Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
100–25K
1825–50K
1950–75K
975–100K
9100–150K
3150K+
68 reports with mileage · 19 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Fuel System, Gasoline. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel/propulsion System. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
3 crash reports1 fire reports2 injury reports
What owners actually said
87 reports
38,000 miles · Sep 30, 2010
Fuel System, Gasoline
2007 CHRYSLER ASPEN GAS TANK OVERFLOWS WHENEVER I TRY TO FILL IT UP. . THE PUMP SHUTS OFF , BUT THEN GAS OVERFLOWS OUT. I DO NOT TOP OFF IT JUST HAPPENS WITH THE FIRST SHUTOFF OF THE GAS PUMP. GAS BUBBLES OUT ALL OVER TRUCK AND GROUND (AND SHOES IF WITHIN REACH). THIS HAPPENS 9 OUT OF 10 TIMES IF I TRY TO FILL IT. IF I ONL…
Read full complaint
2007 CHRYSLER ASPEN GAS TANK OVERFLOWS WHENEVER I TRY TO FILL IT UP. . THE PUMP SHUTS OFF , BUT THEN GAS OVERFLOWS OUT. I DO NOT TOP OFF IT JUST HAPPENS WITH THE FIRST SHUTOFF OF THE GAS PUMP. GAS BUBBLES OUT ALL OVER TRUCK AND GROUND (AND SHOES IF WITHIN REACH). THIS HAPPENS 9 OUT OF 10 TIMES IF I TRY TO FILL IT. IF I ONLY PUT IN 16-17 GALLONS WE ARE FINE (26 GALLON TANK). NOTHING HAS BEEN DONE SAID THEY TESTED IT AND IT IS FINE. HAVE SEEN OTHER POSTS ON THE CHRYSLER FORUMS WHERE OTHER PEOPLE ARE HAVING THE SAME ISSUE. *TR
NHTSA ODI #10358530
48,800 miles · Aug 8, 2010
Air BagsElectronic Stability Control (esc)Traction Control System
UNDER NORMAL DRIVING THE ESP/BAS, AND TRACTION CONTROL WARNING LIGHTS CHIME AND ILLUMINATE. CHRYSLER DEALER HAS DIAGNOSED THAT THERE IS A SHORT IN THE CLOCKSPRING, AND ADVISED ME THAT THE VEHICLE IS UNSAFE TO DRIVE AS I COULD LOSE CONTROL OF THE VEHICLE, AND/OR THE AIR BAGS MAY NOT DEPLOY IN THE EVENT OF AN ACCIDENT. I HAD CLOC…
Read full complaint
UNDER NORMAL DRIVING THE ESP/BAS, AND TRACTION CONTROL WARNING LIGHTS CHIME AND ILLUMINATE. CHRYSLER DEALER HAS DIAGNOSED THAT THERE IS A SHORT IN THE CLOCKSPRING, AND ADVISED ME THAT THE VEHICLE IS UNSAFE TO DRIVE AS I COULD LOSE CONTROL OF THE VEHICLE, AND/OR THE AIR BAGS MAY NOT DEPLOY IN THE EVENT OF AN ACCIDENT. I HAD CLOCKSPRING REPLACED, AND YES I DO HAVE THE OLD PART THAT IS DEFECTIVE. *TR
NHTSA ODI #10348039
64,000 miles · Jul 27, 2010
Steering
MY WIFE WAS DRIVING HER 2007 CHRYSLER ASPEN IN PARSIPANNY, NJ. SHE WAS MERGING FROM 287S ONTO 80W AND TRAVELING ABOUT 35MPH. AS SHE WAS MERGING ONTO 80W THE DRIVER'S SIDE BALL JOINT ON THE STEERING LINKAGE COMPLETELY FAILED RESULTING IN A TOTAL LOSS OF CONTROL. SHE MANAGED TO LIMP CAR TO SIDE OF ROAD AND CALLED MYSELF AND AAA …
Read full complaint
MY WIFE WAS DRIVING HER 2007 CHRYSLER ASPEN IN PARSIPANNY, NJ. SHE WAS MERGING FROM 287S ONTO 80W AND TRAVELING ABOUT 35MPH. AS SHE WAS MERGING ONTO 80W THE DRIVER'S SIDE BALL JOINT ON THE STEERING LINKAGE COMPLETELY FAILED RESULTING IN A TOTAL LOSS OF CONTROL. SHE MANAGED TO LIMP CAR TO SIDE OF ROAD AND CALLED MYSELF AND AAA TO HAVE CAR BROUGHT TO DEALER FOR SERVICE. THIS IS A VERY SERIOUS DEFECT. THE CAR HAS APPROXIMATELY 64K MILES ON IT AND HAS BEEN REGULARLY SERVICED. SHE IS 7 MONTHS PREGNANT AND WE HAVE A 3.5 YEAR OLD SON. THIS COULD HAVE BEEN A VERY SERIOUS ACCIDENT UNDER DIFFERENT CIRCUMSTANCES, TRAFFIC CONDITIONS, AND/OR SPEED WE ARE WAITING TO HEAR DEALERS/MANUFACTURERS RESPONSE AND SOLUTION.. *TR
NHTSA ODI #10345775
32,466 miles · May 7, 2010
Fuel System, Gasoline
FUEL SPILLS OUT OF GAS TANK WHEN FILL UP GAS TANK AND PUMP SHUTS DOWN. DEALER REPLACED PARTS FOUR TIMES. NOW THE PUMP SHUTS DOWN ON MAX, CAN FILL UP GAS TANK ONLY WHEN SELECTING LOWER POSITION OF PUMP BUT IT DOES NOT SPILL OUT ANYMORE. *TR
NHTSA ODI #10329314
35,000 miles · Mar 9, 2010
Fuel System, Gasoline
FUEL SPILLS FROM FILLER TUBE EVERY TIME VEHICLE IS TOPPED OFF. HAPPENS WHEN TANK IS FILLED AND PUMP AUTOMATICALLY SHUTS OFF. THIS IS A VERY DANGEROUS HAZARD. HAS HAPPENED FOR LAST THREE MONTHS. *TR
NHTSA ODI #10318296
21,000 miles · Feb 25, 2010
Fuel System, Gasoline
FOR PAST 3 MONTHS FUEL OVERFLOWS FROM FILLER NECK ON 2007 ASPEN, AFTER PUMP SHUTS OFF. THIS BEEN HAPPENING 100% OF THE TIME AT ANY GAS STATION. *TR
NHTSA ODI #10314081
42,000 miles · Feb 23, 2010
Fuel System, Gasoline
WHEN FILLING UP MY VEHICLE, GAS WILL SPILL OUT OF THE GAS TANK (APPROXIMATELY 1/8 GALLON). MY INTERIOR WILL FILL UP WITH GAS FUMES. THIS PROBLEM IS ONGOING AND HAPPENS EVERYTIME THAT I FILL UP, REGARDLESS OF HOW MUCH GAS IS IN MY TANK BEFORE FILL UP. *TR
NHTSA ODI #10313317
30,600 miles · Jan 15, 2010
Fuel System, Gasoline
FUEL OVERFLOWS FROM GAS TANK ON 2007 CHRYSLER ASPEN, AFTER STATION PUMP AUTO SHUTS OFF. THIS OCCURS 100% OF THE TIME AT ANY GAS STATION. THIS HAS OCCURRED FOR ROUGHLY THE PAST 2 MONTHS. *TR
NHTSA ODI #10299915
45,000 miles · Dec 30, 2009
Fuel System, Gasoline
FUEL OVERFLOWS FROM GAS TANK ON 2007 CHRYSLER ASPEN, AFTER STATION PUMP AUTO SHUTS OFF. THIS OCCURS 100% OF THE TIME AT ANY GAS STATION. PROBLEM IS NOT YET CORRECTED, APPOINTMENT WITH DEALER THIS WEEKEND. THIS HAS OCCURRED FOR ROUGHLY THE PAST 2-3 MONTHS. *TR
NHTSA ODI #10297629
38,000 miles · Sep 21, 2009
Power TrainInjury
THE TRANSMISSION SLIPS OUT OF GEARS (FROM PARK TO REVERSE, REVERSE TO NEUTRAL, ETC.). *TR
NHTSA ODI #10284729
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2007 Chrysler Aspen 4X4 Problems, Complaints & Recalls | Skip That Year
Illustration