NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
63 reportsClear category filterMileage unknown · Dec 6, 2021
Electrical SystemEngine
While driving at 60mph, vehicle shut off and would not allow me to accelerate. Error message displayed on speedometer, vehicle must be in park to shift gears. The PRNDL blue LED was flashing as well. Several indicator lights on my dashboard illuminated too. Vehicle has approximately 9300 miles on it. This is a pacifica e-hybri…
Read full complaint
While driving at 60mph, vehicle shut off and would not allow me to accelerate. Error message displayed on speedometer, vehicle must be in park to shift gears. The PRNDL blue LED was flashing as well. Several indicator lights on my dashboard illuminated too. Vehicle has approximately 9300 miles on it. This is a pacifica e-hybrid. After pulling off the road I was able to restart and the van worked in “limp home” mode with the red turtle displayed. I then limped the van to a gas station, shut off the van, topped off the fuel tank which had been at 1/4 full, and after a few minutes restarted. After restart, only the yellow check engine light was displayed and the van operated normal. I have read a safety recall exists but Chrysler is saying it is not an active recall for my specific VIN even though I am experiencing the same problems as other owners. I am pretty sure it is associated with one of: 19V348000, 18V049000, or 18V524000. The dealer won’t repair this under recall since all my “active recalls” have been fixed. I can’t drive the vehicle safely but how can I get it fixed if Chrysler won’t repair the issue I am having. With no error codes saved, the dealer said unless it replicates while they have it they won’t be able to diagnose.
NHTSA ODI #11442778
Mileage unknown · Jul 31, 2021
EnginePower TrainVehicle Speed Control
Picked up Vehicle from Bayside Chrysler Dodge Jeep Ram of Annapolis after we were told the problems were addressed. After driving about 50 miles home parking than driving the Van again about 5 miles, In the center lane of the road driving about 45 mph the van said "Shift to P to start". The van wouldn't accelerate forcing my wif…
Read full complaint
Picked up Vehicle from Bayside Chrysler Dodge Jeep Ram of Annapolis after we were told the problems were addressed. After driving about 50 miles home parking than driving the Van again about 5 miles, In the center lane of the road driving about 45 mph the van said "Shift to P to start". The van wouldn't accelerate forcing my wife to drift to the shoulder of the road. The van was turned off and attempted to turn back on, but the Van would not turn completely on to drive. After about five minutes the van was able to be restarted and turned on. The check engine light came on, the van was driven to Auto zone to have the check engine light read. "Power Train System - P0BFD" & " Secondary DTC".
NHTSA ODI #11427310
Mileage unknown · Jul 29, 2021
Electrical SystemEngineUnknown Or Other
This happened the Day after we purchased the 2018 hybrid Pacifica limited.While Driving the van started to stall out (wouldn’t go when pushing gas) and said shift to P(park) to start. Pulled over turned off the van and restarted it, that didn’t fix the problem. Restarted again and it went back to normal but the check engine ligh…
Read full complaint
This happened the Day after we purchased the 2018 hybrid Pacifica limited.While Driving the van started to stall out (wouldn’t go when pushing gas) and said shift to P(park) to start. Pulled over turned off the van and restarted it, that didn’t fix the problem. Restarted again and it went back to normal but the check engine light is on. Also the battery is dying extremely fast. Within 5 miles it’ll go from 40% to 0%.
NHTSA ODI #11426922
Mileage unknown · Jul 7, 2021
EngineFuel/propulsion SystemVehicle Speed Control
This is the third and fourth time we have had this issue with our van. The previous two times were on May 25, 2019 and June 4, 2021. In this incident, my wife was driving our van with our two kids and I down Northwest Highway in Arlington Heights, IL. We were going about 35 miles per hour when several alarms and warnings appeare…
Read full complaint
This is the third and fourth time we have had this issue with our van. The previous two times were on May 25, 2019 and June 4, 2021. In this incident, my wife was driving our van with our two kids and I down Northwest Highway in Arlington Heights, IL. We were going about 35 miles per hour when several alarms and warnings appeared on the driver’s dashboard including 'SERVICE HYBRID SYSTEM', a red wrench with a red lightning bolt through it, the orange engine warning light, and red battery warning icon, and a message appeared saying 'SHIFT VEHICLE TO PARK'. (See attached photos.) When my wife pressed the accelerator pedal nothing happened. We were able to coast and turn down a side street. We put the vehicle in park, turned it off and we’re able to restart it. We immediately notified the dealership and drove it there. On the way to the dealership, we made a stop. When in a parking lot, my wife pressed the accelerator to drive and the same issue happened with the same warning lights and alarms. Once again, we shifted to park, turned the vehicle off and we’re able to restart it. We drove straight to the dealership, informed them of the repeated issue and left the van with them. The dealership indicated there were over twenty software updates. We were told the exact same thing on June 4th the last time this happened. They have not yet been able to tell us why this has happened or continues to happen. The problem has not been reproduced by the dealership but this is the third time this has happened. The vehicle has not been inspected by the manufacturer.
NHTSA ODI #11423721
Mileage unknown · Jul 7, 2021
EngineFuel/propulsion SystemVehicle Speed Control
This is the second time we have had this issue with our van. The first time was May 25, 2019. On June 4, 2021, my wife was driving down the highway with our two kids and as she began to exit toward the off ramp, several alarms and warning appeared on the driver’s dashboard including 'SERVICE HYBRID SYSTEM', a red wrench with a…
Read full complaint
This is the second time we have had this issue with our van. The first time was May 25, 2019. On June 4, 2021, my wife was driving down the highway with our two kids and as she began to exit toward the off ramp, several alarms and warning appeared on the driver’s dashboard including 'SERVICE HYBRID SYSTEM', a red wrench with a lightning bolt through it, the orange engine warning light, and a message appeared saying 'SHIFT VEHICLE TO PARK'. The van stalled and when my wife pressed the accelerator, nothing happened. She was able to coast down the exit ramp and pull over to the shoulder. The van was out in park, shut off and we were able to restart it. The orange engine warning light remained on. We immediately drove to the dealership. They ran a diagnostic test and said no issues came up but there were twenty some software updates. The issue has not been reproduced by the dealer but we have had it happen two times. The vehicle has not been inspected by the manufacturer.
NHTSA ODI #11423716
27,000 miles · May 7, 2021
EnginePower Train
WE HAVE A 2018 PACIFICA LIMITED HYBRID. WHILE DRIVING, IT BEEPED, THEN MESSAGE APPEARED TO SAY "SHIFT TO P". THE VAN THEN LOST MOTIVE POWER SHORTLY AFTER. ONCE STOPPED, SHUT DOWN ENGINE THEN RESTARTED, IT WOULD DRIVE AGAIN. THIS ALSO OCCURRED A FEW TIMES WHILE DRIVING ON A FREEWAY, I HAD TO QUICKLY GET TO EMERGENCY LANE/SHOULDER…
Read full complaint
WE HAVE A 2018 PACIFICA LIMITED HYBRID. WHILE DRIVING, IT BEEPED, THEN MESSAGE APPEARED TO SAY "SHIFT TO P". THE VAN THEN LOST MOTIVE POWER SHORTLY AFTER. ONCE STOPPED, SHUT DOWN ENGINE THEN RESTARTED, IT WOULD DRIVE AGAIN. THIS ALSO OCCURRED A FEW TIMES WHILE DRIVING ON A FREEWAY, I HAD TO QUICKLY GET TO EMERGENCY LANE/SHOULDER. VERY DANGEROUS SITUATION WITH CARS WHIPPING BY US WHILE WE STOPPED WITH VAN FULL OF KIDS. BUT IT ALWAYS RESTARTED BACK AND WE WERE ABLE TO KEEP GOING. ENGINE LIGHT WOULD STAY ON BUT THEN WOULD DISAPPEAR LATER. WE TOOK IT TO OUR DEALER (FRESNO CHRYSLER JEEP) AND THEY SAID "SOFTWARE ISSUE" AND THAT THEY WILL UPDATE IT. I DIDN'T GET TO TALK TO THE ADVISOR BUT LOOKING AT THE SERVICE BILL - UNCLEAR IF ANYTHING WAS DONE. THEY DROVE IT AROUND FOR 30 MIN AND ENGINE LIGHT DID NOT COME BACK ON. THE VEHICLE ALREADY HAS DONE ALL THE RECALLS PREVIOUSLY. WE TOOK IT HOME - SHORTLY AFTER THIS HAPPENED AGAIN. NOT SURE WHAT CONDITION TRIGGERS IT. MY WIFE WILL TAKE IT BACK TO THE DEALER TODAY AND WILL ASK THEM AT LEAST CHANGE THE 12V BATTERY (NOT SURE IF THAT IS THE REASON BUT PER FORUM DISCUSSION, THIS CAN BE A CULPRIT). THE PROBLEM IT SEEMS IS THAT DEALERS ARE IN THE DARK ABOUT THE PROBLEM AND MOST PROBABLY DONT HAVE CLUE HOW TO ADDRESS IT.
NHTSA ODI #11415567
41,000 miles · Nov 11, 2020
Electrical SystemEngine
MY CAR PURCHASED IN 2018 FROM REED JEEP CHRYLSER IN OVERLAND PARK KANSAS. IN SEPTEMBER OF 2020, THE VEHICLE WAS IN HYBRID/ELECTRIC MODE AND STOPPED RUNNING AS WE WERE DRIVING DOWN THE STREET. WE WERE DRIVING SLOWLY AND ABLE TO COAST TO THE RIGHT SIDE OF THE ROAD AND WERE ABLE TO SAFELY LEAVE IT ON A RESIDENTIAL STREET. THE CAR W…
Read full complaint
MY CAR PURCHASED IN 2018 FROM REED JEEP CHRYLSER IN OVERLAND PARK KANSAS. IN SEPTEMBER OF 2020, THE VEHICLE WAS IN HYBRID/ELECTRIC MODE AND STOPPED RUNNING AS WE WERE DRIVING DOWN THE STREET. WE WERE DRIVING SLOWLY AND ABLE TO COAST TO THE RIGHT SIDE OF THE ROAD AND WERE ABLE TO SAFELY LEAVE IT ON A RESIDENTIAL STREET. THE CAR WOULD NOT START AND IT WAS NOT AN ISSUE RELATED TO THE STARTER OR BATTERY. WE HAD THE CAR TOWED TO THE DEALERSHIP. THE PROBLEM WAS REVIEWED BY THE ENGINEERING TEAM WITH CHRYSLER AND IT WAS FOUND TO BE A COMPUTER ELECTRICAL HYBRID COMPONENT. ORIGINALLY, CHRYSLER ADVISED THEY HAD NO REPLACEMENT PART ANYWHERE IN THE COUNTRY. AFTER TWO WEEKS, THEY ADVISED THEY WOULD BE ABLE TO GET A COMPONENT FROM THE COMPONENT MANUFACTURER BUT THAT IT WOULD TAKE TIME. THE CAR REMAINED IN THE SERVICE CENTER FOR AT LEAST TWO ADDITIONAL WEEKS. THEY REPLACED THE REGULAR BATTERY AND PERFORMED RECALL ON OTHER COMPONENTS DURING THIS TIME AS WELL. A LITTLE OVER A MONTH LATER, THE SAME FAILURE/PROBLEM OCCURRED. FORTUNATELY, WE WERE AGAIN ON A RESIDENTIAL STREET AND LEAVE IT. A COUPLE OF HOURS LATER, WE WERE ABLE TO START IT AND GET IT BACK TO OUR RESIDENCE. WE TRIED TO CHARGE IT USING THE 240V CHARGER WE HAD BUT THE CAR WOULD NOT TAKE ANY ADDITIONAL CHARGE EVEN THOUGH NOT FULLY CHARGED. THREE DAYS LATER, WE RETURNED THE CAR TO THE DEALERSHIP WITH THE SAME COMPLAINT AND WERE TOLD THAT THEY COULD NOT FIND ANY PROBLEM WITH THE CAR. OUR OVERARCHING CONCERN IS SAFETY, AS THERE IS NO WARNING AS TO WHEN THE CAR WILL SHUT DOWN.
NHTSA ODI #11374102
15,000 miles · Mar 11, 2020
Electrical SystemEnginePower Train
WHILE DRIVING ON A FREEWAY, THE ENGINE STARTED LOSING POWER AND WOULD NOT REACT TO THE GAS PEDAL. IN ADDITION, THE GEAR SHIFT WOULD NOT CHANGE WHEN I TRIED TO CHANGE IT FROM DRIVE TO NEUTRAL. THE CAR WOULD PURPOSELY BE SLOWED DOWN BY THE ENGINE AS IT WAS STUCK IN DRIVE POSITION. THE CREATED A DANGEROUS SITUATION AS IT WAS DIFFIC…
Read full complaint
WHILE DRIVING ON A FREEWAY, THE ENGINE STARTED LOSING POWER AND WOULD NOT REACT TO THE GAS PEDAL. IN ADDITION, THE GEAR SHIFT WOULD NOT CHANGE WHEN I TRIED TO CHANGE IT FROM DRIVE TO NEUTRAL. THE CAR WOULD PURPOSELY BE SLOWED DOWN BY THE ENGINE AS IT WAS STUCK IN DRIVE POSITION. THE CREATED A DANGEROUS SITUATION AS IT WAS DIFFICULT TO CONTROL CAR TO MOVE IT INTO THE EMERGENCY LANE. AFTER PULLING OVER, SMOKE STARTED COMING OUT OF THE ENGINE AND VENTS. I WAS THEN UNABLE TO TURN OFF THE ENGINE AS THE POWER BUTTON WOULD NOT REACT WHEN PRESSED. PER THE DEALERSHIP, THE CATALYTIC CONVERTERS WAS CLOGGED AND OVERHEATED SO NEEDED TO BE REPLACED AS WELL AS THE OXYGEN SENSOR. THIS SHOULD NOT HAVE NEEDED TO BE REPAIRED IN A CAR THAT IS ONLY 1.5 YEARS OLD AND CREATED A VERY DANGEROUS SITUATION ON THE FREEWAY.
NHTSA ODI #11317504
22,000 miles · Mar 4, 2020
Engine
MY CAR ENGINE SUDDENLY SHUT DOWN ON STOP AT RED LIGHT IN AN INTERSECTION AND THEN HAPPEN AGAIN DURING DRIVING ON THE CITY STREET THE ENGINE SHUT OFF AGAIN AND UNABLE TO RESTART. THE DASHBOARD SHOWED MESSAGE OF 'SHIFT TO PARKING TO START' HAD TO TOW THE CAR TO DEALER. ANOTHER EXPERIENCE WITH ENGINE SHUT DOWN WAS ON THE FREEWAY OF…
Read full complaint
MY CAR ENGINE SUDDENLY SHUT DOWN ON STOP AT RED LIGHT IN AN INTERSECTION AND THEN HAPPEN AGAIN DURING DRIVING ON THE CITY STREET THE ENGINE SHUT OFF AGAIN AND UNABLE TO RESTART. THE DASHBOARD SHOWED MESSAGE OF 'SHIFT TO PARKING TO START' HAD TO TOW THE CAR TO DEALER. ANOTHER EXPERIENCE WITH ENGINE SHUT DOWN WAS ON THE FREEWAY OF 210 BUT ENGINE WAS ABLE TO RESTART AFTER TURN OFF THE CAR FOR FEW MINUTES.
NHTSA ODI #11316107
16,000 miles · Jul 23, 2019
EnginePower TrainUnknown Or Other
METALLIC BUZZING / VIBRATION DURING MODERATE ACCELERATION. OCCURS OCCASIONALLY AROUND 30 TO 35 MPH BUT ALSO AT HIGHER SPEEDS. VEHICLE HAS BEEN AT DEALERSHIP MULTIPLE TIMES WHERE THE BELLY HEAT SHIELD WAS REPLACED, ROCKS WERE REMOVED FROM THE HEAT SHIELD, UNDERCARRIAGE WAS INSPECTED AND PARTS SECURED, AND MOST RECENTLY THE ENTIRE…
Read full complaint
METALLIC BUZZING / VIBRATION DURING MODERATE ACCELERATION. OCCURS OCCASIONALLY AROUND 30 TO 35 MPH BUT ALSO AT HIGHER SPEEDS. VEHICLE HAS BEEN AT DEALERSHIP MULTIPLE TIMES WHERE THE BELLY HEAT SHIELD WAS REPLACED, ROCKS WERE REMOVED FROM THE HEAT SHIELD, UNDERCARRIAGE WAS INSPECTED AND PARTS SECURED, AND MOST RECENTLY THE ENTIRE TRANSMISSION WAS REPLACED. ALL OF THE WORK HAS BEEN PERFORMED UNDER WARRANTY AS THE VEHICLE ONLY JUST PASSED 20,000 MILES. EVEN AFTER THE TRANSMISSION WAS REPLACED THE BUZZING SOUND CONTINUES AS BEFORE RESULTING IN ANOTHER TRIP TO THE DEALER. THERE HAVE BEEN NO ISSUES WITH THE OPERATION OF THE VEHICLE YET BUT I AM CONCERNED THAT THE BUZZING / VIBRATION IS INDICATIVE OF A FUTURE ISSUE THAT WOULD RENDER THE VEHICLE INOPERABLE.
NHTSA ODI #11234147
Official recalls
6Jul 18, 2024
Chrysler (FCA US, LLC) is recalling certain 2017-2018 Pacifica Plug-In Hybrid Electric (PHEV) vehicles that received a software update remedy under NHTSA recall number 22V-077. The battery pack may cause a vehicle fire when parked, even with the ignition in the "Off" position.
Consequence & remedy
Consequence: A vehicle fire increases the risk of injury.
Remedy: Owners are advised not to charge their vehicles, and to park outside and away from structures, until they are repaired. Dealers will update the high voltage battery pack control module (BPCM) software. In addition, dealers will inspect and if necessary, replace the battery pack assembly. Repairs will be performed free of charge. Interim notification letters, notifying owners of the safety risk, were mailed August 1, 2024. Owner notification letters were mailed December 12, 2024. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is 73B. Vehicles previously repaired under recall 22V-077 will need to have the new remedy completed.
Feb 11, 2022
Chrysler (FCA US, LLC) is recalling certain 2017-2018 Pacifica Plug-In Hybrid Electric Vehicles (PHEV). A vehicle fire can occur when parked, even with the ignition in the "Off" position.
Consequence & remedy
Consequence: A vehicle fire increases the risk of injury.
Remedy: Owners are advised not to recharge their vehicles, and to park outside and away from structures, until they are repaired. Dealers will update the high voltage battery pack control module (BPCM) software. In addition, dealers will inspect and if necessary, replace the battery pack assembly. Repairs will be performed free of charge. Interim letters, informing owners of the safety risk were mailed on February 25, 2022. Final owner notification letters were mailed October 6, 2022. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is Z11. This recall is superseded by NHTSA recall 24V-538.
Jun 9, 2020
Chrysler (FCA US LLC) is recalling certain 2017-2020 Pacifica Plug-in Hybrid Electric Vehicles ("PHEV"). The 12 volt isolator post located behind the driver's seat may develop high resistance.
Consequence & remedy
Consequence: A high resistance electrical connection may result in the connection overheating, increasing the risk of a fire with the vehicle on or off.
Remedy: FCA will conduct a voluntary safety recall on affected vehicles to increase the torque and install a waterproof gasket to the 12v isolator post, the post will also be inspected for signs of contamination. In the event the post is compromised, the 12v isolator post and associated cables will be replaced. Until the final remedy is available, customers should bring their vehicles to dealers for an interim inspection of this joint. The recall remedy is currently under development. FCA US LLC will notify owners, and dealers will perform an interim inspection of this joint. If the inspection indicates the joint is compromised, owners will receive a loaner vehicle, until a final remedy is developed. Interim notifications are expected to begin around June 22, 2020. The recall began July 30, 2020. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is W46. Note: Consumers are advised to exercise the following precautions until the vehicle has the final repair completed: do not park these vehicles inside of buildings or structures, or near other vehicles. Additionally, keep liquids out of the backseat area, including but not limited to beverages, wet items, umbrellas, or bottled liquids that may leak.
Additional source detail variants (2)
Electrical System:wiring:interior/under Dash
Chrysler (FCA US LLC) is recalling certain 2017-2020 Pacifica Plug-in Hybrid Electric Vehicles ("PHEV"). The 12 volt isolator post located behind the driver's seat may develop high resistance.
Consequence: A high resistance electrical connection may result in the connection overheating, increasing the risk of a fire with the vehicle on or off.
Remedy: FCA will conduct a voluntary safety recall on affected vehicles to increase the torque and install a waterproof gasket to the 12v isolator post, the post will also be inspected for signs of contamination. In the event the post is compromised, the 12v isolator post and associated cables will be replaced. Until the final remedy is available, customers should bring their vehicles to dealers for an interim inspection of this joint. The recall remedy is currently under development. FCA US LLC will notify owners, and dealers will perform an interim inspection of this joint. If the inspection indicates the joint is compromised, owners will receive a loaner vehicle, until a final remedy is developed. Interim notifications are expected to begin around June 22, 2020. The recall began July 30, 2020. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is W46. Note: Consumers are advised to exercise the following precautions until the vehicle has the final repair completed: do not park these vehicles inside of buildings or structures, or near other vehicles. Additionally, keep liquids out of the backseat area, including but not limited to beverages, wet items, umbrellas, or bottled liquids that may leak.
Electrical SYSTEM:12V/24V/48V Battery:cables
Chrysler (FCA US LLC) is recalling certain 2017-2020 Pacifica Plug-in Hybrid Electric Vehicles ("PHEV"). The 12 volt isolator post located behind the driver's seat may develop high resistance.
Consequence: A high resistance electrical connection may result in the connection overheating, increasing the risk of a fire with the vehicle on or off.
Remedy: FCA will conduct a voluntary safety recall on affected vehicles to increase the torque and install a waterproof gasket to the 12v isolator post, the post will also be inspected for signs of contamination. In the event the post is compromised, the 12v isolator post and associated cables will be replaced. Until the final remedy is available, customers should bring their vehicles to dealers for an interim inspection of this joint. The recall remedy is currently under development. FCA US LLC will notify owners, and dealers will perform an interim inspection of this joint. If the inspection indicates the joint is compromised, owners will receive a loaner vehicle, until a final remedy is developed. Interim notifications are expected to begin around June 22, 2020. The recall began July 30, 2020. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is W46. Note: Consumers are advised to exercise the following precautions until the vehicle has the final repair completed: do not park these vehicles inside of buildings or structures, or near other vehicles. Additionally, keep liquids out of the backseat area, including but not limited to beverages, wet items, umbrellas, or bottled liquids that may leak.
Feb 28, 2019
Chrysler (FCA US LLC) is recalling certain 2018 Chrysler Pacifica and Pacifica hybrid vehicles. The right front lower control arm may separate from the steering knuckle.
Consequence & remedy
Consequence: A control arm separation could increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the right front knuckle and lower control arm for damage, replacing the components as necessary. The right front lower control arm knuckle pinch bolt will be replaced with a larger-diameter pinch bolt. These repairs will be performed free of charge. The recall began April 26, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V15.
Oct 19, 2018
Chrysler (FCA US LLC) is recalling certain 2017-2018 Chrysler Pacifica Plug-in Hybrid Electric vehicles (PHEV). After the vehicle has been operating in PHEV propulsion mode, the gas-fueled engine may not restart properly resulting in unburned fuel entering the exhaust catalyst.
Consequence & remedy
Consequence: The improperly started engine could result in a loss of motive power increasing the risk of a crash or the unburned fuel in the catalyst may ignite increasing the risk of a fire.
Remedy: FCA will notify owners, and dealers will update the powertrain controller module software, and inspect and replace the catalytic converter as necessary, free of charge. The recall began November 15, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U94.
Additional source detail variants (2)
Hybrid Propulsion System
Chrysler (FCA US LLC) is recalling certain 2017-2018 Chrysler Pacifica Plug-in Hybrid Electric vehicles (PHEV). After the vehicle has been operating in PHEV propulsion mode, the gas-fueled engine may not restart properly resulting in unburned fuel entering the exhaust catalyst.
Consequence: The improperly started engine could result in a loss of motive power increasing the risk of a crash or the unburned fuel in the catalyst may ignite increasing the risk of a fire.
Remedy: FCA will notify owners, and dealers will update the powertrain controller module software, and inspect and replace the catalytic converter as necessary, free of charge. The recall began November 15, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U94.
Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor
Chrysler (FCA US LLC) is recalling certain 2017-2018 Chrysler Pacifica Plug-in Hybrid Electric vehicles (PHEV). After the vehicle has been operating in PHEV propulsion mode, the gas-fueled engine may not restart properly resulting in unburned fuel entering the exhaust catalyst.
Consequence: The improperly started engine could result in a loss of motive power increasing the risk of a crash or the unburned fuel in the catalyst may ignite increasing the risk of a fire.
Remedy: FCA will notify owners, and dealers will update the powertrain controller module software, and inspect and replace the catalytic converter as necessary, free of charge. The recall began November 15, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U94.
Aug 9, 2018
Chrysler (FCA US LLC) is recalling certain 2018 Jeep Renegade, Compass and Grand Cherokee, RAM 1500 and Promaster, Fiat 500x, Dodge Journey, Challenger, Charger and Durango and Chrysler 300x vehicles, 2017-2018 Jeep Wrangler, Dodge Grand Caravan and Chrysler Town and Country vehicles and 2018-2019 Jeep Cherokee and 2018 Chrysler Pacifica and Pacifica Hybrid vehicles. The powertrain control module may be equipped with a voltage regulator chip in the circuit board that may fail, causing a stall or a no start condition.
Consequence & remedy
Consequence: A vehicle stall can increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the powertrain control module, free of charge. The recall began October 2, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U87.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE24028 · Electrical Arcing And Thermal Events, Potentially Leading To Fires, While Utilizing Enel X Way Usa, Llc's Juicebox Residential Charger.
Opened Oct 3, 2024 · Closed Jun 5, 2025
Status: closed (inferred from source dates) · Equipment:electrical
On October 3, 2024, the Office of Defects Investigations (ODI) opened PE24028 to investigate alleged failures of Enel X Way's JuiceBox Level 2 residential EV chargers. The allegations were described as thermal incidents and electrical malfunctions, which could trip the circuit breakers in Juicebox owners’ homes and disrupt electric vehicle charge cycles. On October 2, 2024, Enel X Way posted on its website that Enel X Way North America would cease operations in the United States and Canada on October 11, 2024. The closure would potentially impact the charging app and supporting software. ODI sent Enel X Way an Information Request (IR) letter on October 21, 2024. Enel X Way provided an incomplete response to the IR on December 9, 2024. Enel X Way later provided a complete response to the IR on January 24, 2025. ODI reviewed Enel X Way’s IR submissions to determine whether further action is required. Based on ODI’s analysis, there was no clear trend in the cause of the failures described in customer complaints and warranty reports. Additionally, there have been no recent reports alleging safety issues. The available information does not warrant further action at this time. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency will continue to monitor for any safety trends and reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in this Closing Resume, go to NHTSA.gov.
RQ24004 · Loss Of Motive Power Due To An Internal Wiring Connector Short.
Opened Feb 27, 2024 · No close date supplied
Status: open (inferred from source dates) · Electrical System:wiring
On July 22, 2022, the Office of Defects Investigation (ODI) opened investigation PE22-008 regarding complaints alleging a loss of motive power condition potentially due to a transmission malfunction in Model Years 2019-2021 Chrysler Pacifica Plug-In Hybrid Electric Vehicles (PHEV). On January 17, 2023, Fiat Chrysler Automobiles (FCA) issued safety recall (NHTSA Recall 23V-010) involving 2017-2023 Model Years (MY) Pacifica Plug-In Hybrid Electric Vehicles (PHEV) produced between August 12, 2016, through January 9, 2023. The recall states that the loss of motive power condition in these vehicles is caused by an internal transmission wiring connector that may short circuit, resulting in an unexpected engine shutdown. An unexpected engine shutdown can cause a loss of drive power, increasing the risk of a crash. In discussions with FCA on Recall 23V-010, ODI confirmed the recall was related to investigation PE22-008. The remedy for 23V-010 is to update the Power Inverter module (PIM) and/or Instrument Panel Cluster (IPC) software to provide drivers a message stating “Stop Safely - Vehicle Will Shut Off Soon” followed by a chime and MIL, PRNDL blinking (on cluster and shifter knob), low SOC (State of Charge) warning and reduced power mode. The recall remedy does not replace the defective hardware that was described in Recall 23V-010, and the wiring connector short still exists on these vehicles. To date, ODI has received 132 reports for the population of vehicles subject to recall 23V-010. These reports allege a loss of motive power condition that reduces the vehicles speed, followed by dashboard warning lamps displaying messages associated with recall 23V-010. The presence of these warning lamps and messages indicates the vehicle likely had the recall remedy applied. Follow up discussions with FCA confirm their remedy does not prevent a loss of motive power, but instead limits torque to the engine and after an unspecified number of miles or period of time, the engine will shut down. When this occurs, FCA relies on the owner to transport the vehicle to a dealership after they experience a loss of motive power condition, at which time the defective hardware is replaced. Furthermore, the dashboard messages introduced in the recall remedy may cause the driver to pull over in an unsafe location. Pulling over in an unsafe location may expose the occupants to undue harm. The Office of Defects Investigation is opening this Recall Query (RQ) to assess the adequacy, frequency, and safety consequence of the remedy for recall 23V-010. To review the ODI reports cited in the opening resume ODI report identification number document, go to NHTSA.gov.
RQ24001 · Ignition-off High Voltage Battery Fire (remedy Effectiveness Of Recall 22V-077)
Opened Jan 16, 2024 · No close date supplied
Status: open (inferred from source dates) · Electrical System:propulsion System:traction Battery
On February 11, 2022, Fiat Chrysler Automobiles (FCA) issued a safety recall (NHTSA Recall 22V-077) on all 2017-2018 Pacifica Plug-In Hybrid Electric Vehicles (PHEV) produced between August 12, 2016 through August 7, 2018. The recall addresses ignition “OFF’ fires that originate at the high voltage (HV) battery pack assembly. An ignition ‘OFF’ vehicle fire can result in an increased risk of occupant injury, injury to persons outside the vehicle, and property damage, with little to no warning. At the time of the recall filing the root cause of the vehicle fires was unknown and under investigation by FCA and suppliers. A software remedy designed to improve thermal event detectability by monitoring battery diagnostics is currently being installed on subject vehicles as an interim remedy. As of November 23, 2023, the root cause of the battery failure is unknown. From December 2022 through December 2023, NHTSA has received four consumer complaints (VOQs) alleging vehicle thermal events involving recalled 2017 and 2018 Chrysler Pacifica PHEVs. Additional information collected from complainants confirmed a thermal event originating near or at the HV battery pack after the Recall 22V077 remedy had been applied to the vehicle. Follow up meetings with FCA and suppliers in November and December 2023 to discuss the ongoing root cause investigation and post-recall remedy incidents indicated a recent increase in HV battery thermal events. Furthermore, a review of NHTSA complaint data indicated the post-recall HV battery thermal event complaint rate now exceeds pre-recall levels. The Office of Defects Investigation (ODI) is opening this Recall Query (RQ) to review the effectiveness of the original recall remedy, understand the root cause of the battery fires, investigate additional reports of Pacifica PHEV HV battery fires, and to increase monitoring of the manufacturer root cause investigation. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE22008 · Transmission Fault Leading To Loss Of Motive Power
Opened Jul 22, 2022 · Closed Mar 27, 2024
Status: closed (inferred from source dates) · Power Train
On July 22, 2022, the Office of Defects Investigation (ODI) opened PE22008 to investigate allegation of loss of motive power, potentially due to transmission malfunction, in certain Chrysler Pacifica vehicles. In a January 17, 2023 letter to NHTSA, Fiat Chrysler Automobiles (FCA) submitted recall notice 23V-010 involving a transmission motor wiring defect in 67,118 model year (MY) 2017-2023 Chrysler Pacifica plug-in hybrid electric vehicles (PHEVs) manufactured from August 12, 2016 through January 9, 2023. FCA determined that an internal transmission connector short could result in an unexpected engine shutdown under certain conditions. Follow up correspondence with FCA confirmed this defect results in an electric motor position trouble code that was the basis for opening PE22008, therefore NHTSA is closing this investigation. The 23V-010 recall remedy is a software update to address the hardware failure associated with PE22008. When a hardware failure is detected, the vehicle limits motive power while instructing the driver to pull over to a safe location. NHTSA is concerned that drivers will pull over to an unsafe location when the warning message associated with the recall remedy displays on the dashboard. Due to the nature of the recall remedy and related reports, NHTSA has opened Recall Query RQ24004 to assess the recall remedy. The reports and failure report summary values included with this closing action are related to allegations of Recall 23V-010 remedy inadequacy. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration