Engine. Review the 132 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 112 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 88 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

22 crash reports11 fire reports17 injury reports

What owners actually said

344 reports

94,221 miles · Aug 20, 2026

Service Brakes, Hydraulic

The contact owns a 2016 Chrysler 200. The contact stated that the vehicle was taken to the local dealer for a recall repair, and the contact was informed that the brake line had suddenly ruptured while reversing out of the service bay. The vehicle was repaired at the owner's expense. The manufacturer was informed of the failure …

Read full complaint

NHTSA ODI #11758254

Mileage unknown · Aug 19, 2026

Electrical SystemEngineFuel/propulsion System

The shift to park light cuts in and the car starts to slow down The coolant constantly runs out

NHTSA ODI #11757993

132,073 miles · Jul 8, 2026

Air Bags

Read full complaint

The contact owns a 2016 Chrysler 200. The contact stated that whenever the front passenger's seat was occupied, the "Service Airbag" warning light illuminated. The contact stated that the failure occurred when the occupants placed their feet near the front passenger footwell area, where the airbag module and wiring harness were located. The contact routinely disconnected and reconnected the airbag wiring harness to reset and clear the warning light from the instrument panel; however, the failure recurred when the front passenger seat was occupied. The vehicle was taken to the dealer for a diagnostic inspection, but the dealer was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 132,073.

NHTSA ODI #11749170

Mileage unknown · Jul 5, 2026

Seat Belts

Read full complaint

I purchased this vehicle believing it was safe to drive. After the sale, I discovered that the driver's seatbelt was completely broken and not properly secured. This serious safety defect was never disclosed to me before I purchased the vehicle. Had I known about this issue, I would not have purchased the vehicle or would have required it to be repaired before the sale. Selling a vehicle with a defective seatbelt without disclosing the defect put my safety and the safety of my passengers at risk. I am requesting that this matter be investigated and that appropriate action be taken regarding the seller's failure to disclose this serious safety issue.

NHTSA ODI #11748355

Mileage unknown · Mar 30, 2026

Electrical SystemEngineStructure

Read full complaint

I am reporting multiple safety-related issues involving my 2016 Chrysler 200 S. On 02/06/2024, after an oil change at a dealership, the underbody skid plate bolts were not reinstalled. While driving, the skid plate fell and I lost control of the vehicle, creating a serious safety hazard. No warning indicators were present prior to this failure. The issue was identified immediately after leaving the dealership and is not properly documented in service records. In July 2022, following a battery replacement by the same dealership, the vehicle repeatedly lost power and stalled, leaving me stranded multiple times. I paid for diagnostic testing, but there is no documentation confirming proper diagnosis or repair. I was later advised incorrect hardware had been installed. On 02/27/2026, I was told the check engine light was on and diagnostic codes were cleared without repair. There is no documentation of the codes or repairs performed. I was also informed on 11/19/2022 that parts were ordered for a safety recall. From that date until 02/27/2026, I was repeatedly told parts were unavailable. I scheduled repair and dropped off the vehicle on 03/13/2026. I received notice that repair had begun, but later discovered the vehicle had not been serviced at all. No explanation was provided. Additionally, service records are inaccurate. A vehicle history report shows service on 03/17/2026 at a dealership I have never visited. The vehicle was not serviced anywhere on that date. These issues involve loss of control, repeated stalling, improper repairs, failure to complete a recall, and inaccurate reporting. Documentation is incomplete or missing. Supporting documents are available.

NHTSA ODI #11728090

Mileage unknown · Dec 30, 2025

Electrical System

Read full complaint

While driving, my 2016 Chrysler 200 (3.6L V6) experienced a sudden and complete electrical failure. All systems shut down simultaneously, including the dashboard, engine, power steering assist, and electrical accessories. The vehicle coasted to a stop and would not restart—no crank, no dash lights, no response. After allowing the vehicle to cool for approximately 30–45 minutes, electrical power returned and the vehicle restarted normally. This failure mode is identical to the Power Distribution Center (PDC) connector defect that resulted in a recall for the 2015 Chrysler 200. My vehicle is the same platform with the same component architecture, yet no recall exists for the 2016 model year. This is a serious safety defect that creates a risk of crash, loss of steering assist, and loss of vehicle control while driving.

NHTSA ODI #11707905

Mileage unknown · Dec 29, 2025

Engine

Read full complaint

During acceleration, thick white smoke began to come out tail pipe. Car instantly turns off in the middle of the street in rush hour traffic while I had my 4 year old daughter in the car. Police threatened to impound car if not moved immediately. Had to pay a hefty tow fee twice to get the car to the dealership. Somehow oil and coolant had mixed together in the engine. Dealer said I’ll need a completely new engine. I’ll have to pay 1600 to get a diagnosis of the “exact” problem once they tear down the engine. At that point warranty company will come out to see IF they can help. I was quoted a possible 12,000 job. I’ve had this car for 7 months and had done all routine work since. I’m so hurt smh

NHTSA ODI #11707530

Mileage unknown · Nov 22, 2025

Air Bags

Service airbag system My car doesn’t start

NHTSA ODI #11701003

146,000 miles · Nov 3, 2025

Engine

Read full complaint

The contact owns a 2016 Chrysler 200. The contact stated that while driving at an undisclosed speed, there was smoke coming from underneath the hood. The contact stated that the vehicle was jerking erratically. There was a strong fuel odor inside the vehicle. The contact also noticed the strong fuel odor on the exterior of the vehicle. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic; however, the contact was informed that the engine might need to be replaced. The contact stated that an oil change was performed, and coolant was added to the coolant reservoir however, the failure reoccurred. The contact stated that the vehicle was taken to an independent mechanic several times, however the failure persisted. The dealer was made aware of the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 146,000.

NHTSA ODI #11697167

Mileage unknown · Oct 13, 2025

Air Bags

My airbag sensor has randomly come on and off for about 2 years, it sense cut off and stayed off up until recently in early 2025 the “service passenger airbag” sensor comes on and stays on which affects the ability to pass a state inspection in Virginia.

NHTSA ODI #11693076

Official recalls

18V332000 · Electrical System:software; Electrical System:wiring; Vehicle Speed Control:cruise Control

May 17, 2018

Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.

Consequence & remedy

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.

Additional source detail variants (3)

Electrical System:software

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.

Vehicle Speed Control:cruise Control

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Electrical System:wiring

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

16V589000 · Steering; Structure; Suspension

Aug 10, 2016

Chrysler (FCA US LLC) is recalling certain model year 2016 Chrysler 200 vehicles manufactured May 24, 2016, to May 25, 2016. Multiple chassis fastener joints may not have been tightened to the proper torque specification.

Consequence & remedy

Consequence: If the chassis fastener joints are improperly torqued they may loosen and fail or fall out, reducing steering and handling capability and increasing the risk of a crash.

Remedy: Chrysler has notified owners, and dealers will inspect the joints and tighten or replace the fasteners, as necessary, free of charge. The recall began on September 2, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S59.

Additional source detail variants (3)

Structure

Consequence: If the chassis fastener joints are improperly torqued they may loosen and fail or fall out, reducing steering and handling capability and increasing the risk of a crash.

Remedy: Chrysler has notified owners, and dealers will inspect the joints and tighten or replace the fasteners, as necessary, free of charge. The recall began on September 2, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S59.

Suspension

Consequence: If the chassis fastener joints are improperly torqued they may loosen and fail or fall out, reducing steering and handling capability and increasing the risk of a crash.

Steering

Consequence: If the chassis fastener joints are improperly torqued they may loosen and fail or fall out, reducing steering and handling capability and increasing the risk of a crash.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.