IllustrationService airbag alert popped up
2015 Chevrolet Volt
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2015 Chevrolet Volt do not stand out strongly from the model-year median of 169.
About this comparison →How this year compares
Owner complaints by model year
Compare all Volt years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
90–25K
325–50K
650–75K
375–100K
2100–150K
0150K+
23 reports with mileage · 21 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports1 fire reports1 injury reports
Air Bags complaints
7 reportsThe passenger presence sensor in the front passenger seat is malfunctioning and spare parts to replace it are not available from the manufacturer. The Chevrolet dealership has inspected and verified this issue, and the system is available for inspection upon request. This is the same issue that NHTSA investigated in the 2013 mod…
Read full complaint
The passenger presence sensor in the front passenger seat is malfunctioning and spare parts to replace it are not available from the manufacturer. The Chevrolet dealership has inspected and verified this issue, and the system is available for inspection upon request. This is the same issue that NHTSA investigated in the 2013 model described below. This sensor failure results in a check airbag signal and prevents the deployment of the passenger frontal and knee air bags, posing risk of serious injury to passengers. The PSS may develop a malfunction due to bunching of the sensor mat in the seat trench. The bunching of the sensor mat could cause the mat to repeatedly fold in the same location. Over time, the repeated folding can cause an increased resistance in the sensor mat. An increased resistance in the PSS sensor mat is detected as a fault in the air bag system diagnostic. If this fault is detected, a diagnostic trouble code will be stored in the air bag control unit and the air bag MIL will illuminate. Further, if the fault is detected, the passenger frontal and knee air bags will be suppressed in a crash of sufficient severity to warrant a commanded deployment regardless of the nature of size of the occupant of the front passenger seat.
The service airbag request keeps showing up and I was told it was the Passenger presence module and sensor. This puts people at risk of the airbag not deploying correctly.
"SERVICE AIRBAG" WARNING ON 2015 VOLT, WHICH APPARENTLY IS A WELL-KNOWN ISSUE FOR WHICH GENERAL MOTORS REFUSES TO TAKE ANY RESPONSIBILITY. AIRBAGS SHOULD NOT BE A CONCERN ON CAR--EVER. THEY WANT OVER $800 FOR THE REPAIR WHEN IT IS CLEARLY A MANUFACTURING DEFECT.
CAR WAS PURCHASED USED ON 9/12/18 WITH 50K MILES AND SOON AFTER PURCHASE THE SERVICE AIRBAG WARNING POPS UP INTERMITTENTLY EVERYDAY DURING SHORT OR LONG DRIVES. COMMON COMPLAINT IS PASSENGER AIRBAG SENSOR BUT I HAVE NOT TAKEN IT TO BE DIAGNOSED SINCE COMMON REPAIR COSTS IS OVER 800 DOLLARS.
WHEN A PASSENGER GETS OUT OF THE FRONT PASSENGER SEAT A WARNING WILL FLASH SAYING TO SERVICE THE AIRBAG. PROBLEM WILL PERSISTS UNTIL THE CAR IS SHUT OFF AND WON'T SHOW UP AGAIN UNTIL A PASSENGER SITS IN THE FRONT PASSENGER SEAT AGAIN. SEEMS TO BE A PROBLEM WITH THE PASSENGER OCCUPANCY SENSOR. THE PROBLEM HAS PERSISTED SINC…
Read full complaint
WHEN A PASSENGER GETS OUT OF THE FRONT PASSENGER SEAT A WARNING WILL FLASH SAYING TO SERVICE THE AIRBAG. PROBLEM WILL PERSISTS UNTIL THE CAR IS SHUT OFF AND WON'T SHOW UP AGAIN UNTIL A PASSENGER SITS IN THE FRONT PASSENGER SEAT AGAIN. SEEMS TO BE A PROBLEM WITH THE PASSENGER OCCUPANCY SENSOR. THE PROBLEM HAS PERSISTED SINCE BEGINNING OF OWNERSHIP APPROX. 1 MONTH AGO, AND CONTINUES UNTIL THE DATE OF THIS REPORT.
THE SERVICE AIR BAG MESSAGE INTERMITTENTLY TURNS ON AND OFF FOR NO REASON. CAR HAS NOT BEEN IN AN ACCIDENT.
Official recalls
115V442000 · Steering
Jul 10, 2015
General Motors LLC (GM) is recalling certain model year 2014-2015 Chevrolet Cruze vehicles manufactured November 8, 2013, to March 12, 2015, and 2015 Chevrolet Volt vehicles manufactured April 11, 2014. In the affected vehicles, the inner tie rod may not be tightened to specification allowing the tie rod to separate from the steering gear.
Consequence & remedy
Consequence: Separation of the tie rod from the steering gear could result in the loss of steering, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the steering gear assembly, free of charge. The recall began on July 28, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15386.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.