NHTSA owner reports · September 18, 2026 snapshot.
Unknown Or Other complaints
34 reportsClear category filterMileage unknown · Mar 17, 2025
Electrical SystemUnknown Or OtherVehicle Speed Control
I was traveling at south bound on TOLL 130 going 80MPH (which is the speed limit on that road) when my Pacifica immediately slowed down and my accelerator gave out. In addition to my dash flashing that the cruise control was no longer available, but the van also said "Service Charging System" and "Shift to P to Start", the engin…
Read full complaint
I was traveling at south bound on TOLL 130 going 80MPH (which is the speed limit on that road) when my Pacifica immediately slowed down and my accelerator gave out. In addition to my dash flashing that the cruise control was no longer available, but the van also said "Service Charging System" and "Shift to P to Start", the engine light and batter light both came on. I am sure that I almost died as I was in the middle lane and cars were whipping around me since I had slowed down so much, there was an 18 wheeler behind me and one of my righthand side, which is the shoulder I was trying to get to. I was finally able to coast to the shoulder and came to a stop, put the car in park and turned it off. I immediately started researching what the problem could be and I was alarmed to find out that this is an issue that others have had and that Chrysler has failed to issue a recall...I was able to start the car once more and get on to a little back road, after pushing through a barricade off the toll just for safety's sake, and my van broke down again, this time on a little 2 lane road, which thankfully had a little bit of a gravel shoulder. This time, my van took quite a bit longer to get started, but I was not safe where I was. I started it once more and was able to get to a Wal-Mart parking lot where my brother-in-law picked me up so that I could have a chance of making it to see my grandmother who was on her deathbed, I missed my window of opportunity to make it to see her, she died that afternoon. I had to pay an additional tow fee to get the vehicle moved from the parking lot to a Chrysler dealership since it was so far from where I usually go.
NHTSA ODI #11648682
Mileage unknown · Jan 28, 2025
Electrical SystemEngineUnknown Or Other
Vehicle states "Stop Safely Vehicle Will Shut Off Soon" with a red turtle logo. I have restarted the vehicle, and the warning persists. I am bringing in the car to the dealer next.
NHTSA ODI #11639047
Mileage unknown · Oct 22, 2024
Unknown Or Other
The unresolved recall with no remedy stems from an earlier recall is entering its fourth month with no further communications from the manufacturer about the status of the remedy. There has been no compensation provided to car owners with increased carrying costs due to the manufacturing failures, decreased car valuation due to…
Read full complaint
The unresolved recall with no remedy stems from an earlier recall is entering its fourth month with no further communications from the manufacturer about the status of the remedy. There has been no compensation provided to car owners with increased carrying costs due to the manufacturing failures, decreased car valuation due to repeated failed attempts to remedy the same recall, nor indirect costs of extended stress and fear. I am unable to park my car by my house due to the fire risk, which has required me to buy monthly parking passes. I am unable to charge my car, which has caused increased gas costs. I previously paid to install a level 2 charger in my home, which I am unable to use. Additionally a concerning electrical noise has started to occur when starting the car or long after turning the car off. I am continually anxious about driving this car with my children, but I have no other choice to continually put all of us at risk. Jul 18,2024 Manufacturer Recall Number73B NHTSA Recall Number24V-536 Recall Status Recall Incomplete, remedy not yet available
NHTSA ODI #11621331
Mileage unknown · Jul 8, 2024
Electrical SystemEngineUnknown Or Other
I was driving with my family on the interstate and was exiting when the car shuddered and I lost propulsion. Interior electrical power was still functional. This occurred as the car was switching to gas mode as I had been been driving about 30-35 miles on electric at that point. The gas motor never came on. I was able to roll…
Read full complaint
I was driving with my family on the interstate and was exiting when the car shuddered and I lost propulsion. Interior electrical power was still functional. This occurred as the car was switching to gas mode as I had been been driving about 30-35 miles on electric at that point. The gas motor never came on. I was able to roll into a gas station since we were on a bit of a downhill. Shut off car and waited a beat then started car again, battery showed 1% and was able to pull 2 more feet into gas station and off to side before it completely died again (battery at 0%). I feel extremely fortunate that this didn't happen a moment earlier when I was on the expressway and that were able to get off of a busy road. I had the vehicle towed to nearest Chrysler dealer and had a friend drive me and my family to a nearby car rental place. After two weeks at the dealer, we were informed that the issue was likely the Power Inverter Module. We are still without car and waiting for updates from service department.
NHTSA ODI #11600061
Mileage unknown · Sep 13, 2023
Electrical SystemPower TrainUnknown Or Other
In March my van stalled as I was turning through a busy intersection with my child in the front seat. We narrowly avoided being t-boned. For a second the dash lit up with lights and then it said to shift to park to start vehicle but I couldn't shift. After finally getting it in neutral some good samaritans helped me push it out …
Read full complaint
In March my van stalled as I was turning through a busy intersection with my child in the front seat. We narrowly avoided being t-boned. For a second the dash lit up with lights and then it said to shift to park to start vehicle but I couldn't shift. After finally getting it in neutral some good samaritans helped me push it out of the intersection and while I sat off to the side, after about 15 minutes of getting out and checking under the hood, the car started. We used our own code reader and it threw the PoA79 code. We brought it to Lewisville with an appointment, told them about the stall and they did the Z11 recall work for the fire risk with the battery but say there are no issues with the battery and no codes, but they have us ready for the recall work on Loss of Motive Power as soon as the recall work is available because loss of power is a known issue. They think my stall is related to the recall and needs a software update so hold off. Pick the van up after Easter. 3 months later it stalls again, this time with my child and husband on the freeway! After about 10 minutes of everything flashing, it starts again just as it did before, and the CEL clears. We call and are told that the Loss of Motive Power recall O3A process is now out for the 2018. We have never noticed an unexpected loss of charge. We were charging outside and far from our house, per the recall. No lobster popping up. Make an appointment for the O3A recall work and the van stalls on the way. This time it doesn't restart As I understand it, the transmission issue is that transmission case castings causes the high voltage wires to chafe and short out. We are told that we do not have a transmission or a battery issue, it is the On Board Charging Module has internal damage. They are unable to explain how a van that was at 95% charge and with a 12V that showed it wasn't depleted now has an internally damaged OBCM. And they don't know if that is the fundamental underlying problem with stalls.
NHTSA ODI #11544424
Mileage unknown · Mar 29, 2023
Electrical SystemEngineUnknown Or Other
Check engine light stays on and car does not charge. Both recalls were done at the dealership
NHTSA ODI #11514439
Mileage unknown · Feb 23, 2023
Electrical SystemEngineUnknown Or Other
While driving at a low speed in a neighborhood, received the message "Service Charging System" then within seconds car completely died. No engine power or electrical systems working, all lights and screens were black. Was able to pull over and park safely.
NHTSA ODI #11508762
Mileage unknown · Nov 20, 2022
Fuel/propulsion SystemPower TrainUnknown Or OtherFire
I was driving on the highway when the check engine light came on and it started running rough. I pulled off the highway and into a parking lot. When I slowed down, I heard a clanging that sounded like metal on metal. After parking, smoke started pouring out from under the hood and it erupted in flames. The vehicle was destroyed.…
Read full complaint
I was driving on the highway when the check engine light came on and it started running rough. I pulled off the highway and into a parking lot. When I slowed down, I heard a clanging that sounded like metal on metal. After parking, smoke started pouring out from under the hood and it erupted in flames. The vehicle was destroyed.
NHTSA ODI #11494293
Mileage unknown · Oct 28, 2022
Electrical SystemSteeringUnknown Or Other
I was driving on a local road and car suddenly stopped running; accelarator unresponsive; power steering not working either. I was able to pull to side. Car said shift P to start , gear change didn't do anything and blinking, check engine light came up. And “check charging system” light came on. It was very dangerous. After 3…
Read full complaint
I was driving on a local road and car suddenly stopped running; accelarator unresponsive; power steering not working either. I was able to pull to side. Car said shift P to start , gear change didn't do anything and blinking, check engine light came up. And “check charging system” light came on. It was very dangerous. After 3-4 minutes I was able to get my car turn off and on and then it drove normal. So I decided to take it in nearby open parking area. It would restart but not do anything even if switched into drive or reverse. Check charging system light on and no power steering again. I had to get it to get it towed the next day from that lot. First tow truck unable to tow due to steering being locked. 2nd tow truck needed help to move car due to steering. Been at dealer for 30 days. They changed charging port but it didn’t work. Now they are changing battery. I don’t want this car back and don’t want to keep making payments on it either. It’s not a safe car.
NHTSA ODI #11491259
Mileage unknown · Aug 9, 2022
Electrical SystemPower TrainUnknown Or Other
2108 Hybrid Pacifica stalled a couple of times on freeway on our recent trip . Here are the details : About 2 hours after driving on freeway. - then, dashboard showed few errors and eventually showing "service charging system" - then displaying "shift to P to start" and "D" symbol is flashing. - after this, pacifica van l…
Read full complaint
2108 Hybrid Pacifica stalled a couple of times on freeway on our recent trip . Here are the details : About 2 hours after driving on freeway. - then, dashboard showed few errors and eventually showing "service charging system" - then displaying "shift to P to start" and "D" symbol is flashing. - after this, pacifica van lost power ( pushing accelerating do nothing ) but steering, brake seems OK and I had to steer the car to freeway shoulder and then turn off the car and start again after a few minutes and can start the car again but "engine check light" is on for at least 24 hours after. - After starting again, then a half a hour later, it happened again with same symptoms as above. The car has about 40,000 miles and running in gas mode only. These are very dangerous situation and luckily this time, I had time to steer the Pacifica to a complete stop.
NHTSA ODI #11478423
Official recalls
6Jul 18, 2024
Chrysler (FCA US, LLC) is recalling certain 2017-2018 Pacifica Plug-In Hybrid Electric (PHEV) vehicles that received a software update remedy under NHTSA recall number 22V-077. The battery pack may cause a vehicle fire when parked, even with the ignition in the "Off" position.
Consequence & remedy
Consequence: A vehicle fire increases the risk of injury.
Remedy: Owners are advised not to charge their vehicles, and to park outside and away from structures, until they are repaired. Dealers will update the high voltage battery pack control module (BPCM) software. In addition, dealers will inspect and if necessary, replace the battery pack assembly. Repairs will be performed free of charge. Interim notification letters, notifying owners of the safety risk, were mailed August 1, 2024. Owner notification letters were mailed December 12, 2024. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is 73B. Vehicles previously repaired under recall 22V-077 will need to have the new remedy completed.
Feb 11, 2022
Chrysler (FCA US, LLC) is recalling certain 2017-2018 Pacifica Plug-In Hybrid Electric Vehicles (PHEV). A vehicle fire can occur when parked, even with the ignition in the "Off" position.
Consequence & remedy
Consequence: A vehicle fire increases the risk of injury.
Remedy: Owners are advised not to recharge their vehicles, and to park outside and away from structures, until they are repaired. Dealers will update the high voltage battery pack control module (BPCM) software. In addition, dealers will inspect and if necessary, replace the battery pack assembly. Repairs will be performed free of charge. Interim letters, informing owners of the safety risk were mailed on February 25, 2022. Final owner notification letters were mailed October 6, 2022. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is Z11. This recall is superseded by NHTSA recall 24V-538.
Jun 9, 2020
Chrysler (FCA US LLC) is recalling certain 2017-2020 Pacifica Plug-in Hybrid Electric Vehicles ("PHEV"). The 12 volt isolator post located behind the driver's seat may develop high resistance.
Consequence & remedy
Consequence: A high resistance electrical connection may result in the connection overheating, increasing the risk of a fire with the vehicle on or off.
Remedy: FCA will conduct a voluntary safety recall on affected vehicles to increase the torque and install a waterproof gasket to the 12v isolator post, the post will also be inspected for signs of contamination. In the event the post is compromised, the 12v isolator post and associated cables will be replaced. Until the final remedy is available, customers should bring their vehicles to dealers for an interim inspection of this joint. The recall remedy is currently under development. FCA US LLC will notify owners, and dealers will perform an interim inspection of this joint. If the inspection indicates the joint is compromised, owners will receive a loaner vehicle, until a final remedy is developed. Interim notifications are expected to begin around June 22, 2020. The recall began July 30, 2020. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is W46. Note: Consumers are advised to exercise the following precautions until the vehicle has the final repair completed: do not park these vehicles inside of buildings or structures, or near other vehicles. Additionally, keep liquids out of the backseat area, including but not limited to beverages, wet items, umbrellas, or bottled liquids that may leak.
Additional source detail variants (2)
Electrical System:wiring:interior/under Dash
Chrysler (FCA US LLC) is recalling certain 2017-2020 Pacifica Plug-in Hybrid Electric Vehicles ("PHEV"). The 12 volt isolator post located behind the driver's seat may develop high resistance.
Consequence: A high resistance electrical connection may result in the connection overheating, increasing the risk of a fire with the vehicle on or off.
Remedy: FCA will conduct a voluntary safety recall on affected vehicles to increase the torque and install a waterproof gasket to the 12v isolator post, the post will also be inspected for signs of contamination. In the event the post is compromised, the 12v isolator post and associated cables will be replaced. Until the final remedy is available, customers should bring their vehicles to dealers for an interim inspection of this joint. The recall remedy is currently under development. FCA US LLC will notify owners, and dealers will perform an interim inspection of this joint. If the inspection indicates the joint is compromised, owners will receive a loaner vehicle, until a final remedy is developed. Interim notifications are expected to begin around June 22, 2020. The recall began July 30, 2020. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is W46. Note: Consumers are advised to exercise the following precautions until the vehicle has the final repair completed: do not park these vehicles inside of buildings or structures, or near other vehicles. Additionally, keep liquids out of the backseat area, including but not limited to beverages, wet items, umbrellas, or bottled liquids that may leak.
Electrical SYSTEM:12V/24V/48V Battery:cables
Chrysler (FCA US LLC) is recalling certain 2017-2020 Pacifica Plug-in Hybrid Electric Vehicles ("PHEV"). The 12 volt isolator post located behind the driver's seat may develop high resistance.
Consequence: A high resistance electrical connection may result in the connection overheating, increasing the risk of a fire with the vehicle on or off.
Remedy: FCA will conduct a voluntary safety recall on affected vehicles to increase the torque and install a waterproof gasket to the 12v isolator post, the post will also be inspected for signs of contamination. In the event the post is compromised, the 12v isolator post and associated cables will be replaced. Until the final remedy is available, customers should bring their vehicles to dealers for an interim inspection of this joint. The recall remedy is currently under development. FCA US LLC will notify owners, and dealers will perform an interim inspection of this joint. If the inspection indicates the joint is compromised, owners will receive a loaner vehicle, until a final remedy is developed. Interim notifications are expected to begin around June 22, 2020. The recall began July 30, 2020. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is W46. Note: Consumers are advised to exercise the following precautions until the vehicle has the final repair completed: do not park these vehicles inside of buildings or structures, or near other vehicles. Additionally, keep liquids out of the backseat area, including but not limited to beverages, wet items, umbrellas, or bottled liquids that may leak.
Feb 28, 2019
Chrysler (FCA US LLC) is recalling certain 2018 Chrysler Pacifica and Pacifica hybrid vehicles. The right front lower control arm may separate from the steering knuckle.
Consequence & remedy
Consequence: A control arm separation could increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the right front knuckle and lower control arm for damage, replacing the components as necessary. The right front lower control arm knuckle pinch bolt will be replaced with a larger-diameter pinch bolt. These repairs will be performed free of charge. The recall began April 26, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V15.
Oct 19, 2018
Chrysler (FCA US LLC) is recalling certain 2017-2018 Chrysler Pacifica Plug-in Hybrid Electric vehicles (PHEV). After the vehicle has been operating in PHEV propulsion mode, the gas-fueled engine may not restart properly resulting in unburned fuel entering the exhaust catalyst.
Consequence & remedy
Consequence: The improperly started engine could result in a loss of motive power increasing the risk of a crash or the unburned fuel in the catalyst may ignite increasing the risk of a fire.
Remedy: FCA will notify owners, and dealers will update the powertrain controller module software, and inspect and replace the catalytic converter as necessary, free of charge. The recall began November 15, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U94.
Additional source detail variants (2)
Hybrid Propulsion System
Chrysler (FCA US LLC) is recalling certain 2017-2018 Chrysler Pacifica Plug-in Hybrid Electric vehicles (PHEV). After the vehicle has been operating in PHEV propulsion mode, the gas-fueled engine may not restart properly resulting in unburned fuel entering the exhaust catalyst.
Consequence: The improperly started engine could result in a loss of motive power increasing the risk of a crash or the unburned fuel in the catalyst may ignite increasing the risk of a fire.
Remedy: FCA will notify owners, and dealers will update the powertrain controller module software, and inspect and replace the catalytic converter as necessary, free of charge. The recall began November 15, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U94.
Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor
Chrysler (FCA US LLC) is recalling certain 2017-2018 Chrysler Pacifica Plug-in Hybrid Electric vehicles (PHEV). After the vehicle has been operating in PHEV propulsion mode, the gas-fueled engine may not restart properly resulting in unburned fuel entering the exhaust catalyst.
Consequence: The improperly started engine could result in a loss of motive power increasing the risk of a crash or the unburned fuel in the catalyst may ignite increasing the risk of a fire.
Remedy: FCA will notify owners, and dealers will update the powertrain controller module software, and inspect and replace the catalytic converter as necessary, free of charge. The recall began November 15, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U94.
Aug 9, 2018
Chrysler (FCA US LLC) is recalling certain 2018 Jeep Renegade, Compass and Grand Cherokee, RAM 1500 and Promaster, Fiat 500x, Dodge Journey, Challenger, Charger and Durango and Chrysler 300x vehicles, 2017-2018 Jeep Wrangler, Dodge Grand Caravan and Chrysler Town and Country vehicles and 2018-2019 Jeep Cherokee and 2018 Chrysler Pacifica and Pacifica Hybrid vehicles. The powertrain control module may be equipped with a voltage regulator chip in the circuit board that may fail, causing a stall or a no start condition.
Consequence & remedy
Consequence: A vehicle stall can increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the powertrain control module, free of charge. The recall began October 2, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U87.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE24028 · Electrical Arcing And Thermal Events, Potentially Leading To Fires, While Utilizing Enel X Way Usa, Llc's Juicebox Residential Charger.
Opened Oct 3, 2024 · Closed Jun 5, 2025
Status: closed (inferred from source dates) · Equipment:electrical
On October 3, 2024, the Office of Defects Investigations (ODI) opened PE24028 to investigate alleged failures of Enel X Way's JuiceBox Level 2 residential EV chargers. The allegations were described as thermal incidents and electrical malfunctions, which could trip the circuit breakers in Juicebox owners’ homes and disrupt electric vehicle charge cycles. On October 2, 2024, Enel X Way posted on its website that Enel X Way North America would cease operations in the United States and Canada on October 11, 2024. The closure would potentially impact the charging app and supporting software. ODI sent Enel X Way an Information Request (IR) letter on October 21, 2024. Enel X Way provided an incomplete response to the IR on December 9, 2024. Enel X Way later provided a complete response to the IR on January 24, 2025. ODI reviewed Enel X Way’s IR submissions to determine whether further action is required. Based on ODI’s analysis, there was no clear trend in the cause of the failures described in customer complaints and warranty reports. Additionally, there have been no recent reports alleging safety issues. The available information does not warrant further action at this time. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency will continue to monitor for any safety trends and reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in this Closing Resume, go to NHTSA.gov.
RQ24004 · Loss Of Motive Power Due To An Internal Wiring Connector Short.
Opened Feb 27, 2024 · No close date supplied
Status: open (inferred from source dates) · Electrical System:wiring
On July 22, 2022, the Office of Defects Investigation (ODI) opened investigation PE22-008 regarding complaints alleging a loss of motive power condition potentially due to a transmission malfunction in Model Years 2019-2021 Chrysler Pacifica Plug-In Hybrid Electric Vehicles (PHEV). On January 17, 2023, Fiat Chrysler Automobiles (FCA) issued safety recall (NHTSA Recall 23V-010) involving 2017-2023 Model Years (MY) Pacifica Plug-In Hybrid Electric Vehicles (PHEV) produced between August 12, 2016, through January 9, 2023. The recall states that the loss of motive power condition in these vehicles is caused by an internal transmission wiring connector that may short circuit, resulting in an unexpected engine shutdown. An unexpected engine shutdown can cause a loss of drive power, increasing the risk of a crash. In discussions with FCA on Recall 23V-010, ODI confirmed the recall was related to investigation PE22-008. The remedy for 23V-010 is to update the Power Inverter module (PIM) and/or Instrument Panel Cluster (IPC) software to provide drivers a message stating “Stop Safely - Vehicle Will Shut Off Soon” followed by a chime and MIL, PRNDL blinking (on cluster and shifter knob), low SOC (State of Charge) warning and reduced power mode. The recall remedy does not replace the defective hardware that was described in Recall 23V-010, and the wiring connector short still exists on these vehicles. To date, ODI has received 132 reports for the population of vehicles subject to recall 23V-010. These reports allege a loss of motive power condition that reduces the vehicles speed, followed by dashboard warning lamps displaying messages associated with recall 23V-010. The presence of these warning lamps and messages indicates the vehicle likely had the recall remedy applied. Follow up discussions with FCA confirm their remedy does not prevent a loss of motive power, but instead limits torque to the engine and after an unspecified number of miles or period of time, the engine will shut down. When this occurs, FCA relies on the owner to transport the vehicle to a dealership after they experience a loss of motive power condition, at which time the defective hardware is replaced. Furthermore, the dashboard messages introduced in the recall remedy may cause the driver to pull over in an unsafe location. Pulling over in an unsafe location may expose the occupants to undue harm. The Office of Defects Investigation is opening this Recall Query (RQ) to assess the adequacy, frequency, and safety consequence of the remedy for recall 23V-010. To review the ODI reports cited in the opening resume ODI report identification number document, go to NHTSA.gov.
RQ24001 · Ignition-off High Voltage Battery Fire (remedy Effectiveness Of Recall 22V-077)
Opened Jan 16, 2024 · No close date supplied
Status: open (inferred from source dates) · Electrical System:propulsion System:traction Battery
On February 11, 2022, Fiat Chrysler Automobiles (FCA) issued a safety recall (NHTSA Recall 22V-077) on all 2017-2018 Pacifica Plug-In Hybrid Electric Vehicles (PHEV) produced between August 12, 2016 through August 7, 2018. The recall addresses ignition “OFF’ fires that originate at the high voltage (HV) battery pack assembly. An ignition ‘OFF’ vehicle fire can result in an increased risk of occupant injury, injury to persons outside the vehicle, and property damage, with little to no warning. At the time of the recall filing the root cause of the vehicle fires was unknown and under investigation by FCA and suppliers. A software remedy designed to improve thermal event detectability by monitoring battery diagnostics is currently being installed on subject vehicles as an interim remedy. As of November 23, 2023, the root cause of the battery failure is unknown. From December 2022 through December 2023, NHTSA has received four consumer complaints (VOQs) alleging vehicle thermal events involving recalled 2017 and 2018 Chrysler Pacifica PHEVs. Additional information collected from complainants confirmed a thermal event originating near or at the HV battery pack after the Recall 22V077 remedy had been applied to the vehicle. Follow up meetings with FCA and suppliers in November and December 2023 to discuss the ongoing root cause investigation and post-recall remedy incidents indicated a recent increase in HV battery thermal events. Furthermore, a review of NHTSA complaint data indicated the post-recall HV battery thermal event complaint rate now exceeds pre-recall levels. The Office of Defects Investigation (ODI) is opening this Recall Query (RQ) to review the effectiveness of the original recall remedy, understand the root cause of the battery fires, investigate additional reports of Pacifica PHEV HV battery fires, and to increase monitoring of the manufacturer root cause investigation. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE22008 · Transmission Fault Leading To Loss Of Motive Power
Opened Jul 22, 2022 · Closed Mar 27, 2024
Status: closed (inferred from source dates) · Power Train
On July 22, 2022, the Office of Defects Investigation (ODI) opened PE22008 to investigate allegation of loss of motive power, potentially due to transmission malfunction, in certain Chrysler Pacifica vehicles. In a January 17, 2023 letter to NHTSA, Fiat Chrysler Automobiles (FCA) submitted recall notice 23V-010 involving a transmission motor wiring defect in 67,118 model year (MY) 2017-2023 Chrysler Pacifica plug-in hybrid electric vehicles (PHEVs) manufactured from August 12, 2016 through January 9, 2023. FCA determined that an internal transmission connector short could result in an unexpected engine shutdown under certain conditions. Follow up correspondence with FCA confirmed this defect results in an electric motor position trouble code that was the basis for opening PE22008, therefore NHTSA is closing this investigation. The 23V-010 recall remedy is a software update to address the hardware failure associated with PE22008. When a hardware failure is detected, the vehicle limits motive power while instructing the driver to pull over to a safe location. NHTSA is concerned that drivers will pull over to an unsafe location when the warning message associated with the recall remedy displays on the dashboard. Due to the nature of the recall remedy and related reports, NHTSA has opened Recall Query RQ24004 to assess the recall remedy. The reports and failure report summary values included with this closing action are related to allegations of Recall 23V-010 remedy inadequacy. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration