IllustrationTHE LEFT REAR WHEEL DRUM BRAKE FROZE UP. NLM
1991 Chrysler Lebaron
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Lebaron years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 3 of 63 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports4 fire reports4 injury reports
Visibility complaints
9 reportsRECEIVED A RECALL FOR MALFUNCTION OF MOTOR FOR REAR WINDOW. HAD HOLES DRILLED SO WATER CAN ESCAPE BUT MOTOR FAILED ANYWAY. I REPLACE THE MOTOR BUT 1 AND 1/2 YEAR LATER IT HAS MALFUNCTIONED AGAIN.*AK
BPTH OF THE POWER BACK QUARTER WINDOWS STOPPED WORKING AT THE SAME TIME. *AK
2 MONTHS FROM THE DATE THAT I PURCHASED MY VEHICLE, THE REAR DRIVER'S SIDE POWER SIDELIGHT WINDOW MTR. MALFUNCTIONED AND THEN BROKE. I ATTEMPTED TO RIG IT FOR THE TIME BEING AS THE PARTS ARE EXTREMELY EXPENSIVE. THEN ABOUT 5 MONTHS LATER, THE MOTOR DIED ALTOGETHER. NOW I CANNOT PUT THE WINDOW DOWN AND THE VEHICLE IS A CONV., …
Read full complaint
2 MONTHS FROM THE DATE THAT I PURCHASED MY VEHICLE, THE REAR DRIVER'S SIDE POWER SIDELIGHT WINDOW MTR. MALFUNCTIONED AND THEN BROKE. I ATTEMPTED TO RIG IT FOR THE TIME BEING AS THE PARTS ARE EXTREMELY EXPENSIVE. THEN ABOUT 5 MONTHS LATER, THE MOTOR DIED ALTOGETHER. NOW I CANNOT PUT THE WINDOW DOWN AND THE VEHICLE IS A CONV., WHICH MEANS THAT I RISK BREAKING THE WINDOW EVERYTIME I PUT THE TOP DOWN. THE VEH. CHUGS SEVERLY BET. 55 & 75 MPH. ACCELERATING PAST 75 OR DROPPING TO BELOW 55 IS THE ONLY WAY TO SOLVE THE PROBLEM. THE HEADLIGHT COVER MTR. BROKE APPROX. 8 MONTHS AFTER I PURCHASED MY VEH., I REPLACED THE MTR. & 4 MONTHS LATER IT SEEMS TO BE BURNING OUT AGAIN. I CONNOT GO W/O THE USE OF MY HDLIGHTS, THE TRUCK RELEASE HAS NOT OPERATED PROPERLY SINCE THE PURCHASE OF THE VEH., THE HYDRAULIC RODS HAVE ALWAYS BEEN BAD.
TRANSMISSION HAS GONE OUT THREE TIMES. IT NEVER SHIFTS SMOOTHLY WHEN WORKING. REAR POWER WINDOWS WENT OUT SIMULTANEOUSLY AT 30,000 MILES. DEALER SAID BOTH MOTORS STOPPED WORKING AND WOULD BE A MINIMUM OF $500 TO REPAIR. DO NOT BELIEVE BOTH MOTORS FAILED AT SAME TIME.
BRAKES MAKE A CLICKING NOISE, 2. OIL LEAKAGE APPEARS UNDERNEATH OF VEHICLE, 3. ELECTRICAL WINDOWS WILL NOT GO UP AFTER BEING PUT DOWN, 4. ENGINE STALLS OUT WHEN DRIVING AND VEHICLE DIES OUT. DEALER CONTACTED AND AWARE OF PROBLEMS. PROBLEMS STILL EXISTS. PROVIDE FURTHER INFORMATION. *AK
SPEEDOMETER FAILED.
THE REAR WINDOWS ON A CONVERTIBLE LEAK WHEN IT RAINS. MANUFACTURER REFUSES TO DO ANYTHING. *AK
POWER WINDOWS INOPERATIVE.
Official recalls
592V016000 · Structure:body:door
Feb 11, 1992
THE OWNER'S MANUAL INCORRECTLY STATES THAT THE FRONT PASSENGER DOOR CANNOT BE OPENED FROM THE INSIDE IF THE DOOR IS LOCKED UNTIL THE LOCK CONTROL HANDLE HAS BEEN PULLED UP. ON THESE VEHICLES, THE FRONT PASSENGER DOOR CAN BE OPENED BY THE INSIDE DOOR HANDLE EVEN IF THE DOOR IS LOCKED.
Consequence & remedy
Consequence: THE ERROR IN THE OWNER'S MANUAL MAY LEAD A FRONT SEATPASSENGER TO MISTAKENLY OPEN THE CAR DOOR WHILE THE VEHICLE IS IN MOTION,BELIEVING THE INSIDE DOOR HANDLE WOULD NOT OPEN IF THE DOOR WAS LOCKED. THISCOULD RESULT IN AN INJURY TO THE FRONT SEAT PASSENGER.
Remedy: NOTIFY THE VEHICLE OWNERS OF THE ERROR IN THE OWNER'S MANUAL AND INFORM THEM OF THE ACTUAL OPERATION OF THE FRONT DOOR LOCK SYSTEM.
91V122000 · Seat Belts:front:anchorage
Jul 11, 1991
FRONT OUTBOARD SAFETY BELT MAY BECOME DIFFICULT TO LATCH AND OR UNLATCH DUE TO A WEBBING STIFFENER ENTERING THE BUCKLE HOUSING AND DISLODGING THE BUCKLE LATCH GUIDE.
Consequence & remedy
Consequence: LATCH MAY OPEN DURING ACCIDENT OR SUDDEN STOP, EXPOSINGSEAT OCCUPANT TO INCREASED RISK OF INJURY.
Remedy: REPLACE BUCKLE LATCH ENGAGEMENT.
91V078000 · Parking Brake:conventional:mechanical:linkage And Cable
May 14, 1991
MISMATCHED PARKING BRAKE CABLE LENGTHS TO THE REAR WHEELS REDUCES BRAKING ABILITY OF ONE OF THE REAR WHEELS, IN VIOLATION OF FMVSS 105.
Consequence & remedy
Consequence: INSUFFICIENT BRAKING ABLITY COULD RESULT IN INADVERTENTVEHICLE ROLLAWAY WHICH COULD RESULT IN A VEHICLE ACCIDENT.
Remedy: REPLACE MISMATCHED PARKING BRAKE CABLE WITH ONE OF CORRECT LENGTH.
90V194000 · Air Bags:frontal:sensor/control MODULE-INACTIVE
Nov 19, 1990
THE TWO AIR BAG SYSTEM FRONT IMPACT SENSORS MAY NOT BE SECURED TO THEIR MOUNTING BRACKETS.
Consequence & remedy
Consequence: AIR BAG WILL NOT DEPLOY IN A FRONTAL COLLISION IF THEFRONT IMPACT SENSORS ARE NOT ATTACHED.
Remedy: REPAIR TO ASSURE PROPER ATTACHMENT OF FRONT IMPACT SENSORS TO BRACKETS.
90V162000 · Service Brakes, Hydraulic:foundation Components:disc:caliper
Sep 4, 1990
FRONT DISC BRAKE CALIPER GUIDE PIN BOLTS MAY NOT HAVE BEEN ADEQUATELY TORQUED AND COULD LOOSEN.
Consequence & remedy
Consequence: THIS COULD CAUSE REDUCED BRAKING EFFECTIVENESS AND COULDRESULT IN AN ACCIDENT.
Remedy: PROPERLY TORQUE FRONT BRAKE CALIPER GUIDE PIN BOLTS TO 250 POUNDS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE96036 · Throttle Will Not Return To The Position
Opened May 14, 1996 · Closed Oct 31, 1996
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
UNCONTROLLED ENGINE SPEED CONDITION RESULTS FRO THROTTLE SHAFT BINDING