IllustrationNO CHECK ENGINE LIGHT, PRESSING ON BRAKE PEDAL WHILE AT A STOP SIGN OR RED LIGHT, AUTOMOBILE STALLS. PUT IT IN PARK AND RESTART, RPM RANGE VARIES. USE BRAKES TOO MUCH RPM INCREASES NEED TO STOP VEHICLE AND RESTART TO GET BETTER RPM AND DASHBOARD BLINKS FOR THE MILEAGE
2013 Chrysler 200
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2013 Chrysler 200 do not stand out strongly from the model-year median of 336.
About this comparison →How this year compares
Owner complaints by model year
Compare all 200 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1050–25K
6725–50K
8750–75K
6975–100K
62100–150K
16150K+
406 reports with mileage · 222 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 171 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 145 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 102 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
23 crash reports3 fire reports32 injury reports
Engine complaints
145 reportsMY CAR WILL STALL WHILE DRIVING. STEERING WHEEL WILL LOCK. I HAVE TO PUT IT TO A COMPLETE STOP TO RESTART. SOMETIMES IT STARTS RIGHT AWAY. MOST TIMES I HAVE TO WAIT A FEW MINUTES
ACCELERATOR GOT STUCK AND ALMOST DROVE CUSTOMER INTO A TREE. AT 43K MILES THEY REPLACED THE TRANSMISSION.
MY CAR KEEPS GOING DEAD FOR NO REASON, THEN STARTS UP AFTER FIVE MINUTES.
TL* THE CONTACT OWNS A 2013 CHRYSLER 200. WHILE DRIVING APPROXIMATELY 60 MPH, SMOKE EMITTED FROM UNDERNEATH THE HOOD. THE VEHICLE WAS PULLED OVER TO THE SIDE OF THE ROAD AND THE ENGINE CAUGHT FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE VEHICLE WAS DAMAGED AND TOWED TO AN IMPOUND. A FIRE REPORT WAS NOT FILED AND THERE WE…
Read full complaint
TL* THE CONTACT OWNS A 2013 CHRYSLER 200. WHILE DRIVING APPROXIMATELY 60 MPH, SMOKE EMITTED FROM UNDERNEATH THE HOOD. THE VEHICLE WAS PULLED OVER TO THE SIDE OF THE ROAD AND THE ENGINE CAUGHT FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE VEHICLE WAS DAMAGED AND TOWED TO AN IMPOUND. A FIRE REPORT WAS NOT FILED AND THERE WERE NO INJURIES. THE CONTACT CALLED US AUTO SALES INC AT 313-952-2920 (LOCATED AT 27131 PLYMOUTH RD, REDFORD CHARTER TWP, MI 48239) AND WAS ADVISED TO FILE A COMPLAINT. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000.
MY CAR ONLY HAS 73,000 MILES ON IT. I TAKE EXCELLENT CARE OF IT. LAST WEEK I THE ENGINE STARTED TO JUST TURN OFF WHILE AT A STOP. NO WARNINGS, NO INDICATORS THAT SOMETHING WAS WRONG. THE CAR WILL TURN BACK ON WHEN I PUT IT IN PARK AND RESTART ENGINE BY TURNING THE KEY. I HAVE RECENTLY SEEN ONLINE THAT THIS HAS BEEN AN ISSUE WITH…
Read full complaint
MY CAR ONLY HAS 73,000 MILES ON IT. I TAKE EXCELLENT CARE OF IT. LAST WEEK I THE ENGINE STARTED TO JUST TURN OFF WHILE AT A STOP. NO WARNINGS, NO INDICATORS THAT SOMETHING WAS WRONG. THE CAR WILL TURN BACK ON WHEN I PUT IT IN PARK AND RESTART ENGINE BY TURNING THE KEY. I HAVE RECENTLY SEEN ONLINE THAT THIS HAS BEEN AN ISSUE WITH A LOT OF 200'S. I FEEL CHRYSLER HAS SOLD A LOT OF PEOPLE LEMONS. MORE IMPORTANTLY I'M CONCERNED FOR MY SAFETY, THE SAFETY OF MY FAMILY, AND SAFETY OF OTHER I SHARE THE ROAD WITH.
THIS CHRYSLER 200 213 NEEDS TO BE RECALLED WE HAVE A PROBLEM WITH THE LIGHTING FOR HEADLIGHT ALLO BEING THERE LIKE A WALL HIGH BEAM YOU CAN'T SEE VERY FAR HIT A DEER AT 70 MILES PER HOUR ON HIGHWAY 41 FOND DU LAC WISCONSIN MARCUS CAR 2013 FROM SUMMIT AUTOMOTIVE TOOK A BACK AS WE HAD A SHIFTING PROBLEM BETWEEN 25 AND 30 MILES PER…
Read full complaint
THIS CHRYSLER 200 213 NEEDS TO BE RECALLED WE HAVE A PROBLEM WITH THE LIGHTING FOR HEADLIGHT ALLO BEING THERE LIKE A WALL HIGH BEAM YOU CAN'T SEE VERY FAR HIT A DEER AT 70 MILES PER HOUR ON HIGHWAY 41 FOND DU LAC WISCONSIN MARCUS CAR 2013 FROM SUMMIT AUTOMOTIVE TOOK A BACK AS WE HAD A SHIFTING PROBLEM BETWEEN 25 AND 30 MILES PER HOUR JERKING AND SHIFTING WE'RE HAVING HEATING PROBLEMS AND NOW WE HAVE 80,000 MILES ON THE CAR TRYING TO GET THIS CAR RECALL AT 325 MILES ON THE CAR HAVE ALL THE PAPERWORK FOR THE LEMON LAW THE GUY COME DOWN TO THE CAR DRIVES AWAY IT DOES AND THAT'S JUST HOW THE CAR WAS MADE BULL CRAP HOW MANY COMPLAINTS DO WE HAVE NOW FEEDING ON THE PASSENGER SIDE NO HEAT DRIVER SIDE HAS HEAT 80000 MILES ON THE CAR NOW STARTING PROBLEMS WITH THE CAR STARTS WITH A RATTLE YOU SHUT IT OFF AND IT RUNS OKAY YOU HAVE 1120 CARS OUT THERE RIGHT NOW WITH THIS PROBLEM THAT I HAVE I HAVE ALL THE PAPERWORK ALL THE RECEIPTS AND I TRIED TO RECALL THIS CAR LIKE I SAID 325 MILES ON IT DID NOT PREVAIL FAMILY NEEDS TO STEP UP ON THE PLATE ON THIS CAR NOT EASY USED TO HAVE 15 DIFFERENT PROBLEMS WITH A CAR BRAND NEW A 2013 AND NOW YOU ONLY HAVE 80,000 MILES ON THE CAR FULL OF CRAP [XXX] YOU CAN CONTACT ME YOU CAN CONTACT ME AT [XXX] THANKS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
THE ENGINE COMPLETELY SHUTS OFF WITHOUT WARNING WHEN AT AN IDLE OR SLOWING DOWN TO MAKE A STOP. IT HAS DONE THIS NOW ABOUT 12 TIMES WITHIN THE LAST MONTH. MY CAR JUST MADE IT TO 53,000 MILES AND HAS ALWAYS HAD REGULAR OIL CHANGES AND MAINTENANCE. SO FAR, I HAVE BEEN ABLE TO PUT IT IN PARK AND RESTART. I WAS TAKING MY DAUGHTER TO…
Read full complaint
THE ENGINE COMPLETELY SHUTS OFF WITHOUT WARNING WHEN AT AN IDLE OR SLOWING DOWN TO MAKE A STOP. IT HAS DONE THIS NOW ABOUT 12 TIMES WITHIN THE LAST MONTH. MY CAR JUST MADE IT TO 53,000 MILES AND HAS ALWAYS HAD REGULAR OIL CHANGES AND MAINTENANCE. SO FAR, I HAVE BEEN ABLE TO PUT IT IN PARK AND RESTART. I WAS TAKING MY DAUGHTER TO SCHOOL YESTERDAY AND IT STALLED IN THE MIDDLE OF THE ROAD AND THE ENGINE DIED. THE FIRST TIME THAT IT EVER HAPPENED I PUT THE CAR IN REVERSE TO BACK OUT OF MY DRIVEWAY AND IT DIED THREE DIFFERENT TIMES. NO WARNINGS OR LIGHTS. I HAVE TAKEN IT TO A MECHANIC SHOP AND THEY COULDN'T FIND ANYTHING WRONG WITH IT. THEY RAN A DIAGNOSTIC TEST AND...NOTHING. THE ENGINE HAS DIED AND STALLED 3 TIMES SINCE BEING IN THE SHOP.
TAKATA RECALL LAST TIME I WAS DRIVING ON THE FREEWAY GOING 70 MILES PER HOUR AND THE VEHICLE SUDDENLY LOST POWER WITH A SEMI TRUCK RIGHT BEHIND ME AND I HAD TO SWERVE OFF OF THE ROAD TO AVOID BEING HIT AND NEARLY CAUSING AN ACCIDENT I DO NOT FEEL SAFE IN THIS VEHICLE AND I'M IN FEAR FOR MY LIFE
I HAVE OWNED THIS CAR FOR A WHILE NOW. I LIVE IN A PLACE THAT IS BELOW 40 DEGREES MORE OFTEN THAN IT IS ABOVE 40 DEGREES. THE ISSUE THIS CAR AND MANY OTHERS ARE PLAGUED WITH IS A HEATER CORE AND RADIATOR THAT ARE PLUGGED DUE TO A MANUFACTURING ERROR FROM CHRYSLER DIRECTLY. A PLUGGED HEATER CORE AND RADIATOR NOT ONLY IS UNSAFE; I…
Read full complaint
I HAVE OWNED THIS CAR FOR A WHILE NOW. I LIVE IN A PLACE THAT IS BELOW 40 DEGREES MORE OFTEN THAN IT IS ABOVE 40 DEGREES. THE ISSUE THIS CAR AND MANY OTHERS ARE PLAGUED WITH IS A HEATER CORE AND RADIATOR THAT ARE PLUGGED DUE TO A MANUFACTURING ERROR FROM CHRYSLER DIRECTLY. A PLUGGED HEATER CORE AND RADIATOR NOT ONLY IS UNSAFE; IT IS UNETHICAL BUSINESS PRACTICE. WHEN MY CAR DOES NOT PROPERLY HEAT, I CANNOT DEFROST MY WINDSHIELD BARRING MY VISIBILITY AND CREATING A MASSIVE SAFETY RISK FOR MYSELF AND FELLOW MOTORISTS. NOT ONLY DOES MY HEAT NOT WORK PROPERLY, MY CAR WILL OVERHEAT ON CERTAIN OCCASIONS. TO AN INEXPERIENCED CAR OWNER THE RISK OF DESTROYING THEIR ENGINE IS INCREDIBLY HIGH. THE REPAIR CAN RUN AS HIGH AS 1500 DOLLARS AT THE DEALERSHIP. I SHOULD NOT HAVE TO PAY FOR AN ERROR THAT IS NOT MY OR A SHOPS OVERSIGHT, AND AN INCREDIBLY DANGEROUS OVERSIGHT AT THAT.
Official recalls
517V640000 · Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seats:front Assembly:head Restraint
Oct 10, 2017
Chrysler (FCA US LLC) is recalling certain 2012 Jeep Liberty and 2012-2013 Chrysler 200 and Dodge Avenger vehicles. A component within the occupant restraint controller (ORC) may fail and prevent the active headrests from deploying in the event of a rear-end crash.
Consequence & remedy
Consequence: If the active headrests do not deploy in certain rear-end crashes, the front seat occupants have an increased risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the ORC as necessary, free of charge. The recall began on December 4, 2017. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is T56.
Additional source detail variants (2)
Seats:front Assembly:head Restraint
Chrysler (FCA US LLC) is recalling certain 2012 Jeep Liberty and 2012-2013 Chrysler 200 and Dodge Avenger vehicles. A component within the occupant restraint controller (ORC) may fail and prevent the active headrests from deploying in the event of a rear-end crash.
Consequence: If the active headrests do not deploy in certain rear-end crashes, the front seat occupants have an increased risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the ORC as necessary, free of charge. The recall began on December 4, 2017. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is T56.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Chrysler (FCA US LLC) is recalling certain 2012 Jeep Liberty and 2012-2013 Chrysler 200 and Dodge Avenger vehicles. A component within the occupant restraint controller (ORC) may fail and prevent the active headrests from deploying in the event of a rear-end crash.
Consequence: If the active headrests do not deploy in certain rear-end crashes, the front seat occupants have an increased risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the ORC as necessary, free of charge. The recall began on December 4, 2017. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is T56.
16V668000 · Air Bags; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seat Belts:pretensioner
Sep 15, 2016
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence & remedy
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Additional source detail variants (3)
Seat Belts:pretensioner
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Air Bags
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
13V552000 · Engine
Nov 6, 2013
Chrysler Group LLC (Chrysler) is recalling certain model year 2013 Dodge Avenger and Chrysler 200, and model year 2014 Jeep Compass and Patriot vehicles equipped with 2.4L engines. Due to abrasive debris in the balance shaft bearings, these engines may have a loss of engine oil pressure, possibly resulting in an engine stall or engine failure.
Consequence & remedy
Consequence: If the engine stalls while driving it may increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the engine balance shaft module, free of charge. The recall began on December 24, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N52.
13V282000 · Air Bags; Electrical System
Jul 2, 2013
Chrysler is recalling certain model year 2011-2013 Sebring and 200 vehicles manufactured June 28, 2011, through December 13, 2012; model year 2011-2013 Dodge Avenger vehicles manufactured June 25, 2011, through January 14, 2013; model year 2011-2012 Dodge Nitro vehicles manufactured June 17, 2011, through December 15, 2011; and model year 2011-2012 Jeep Liberty vehicles manufactured June 17, 2011, through August 15, 2012. Electrical over-stress of a resistor in the occupant restraint control module may lead to the non-deployment of the active head restraints during a rear impact collision.
Consequence & remedy
Consequence: In the event of a crash necessitating the deployment of the active head restraints , their non-deployment could increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will flash the Totally Integrated Power Module (TIPM) or replace the occupant restraint control module, as needed, free of charge. The recall began on November 19, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N38.
Additional source detail variants (2)
Air Bags
Chrysler is recalling certain model year 2011-2013 Sebring and 200 vehicles manufactured June 28, 2011, through December 13, 2012; model year 2011-2013 Dodge Avenger vehicles manufactured June 25, 2011, through January 14, 2013; model year 2011-2012 Dodge Nitro vehicles manufactured June 17, 2011, through December 15, 2011; and model year 2011-2012 Jeep Liberty vehicles manufactured June 17, 2011, through August 15, 2012. Electrical over-stress of a resistor in the occupant restraint control module may lead to the non-deployment of the active head restraints during a rear impact collision.
Consequence: In the event of a crash necessitating the deployment of the active head restraints , their non-deployment could increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will flash the Totally Integrated Power Module (TIPM) or replace the occupant restraint control module, as needed, free of charge. The recall began on November 19, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N38.
Electrical System
Chrysler is recalling certain model year 2011-2013 Sebring and 200 vehicles manufactured June 28, 2011, through December 13, 2012; model year 2011-2013 Dodge Avenger vehicles manufactured June 25, 2011, through January 14, 2013; model year 2011-2012 Dodge Nitro vehicles manufactured June 17, 2011, through December 15, 2011; and model year 2011-2012 Jeep Liberty vehicles manufactured June 17, 2011, through August 15, 2012. Electrical over-stress of a resistor in the occupant restraint control module may lead to the non-deployment of the active head restraints during a rear impact collision.
Consequence: In the event of a crash necessitating the deployment of the active head restraints , their non-deployment could increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will flash the Totally Integrated Power Module (TIPM) or replace the occupant restraint control module, as needed, free of charge. The recall began on November 19, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N38.
13V043000 · Fuel System, Gasoline; Fuel System, Gasoline:storage:tank Assembly
Feb 6, 2013
Chrysler is recalling certain model year 2013 Chrysler 200 and Dodge Avenger vehicles manufactured from October 30, 2012, through November 2, 2012. These vehicles may have a gas tank that has a broken control valve in the fuel tank assembly.
Consequence & remedy
Consequence: A broken control valve in the fuel tank assembly may lead to an engine stall or fuel leakage. An engine stall while driving may contribute to a vehicle crash. Fuel leakage, in the presence of an ignition source, may result in a fire.
Remedy: Chrysler will notify owners, and dealers will inspect the fuel tank assembly and replace any affected control valves, free of charge. The recall began on April 4, 2013. Owners may contact Chrysler at 1-800-247-9753.
Additional source detail variants (2)
Fuel System, Gasoline:storage:tank Assembly
Chrysler is recalling certain model year 2013 Chrysler 200 and Dodge Avenger vehicles manufactured from October 30, 2012, through November 2, 2012. These vehicles may have a gas tank that has a broken control valve in the fuel tank assembly.
Consequence: A broken control valve in the fuel tank assembly may lead to an engine stall or fuel leakage. An engine stall while driving may contribute to a vehicle crash. Fuel leakage, in the presence of an ignition source, may result in a fire.
Remedy: Chrysler will notify owners, and dealers will inspect the fuel tank assembly and replace any affected control valves, free of charge. The recall began on April 4, 2013. Owners may contact Chrysler at 1-800-247-9753.
Fuel System, Gasoline
Chrysler is recalling certain model year 2013 Chrysler 200 and Dodge Avenger vehicles manufactured from October 30, 2012, through November 2, 2012. These vehicles may have a gas tank that has a broken control valve in the fuel tank assembly.
Consequence: A broken control valve in the fuel tank assembly may lead to an engine stall or fuel leakage. An engine stall while driving may contribute to a vehicle crash. Fuel leakage, in the presence of an ignition source, may result in a fire.
Remedy: Chrysler will notify owners, and dealers will inspect the fuel tank assembly and replace any affected control valves, free of charge. The recall began on April 4, 2013. Owners may contact Chrysler at 1-800-247-9753.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE19014 · Active Head Rest Inadvertent Deployment
Opened Sep 9, 2019 · Closed Feb 25, 2026
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Seats
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.