IllustrationHINGES FAILED ON DRIVER SIDE DOOR, DOOR SAGGED AND ALMOST FELL OFF. ENTIRE DOOR HAD TO BE REPLACED.
1994 Chrysler Lebaron
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Lebaron years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 5 of 102 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 31 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 22 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports5 fire reports4 injury reports
Structure complaints
31 reportsFRONT DOOR HINGES SEPARATED FROM THE FRAME.
THE HINGES ON THE DRIVER'S SIDE DOOR HAVE RUSTED THROUGH THE DOOR COMPLETELY. THE HINGES ON THE PASSENGER'S SIDE DOOR ARE DOING THE SAME. THE OWNER FEELS THAT THE DRIVER'S DOOR WILL FALL OFF AT ANY MOMENT, AND USES THE PASSENGER'S SIDE DOOR WHEN GETTING IN AND OUT OF VEHICLE. *AK
THE WELDS ATTACHING THE DRIVER'S SIDE DOOR TO ITS LOWER HINGE FAILED WITHOUT WARNING.
DRIVER'S SIDE DOOR IS FALLING OFF HINGES. *AK
BODY LEAK.
DRIVING TO BROTHER'S PLACE, HEARD LOUD POPPING SOUND UNDERHOOD; ARRIVED AT BROTHER'S; FRIDAY HAD VEHICLE TOWED TO MECHANIC; WAS INFORMED THAT MOTOR MOUNT (A-JOINT) CRACKED IN HALF DUE TO A BROKEN BOLT. *AK
WATER LEAKS INTO INSIDE OF VEHICLE,UNABLE TO FIX.
WINDOWS LEAK, CAUSING MILDEW ODOR IN PASSENGER COMPARTMENT.
BOTTOM HINGES ON 2-DOOR CONVERTIBLE WEAKENING DUE TO WELLS BUSTING. VEHICLE FAILS TO PASS STATE INSPECTION. PLEASE DESCRIBE DETAILS.
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP03002 · Steering Column Separation
Opened May 7, 2003 · Closed Jul 22, 2003
Status: closed (inferred from source dates) · Steering:column
MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.