NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
369 reports130,000 miles · Mar 27, 2012
Power Train
TL* THE CONTACT OWNS A 1995 CHRYSLER CIRRUS. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE SUDDENLY SHIFTED INTO NEUTRAL. THE VEHICLE THEN SHIFTED OUT OF NEUTRAL, BUT WOULD NOT ACCELERATE OUT OF FIRST GEAR. THE VEHICLE WAS TAKEN TO A MECHANIC FOR A DIAGNOSTIC TEST. THE MECHANIC STATED THAT THE TRANSMISS…
Read full complaint
TL* THE CONTACT OWNS A 1995 CHRYSLER CIRRUS. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE SUDDENLY SHIFTED INTO NEUTRAL. THE VEHICLE THEN SHIFTED OUT OF NEUTRAL, BUT WOULD NOT ACCELERATE OUT OF FIRST GEAR. THE VEHICLE WAS TAKEN TO A MECHANIC FOR A DIAGNOSTIC TEST. THE MECHANIC STATED THAT THE TRANSMISSION WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.
NHTSA ODI #10453215
35 miles · Mar 27, 2012
Electrical SystemPower TrainVehicle Speed Control
OUR CAR WILL SHIFT PERFECTLY ONE DAY AND DON'T WANT TO SHIFT THE NEXT SECOND FOR NP REASON, WE HAVE REPLACED THE MODULATOR.. COOLANT TEMP SENSOR.. WE HAVE ALSO EVEN RECABLIORATED THE SHIFTING PATTERN AND STILL HAVE THIS PROBLEM.. IS THIS GOING TO KEEP HAPPENING OR IS THERE SOMETHING I CAN DO TO FIX IT. WE DID A DIAGNOSTIC ON IT …
Read full complaint
OUR CAR WILL SHIFT PERFECTLY ONE DAY AND DON'T WANT TO SHIFT THE NEXT SECOND FOR NP REASON, WE HAVE REPLACED THE MODULATOR.. COOLANT TEMP SENSOR.. WE HAVE ALSO EVEN RECABLIORATED THE SHIFTING PATTERN AND STILL HAVE THIS PROBLEM.. IS THIS GOING TO KEEP HAPPENING OR IS THERE SOMETHING I CAN DO TO FIX IT. WE DID A DIAGNOSTIC ON IT AND THE TRANSMISSION WAS GOOD.. I DON'T KNOW WHAT ELSE TO DO.? *TR
NHTSA ODI #10453166
40,000 miles · Aug 28, 2010
Power Train
TRANSMISSION WITHOUT WARNING EITHER SHIFTS DOWN INTO SECOND GEAR AND WILL NOT SHIFT UP OR WORSE THE TRANSMISSION GOES LIMP WHEN DRIVING AT ANY SPEED IN OTHER WORDS YOU END UP COASTING AND COULD POSSIBLY CAUSE A SERIOUS ACCIDENT, THE FIRST TIME THIS HAPPENED TO ME I WAS GOING 65 MPH ON THE FREEWAY. FORTUNATELY, I WAS ON THE RIG…
Read full complaint
TRANSMISSION WITHOUT WARNING EITHER SHIFTS DOWN INTO SECOND GEAR AND WILL NOT SHIFT UP OR WORSE THE TRANSMISSION GOES LIMP WHEN DRIVING AT ANY SPEED IN OTHER WORDS YOU END UP COASTING AND COULD POSSIBLY CAUSE A SERIOUS ACCIDENT, THE FIRST TIME THIS HAPPENED TO ME I WAS GOING 65 MPH ON THE FREEWAY. FORTUNATELY, I WAS ON THE RIGHT HAND SIDE OF THE ROAD SO I COULD COAST OFF AND COME TO A STOP. IF I HAD BEEN IN HEAVY TRAFFIC IN EITHER THE CENTER OR LEFT HAND LANE THERE WOULD BE NO WAY FOR ME TO AVOID OTHER CARS AND THIS WOULD HAVE RESULTED IN A SERIOUS ACCIDENT. I TOOK THE CAR TO THE CHRYSLER DEALER AND THEY SAID IT WAS A FAULTY SOLENOID PACK AND THEY REPLACED IT FOR $900+ DOLLARS. THE CAR RAN FOR A COUPLE OF WEEKS AND THE SHIFTING DOWN AND LIMP EPISODES BEGAN AGAIN. I NOW HAVE A CAR WITH 45000 MILES PARKED IN MY GARAGE AND AM AFRAID TO DRIVE IT. THERE ARE DOZENS OF BLOGS ON THE INTERNET DESCRIBING THE SAME PROBLEM AND I DO NOT SEE ANY RECALLS BUT THIS IS CERTAINLY A LIFE THREATENING HAZARD. UNFORTUNATELY THIS IS AN INTERMITTENT PROBLEM THAT HAPPENS WITH NO WARNING. *TR
NHTSA ODI #10352499
140,000 miles · Mar 10, 2009
Electrical SystemPower Train
I BOUGHT A 1995 CHRYSLER CIRRUS LXI AND FOR THE FIRST LITTLE WHILE IT WAS GREAT, THEN ALL OF A SUDDEN I WAS DRIVING DOWN THE ROAD AT 62 MPH AND THE CAR SHIFTED INTO NEUTRAL I SLOWED DOWN TO ABOUT 30MPH AND IT DROPPED INTO GEAR BUT IT WOULD NOT SHIFT FROM FIRST GEAR. NOW SOMETIMES IT WILL SHIFT FINE AND OTHER TIMES IT WILL NOT SH…
Read full complaint
I BOUGHT A 1995 CHRYSLER CIRRUS LXI AND FOR THE FIRST LITTLE WHILE IT WAS GREAT, THEN ALL OF A SUDDEN I WAS DRIVING DOWN THE ROAD AT 62 MPH AND THE CAR SHIFTED INTO NEUTRAL I SLOWED DOWN TO ABOUT 30MPH AND IT DROPPED INTO GEAR BUT IT WOULD NOT SHIFT FROM FIRST GEAR. NOW SOMETIMES IT WILL SHIFT FINE AND OTHER TIMES IT WILL NOT SHIFT AT ALL. AND MY A/C QUIT WORKING AND THE RPM GAUGE STOPPED WORKING AT AROUND THE SAME TIME AS THE SHIFTING ISSUES STARTED. *TR
NHTSA ODI #10261432
75,500 miles · Nov 12, 2008
Suspension
TL*THE CONTACT OWNS A 1995 CHRYSLER CIRRUS. SEVERAL MONTHS AGO, WHILE DRIVING 20 MPH, THE DRIVER'S SIDE FRONT SUSPENSION BEGAN MAKING A CREAKING NOISE. THE NOISE DID NOT SOUND LIKE THE SPRINGS, BUT MORE LIKE PLASTIC RUBBING OVER A HEAVY LOAD. THE CONTACT TOOK THE VEHICLE TO A MECHANIC AND WAS INFORMED THAT BOTH THE PASSENGER …
Read full complaint
TL*THE CONTACT OWNS A 1995 CHRYSLER CIRRUS. SEVERAL MONTHS AGO, WHILE DRIVING 20 MPH, THE DRIVER'S SIDE FRONT SUSPENSION BEGAN MAKING A CREAKING NOISE. THE NOISE DID NOT SOUND LIKE THE SPRINGS, BUT MORE LIKE PLASTIC RUBBING OVER A HEAVY LOAD. THE CONTACT TOOK THE VEHICLE TO A MECHANIC AND WAS INFORMED THAT BOTH THE PASSENGER AND DRIVER'S SIDE FRONT SUSPENSION WERE OUT OF LUBRICANT. IN ADDITION, THE SUSPENSION JOINTS NEEDED TO BE REPLACED. AFTER RESEARCHING THE ISSUE, THE CONTACT DISCOVERED NHTSA CAMPAIGN ID NUMBER 97V201000 (SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT) FOR THE SAME FAILURE HIS VEHICLE WAS EXPERIENCING. THE MANUFACTURER STATED THAT THE RECALL DID APPLY TO HIS VEHICLE; THE MANUFACTURER WAS TAKING RESPONSIBILITY FOR THE REPAIRS. THE FAILURE MILEAGE WAS 75,500 AND CURRENT MILEAGE WAS 76,200. UPDATED 12-02-08 *BF UPDATED 12/02/08. *JB
NHTSA ODI #10248559
86,000 miles · Feb 5, 2008
Engine And Engine Cooling
TL*THE CONTACT OWNS A 1995 CHRYSLER CIRRUS. WHILE APPROACHING A STOP SIGN OR RED LIGHT, THE VEHICLE SHUTS OFF AND WILL NOT RESTART. THE VEHICLE IS ALSO RATTLING VERY LOUDLY. THE DEALER REPAIRED THE STARTER. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT MILEAGE WAS 89,000 AND FAILURE MILEAGE WAS 86,000.
NHTSA ODI #10216959
Mileage unknown · Jan 18, 2008
Engine And Engine CoolingService Brakes, Hydraulic
TL*THE CONTACT OWNS A 1995 CHRYSLER CIRRUS. THE CONTACT ATTEMPTED TO START HER VEHICLE, BUT WAS UNSUCCESSFUL. THE ENTIRE INSTRUMENT PANEL ILLUMINATED. THE VEHICLE WAS TAKEN TO A MECHANIC AND HE STATED THAT THE MODULATOR NEEDED TO BE REPLACED. THE WORK WAS PERFORMED, BUT THE FAILURE RECURRED A MONTH LATER. THERE IS A ROD ON …
Read full complaint
TL*THE CONTACT OWNS A 1995 CHRYSLER CIRRUS. THE CONTACT ATTEMPTED TO START HER VEHICLE, BUT WAS UNSUCCESSFUL. THE ENTIRE INSTRUMENT PANEL ILLUMINATED. THE VEHICLE WAS TAKEN TO A MECHANIC AND HE STATED THAT THE MODULATOR NEEDED TO BE REPLACED. THE WORK WAS PERFORMED, BUT THE FAILURE RECURRED A MONTH LATER. THERE IS A ROD ON THE REAR DRIVER SIDE THAT IS SUPPOSED TO HOLD THE WHEEL IN PLACE, BUT IT HAS RUSTED. THE ROD FELL APART AND THE CONTACT HAD IT REPLACED. WHILE THE VEHICLE WAS PARKED, SHE NOTICED THAT THE BRAKELINE WAS LEAKING BRAKE FLUID ONTO THE GROUND. THE CONTACT TOOK THE VEHICLE TO A MECHANIC AND HAD IT REPAIRED. THE VIN, ENGINE SIZE, NUMBER OF CYLINDERS, POWERTRAIN, AND FAILURE MILEAGE WERE UNKNOWN. THE CURRENT MILEAGE WAS 63,742.
NHTSA ODI #10215361
122,876 miles · Dec 16, 2007
Air BagsCrashInjury
I HAD A FRONT END CRASH AT 25 TO 30 MPH, AND NONE OF THE AIR BAGS DEPLOYED JEOPARDIZING MY LIFE. THIS MAY BE ISOLATED OR MY BE ALL THE CARS LEFT ON THE ROAD. *TR
NHTSA ODI #10212007
82,064 miles · May 9, 2006
Electrical SystemEngine And Engine CoolingPower Train
DT*: THE CONTACT STATED WHILE DRIVING THE VEHICLE STALLED WITHOUT WARNING. THIS OCCURRED AT VARIOUS SPEEDS. THE VEHICLE WAS TOWED TO THE DEALERSHIP, WHERE THEY DETERMINED THE COMPUTER WAS BAD AND NEEDED TO BE REPLACED. THE MANUFACTURER HAS NOT BEEN CONTACTED. THE CONSUMER STATED THE RECALL REGARDING THE AUTOMATIC SHIFTER WA…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING THE VEHICLE STALLED WITHOUT WARNING. THIS OCCURRED AT VARIOUS SPEEDS. THE VEHICLE WAS TOWED TO THE DEALERSHIP, WHERE THEY DETERMINED THE COMPUTER WAS BAD AND NEEDED TO BE REPLACED. THE MANUFACTURER HAS NOT BEEN CONTACTED. THE CONSUMER STATED THE RECALL REGARDING THE AUTOMATIC SHIFTER WAS NOT PROPERLY FIXED. THE CONSUMER HAD PROBLEMS SHIFTING GEARS. UPDATED 05/30/06. *AK
NHTSA ODI #10157080
122,150 miles · May 1, 2006
Engine And Engine CoolingPower TrainSeat Belts
I'VE HAD MY ENGINE CHECKED BACK IN MAY OF 05 BY THE DEALER THEY SAID IT WAS ENGINE MISFIRE,THE DISTRIBUTOR IGNITION WAS BAD. THEY CHARGED ME $321 JUST TO CHECK IT,THEN I PAID $276 TO GET IT FIXED. THE CAR HAS HAD A DRIP EVER SINCE. IN THE PAST 6 TO 8 MONTHS OR LONGER I'VE HAD A DRIP FROM THE ENGINE THAT CAN'T BE FIXED , I REC…
Read full complaint
I'VE HAD MY ENGINE CHECKED BACK IN MAY OF 05 BY THE DEALER THEY SAID IT WAS ENGINE MISFIRE,THE DISTRIBUTOR IGNITION WAS BAD. THEY CHARGED ME $321 JUST TO CHECK IT,THEN I PAID $276 TO GET IT FIXED. THE CAR HAS HAD A DRIP EVER SINCE. IN THE PAST 6 TO 8 MONTHS OR LONGER I'VE HAD A DRIP FROM THE ENGINE THAT CAN'T BE FIXED , I RECENTLY HAD MY CAR WORKED ON IT WAS IN THE SHOP FOR A MONTH IT COST ME $2500 TO REPAIR AND IT STILL HAS A LEAK. IT'S BACK THERE AGAIN BECAUSE IT NEEDS THAT EXPANSION PLUG AND RETAINING BRACKET THAT ONLY THE DEALER CAN PROVIDE ACCORDING TO EVERY SITE BUT THE PLACE THE CAR COMES FROM. I'M ALSO HAVING TRANSMISSION PROBLEMS WHICH I'VE HAD SINCE I BROUGHT THE VEHICLE. BECAUSE I NEED A SHIFT MECHANISM AND CABLE FROM THE DEALER ACCORDING TO EVERY SITE BUT WHERE THE CAR COMES FROM. A FEW OF THE PROBLEMS THAT ARE ON THE LIST I'VE EITHER GOT FIXED OR GOT AN ESTIMATE FOR.(ONE ) OF THE PROBLEMS ON THE LIST ,THE DEALER SENT SOMETHING IN THE MAIL AND I GOT IT TAKEN CARE OF BY THE DEALER,IT WAS THE( TRANS. FLOOR SHIFTER). ALSO ON YOUR LIST! I'VE SPENT A LOT OF MONEY TO REPAIR THIS VEHICLE FOR MISTAKES MADE BY THE DEALER AND IT'S NOT FAIR . I WOULD LIKE TO BE REIMBURSED AND THE RECALL PROBLEM FIXED. *NM
NHTSA ODI #10156496
Official recalls
7Jan 13, 2004
ON CERTAIN PASSENGER VEHICLES, THE FLOOR SHIFTER IGNITION-PARK INTERLOCK MAY FAIL AND ALLOW THE SHIFTER TO BE MOVED OUT OF THE PARK POSITION WITH THE KEY REMOVED. AN INOPERATIVE INTERLOCK MAY ALSO ALLOW THE KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE PARK POSITION.
Consequence & remedy
Consequence: EITHER CIRCUMSTANCE MAY RESULT IN THE VEHICLE ROLLING AWAY WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL A NEW LOAD-LIMITING PUSH ROD INTO THE FLOOR SHIFTER LEVER OF THE AFFECTED VEHICLES. OWNER NOTIFICATION BEGAN ON JUNE 14, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Aug 6, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS. THE ADJUSTMENT OF THE CABLE CONNECTING THE CONSOLE SHIFTER MECHANISM TO THE IGNITION KEY CAN CAUSE A TRAPPED KEY CONDITION WHICH CAN RESULT IN A LOW FORCE REQUIRED TO DEPRESS THE SHIFT BUTTON. A COMBINATION OF APPLYING A MIS-ADJUSTED RELEASE BUTTON WITH A LOW FORCE ATTEMPT TO SHIFT OUT OF PARK WITH THE KEY IN THE LOCKED POSITION, CAN BREAK THE CONNECTING PIN IN THE SHIFTER.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE "IGNITION-PARK" INTERLOCK SYSTEM WILL BE NONFUNCTIONAL.
Remedy: DEALERS WILL INSPECT FOR PROPER OPERATION OF THE SYSTEM. ANY VEHICLES THAT ARE NOT FUNCTIONAL AFTER THE INSPECTION WILL HAVE THE SHIFT MECHANISM AND CABLE REPLACED WITH A "SELF-ADJUSTING" DESIGN.
Mar 20, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR SEAT BELT ANCHOR DOES NOT ACHIEVE THE LOADING REQUIRED BY FMVSS NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES."
Consequence & remedy
Consequence: FAILURE OF A SEAT BELT ANCHOR CAN RESULT IN THE LOSS OF SEAT BELT PROTECTION, WHICH COULD LEAD TO SERIOUS INJURY OR DEATH IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR SEAT BELT OUTBOARD ANCHOR FLOOR ATTACHMENTS FOR PROPER POSITIONING. IF THE ANCHOR WAS IMPROPERLY ORIENTED, THE ORIENTATION WILL BE CORRECTED.
Nov 13, 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE LOWER CONTROL ARM BALL JOINT CAN SEPARATE DUE TO LOSS OF LUBRICATION.
Consequence & remedy
Consequence: SEPARATION OF THE BALL JOINT COULD CAUSE A LOSS OF STEERING CONTROL INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE BALL JOINT END HOUSING COVER SEAL FOR LEAKAGE WITH A HIGH PRESSURE AIR TESTER AND THE RUBBER BOOT WILL BE VISUALLY INSPECTED FOR DAMAGE. IF THE COVER SEAL LEAKS OR THE BOOT IS DAMAGED, THE LOWER CONTROL ARM WILL BE REPLACED.
May 3, 1996
THE BRAKE MASTER CYLINDER CAN LEAK BRAKE FLUID DUE TO A DAMAGED DOUBLE LIP REAR PISTON SEAL.
Consequence & remedy
Consequence: BRAKE FLUID LEAKAGE CAN RESULT IN DIMINISHED EFFECTIVENESS OF ONE HALF OF THE SPLIT BRAKE SYSTEM. THE INSTRUMENT PANEL WARNING LIGHT(S) WILL SIGNAL SYSTEM IMPAIRMENT PRIOR TO PARTIAL BRAKE SYSTEM LOSS.
Remedy: DEALERS WILL REPLACE THE REAR BRAKE MASTER CYLINDR PISTON ASSEMBLY.
May 2, 1996
CORROSION OF THE ABS HYDRAULIC CONTROL UNIT CAN CAUSE THE SOLENOID VALVES TO STICK IN THE OPEN POSITION.
Consequence & remedy
Consequence: IF EITHER FRONT WHEEL VALVE STICKS, THE VEHICLE WOULD SWERVE FROM A STRAIGHT STOP WHEN THE BRAKES ARE APPLIED.
Remedy: DEALERS WILL INSTALL A PLATE AND SILICONE GREASE INJECTED INTO THE SOLENOID CAVITY TO ELIMINATE THE POTENTIAL FOR THIS CONDITION.
Jan 11, 1996
IN CERTAIN VEHICLES, THE ENGINE CYLINDER HEAD OIL GALLEY PLUG DOES NOT SEAL PROPERLY AND ENGINE CYLINDER HEAD OIL IS NOT ADEQUATELY RETAINED.
Consequence & remedy
Consequence: INADEQUATE SEALING AND RETENTION OF THE PLUG CAN RESULT IN OIL LEAKAGE WHICH COULD CAUSE A FIRE IN THE ENGINE COMPARTMENT.
Remedy: DEALERS WILL INSTALL AN EXPANSION PLUG AND RETAINING BRACKET OVER THE CYLINDER HEAD OIL GALLEY PLUG.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA03011 · Auto Trans IGNITION-PARK Interlock
Opened Jul 17, 2003 · Closed Jan 30, 2004
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Additional source detail variants (2)
Power Train:automatic Transmission
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
DP03002 · Steering Column Separation
Opened May 7, 2003 · Closed Jul 22, 2003
Status: closed (inferred from source dates) · Steering:column
MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.
EA97016 · Lower Control Arm Ball Joint Failure
Opened Sep 29, 1997 · Closed Nov 20, 1997
Status: closed (inferred from source dates) · Suspension
BY LETTER DATED NOVEMBER 6, 1997, THE MANUFACTURER ADVISED THIS AGENCY OF ITS DECISION TO INITIATE A SAFETY RECALL CAMPAIGN OF THE SUBJECT VEHICLES TO CORRECT THE DEFECT IDENTIFIED IN THIS EA.THE RECALL WILL ALSO COVER 1996 AND 1997 CHRYSLER CIRRUS/DODGE STRATUS VEHICLES, AS WELL AS 1995 THROUGH 1997 CHRYSLER SEBRING CONVERTIBLE AND PLYMOUTH BREEZE VEHICLES EQUIPPED WITH IDENTICAL LOWER CONTROL ARM BALL JOINTS.AN ESTIMATED TOTAL OF 599,00VEHICLES ARE AFFECTED BY THIS RECALL.THE MANUFACTURER'S INVESTIGATION DISCLOSED THAT PROCESS VARIABILITY, TOGETHER WITH THE BALL JOINT HOUSING COVER CRIMPING OPERATION, CAN RESULT IN AN INEFFECTIVE SEAL THAT PERMITS A LOSS OF LUBRICATION AND ACCELERTED WEAR OF THE BALL JOINT ASSEMBLY.THIS CONDITION CAN LEAD TO FAILURE AND SEPARTION OF THE LOWER CONTROL ARM BALL JOINT.THE RECALL IS IDENTIFIED AS NHTSA 97V-201 AND A COPY OF CHRYSLER'S LETTER TO NHTSA IS ATTACHED HERETO.
PE97009 · Lower Control Arm Ball Joint Failure
Opened Mar 13, 1997 · Closed Sep 29, 1997
Status: closed (inferred from source dates) · Suspension
THE MANUFACTURER IDENTIFED VEHICLE OWNER COMPLAINTS OF THE SUBJECT BALL JOINT FAILURES AS TABULATED ABOVE.IN ADDITION, A TOTAL OF 72 WARRANTY REPORTS WERE IDENTIFIED FOR REPLACEMENT OF BROKEN OR CRACKED BALL JOINT ASSEMBLIES IN THE SUBJECT VEHICLES.CHRYSLER ALSO REPORTED THAT 1996 AND 1997 MODELS ARE EQUIPPED WITH IDENTICAL BALL JOINT ASSEMBLIES AS THE SUBJECT 1995 MODEL YEAR VEHICLES.A PARTIAL RESPONSE TO NHTSA'S INFORMATION REQUEST INDICATED THAT THE MANUFACTURER'S ANALYSES AND EVALUATIONS OF THE CONDITION WERE CONTINUING.IN ORDER TO CONTINUE NHTSA'S COMPLETE ASSESSMENT OF THE NATURE AND SCOPE OF THIS MATTER, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
Illustration