WHICH MAY HAVE AN IMPROPER PRESS FITTING ON THE INLET THAT CAN BECOME DISLODGED AND SHUT-OFF FUEL FLOW.ALL MY 2005-2006 VEHICLES BUILT BETWEEN JULY 8, 2004 AND NOVEMBER 11, 2005 ARE BEING RECALLED TO CORRECT A POWERTRAIN CONTROL MODULE (PCM) SOFTWARE ISSUE WITH THE EVAPORATIVE EMISSIONS SYSTEM WHICH CAN ALSO CAUSE STALLING.FOR BOTH CONDITIONS, ENGINE STALL INCIDENTS TEND TO OCCUR DURING LEFT TURNS. THERE WERE 17,375 VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004 THAT WERE AFFECTED BY BOTH THE FUEL PUMP MODULE AND PCM SOFTWARE CONDITIONS.THERE WERE 30 VOQS SUBMITTED TO ODI, 58 CONSUMER COMPLAINTS TO DCC AND 829 FIELD REPORTS RELATING TO VEHICLES PRODUCED DURING THIS PERIOD.WHILE THESE ARE MOSTLY RELATED TO THE FUEL PUMP CONDITION, SOME MAY HAVE BEEN CAUSED BY THE SOFTWARE FAULT.THE RESULTING STALL WHILE DRIVING FAILURE RATE FOR THIS PERIOD IS 5,278 INCIDENTS PER 100,000 VEHICLES.THERE WERE TWO CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 1,021 WARRANTY CLAIMS FOR FUEL PUMP MODULE REPLACEMENT THAT APPEAR RELATED TO ENGINE STALL (5.9% CLAIM RATE). THE POPULATION FOR THE REMAINING VEHICLES INCLUDED IN 06V-432 (I.E., THOSE ONLY AFFECTED BY THE SOFTWARE CONDITION) IS 114,523.THERE WERE 97 VOQS, 124 CONSUMER COMPLAINTS TO DCC AND 454 DCC FIELD REPORTS RELATING TO THESE VEHICLES.THE RESULTING STALL WHILE DRIVING FAILURE RATE IS 589 PER 100,000 VEHICLES.THERE WERE SEVEN CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 3,211 WARRANTY CLAIMS FOR PCM REFLASH THAT APPEAR RELATED TO ENGINE STALL IN THE TOTAL POPULATION OF 131,898 VEHICLES (2.4% CLAIM RATE). ALL CALCULATIONS ARE BASED ON UNIQUE VINS (MULTIPLE/REPEAT FAILURES NOT INCLUDED IN THESE CALCULATIONS) WITH NO DUPLICATION ACROSS CATEGORIES.DCC'S RECALL WILL REPROGRAM THE PCM SOFTWARE AND REPLACE THE FUEL PUMP MODULES IN ALL AFFECTED VEHICLES.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
EA06010 · Fuel Tank Punctures
Opened Jun 15, 2006 · Closed Oct 11, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:storage; Fuel System, Other:storage:tank Assembly
EA06-010 WAS OPENED BASED ON INFORMATION GATHERED IN PRELIMINARY EVALUATION PE06-009.PE06-009 WAS OPENED BASED ON INFORMATION OBTAINED IN A PEER INFORMATION REQUEST AS PART OF A PRELIMINARY EVALUATION (PE05-050) OF FUEL TANK PUNCTURE IN MODEL YEAR (MY) 2003 THROUGH 2006 NISSAN MURANO VEHICLES.IN JANUARY 2006, NISSAN SUBMITTED A DEFECT INFORMATION REPORT TO ODI THAT IDENTIFIED A DEFECT IN THE FUEL TANK SHIELDING IN APPROXIMATELY 209,000 MY 2003 THROUGH 2006 NISSAN MURANO VEHICLES.TO REMEDY THE PROBLEM, NISSAN INSTALLED SHIELDS ON THE EXPOSED FRONT SURFACES OF THE RECALLED VEHICLES.PEER DATA COLLECTED FOR MY 2004 THROUGH 2005 PACIFICA VEHICLES DURING PE05-050 INCLUDED 120 FIELD REPORTS DOCUMENTING TANK REPLACEMENTS DUE TO PUNCTURE OR DAMAGE BY ROAD DEBRIS AS PART OF A PARTS RESTRICTION PROGRAM CONDUCTED AT THE REQUEST OF THE TANK SUPPLIER (INERGY). ANALYSIS OF THE INFORMATION PROVIDED BY CHRYSLER DURING PE05-050, PE06-009 AND EA06-010 SHOW THAT THE FRONT SURFACE OF THE FUEL TANKS IN THE SUBJECT PACIFICA VEHICLES IS NOT COMPLETELY PROTECTED FROMROAD DEBRIS BY THE FLOOR PAN OR OTHER BODY STRUCTURE.THE TANKS WERE COMPARED WITH PEER VEHICLES, INCLUDING SEVERAL IDENTIFIED BY CHRYSLER AS SHARING SIMILAR DESIGN CHARACTERISTICS (UNSHIELDED HIGH-DENSITY POLYETHYLENE PLASTIC FUEL TANKS IN A SADDLEBAG CONFIGURATION).SOME OF THE PEER DESIGNS REVIEWED BY ODI PACKAGED THE TANKS IN RECESSED CAVITIES IN THE FLOOR PAN OR USED SHIELDS TO PROTECT EXPOSED SURFACES ON THE FRONT OF THE TANK.IN GENERAL, THESE TANKS HAD THE LOWEST COMPLAINT RATES FOR TANK PUNCTURE BY ROAD DEBRIS. HOWEVER, OTHER PEER DESIGNS REVIEWED BY ODI HAD PACKAGING SIMILAR TO THE SUBJECT VEHICLES AND SOME OF THESE ALSO HAD SOME COMPLAINTS OF TANK PUNCTURE.NONE OF THE PEER VEHICLES ANALYZED BY ODI HAD TANKS PUNCTURE DATA COMPARABLE TO CHRYSLER'S FIELD REPORTS FROM ITS PART RESTRICTION PROGRAMS, SO THAT DATA COULD NOT BE USED IN PEER COMPARISONS. ANALYSIS OF THE COMPLAINT DATA SHOWS THAT THE RATE FOR THE SUBJECT VEHICLES IS ABOUT HALF THAT OBSERVED IN THE RECALLED MURANO VEHICLES AND NOT SIGNIFICANTLY HIGHER THAN SOME OF THE PEER VEHICLES ANALYZED WITH SIMILAR DESIGN CHARACTERISTICS.TESTING BY THE NHTSA VEHICLE RESEARCH AND TESTING CENTER (VRTC) SHOWED DIFFERENCES BETWEEN THE MURANO AND PACIFICA FUEL TANK PACKAGING AND EXPOSURE TO ROAD DEBRIS THROWN BY THE FRONT TIRES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (4)
Fuel System, Gasoline:storage
EA06-010 WAS OPENED BASED ON INFORMATION GATHERED IN PRELIMINARY EVALUATION PE06-009.PE06-009 WAS OPENED BASED ON INFORMATION OBTAINED IN A PEER INFORMATION REQUEST AS PART OF A PRELIMINARY EVALUATION (PE05-050) OF FUEL TANK PUNCTURE IN MODEL YEAR (MY) 2003 THROUGH 2006 NISSAN MURANO VEHICLES.IN JANUARY 2006, NISSAN SUBMITTED A DEFECT INFORMATION REPORT TO ODI THAT IDENTIFIED A DEFECT IN THE FUEL TANK SHIELDING IN APPROXIMATELY 209,000 MY 2003 THROUGH 2006 NISSAN MURANO VEHICLES.TO REMEDY THE PROBLEM, NISSAN INSTALLED SHIELDS ON THE EXPOSED FRONT SURFACES OF THE RECALLED VEHICLES.PEER DATA COLLECTED FOR MY 2004 THROUGH 2005 PACIFICA VEHICLES DURING PE05-050 INCLUDED 120 FIELD REPORTS DOCUMENTING TANK REPLACEMENTS DUE TO PUNCTURE OR DAMAGE BY ROAD DEBRIS AS PART OF A PARTS RESTRICTION PROGRAM CONDUCTED AT THE REQUEST OF THE TANK SUPPLIER (INERGY). ANALYSIS OF THE INFORMATION PROVIDED BY CHRYSLER DURING PE05-050, PE06-009 AND EA06-010 SHOW THAT THE FRONT SURFACE OF THE FUEL TANKS IN THE SUBJECT PACIFICA VEHICLES IS NOT COMPLETELY PROTECTED FROMROAD DEBRIS BY THE FLOOR PAN OR OTHER BODY STRUCTURE.THE TANKS WERE COMPARED WITH PEER VEHICLES, INCLUDING SEVERAL IDENTIFIED BY CHRYSLER AS SHARING SIMILAR DESIGN CHARACTERISTICS (UNSHIELDED HIGH-DENSITY POLYETHYLENE PLASTIC FUEL TANKS IN A SADDLEBAG CONFIGURATION).SOME OF THE PEER DESIGNS REVIEWED BY ODI PACKAGED THE TANKS IN RECESSED CAVITIES IN THE FLOOR PAN OR USED SHIELDS TO PROTECT EXPOSED SURFACES ON THE FRONT OF THE TANK.IN GENERAL, THESE TANKS HAD THE LOWEST COMPLAINT RATES FOR TANK PUNCTURE BY ROAD DEBRIS. HOWEVER, OTHER PEER DESIGNS REVIEWED BY ODI HAD PACKAGING SIMILAR TO THE SUBJECT VEHICLES AND SOME OF THESE ALSO HAD SOME COMPLAINTS OF TANK PUNCTURE.NONE OF THE PEER VEHICLES ANALYZED BY ODI HAD TANKS PUNCTURE DATA COMPARABLE TO CHRYSLER'S FIELD REPORTS FROM ITS PART RESTRICTION PROGRAMS, SO THAT DATA COULD NOT BE USED IN PEER COMPARISONS. ANALYSIS OF THE COMPLAINT DATA SHOWS THAT THE RATE FOR THE SUBJECT VEHICLES IS ABOUT HALF THAT OBSERVED IN THE RECALLED MURANO VEHICLES AND NOT SIGNIFICANTLY HIGHER THAN SOME OF THE PEER VEHICLES ANALYZED WITH SIMILAR DESIGN CHARACTERISTICS.TESTING BY THE NHTSA VEHICLE RESEARCH AND TESTING CENTER (VRTC) SHOWED DIFFERENCES BETWEEN THE MURANO AND PACIFICA FUEL TANK PACKAGING AND EXPOSURE TO ROAD DEBRIS THROWN BY THE FRONT TIRES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Gasoline:storage:tank Assembly
EA06-010 WAS OPENED BASED ON INFORMATION GATHERED IN PRELIMINARY EVALUATION PE06-009.PE06-009 WAS OPENED BASED ON INFORMATION OBTAINED IN A PEER INFORMATION REQUEST AS PART OF A PRELIMINARY EVALUATION (PE05-050) OF FUEL TANK PUNCTURE IN MODEL YEAR (MY) 2003 THROUGH 2006 NISSAN MURANO VEHICLES.IN JANUARY 2006, NISSAN SUBMITTED A DEFECT INFORMATION REPORT TO ODI THAT IDENTIFIED A DEFECT IN THE FUEL TANK SHIELDING IN APPROXIMATELY 209,000 MY 2003 THROUGH 2006 NISSAN MURANO VEHICLES.TO REMEDY THE PROBLEM, NISSAN INSTALLED SHIELDS ON THE EXPOSED FRONT SURFACES OF THE RECALLED VEHICLES.PEER DATA COLLECTED FOR MY 2004 THROUGH 2005 PACIFICA VEHICLES DURING PE05-050 INCLUDED 120 FIELD REPORTS DOCUMENTING TANK REPLACEMENTS DUE TO PUNCTURE OR DAMAGE BY ROAD DEBRIS AS PART OF A PARTS RESTRICTION PROGRAM CONDUCTED AT THE REQUEST OF THE TANK SUPPLIER (INERGY). ANALYSIS OF THE INFORMATION PROVIDED BY CHRYSLER DURING PE05-050, PE06-009 AND EA06-010 SHOW THAT THE FRONT SURFACE OF THE FUEL TANKS IN THE SUBJECT PACIFICA VEHICLES IS NOT COMPLETELY PROTECTED FROMROAD DEBRIS BY THE FLOOR PAN OR OTHER BODY STRUCTURE.THE TANKS WERE COMPARED WITH PEER VEHICLES, INCLUDING SEVERAL IDENTIFIED BY CHRYSLER AS SHARING SIMILAR DESIGN CHARACTERISTICS (UNSHIELDED HIGH-DENSITY POLYETHYLENE PLASTIC FUEL TANKS IN A SADDLEBAG CONFIGURATION).SOME OF THE PEER DESIGNS REVIEWED BY ODI PACKAGED THE TANKS IN RECESSED CAVITIES IN THE FLOOR PAN OR USED SHIELDS TO PROTECT EXPOSED SURFACES ON THE FRONT OF THE TANK.IN GENERAL, THESE TANKS HAD THE LOWEST COMPLAINT RATES FOR TANK PUNCTURE BY ROAD DEBRIS. HOWEVER, OTHER PEER DESIGNS REVIEWED BY ODI HAD PACKAGING SIMILAR TO THE SUBJECT VEHICLES AND SOME OF THESE ALSO HAD SOME COMPLAINTS OF TANK PUNCTURE.NONE OF THE PEER VEHICLES ANALYZED BY ODI HAD TANKS PUNCTURE DATA COMPARABLE TO CHRYSLER'S FIELD REPORTS FROM ITS PART RESTRICTION PROGRAMS, SO THAT DATA COULD NOT BE USED IN PEER COMPARISONS. ANALYSIS OF THE COMPLAINT DATA SHOWS THAT THE RATE FOR THE SUBJECT VEHICLES IS ABOUT HALF THAT OBSERVED IN THE RECALLED MURANO VEHICLES AND NOT SIGNIFICANTLY HIGHER THAN SOME OF THE PEER VEHICLES ANALYZED WITH SIMILAR DESIGN CHARACTERISTICS.TESTING BY THE NHTSA VEHICLE RESEARCH AND TESTING CENTER (VRTC) SHOWED DIFFERENCES BETWEEN THE MURANO AND PACIFICA FUEL TANK PACKAGING AND EXPOSURE TO ROAD DEBRIS THROWN BY THE FRONT TIRES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Other:storage
EA06-010 WAS OPENED BASED ON INFORMATION GATHERED IN PRELIMINARY EVALUATION PE06-009.PE06-009 WAS OPENED BASED ON INFORMATION OBTAINED IN A PEER INFORMATION REQUEST AS PART OF A PRELIMINARY EVALUATION (PE05-050) OF FUEL TANK PUNCTURE IN MODEL YEAR (MY) 2003 THROUGH 2006 NISSAN MURANO VEHICLES.IN JANUARY 2006, NISSAN SUBMITTED A DEFECT INFORMATION REPORT TO ODI THAT IDENTIFIED A DEFECT IN THE FUEL TANK SHIELDING IN APPROXIMATELY 209,000 MY 2003 THROUGH 2006 NISSAN MURANO VEHICLES.TO REMEDY THE PROBLEM, NISSAN INSTALLED SHIELDS ON THE EXPOSED FRONT SURFACES OF THE RECALLED VEHICLES.PEER DATA COLLECTED FOR MY 2004 THROUGH 2005 PACIFICA VEHICLES DURING PE05-050 INCLUDED 120 FIELD REPORTS DOCUMENTING TANK REPLACEMENTS DUE TO PUNCTURE OR DAMAGE BY ROAD DEBRIS AS PART OF A PARTS RESTRICTION PROGRAM CONDUCTED AT THE REQUEST OF THE TANK SUPPLIER (INERGY). ANALYSIS OF THE INFORMATION PROVIDED BY CHRYSLER DURING PE05-050, PE06-009 AND EA06-010 SHOW THAT THE FRONT SURFACE OF THE FUEL TANKS IN THE SUBJECT PACIFICA VEHICLES IS NOT COMPLETELY PROTECTED FROMROAD DEBRIS BY THE FLOOR PAN OR OTHER BODY STRUCTURE.THE TANKS WERE COMPARED WITH PEER VEHICLES, INCLUDING SEVERAL IDENTIFIED BY CHRYSLER AS SHARING SIMILAR DESIGN CHARACTERISTICS (UNSHIELDED HIGH-DENSITY POLYETHYLENE PLASTIC FUEL TANKS IN A SADDLEBAG CONFIGURATION).SOME OF THE PEER DESIGNS REVIEWED BY ODI PACKAGED THE TANKS IN RECESSED CAVITIES IN THE FLOOR PAN OR USED SHIELDS TO PROTECT EXPOSED SURFACES ON THE FRONT OF THE TANK.IN GENERAL, THESE TANKS HAD THE LOWEST COMPLAINT RATES FOR TANK PUNCTURE BY ROAD DEBRIS. HOWEVER, OTHER PEER DESIGNS REVIEWED BY ODI HAD PACKAGING SIMILAR TO THE SUBJECT VEHICLES AND SOME OF THESE ALSO HAD SOME COMPLAINTS OF TANK PUNCTURE.NONE OF THE PEER VEHICLES ANALYZED BY ODI HAD TANKS PUNCTURE DATA COMPARABLE TO CHRYSLER'S FIELD REPORTS FROM ITS PART RESTRICTION PROGRAMS, SO THAT DATA COULD NOT BE USED IN PEER COMPARISONS. ANALYSIS OF THE COMPLAINT DATA SHOWS THAT THE RATE FOR THE SUBJECT VEHICLES IS ABOUT HALF THAT OBSERVED IN THE RECALLED MURANO VEHICLES AND NOT SIGNIFICANTLY HIGHER THAN SOME OF THE PEER VEHICLES ANALYZED WITH SIMILAR DESIGN CHARACTERISTICS.TESTING BY THE NHTSA VEHICLE RESEARCH AND TESTING CENTER (VRTC) SHOWED DIFFERENCES BETWEEN THE MURANO AND PACIFICA FUEL TANK PACKAGING AND EXPOSURE TO ROAD DEBRIS THROWN BY THE FRONT TIRES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Other:storage:tank Assembly
EA06-010 WAS OPENED BASED ON INFORMATION GATHERED IN PRELIMINARY EVALUATION PE06-009.PE06-009 WAS OPENED BASED ON INFORMATION OBTAINED IN A PEER INFORMATION REQUEST AS PART OF A PRELIMINARY EVALUATION (PE05-050) OF FUEL TANK PUNCTURE IN MODEL YEAR (MY) 2003 THROUGH 2006 NISSAN MURANO VEHICLES.IN JANUARY 2006, NISSAN SUBMITTED A DEFECT INFORMATION REPORT TO ODI THAT IDENTIFIED A DEFECT IN THE FUEL TANK SHIELDING IN APPROXIMATELY 209,000 MY 2003 THROUGH 2006 NISSAN MURANO VEHICLES.TO REMEDY THE PROBLEM, NISSAN INSTALLED SHIELDS ON THE EXPOSED FRONT SURFACES OF THE RECALLED VEHICLES.PEER DATA COLLECTED FOR MY 2004 THROUGH 2005 PACIFICA VEHICLES DURING PE05-050 INCLUDED 120 FIELD REPORTS DOCUMENTING TANK REPLACEMENTS DUE TO PUNCTURE OR DAMAGE BY ROAD DEBRIS AS PART OF A PARTS RESTRICTION PROGRAM CONDUCTED AT THE REQUEST OF THE TANK SUPPLIER (INERGY). ANALYSIS OF THE INFORMATION PROVIDED BY CHRYSLER DURING PE05-050, PE06-009 AND EA06-010 SHOW THAT THE FRONT SURFACE OF THE FUEL TANKS IN THE SUBJECT PACIFICA VEHICLES IS NOT COMPLETELY PROTECTED FROMROAD DEBRIS BY THE FLOOR PAN OR OTHER BODY STRUCTURE.THE TANKS WERE COMPARED WITH PEER VEHICLES, INCLUDING SEVERAL IDENTIFIED BY CHRYSLER AS SHARING SIMILAR DESIGN CHARACTERISTICS (UNSHIELDED HIGH-DENSITY POLYETHYLENE PLASTIC FUEL TANKS IN A SADDLEBAG CONFIGURATION).SOME OF THE PEER DESIGNS REVIEWED BY ODI PACKAGED THE TANKS IN RECESSED CAVITIES IN THE FLOOR PAN OR USED SHIELDS TO PROTECT EXPOSED SURFACES ON THE FRONT OF THE TANK.IN GENERAL, THESE TANKS HAD THE LOWEST COMPLAINT RATES FOR TANK PUNCTURE BY ROAD DEBRIS. HOWEVER, OTHER PEER DESIGNS REVIEWED BY ODI HAD PACKAGING SIMILAR TO THE SUBJECT VEHICLES AND SOME OF THESE ALSO HAD SOME COMPLAINTS OF TANK PUNCTURE.NONE OF THE PEER VEHICLES ANALYZED BY ODI HAD TANKS PUNCTURE DATA COMPARABLE TO CHRYSLER'S FIELD REPORTS FROM ITS PART RESTRICTION PROGRAMS, SO THAT DATA COULD NOT BE USED IN PEER COMPARISONS. ANALYSIS OF THE COMPLAINT DATA SHOWS THAT THE RATE FOR THE SUBJECT VEHICLES IS ABOUT HALF THAT OBSERVED IN THE RECALLED MURANO VEHICLES AND NOT SIGNIFICANTLY HIGHER THAN SOME OF THE PEER VEHICLES ANALYZED WITH SIMILAR DESIGN CHARACTERISTICS.TESTING BY THE NHTSA VEHICLE RESEARCH AND TESTING CENTER (VRTC) SHOWED DIFFERENCES BETWEEN THE MURANO AND PACIFICA FUEL TANK PACKAGING AND EXPOSURE TO ROAD DEBRIS THROWN BY THE FRONT TIRES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
RQ06002 · Engine Stalling
Opened Feb 27, 2006 · Closed Jun 22, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling; Fuel System, Gasoline; Vehicle Speed Control
ON FEBRUARY 27, 2006 RQ06-002 WAS OPENED IN RESPONSE TO 60 COMPLAINTS OF ENGINE STALL, MOSTLY DURING LEFT-HAND TURNS, IN MODEL YEAR (MY) 2004 TO 2006 CHRYSLER PACIFICA VEHICLES THAT WERE OUTSIDE THE SCOPE OF RECALL 04V-113.IN MARCH 2004, DAIMLERCHRYSLER INITIATED RECALL 04V-113 ON 34,561 MY 2004 PACIFICA VEHICLES TO CORRECT A CONDITION THAT COULD RESULT IN ENGINE STALL WHILE MAKING A LEFT-HAND TURN AFTER A COLD-START.DURING RQ06-002 IT WAS DETERMINED THAT RECALL 04V-113 DID CORRECT THE SPECIFIC CAUSE OF THE ENGINE STALLING CONDITION FOR THAT SPECIFIC POPULATION.HOWEVER, TWO OTHER CONDITIONS WERE IDENTIFIED THAT COULD ALSO CAUSE ENGINE STALLING DURING TURNING MANEUVERS:(1) AN ISSUE WITH MISBUILT FUEL PUMPS THAT PRIMARILY AFFECTED ABOUT 17,000 MY 2005 PACIFICA VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004; AND (2) A SOFTWARE CONDITION AFFECTING VAPOR PURGE IN ABOUT 131,000 MY 2005-06 PACIFICA VEHICLES BUILT FROM JULY 2004 THROUGH NOVEMBER 2005. AN ENGINEERING ANALYSIS, EA06-013, HAS BEEN OPENED TO FURTHER EXAMINE THE SCOPE, FREQUENCY AND SAFETY CONSEQUENCES ASSOCIATED WITH EACH OF THESE CONDITIONS IN THE SUBJECT VEHICLES.
Additional source detail variants (3)
Engine And Engine Cooling
ON FEBRUARY 27, 2006 RQ06-002 WAS OPENED IN RESPONSE TO 60 COMPLAINTS OF ENGINE STALL, MOSTLY DURING LEFT-HAND TURNS, IN MODEL YEAR (MY) 2004 TO 2006 CHRYSLER PACIFICA VEHICLES THAT WERE OUTSIDE THE SCOPE OF RECALL 04V-113.IN MARCH 2004, DAIMLERCHRYSLER INITIATED RECALL 04V-113 ON 34,561 MY 2004 PACIFICA VEHICLES TO CORRECT A CONDITION THAT COULD RESULT IN ENGINE STALL WHILE MAKING A LEFT-HAND TURN AFTER A COLD-START.DURING RQ06-002 IT WAS DETERMINED THAT RECALL 04V-113 DID CORRECT THE SPECIFIC CAUSE OF THE ENGINE STALLING CONDITION FOR THAT SPECIFIC POPULATION.HOWEVER, TWO OTHER CONDITIONS WERE IDENTIFIED THAT COULD ALSO CAUSE ENGINE STALLING DURING TURNING MANEUVERS:(1) AN ISSUE WITH MISBUILT FUEL PUMPS THAT PRIMARILY AFFECTED ABOUT 17,000 MY 2005 PACIFICA VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004; AND (2) A SOFTWARE CONDITION AFFECTING VAPOR PURGE IN ABOUT 131,000 MY 2005-06 PACIFICA VEHICLES BUILT FROM JULY 2004 THROUGH NOVEMBER 2005. AN ENGINEERING ANALYSIS, EA06-013, HAS BEEN OPENED TO FURTHER EXAMINE THE SCOPE, FREQUENCY AND SAFETY CONSEQUENCES ASSOCIATED WITH EACH OF THESE CONDITIONS IN THE SUBJECT VEHICLES.
Fuel System, Gasoline
ON FEBRUARY 27, 2006 RQ06-002 WAS OPENED IN RESPONSE TO 60 COMPLAINTS OF ENGINE STALL, MOSTLY DURING LEFT-HAND TURNS, IN MODEL YEAR (MY) 2004 TO 2006 CHRYSLER PACIFICA VEHICLES THAT WERE OUTSIDE THE SCOPE OF RECALL 04V-113.IN MARCH 2004, DAIMLERCHRYSLER INITIATED RECALL 04V-113 ON 34,561 MY 2004 PACIFICA VEHICLES TO CORRECT A CONDITION THAT COULD RESULT IN ENGINE STALL WHILE MAKING A LEFT-HAND TURN AFTER A COLD-START.DURING RQ06-002 IT WAS DETERMINED THAT RECALL 04V-113 DID CORRECT THE SPECIFIC CAUSE OF THE ENGINE STALLING CONDITION FOR THAT SPECIFIC POPULATION.HOWEVER, TWO OTHER CONDITIONS WERE IDENTIFIED THAT COULD ALSO CAUSE ENGINE STALLING DURING TURNING MANEUVERS:(1) AN ISSUE WITH MISBUILT FUEL PUMPS THAT PRIMARILY AFFECTED ABOUT 17,000 MY 2005 PACIFICA VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004; AND (2) A SOFTWARE CONDITION AFFECTING VAPOR PURGE IN ABOUT 131,000 MY 2005-06 PACIFICA VEHICLES BUILT FROM JULY 2004 THROUGH NOVEMBER 2005. AN ENGINEERING ANALYSIS, EA06-013, HAS BEEN OPENED TO FURTHER EXAMINE THE SCOPE, FREQUENCY AND SAFETY CONSEQUENCES ASSOCIATED WITH EACH OF THESE CONDITIONS IN THE SUBJECT VEHICLES.
Vehicle Speed Control
ON FEBRUARY 27, 2006 RQ06-002 WAS OPENED IN RESPONSE TO 60 COMPLAINTS OF ENGINE STALL, MOSTLY DURING LEFT-HAND TURNS, IN MODEL YEAR (MY) 2004 TO 2006 CHRYSLER PACIFICA VEHICLES THAT WERE OUTSIDE THE SCOPE OF RECALL 04V-113.IN MARCH 2004, DAIMLERCHRYSLER INITIATED RECALL 04V-113 ON 34,561 MY 2004 PACIFICA VEHICLES TO CORRECT A CONDITION THAT COULD RESULT IN ENGINE STALL WHILE MAKING A LEFT-HAND TURN AFTER A COLD-START.DURING RQ06-002 IT WAS DETERMINED THAT RECALL 04V-113 DID CORRECT THE SPECIFIC CAUSE OF THE ENGINE STALLING CONDITION FOR THAT SPECIFIC POPULATION.HOWEVER, TWO OTHER CONDITIONS WERE IDENTIFIED THAT COULD ALSO CAUSE ENGINE STALLING DURING TURNING MANEUVERS:(1) AN ISSUE WITH MISBUILT FUEL PUMPS THAT PRIMARILY AFFECTED ABOUT 17,000 MY 2005 PACIFICA VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004; AND (2) A SOFTWARE CONDITION AFFECTING VAPOR PURGE IN ABOUT 131,000 MY 2005-06 PACIFICA VEHICLES BUILT FROM JULY 2004 THROUGH NOVEMBER 2005. AN ENGINEERING ANALYSIS, EA06-013, HAS BEEN OPENED TO FURTHER EXAMINE THE SCOPE, FREQUENCY AND SAFETY CONSEQUENCES ASSOCIATED WITH EACH OF THESE CONDITIONS IN THE SUBJECT VEHICLES.
PE06009 · Fuel Tank Punctures
Opened Feb 22, 2006 · Closed Jun 15, 2006
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly
ON FEBRUARY 22, 2006, ODI OPENED PE06-009 TO INVESTIGATE REPORTS THAT THE FUEL TANKS ON MODEL YEAR (MY) 2004 TO 2005 CHRYSLER PACIFICA VEHICLES MAY BE PUNCTURED BY CONTACT WITH ROAD DEBRIS.THE NUMBER OF REPORTS SUBMITTED BY CHRYSLER WAS SIGNIFICANTLY HIGHER THAN THOSE SUBMITTED BY OTHER MANUFACTURERS WHO WERE REQUESTED TO SUBMIT DATA AS PART OF INVESTIGATION PE05-050 INTO MY 2003 TO 2006 NISSAN MURANO VEHICLES THAT MAY HAVE HAD INSUFFICIENT SHIELDING OF THE FUEL TANK TO PREVENT PUNCTURES AFTER CONTACT WITH ROAD DEBRIS.NISSAN ISSUED RECALL 06V-003 INVOLVING INCREASING THE SHIELDING OF THE FUEL TANKS TO REDUCE THE LIKELIHOOD OF TANK PUNCTURES. CHRYSLER HAS NOTED THAT THEY HAD IN PLACE FROM JANUARY 2003 TO JUNE 2005 A PARTS RESTRICTION PROGRAM ON PACIFICA FUEL TANK REPLACEMENTS WHICH MAY HAVE MADE THE NUMBER OF REPORTS ARTIFICIALLY HIGH IN COMPARISON TO MANUFACTURERS WHICH DID NOT HAVE A SIMILAR PROGRAM IN EFFECT.CHRYSLER ALSO QUESTIONED WHETHER MANY OF THE FIELD REPORTS OF FUEL TANKS REPLACED DUE TO DAMAGE FROM UNKNOWN CAUSE WERE ACTUALLY PUNCTURED. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-010) TO GATHER ADDITIONAL INFORMATION CONCERNING THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.