IllustrationSudden loss of power. Driving on freeway. Speed decreased by 25 mph. Just about avoided a rear end accident. Have seen that 2016 onwards Volts have experienced this malfunction. Request that it be noted that this is a 2013 model with less than 60,000 miles. Have already had the latest programming done by Chevy.
2013 Chevrolet Volt
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2013 Chevrolet Volt do not stand out strongly from the model-year median of 169.
About this comparison →How this year compares
Owner complaints by model year
Compare all Volt years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
380–25K
2925–50K
6050–75K
4775–100K
33100–150K
6150K+
213 reports with mileage · 95 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 161 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 63 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports2 fire reports7 injury reports
What owners actually said
308 reportsI have a 2013 Volt. Passenger Presence pad in the passenger front seat caused the "Airbag Service" warning light. It is very common. So many people have suffered from it. It cost over $1000. But it is not a recall.
1)A diagnostic inspection performed by Terry Labonte Chevrolet in Greensboro, N.C., during the week of Feb. 5-9 found that the car’s propulsion system suffered “catastrophic failure” and was a “total loss.” 2)My wife and I were in convoy when we drove off the used-car lot in Pittsboro, N.C., on [XXX], heading for my sister’s h…
Read full complaint
1)A diagnostic inspection performed by Terry Labonte Chevrolet in Greensboro, N.C., during the week of Feb. 5-9 found that the car’s propulsion system suffered “catastrophic failure” and was a “total loss.” 2)My wife and I were in convoy when we drove off the used-car lot in Pittsboro, N.C., on [XXX], heading for my sister’s home in Greensboro. By the time we reached [XXX], the Volt would not reach highway speeds as heavy traffic sped past. As NHTSA has reported in another Volt investigation, “the problem could pose a safety risk if vehicles can’t move with the flow of surrounding traffic and is more serious if a stalled vehicle is unable to restart.” 3) On Tuesday, [XXX], a Terry Labonte Chevrolet service representative in Greensboro reported that the main battery had experienced “catastrophic” failure and the “major malfunction” represented a “total loss." 4) Factory dealer Terry Labonte Chevrolet in Greensboro performed the diagnostics. 5) An instrument-panel message appeared about 15 minutes after I drove the Volt off the used-car lot in Pittsboro. The message read “propulsion power is reduced.” The owner manual (Page 5-48) read: “The vehicle may be driven at a reduced speed while this message is on, but maximum acceleration and speed may be reduced.” INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The passenger side seat airbag sensor is malfunctioning. A message displaying “Service Airbag” comes up and the airbag light comes on. This happens numerous times during a typical drive (around 20 minutes) The airbag is turned off while the message and light is displayed. This issue has been occurring for about a year or two now…
Read full complaint
The passenger side seat airbag sensor is malfunctioning. A message displaying “Service Airbag” comes up and the airbag light comes on. This happens numerous times during a typical drive (around 20 minutes) The airbag is turned off while the message and light is displayed. This issue has been occurring for about a year or two now. Starting around 90k miles, currently has 111k miles. I’ve done my research on this issue and many other Volt owners have this issue. Which is caused by a defect in the passenger side sensor mat in the seat that can fold over itself with normal use, causing the issue.
I was driving my plugin hybrid Volt on a highway when the engine stalled and the engine light turned on. I tap the throttle a few times to get it to stay on. It worked, but I had to continue to tap the throttle to keep it going. It also revved up sharply when it was in low gear. The vehicle was out of battery, so it was as runn…
Read full complaint
I was driving my plugin hybrid Volt on a highway when the engine stalled and the engine light turned on. I tap the throttle a few times to get it to stay on. It worked, but I had to continue to tap the throttle to keep it going. It also revved up sharply when it was in low gear. The vehicle was out of battery, so it was as running on engine.
My 2013 Volt will not charge or start. This happened suddenly. It has been working fine.
Airbag Sensor Service light keeps going off. Passenger side.
I received a notification on the dashboard that the engine is not in service and propulsion has been reduced. The car is available for inspection upon request. The safety and myself has been deeply compromised because the issues cause the car to suddenly not accelerate without warning. The issue happened to me on a freeway and c…
Read full complaint
I received a notification on the dashboard that the engine is not in service and propulsion has been reduced. The car is available for inspection upon request. The safety and myself has been deeply compromised because the issues cause the car to suddenly not accelerate without warning. The issue happened to me on a freeway and could have caused an accident due to the engine and propulsion systems stop functioning without warning. The vehicle has been inspected. There were no warnings on why the car was doing what it was doing. The only warning I received was that the engine and propulsion system has now stopped functioning.
We purchased this car used in January 2023. Several times throughout 2023 we have gotten a Propoulsion Power Reduced warning. When this happens the car’s ability to accelerate drops and we have also had problems getting it to charge. Following one incident, we let the car sit for 4 days. While the car still would not charge us…
Read full complaint
We purchased this car used in January 2023. Several times throughout 2023 we have gotten a Propoulsion Power Reduced warning. When this happens the car’s ability to accelerate drops and we have also had problems getting it to charge. Following one incident, we let the car sit for 4 days. While the car still would not charge using our at home level 2 charger, the warning went away and I was able to drive it to a dealership. They ran a software update which they said should resolve the issue. Three times since then, when turning the car on from parked it in parking lots away from home, it has given the warning. While driving the car to get it home, the warning has spontaneously resolved.
Intermittent warning for front passenger airbag. Module saying service airbag comes on and off when front passenger is occupying seat. Just a quick anecdote just had car inspected warning does not appear while someone is occupying front seat, nor does it appear if someone is occupying rear seats.
Official recalls
323V516000 · Air Bags:frontal:driver Side:inflator Module
Jul 27, 2023
General Motors, LLC (GM) is recalling certain 2013 Buick Verano, Chevrolet Camero, Sonic, and Volt vehicles. The driver-side air bag inflator may explode during deployment due to a manufacturing defect.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver-side air bag module, free of charge. On some 2013 Volt vehicles, the steering wheel will be replaced as well, free of charge. Owner notification letters were mailed October 23, 2023. Owners may contact Buick customer service at 1-800-521-7300 and Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N232413120.
18V397000 · Hybrid Propulsion System
Jun 14, 2018
General Motors LLC (GM) is recalling certain 2013 Chevrolet Volt vehicles. An update to the Hybrid Powertrain Control Module 2 (HPCM2) may have disabled the cell balancing function causing a low-voltage condition.
Consequence & remedy
Consequence: If the voltage drops, the vehicle may lose propulsion, increasing the risk of crash.
Remedy: GM will notify owners, and dealers will reprogram the HPCM2, free of charge. The recall began July 24, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 18215.
15V145000 · Electrical System:ignition; Engine And Engine Cooling:engine:gasoline
Mar 13, 2015
General Motors LLC (GM) is recalling certain model year 2011-2013 Volt vehicles manufactured August 25, 2010, to June 26, 2013. If the driver exits the vehicle without turning off the electrical system, the battery may drain low enough that the gasoline engine will automatically start itself to recharge the electric battery.
Consequence & remedy
Consequence: If the engine runs for an extended period of time in an enclosed space, there may be a build up of carbon monoxide, increasing the risk of personal injury.
Remedy: GM will notify owners, and dealers will update the engine management software to limit the time that the stationary vehicle can be left in the ON position, free of charge. The recall began April 15, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14617.
Additional source detail variants (2)
Electrical System:ignition
General Motors LLC (GM) is recalling certain model year 2011-2013 Volt vehicles manufactured August 25, 2010, to June 26, 2013. If the driver exits the vehicle without turning off the electrical system, the battery may drain low enough that the gasoline engine will automatically start itself to recharge the electric battery.
Consequence: If the engine runs for an extended period of time in an enclosed space, there may be a build up of carbon monoxide, increasing the risk of personal injury.
Remedy: GM will notify owners, and dealers will update the engine management software to limit the time that the stationary vehicle can be left in the ON position, free of charge. The recall began April 15, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14617.
Engine And Engine Cooling:engine:gasoline
General Motors LLC (GM) is recalling certain model year 2011-2013 Volt vehicles manufactured August 25, 2010, to June 26, 2013. If the driver exits the vehicle without turning off the electrical system, the battery may drain low enough that the gasoline engine will automatically start itself to recharge the electric battery.
Consequence: If the engine runs for an extended period of time in an enclosed space, there may be a build up of carbon monoxide, increasing the risk of personal injury.
Remedy: GM will notify owners, and dealers will update the engine management software to limit the time that the stationary vehicle can be left in the ON position, free of charge. The recall began April 15, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14617.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
PE19013 · Passenger Sensing System
Opened Sep 17, 2019 · Closed Jul 2, 2021
Status: closed (inferred from source dates) · Air Bags:sensor:occupant Classification:front Passenger
In September 2019, the Office of Defects Investigation (ODI) opened PE19-013 to assess the potential safety related effects of a malfunction of the Passenger Sensing System (PSS) in 2012-2013 Model Year (MY) Chevrolet Volt vehicles. Consumers reported that due to a malfunction of the PSS, the air bag system malfunction indicator light (MIL) was activated. Many of the complaints noted the malfunction occurred after the warranty period expired and mentioned high repair costs as a major deterrent to the repair of the vehicle.The PSS sensor mat is embedded in the front passenger seat cushion and is intended to detect child seats and small statured occupants who could be harmed by deployment of the frontal passenger air bag. The PSS may develop a malfunction due to bunching of the sensor mat in the seat trench. The bunching of the sensor mat could cause the mat to repeatedly fold in the same location. Over time, the repeated folding can cause an increased resistance in the sensor mat. An increased resistance in the PSS sensor mat is detected as a fault in the air bag system diagnostic. If this fault is detected, a diagnostic trouble code will be stored in the air bag control unit and the air bag MIL will illuminate.Further, if the fault is detected, the passenger frontal and knee air bags will be suppressed in a crash of sufficient severity to warrant a commanded deployment regardless of the nature of size of the occupant of the front passenger seat.The report counts shown above include only those reports that specifically address the issue covered by this investigation, failure of the PSS sensor mat. Reports alleging only that the air bag light is on with no cause stated, or where a different cause was otherwise identified, were excluded as the air bag light could be illuminated for system faults other than a PSS malfunction.The subject vehicles have been in service for approximately ten (10) years. An analysis of General Motors (GM) warranty data for the subject vehicles, including a comparison with other agency and manufacturer data pertaining to similar occupant detection system failure investigations, indicates the subject vehicles experience a comparatively low complaint rate for this issue given the number of years the vehicles have been in service.GM has instituted a cost reduction program for the repair/replacement of the PSS in the subject vehicles. Based on this cost reduction program as well as:1) a comparatively low warranty rate; 2) no reported injuries, deaths or asymmetric deployments; and 3) the age of the vehicles; ODI is closing this Preliminary Evaluation. The closing of this investigation does not constitute a finding by NHTSA that a safety related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.