Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 1 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Service Brakes, Air. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
1 reports
48,063 miles · Feb 28, 2009
Service Brakes, Air
WAS DRIVING TO MY DEALER MOTORHOME SUPERSTORE ,VERO BCH. FL. 78 MILES AWAY I SMELLED SOMETHING HOT AND FLUID SMELL. I STOPPED LOOKED AROUND AND DROVE THE LAST COUPLE OF BLOCKS TO THE RV PLACE WHEN I GOT THERE THEY SAID MY FRONT WHEELS WERE SMOKING I SAW FLUID ALL OVER THE TIRES ,THEY SENT ME TO SERVICE CHEVROLET A FEW BLOCKS A…
Read full complaint
WAS DRIVING TO MY DEALER MOTORHOME SUPERSTORE ,VERO BCH. FL. 78 MILES AWAY I SMELLED SOMETHING HOT AND FLUID SMELL. I STOPPED LOOKED AROUND AND DROVE THE LAST COUPLE OF BLOCKS TO THE RV PLACE WHEN I GOT THERE THEY SAID MY FRONT WHEELS WERE SMOKING I SAW FLUID ALL OVER THE TIRES ,THEY SENT ME TO SERVICE CHEVROLET A FEW BLOCKS AWAY ON SATURDAY HE CALLED ME TO SAY I NEEDED NEW CALIPERS AND ROTORS AND PADS AND FT/SENSORSSEALS COVER BEARINGS COST TO ME 4,826.24///THIS OCCURRED 3 MONTHS AFTER I PURCHASED THE RV ///YESTERDAY I TOOK RV IN FOR SAFETY CHECK AND OIL CHANGE TO MAROONE CHEVY IN GREENACRES ,FL HE SAID THE BACK CALIPERS ARE BURNT ONE BOLT MISSING ,THE SPEED SENSOR IS MELTED CAUSING ABS LIGHT TO STAY ON, APROX COST 2,000. I HEAR NOW THAT THERE ARE OTHERS WITH THE SAME PROBLEM I HAVE 2002/2003 DOLPHIN LX AND HAVE PUT ON LESS THAN 10,000. MILES NOW I'M AFRAID TO DRIVE IT. AT 57,000.MILES. ON ODOMIS THERE ANYTHING I CAN DO ? I WAS TOLD WORKHORSE WAS THE BEST , I 'M NOT SO SURE NOW? PLANNING A TRIP THROUGH THE MOUNTAINS THIS SUMMER FROM FLORIDA SHOULD I BE CONCERNED?*TR
Isuzu Manufacturing Services of America, Inc. (Isuzu) is recalling certain model year 2001-2013 Isuzu N-Series; model year 2001-2010 Chevrolet and GMC W-Series; model year 2001-2004 Isuzu FRR and model year 2001-2004 Chevrolet and GMC WT5500 trucks. The affected vehicles are equipped with an optional oil pan heater (RPO code IG3). Debris may collect at the contact point of the heater plug and the extension cord. This may cause overheating of the extension cord.
Consequence & remedy
Consequence: Overheating of the extension cord could melt the oil pan heater plug and/or block heater plug, resulting in an increased risk of fire.
Remedy: Isuzu will notify owners and dealers will inspect the trucks. The extension cord and damaged components will be replaced, free of charge. The recall began on August 30, 2013. Owners may contact Isuzu at 1-866-441-9638.
Additional source detail variants (2)
Equipment
Isuzu Manufacturing Services of America, Inc. (Isuzu) is recalling certain model year 2001-2013 Isuzu N-Series; model year 2001-2010 Chevrolet and GMC W-Series; model year 2001-2004 Isuzu FRR and model year 2001-2004 Chevrolet and GMC WT5500 trucks. The affected vehicles are equipped with an optional oil pan heater (RPO code IG3). Debris may collect at the contact point of the heater plug and the extension cord. This may cause overheating of the extension cord.
Consequence: Overheating of the extension cord could melt the oil pan heater plug and/or block heater plug, resulting in an increased risk of fire.
Remedy: Isuzu will notify owners and dealers will inspect the trucks. The extension cord and damaged components will be replaced, free of charge. The recall began on August 30, 2013. Owners may contact Isuzu at 1-866-441-9638.
Electrical System
Isuzu Manufacturing Services of America, Inc. (Isuzu) is recalling certain model year 2001-2013 Isuzu N-Series; model year 2001-2010 Chevrolet and GMC W-Series; model year 2001-2004 Isuzu FRR and model year 2001-2004 Chevrolet and GMC WT5500 trucks. The affected vehicles are equipped with an optional oil pan heater (RPO code IG3). Debris may collect at the contact point of the heater plug and the extension cord. This may cause overheating of the extension cord.
Consequence: Overheating of the extension cord could melt the oil pan heater plug and/or block heater plug, resulting in an increased risk of fire.
Remedy: Isuzu will notify owners and dealers will inspect the trucks. The extension cord and damaged components will be replaced, free of charge. The recall began on August 30, 2013. Owners may contact Isuzu at 1-866-441-9638.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2003 Chevrolet W-SERIES Problems, Complaints & Recalls | Skip That Year
Illustration