NHTSA owner reports · September 18, 2026 snapshot.
Unknown Or Other complaints
34 reportsClear category filterMileage unknown · Jul 11, 2022
EngineUnknown Or Other
I was driving on I95 in Virginia doing 70mph and the car lost all power. I was able to glide to the side of the interstate and wait for a tow. I had 2 kids and our dog in the car. We live in Maryland and were far from home. It was a very dangerous situation on the should of I95. When the car lost power I got an error message to …
Read full complaint
I was driving on I95 in Virginia doing 70mph and the car lost all power. I was able to glide to the side of the interstate and wait for a tow. I had 2 kids and our dog in the car. We live in Maryland and were far from home. It was a very dangerous situation on the should of I95. When the car lost power I got an error message to put the Van into park. The Van is under recall for a fire risk which still hasn't been fixed. This is another issue with the Van. It is currently at Ourisman Chrysler in Clarksville, MD. No answers yet.
NHTSA ODI #11473411
Mileage unknown · Feb 28, 2022
Unknown Or Other
This is in regard to the most recent recall on the 2018 Chrysler Pacific Hybrids. The entire reason that we purchased this vehicle, was so that we did not have to spend money on gas, as well as for the environment. It is unacceptable that we are expected to sit and wait with a major potential fire hazard. We live in a gated comm…
Read full complaint
This is in regard to the most recent recall on the 2018 Chrysler Pacific Hybrids. The entire reason that we purchased this vehicle, was so that we did not have to spend money on gas, as well as for the environment. It is unacceptable that we are expected to sit and wait with a major potential fire hazard. We live in a gated community where we cannot park the vehicle away from our home. We have a short driveway and my 67 year old Mother sleeps in the room RIGHT next to the driveway. We are not okay just accepting this as it is and think it is completely wrong that people just have to "hope it doesn't catch on fire." This is also already the second or third recall on the vehicle.
NHTSA ODI #11454591
Mileage unknown · Jul 29, 2021
Electrical SystemEngineUnknown Or Other
This happened the Day after we purchased the 2018 hybrid Pacifica limited.While Driving the van started to stall out (wouldn’t go when pushing gas) and said shift to P(park) to start. Pulled over turned off the van and restarted it, that didn’t fix the problem. Restarted again and it went back to normal but the check engine ligh…
Read full complaint
This happened the Day after we purchased the 2018 hybrid Pacifica limited.While Driving the van started to stall out (wouldn’t go when pushing gas) and said shift to P(park) to start. Pulled over turned off the van and restarted it, that didn’t fix the problem. Restarted again and it went back to normal but the check engine light is on. Also the battery is dying extremely fast. Within 5 miles it’ll go from 40% to 0%.
NHTSA ODI #11426922
19,826 miles · May 11, 2021
Unknown Or Other
BACKUP CAMERA DOES NOT SHOW AFTER THE DRIVER SHIFTS OUT OF REVERSE.
NHTSA ODI #11416212
Mileage unknown · Mar 24, 2021
Electrical SystemUnknown Or Other
MANUFACTURER (CHRYSLER) MAILED ME A LEGAL NOTICE THAT MY VEHICLE COULD CATCH FIRE AND / OR EXPLODE AT ANYTIME WHETHER PARKED, IDLING OR DRIVING BECAUSE OF A DEFECT IN THE HYBRID BATTERY COMPONENTS (INVERTER). THEY TOLD ME NOT TO PARK NEXT TO ANYTHING OR ANYONE, NOT TO ALLOW MOISTURE OF ANY KIND INTO THE VEHICLE AND TO NOT PARK O…
Read full complaint
MANUFACTURER (CHRYSLER) MAILED ME A LEGAL NOTICE THAT MY VEHICLE COULD CATCH FIRE AND / OR EXPLODE AT ANYTIME WHETHER PARKED, IDLING OR DRIVING BECAUSE OF A DEFECT IN THE HYBRID BATTERY COMPONENTS (INVERTER). THEY TOLD ME NOT TO PARK NEXT TO ANYTHING OR ANYONE, NOT TO ALLOW MOISTURE OF ANY KIND INTO THE VEHICLE AND TO NOT PARK OR STORE IT IN ANY ENCLOSED STRUCTURE LIKE A GARAGE. THEY SAID TO WAIT FOR A FIX FOR THE PROBLEM AS THERE WAS NOT YET RESOLUTION. I RESPONDED TO THEM ASKING FOR A LOANER CAR OR RENTAL AND WAS TOLD NO. IT HAS BEEN ALMOST A YEAR AND STILL NO CHRYSLER DEALERSHIP CAN OFFER A FIX, HOWEVER THEY DID COME OUT WITH A 2020 MODEL THAT WAS BUILT WITHOUT THE PROBLEM. THIS IS A SERIOUS SAFETY RECALL THAT OUR GOVERNMENT SEEMS TO BE IGNORING. I AM LEFT WITH A LEMON I CANNOT SAFELY STORE PARK OR DRIVE. I PAID 55K FOR THIS HYBRID, WAS TOLD I WOULD GET 80 MPG WHEN I ONLY GET 17 MPG AND I HAVE TO WORRY THAT IF MOISTURE GETS INTO THESE HYBRID BATTERY COMPONENTS BY VEHICLE COULD KILL ME OR OTHERS. I LIVE IN WASHINGTON WHERE EVERYTHING IS WET AND WE HAVE TO TAKE FERRIES..: CHRYSLER DOESN'T RESPOND TO MY LETTERS.
NHTSA ODI #11404749
25,000 miles · Aug 24, 2020
Unknown Or Other
I BUY THE NEW CAR ON 2019, THE CAR HAD 25000 MILES , THE FIRST TIME , THE CAR CAN NOT DRIVE SMOOTH , LOOK LIKE SOMETHING IS WRONG, I TOOK THE CAR TO THE DEALER AND THEY CHECKED AND THEY SAID THE CAR IS OK, THE SECOND TIME , I DROVE THE CAR ON 91 FREEWAY FROM WEST TO EAST, THE CAR SHUT DOWN AND CAN NOT MOVE ANYTHING, I CALLED THE…
Read full complaint
I BUY THE NEW CAR ON 2019, THE CAR HAD 25000 MILES , THE FIRST TIME , THE CAR CAN NOT DRIVE SMOOTH , LOOK LIKE SOMETHING IS WRONG, I TOOK THE CAR TO THE DEALER AND THEY CHECKED AND THEY SAID THE CAR IS OK, THE SECOND TIME , I DROVE THE CAR ON 91 FREEWAY FROM WEST TO EAST, THE CAR SHUT DOWN AND CAN NOT MOVE ANYTHING, I CALLED THE TOW COMPANY TO TOW THE CAR TO DEALER MOSS BROS RIVERSIDE, AFTER 4 DAYS THEY FIXED FOR ME , I CAME TO PICKED UP AND DRIVING BACK HOME , ON THE WAY ABOUY 15 MINUTES, THE CAR HAD THE SAME PROBLEM, IT SHUT DOWN AND CAN NOT MOVE ANYTHING , IT HAPPENED ON 60 FREEWAY FROM WEST TO EAST, I CALLED THE TOW COMPANY AGAIN TO THE DEALER MOSS BROSS MORENO VALLEY, THE CAR STAYED THERE 3 DAYS AND THEY CALLED ME THAT THEY CAN NOT FIX THE CAR, AND THEY TOLD ME THAT HELP TO MOVE THE CAR OTHER DEALER TO FIX IT, I HAVE TO CALL THE TOW COMPANY AGAIN TO MOVE THE CAR FROM MOSS BROSS MORENO VALLEY TO MOSS BROSS RIVERSIDE AGAIN, THE CAR STAYED THERE 10 DAYS ALREADY UNTIL TODAY ON 08/24/2020 BUT THEY TOLD ME THAT THEY DONT KNOW WHAT HAPPENED FOR THE CAR, AND THEY DO NOT FIX FOR ME, THE CAR STAYED IN THE DEALER ALMOST A MONTH BUT THEY DONT FIX FOR ME , THE CAR STILL HAVE UNDER WARRANTY, BUT THEY DONT FIX ANYTHING FOR ME AND THE CAR HAD 3 TIMES PROBLEMS THE SAME THINGS, EVERYTIME I HAD THE BABY IN THE CAR WITH ME , AND EVERY TIME PROBLEMS I ALSO CALLED THE 911 COME TO HELP ME BECAUSE IT TOOK AROUND 5 HOURS FOR THE TOWING COMPANY COMING TO MOVE THE CAR, PLEASE HELP ME, I DONT KNOW WHAT CAN I DO
NHTSA ODI #11350923
Mileage unknown · Jul 30, 2020
Unknown Or Other
IT LOOKS LIKE THE VEHICLE'S 12-VOLT ISOLATOR POST IS COMPROMISED AND NEEDS SOME WORK. THE DEALER ASKED ME TO LEAVE THE VEHICLE FOR 1 WEEK OR MORE TILL THEY CAN RECTIFY THE PROBLEM. I ASKED THE DEALER TO GIVE ME A LOANER VEHICLE. THEY THEN SAID THAT THEY DON'T HAVE LOANER VEHICLE. ONCE WHEN THE LOANER VEHICLE IS AVAILABLE THEY WI…
Read full complaint
IT LOOKS LIKE THE VEHICLE'S 12-VOLT ISOLATOR POST IS COMPROMISED AND NEEDS SOME WORK. THE DEALER ASKED ME TO LEAVE THE VEHICLE FOR 1 WEEK OR MORE TILL THEY CAN RECTIFY THE PROBLEM. I ASKED THE DEALER TO GIVE ME A LOANER VEHICLE. THEY THEN SAID THAT THEY DON'T HAVE LOANER VEHICLE. ONCE WHEN THE LOANER VEHICLE IS AVAILABLE THEY WILL CALL ME. UNTIL THEN THEY SAID I CAN TAKE THE RISK AND DRIVE THE VEHICLE. I CALLED FIAT CHRYSLER RECALL LINE TO COMPLAINT. THEY SAID THAT THE DEALER IS NOT DOESN'T HAVE TO GIVE THE LOANER VEHICLE HOWEVER LONG THEY KEEP MY VEHICLE FOR REPAIR. THEY ALSO MENTIONED THAT THE FINAL REPAIR IS ALSO THERE WHEN IT IS CLEARLY STATED IN NHTSA WEBSITE IT IS NOT AVAILABLE. THEY PUT ME ON HOLD FOR 2 HOURS TO SPEAK TO THE SUPERVISOR WITH STILL NO SUPERVISOR TO SPEAK TO. THE NOTICE THAT CHRYSLER SENT ME CLEARLY STATES THAT THE LOANER VEHICLE WILL BE GIVEN AND THE NOTE IN THE NHTSA WEBSITE SAYS THAT THE LOANER VEHICLE WILL BE GIVEN. THE DEALER SAYS THAT THE RECALL IS NOT A BIG DEAL AND THE CHRYSLER ALSO DOESN'T SEEMS TO BE WORRIED ABOUT IT. THIS IS A VERY CALLOUS ATTITUDE FROM BOTH THE DEALER AND THE COMPANY.
NHTSA ODI #11342423
4,500 miles · Jun 17, 2020
Electrical SystemUnknown Or Other
SINCE DECEMBER 2018, WE HAD TO REPLACE THE BATTERY 3 TIMES SINCE THE VEHICLE SHUT OFF WHILE DRIVING ON THE HIGHWAY. THERE WAS SMOKE SMELL COMING FROM THE ENGINE. THE VEHICLE WAS TOWED AND PROBLEMS CORRECTED, BUT THE ENGINE LIGHT HAS BEEN COMING ON MORE THAN 3 OCCASIONS. THE GPS SYSTEM HAS NOT BEEN WORKING SINCE MARCH 2020, BU…
Read full complaint
SINCE DECEMBER 2018, WE HAD TO REPLACE THE BATTERY 3 TIMES SINCE THE VEHICLE SHUT OFF WHILE DRIVING ON THE HIGHWAY. THERE WAS SMOKE SMELL COMING FROM THE ENGINE. THE VEHICLE WAS TOWED AND PROBLEMS CORRECTED, BUT THE ENGINE LIGHT HAS BEEN COMING ON MORE THAN 3 OCCASIONS. THE GPS SYSTEM HAS NOT BEEN WORKING SINCE MARCH 2020, BUT THEY ARE NOT ABLE TO FIX THE ISSUES. OUR LOCAL DEALERSHIP SAYS THAT CHRYSLER HAS NOT RESPONDED TO THEIR MULTIPLE REQUESTS FOR THE RADIO REPLACEMENT. *TR
NHTSA ODI #11329430
4,500 miles · Sep 4, 2019
Electrical SystemPower TrainUnknown Or Other
ON AUGUST 7, WHILE I WAS DRIVING ON A STATE HIGHWAY, AROUND 30 MPH, MY VAN SUDDENLY STOPPED AND WOULD NOT START AGAIN. I WAS STUCK IN THE MIDDLE OF THE ROAD FOR ABOUT 5 MINUTES WHILE THE CAR MADE NOISES AND THE CHECK ENGINE LIGHTS AND OTHER DASHBOARD WARNINGS FLASHED. AFTER A FEW MINUTES I WAS ABLE TO RESTART MY CAR TO MOVE IT T…
Read full complaint
ON AUGUST 7, WHILE I WAS DRIVING ON A STATE HIGHWAY, AROUND 30 MPH, MY VAN SUDDENLY STOPPED AND WOULD NOT START AGAIN. I WAS STUCK IN THE MIDDLE OF THE ROAD FOR ABOUT 5 MINUTES WHILE THE CAR MADE NOISES AND THE CHECK ENGINE LIGHTS AND OTHER DASHBOARD WARNINGS FLASHED. AFTER A FEW MINUTES I WAS ABLE TO RESTART MY CAR TO MOVE IT TO A SAFE LOCATION. MY "MICROMECHANIC" ENGINE LIGHT READER GAVE ME CODES U0401 AND U0100, LOST COMMUNICATION WITH ECM/PCM AND INVALID DATA RECEIVED FROM ECM/PCM- AND SAID THE CAR WAS UNSAFE TO DRIVE. I HAD IT TOWED TO THE DEALERSHIP. AFTER ABOUT A WEEK, THE DEALERSHIP SAID THEY REBOOTED THE COMPUTER AND TEST DROVE THE CAR ABOUT 15 MILES AND IT WAS WORKING AGAIN. THEY SAID IT WAS SAFE FOR ME TO DRIVE AND HAD ME PICK IT UP. I HAD THE CAR BACK FOR 10 DAYS. ON AUGUST 22, I WAS ATTEMPTING TO LEAVE WORK. THE CAR WAS STATIONARY IN THE PARKING GARAGE. WHEN I STARTED MY CAR, THE SAME THING HAPPENED - IT BEGAN FLASHING AND BEEPING. I WAS UNABLE TO TURN THE CAR OFF OR MOVE THE CAR. WHEN I PUSHED THE IGNITION BUTTON INSTEAD OF TURNING THE CAR OFF IT WOULD RE-CYCLE AND BEGIN BEEPING AGAIN. I RAN THE MICROMECHANIC AND IT GAVE ME THE SAME CODES U0100 AND U0401 DEALING WITH ECM AND PCM. I HAD TO STAY WITH THE CAR 2.5 HOURS TO WAIT FOR THE TOW TRUCK AND THE ENTIRE TIME IT BEEPED AND FLASHED - I WAS UNABLE TO TURN IT OFF. I HAD IT TOWED BACK TO THE SAME DEALERSHIP, WHERE IT STILL IS CURRENTLY. BOTH TIMES THIS OCCURRED THE CAR WAS NOT CHARGED ELECTRICALLY BUT HAD GASOLINE FUEL.
NHTSA ODI #11253240
16,000 miles · Jul 23, 2019
EnginePower TrainUnknown Or Other
METALLIC BUZZING / VIBRATION DURING MODERATE ACCELERATION. OCCURS OCCASIONALLY AROUND 30 TO 35 MPH BUT ALSO AT HIGHER SPEEDS. VEHICLE HAS BEEN AT DEALERSHIP MULTIPLE TIMES WHERE THE BELLY HEAT SHIELD WAS REPLACED, ROCKS WERE REMOVED FROM THE HEAT SHIELD, UNDERCARRIAGE WAS INSPECTED AND PARTS SECURED, AND MOST RECENTLY THE ENTIRE…
Read full complaint
METALLIC BUZZING / VIBRATION DURING MODERATE ACCELERATION. OCCURS OCCASIONALLY AROUND 30 TO 35 MPH BUT ALSO AT HIGHER SPEEDS. VEHICLE HAS BEEN AT DEALERSHIP MULTIPLE TIMES WHERE THE BELLY HEAT SHIELD WAS REPLACED, ROCKS WERE REMOVED FROM THE HEAT SHIELD, UNDERCARRIAGE WAS INSPECTED AND PARTS SECURED, AND MOST RECENTLY THE ENTIRE TRANSMISSION WAS REPLACED. ALL OF THE WORK HAS BEEN PERFORMED UNDER WARRANTY AS THE VEHICLE ONLY JUST PASSED 20,000 MILES. EVEN AFTER THE TRANSMISSION WAS REPLACED THE BUZZING SOUND CONTINUES AS BEFORE RESULTING IN ANOTHER TRIP TO THE DEALER. THERE HAVE BEEN NO ISSUES WITH THE OPERATION OF THE VEHICLE YET BUT I AM CONCERNED THAT THE BUZZING / VIBRATION IS INDICATIVE OF A FUTURE ISSUE THAT WOULD RENDER THE VEHICLE INOPERABLE.
NHTSA ODI #11234147
Official recalls
6Jul 18, 2024
Chrysler (FCA US, LLC) is recalling certain 2017-2018 Pacifica Plug-In Hybrid Electric (PHEV) vehicles that received a software update remedy under NHTSA recall number 22V-077. The battery pack may cause a vehicle fire when parked, even with the ignition in the "Off" position.
Consequence & remedy
Consequence: A vehicle fire increases the risk of injury.
Remedy: Owners are advised not to charge their vehicles, and to park outside and away from structures, until they are repaired. Dealers will update the high voltage battery pack control module (BPCM) software. In addition, dealers will inspect and if necessary, replace the battery pack assembly. Repairs will be performed free of charge. Interim notification letters, notifying owners of the safety risk, were mailed August 1, 2024. Owner notification letters were mailed December 12, 2024. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is 73B. Vehicles previously repaired under recall 22V-077 will need to have the new remedy completed.
Feb 11, 2022
Chrysler (FCA US, LLC) is recalling certain 2017-2018 Pacifica Plug-In Hybrid Electric Vehicles (PHEV). A vehicle fire can occur when parked, even with the ignition in the "Off" position.
Consequence & remedy
Consequence: A vehicle fire increases the risk of injury.
Remedy: Owners are advised not to recharge their vehicles, and to park outside and away from structures, until they are repaired. Dealers will update the high voltage battery pack control module (BPCM) software. In addition, dealers will inspect and if necessary, replace the battery pack assembly. Repairs will be performed free of charge. Interim letters, informing owners of the safety risk were mailed on February 25, 2022. Final owner notification letters were mailed October 6, 2022. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is Z11. This recall is superseded by NHTSA recall 24V-538.
Jun 9, 2020
Chrysler (FCA US LLC) is recalling certain 2017-2020 Pacifica Plug-in Hybrid Electric Vehicles ("PHEV"). The 12 volt isolator post located behind the driver's seat may develop high resistance.
Consequence & remedy
Consequence: A high resistance electrical connection may result in the connection overheating, increasing the risk of a fire with the vehicle on or off.
Remedy: FCA will conduct a voluntary safety recall on affected vehicles to increase the torque and install a waterproof gasket to the 12v isolator post, the post will also be inspected for signs of contamination. In the event the post is compromised, the 12v isolator post and associated cables will be replaced. Until the final remedy is available, customers should bring their vehicles to dealers for an interim inspection of this joint. The recall remedy is currently under development. FCA US LLC will notify owners, and dealers will perform an interim inspection of this joint. If the inspection indicates the joint is compromised, owners will receive a loaner vehicle, until a final remedy is developed. Interim notifications are expected to begin around June 22, 2020. The recall began July 30, 2020. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is W46. Note: Consumers are advised to exercise the following precautions until the vehicle has the final repair completed: do not park these vehicles inside of buildings or structures, or near other vehicles. Additionally, keep liquids out of the backseat area, including but not limited to beverages, wet items, umbrellas, or bottled liquids that may leak.
Additional source detail variants (2)
Electrical System:wiring:interior/under Dash
Chrysler (FCA US LLC) is recalling certain 2017-2020 Pacifica Plug-in Hybrid Electric Vehicles ("PHEV"). The 12 volt isolator post located behind the driver's seat may develop high resistance.
Consequence: A high resistance electrical connection may result in the connection overheating, increasing the risk of a fire with the vehicle on or off.
Remedy: FCA will conduct a voluntary safety recall on affected vehicles to increase the torque and install a waterproof gasket to the 12v isolator post, the post will also be inspected for signs of contamination. In the event the post is compromised, the 12v isolator post and associated cables will be replaced. Until the final remedy is available, customers should bring their vehicles to dealers for an interim inspection of this joint. The recall remedy is currently under development. FCA US LLC will notify owners, and dealers will perform an interim inspection of this joint. If the inspection indicates the joint is compromised, owners will receive a loaner vehicle, until a final remedy is developed. Interim notifications are expected to begin around June 22, 2020. The recall began July 30, 2020. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is W46. Note: Consumers are advised to exercise the following precautions until the vehicle has the final repair completed: do not park these vehicles inside of buildings or structures, or near other vehicles. Additionally, keep liquids out of the backseat area, including but not limited to beverages, wet items, umbrellas, or bottled liquids that may leak.
Electrical SYSTEM:12V/24V/48V Battery:cables
Chrysler (FCA US LLC) is recalling certain 2017-2020 Pacifica Plug-in Hybrid Electric Vehicles ("PHEV"). The 12 volt isolator post located behind the driver's seat may develop high resistance.
Consequence: A high resistance electrical connection may result in the connection overheating, increasing the risk of a fire with the vehicle on or off.
Remedy: FCA will conduct a voluntary safety recall on affected vehicles to increase the torque and install a waterproof gasket to the 12v isolator post, the post will also be inspected for signs of contamination. In the event the post is compromised, the 12v isolator post and associated cables will be replaced. Until the final remedy is available, customers should bring their vehicles to dealers for an interim inspection of this joint. The recall remedy is currently under development. FCA US LLC will notify owners, and dealers will perform an interim inspection of this joint. If the inspection indicates the joint is compromised, owners will receive a loaner vehicle, until a final remedy is developed. Interim notifications are expected to begin around June 22, 2020. The recall began July 30, 2020. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is W46. Note: Consumers are advised to exercise the following precautions until the vehicle has the final repair completed: do not park these vehicles inside of buildings or structures, or near other vehicles. Additionally, keep liquids out of the backseat area, including but not limited to beverages, wet items, umbrellas, or bottled liquids that may leak.
Feb 28, 2019
Chrysler (FCA US LLC) is recalling certain 2018 Chrysler Pacifica and Pacifica hybrid vehicles. The right front lower control arm may separate from the steering knuckle.
Consequence & remedy
Consequence: A control arm separation could increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the right front knuckle and lower control arm for damage, replacing the components as necessary. The right front lower control arm knuckle pinch bolt will be replaced with a larger-diameter pinch bolt. These repairs will be performed free of charge. The recall began April 26, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V15.
Oct 19, 2018
Chrysler (FCA US LLC) is recalling certain 2017-2018 Chrysler Pacifica Plug-in Hybrid Electric vehicles (PHEV). After the vehicle has been operating in PHEV propulsion mode, the gas-fueled engine may not restart properly resulting in unburned fuel entering the exhaust catalyst.
Consequence & remedy
Consequence: The improperly started engine could result in a loss of motive power increasing the risk of a crash or the unburned fuel in the catalyst may ignite increasing the risk of a fire.
Remedy: FCA will notify owners, and dealers will update the powertrain controller module software, and inspect and replace the catalytic converter as necessary, free of charge. The recall began November 15, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U94.
Additional source detail variants (2)
Hybrid Propulsion System
Chrysler (FCA US LLC) is recalling certain 2017-2018 Chrysler Pacifica Plug-in Hybrid Electric vehicles (PHEV). After the vehicle has been operating in PHEV propulsion mode, the gas-fueled engine may not restart properly resulting in unburned fuel entering the exhaust catalyst.
Consequence: The improperly started engine could result in a loss of motive power increasing the risk of a crash or the unburned fuel in the catalyst may ignite increasing the risk of a fire.
Remedy: FCA will notify owners, and dealers will update the powertrain controller module software, and inspect and replace the catalytic converter as necessary, free of charge. The recall began November 15, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U94.
Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor
Chrysler (FCA US LLC) is recalling certain 2017-2018 Chrysler Pacifica Plug-in Hybrid Electric vehicles (PHEV). After the vehicle has been operating in PHEV propulsion mode, the gas-fueled engine may not restart properly resulting in unburned fuel entering the exhaust catalyst.
Consequence: The improperly started engine could result in a loss of motive power increasing the risk of a crash or the unburned fuel in the catalyst may ignite increasing the risk of a fire.
Remedy: FCA will notify owners, and dealers will update the powertrain controller module software, and inspect and replace the catalytic converter as necessary, free of charge. The recall began November 15, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U94.
Aug 9, 2018
Chrysler (FCA US LLC) is recalling certain 2018 Jeep Renegade, Compass and Grand Cherokee, RAM 1500 and Promaster, Fiat 500x, Dodge Journey, Challenger, Charger and Durango and Chrysler 300x vehicles, 2017-2018 Jeep Wrangler, Dodge Grand Caravan and Chrysler Town and Country vehicles and 2018-2019 Jeep Cherokee and 2018 Chrysler Pacifica and Pacifica Hybrid vehicles. The powertrain control module may be equipped with a voltage regulator chip in the circuit board that may fail, causing a stall or a no start condition.
Consequence & remedy
Consequence: A vehicle stall can increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the powertrain control module, free of charge. The recall began October 2, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U87.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE24028 · Electrical Arcing And Thermal Events, Potentially Leading To Fires, While Utilizing Enel X Way Usa, Llc's Juicebox Residential Charger.
Opened Oct 3, 2024 · Closed Jun 5, 2025
Status: closed (inferred from source dates) · Equipment:electrical
On October 3, 2024, the Office of Defects Investigations (ODI) opened PE24028 to investigate alleged failures of Enel X Way's JuiceBox Level 2 residential EV chargers. The allegations were described as thermal incidents and electrical malfunctions, which could trip the circuit breakers in Juicebox owners’ homes and disrupt electric vehicle charge cycles. On October 2, 2024, Enel X Way posted on its website that Enel X Way North America would cease operations in the United States and Canada on October 11, 2024. The closure would potentially impact the charging app and supporting software. ODI sent Enel X Way an Information Request (IR) letter on October 21, 2024. Enel X Way provided an incomplete response to the IR on December 9, 2024. Enel X Way later provided a complete response to the IR on January 24, 2025. ODI reviewed Enel X Way’s IR submissions to determine whether further action is required. Based on ODI’s analysis, there was no clear trend in the cause of the failures described in customer complaints and warranty reports. Additionally, there have been no recent reports alleging safety issues. The available information does not warrant further action at this time. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency will continue to monitor for any safety trends and reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in this Closing Resume, go to NHTSA.gov.
RQ24004 · Loss Of Motive Power Due To An Internal Wiring Connector Short.
Opened Feb 27, 2024 · No close date supplied
Status: open (inferred from source dates) · Electrical System:wiring
On July 22, 2022, the Office of Defects Investigation (ODI) opened investigation PE22-008 regarding complaints alleging a loss of motive power condition potentially due to a transmission malfunction in Model Years 2019-2021 Chrysler Pacifica Plug-In Hybrid Electric Vehicles (PHEV). On January 17, 2023, Fiat Chrysler Automobiles (FCA) issued safety recall (NHTSA Recall 23V-010) involving 2017-2023 Model Years (MY) Pacifica Plug-In Hybrid Electric Vehicles (PHEV) produced between August 12, 2016, through January 9, 2023. The recall states that the loss of motive power condition in these vehicles is caused by an internal transmission wiring connector that may short circuit, resulting in an unexpected engine shutdown. An unexpected engine shutdown can cause a loss of drive power, increasing the risk of a crash. In discussions with FCA on Recall 23V-010, ODI confirmed the recall was related to investigation PE22-008. The remedy for 23V-010 is to update the Power Inverter module (PIM) and/or Instrument Panel Cluster (IPC) software to provide drivers a message stating “Stop Safely - Vehicle Will Shut Off Soon” followed by a chime and MIL, PRNDL blinking (on cluster and shifter knob), low SOC (State of Charge) warning and reduced power mode. The recall remedy does not replace the defective hardware that was described in Recall 23V-010, and the wiring connector short still exists on these vehicles. To date, ODI has received 132 reports for the population of vehicles subject to recall 23V-010. These reports allege a loss of motive power condition that reduces the vehicles speed, followed by dashboard warning lamps displaying messages associated with recall 23V-010. The presence of these warning lamps and messages indicates the vehicle likely had the recall remedy applied. Follow up discussions with FCA confirm their remedy does not prevent a loss of motive power, but instead limits torque to the engine and after an unspecified number of miles or period of time, the engine will shut down. When this occurs, FCA relies on the owner to transport the vehicle to a dealership after they experience a loss of motive power condition, at which time the defective hardware is replaced. Furthermore, the dashboard messages introduced in the recall remedy may cause the driver to pull over in an unsafe location. Pulling over in an unsafe location may expose the occupants to undue harm. The Office of Defects Investigation is opening this Recall Query (RQ) to assess the adequacy, frequency, and safety consequence of the remedy for recall 23V-010. To review the ODI reports cited in the opening resume ODI report identification number document, go to NHTSA.gov.
RQ24001 · Ignition-off High Voltage Battery Fire (remedy Effectiveness Of Recall 22V-077)
Opened Jan 16, 2024 · No close date supplied
Status: open (inferred from source dates) · Electrical System:propulsion System:traction Battery
On February 11, 2022, Fiat Chrysler Automobiles (FCA) issued a safety recall (NHTSA Recall 22V-077) on all 2017-2018 Pacifica Plug-In Hybrid Electric Vehicles (PHEV) produced between August 12, 2016 through August 7, 2018. The recall addresses ignition “OFF’ fires that originate at the high voltage (HV) battery pack assembly. An ignition ‘OFF’ vehicle fire can result in an increased risk of occupant injury, injury to persons outside the vehicle, and property damage, with little to no warning. At the time of the recall filing the root cause of the vehicle fires was unknown and under investigation by FCA and suppliers. A software remedy designed to improve thermal event detectability by monitoring battery diagnostics is currently being installed on subject vehicles as an interim remedy. As of November 23, 2023, the root cause of the battery failure is unknown. From December 2022 through December 2023, NHTSA has received four consumer complaints (VOQs) alleging vehicle thermal events involving recalled 2017 and 2018 Chrysler Pacifica PHEVs. Additional information collected from complainants confirmed a thermal event originating near or at the HV battery pack after the Recall 22V077 remedy had been applied to the vehicle. Follow up meetings with FCA and suppliers in November and December 2023 to discuss the ongoing root cause investigation and post-recall remedy incidents indicated a recent increase in HV battery thermal events. Furthermore, a review of NHTSA complaint data indicated the post-recall HV battery thermal event complaint rate now exceeds pre-recall levels. The Office of Defects Investigation (ODI) is opening this Recall Query (RQ) to review the effectiveness of the original recall remedy, understand the root cause of the battery fires, investigate additional reports of Pacifica PHEV HV battery fires, and to increase monitoring of the manufacturer root cause investigation. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE22008 · Transmission Fault Leading To Loss Of Motive Power
Opened Jul 22, 2022 · Closed Mar 27, 2024
Status: closed (inferred from source dates) · Power Train
On July 22, 2022, the Office of Defects Investigation (ODI) opened PE22008 to investigate allegation of loss of motive power, potentially due to transmission malfunction, in certain Chrysler Pacifica vehicles. In a January 17, 2023 letter to NHTSA, Fiat Chrysler Automobiles (FCA) submitted recall notice 23V-010 involving a transmission motor wiring defect in 67,118 model year (MY) 2017-2023 Chrysler Pacifica plug-in hybrid electric vehicles (PHEVs) manufactured from August 12, 2016 through January 9, 2023. FCA determined that an internal transmission connector short could result in an unexpected engine shutdown under certain conditions. Follow up correspondence with FCA confirmed this defect results in an electric motor position trouble code that was the basis for opening PE22008, therefore NHTSA is closing this investigation. The 23V-010 recall remedy is a software update to address the hardware failure associated with PE22008. When a hardware failure is detected, the vehicle limits motive power while instructing the driver to pull over to a safe location. NHTSA is concerned that drivers will pull over to an unsafe location when the warning message associated with the recall remedy displays on the dashboard. Due to the nature of the recall remedy and related reports, NHTSA has opened Recall Query RQ24004 to assess the recall remedy. The reports and failure report summary values included with this closing action are related to allegations of Recall 23V-010 remedy inadequacy. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration