GAS GAUGE DOES NOT ACCURATELY REFLECT FUEL. IT JUMPS WILDLY AT TIMES FROM FULL TO EMPTY AND BACK TO FULL. IT OFTEN SHOWS 3/4 OF A TANK WHEN IT IS ACTUALLY NEAR EMPTY. I HAD TO BEGIN TRACKING MY MILEAGE TO ENSURE I DO NOT RUN OUT OF GAS. GAS LIGHT GOES ON AND OFF BUT USUALLY COINCIDES WITH AN EMPTY READING. AND THIS IS NOT COVERE…
Read full complaint
GAS GAUGE DOES NOT ACCURATELY REFLECT FUEL. IT JUMPS WILDLY AT TIMES FROM FULL TO EMPTY AND BACK TO FULL. IT OFTEN SHOWS 3/4 OF A TANK WHEN IT IS ACTUALLY NEAR EMPTY. I HAD TO BEGIN TRACKING MY MILEAGE TO ENSURE I DO NOT RUN OUT OF GAS. GAS LIGHT GOES ON AND OFF BUT USUALLY COINCIDES WITH AN EMPTY READING. AND THIS IS NOT COVERED UNDER ANY WARRANTY. WHEN THIS STARTED HAPPENING I RAN OUT OF GAS WITH 2 SMALL CHILDREN IN THE CAR IN WINTER DUE TO GAUGE SAID 1/2 TANK... *TR
NHTSA ODI #10553812
125,000 miles · Feb 25, 2012
Electrical SystemFuel System, Gasoline
THE SPEEDOMETER STARTED ACTING SPORADIC NOT REGISTERING SPEED ACCURATELY THEN STOPPED WORKING ALL TOGETHER ALSO THE GAS GAUGE DOES NOT REGISTER AT ALL SINCE THE PROBLEM BEGAN .THE LOW FUEL LIGHT DOES OPERATE AS OF RIGHT NOW.I HAVE READ THAT ALOT OF VENTURE OWNERS HAVE THIS PROBLEM IT IS AVERY EXPENSIVE REPAIR 500 JUST FOR THE PA…
Read full complaint
THE SPEEDOMETER STARTED ACTING SPORADIC NOT REGISTERING SPEED ACCURATELY THEN STOPPED WORKING ALL TOGETHER ALSO THE GAS GAUGE DOES NOT REGISTER AT ALL SINCE THE PROBLEM BEGAN .THE LOW FUEL LIGHT DOES OPERATE AS OF RIGHT NOW.I HAVE READ THAT ALOT OF VENTURE OWNERS HAVE THIS PROBLEM IT IS AVERY EXPENSIVE REPAIR 500 JUST FOR THE PARTS. *TR
NHTSA ODI #10449310
Mileage unknown · Sep 17, 2011
Fuel System, Gasoline
OUR MECHANIC FOUND THAT THE FUEL TANK WAS LEAKING AND THAT THERE IS A RECALL FOR THAT PART. WE TOOK IT TO THE DEALER AND THE DEALER STATED THAT THERE IS NO RECALL FOR OUR VAN. THE DEALER WAS. THE NHTSA ACTION NUMBER IS EA 07006. WE CALLED GM AND LEFT TWO MESSAGES FOR A REPRESENTATIVE NAMED. PLEASE REQUIRE THE DEALER TO HONO…
Read full complaint
OUR MECHANIC FOUND THAT THE FUEL TANK WAS LEAKING AND THAT THERE IS A RECALL FOR THAT PART. WE TOOK IT TO THE DEALER AND THE DEALER STATED THAT THERE IS NO RECALL FOR OUR VAN. THE DEALER WAS. THE NHTSA ACTION NUMBER IS EA 07006. WE CALLED GM AND LEFT TWO MESSAGES FOR A REPRESENTATIVE NAMED. PLEASE REQUIRE THE DEALER TO HONOR THE RECALL. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) *TT
NHTSA ODI #10425867
71,390 miles · Jul 22, 2010
Fuel System, Gasoline
GAS GAUGE READS EMPTY WHEN FULL OR HALF FULL. *TR
NHTSA ODI #10344736
43,050 miles · Aug 21, 2008
Fuel System, Gasoline
WHERE THE RUBBER GAS TANK FILL HOSE ATTACHES TO THE GAS TANK, AT THE CHECK VALVE, IT HAS FRACTURED AND BROKEN OFF THE GAS TANK SO THAT NOW WHEN ATTEMPTING TO ADD FUEL TO THE VEHICLE IT LEAK OUT ALL OVER THE EXTERIOR OF THE TANK. *TR
ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).
Consequence & remedy
Consequence: A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION INCLUDES BUICK RENDEZVOUS AND PONTIAC AZTEK VEHICLE BUILT IN MAY 2003; CHEVROLET VENTURE AND PONTIAC MONTANA VEHICLES BUILT FROM JUNE THROUGH AUGUST 2002; AND ALL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO, AND HAWAII.
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Consequence & remedy
Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
CERTAIN MINIVANS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 213, "CHILD RESTRAINT SYSTEMS." THESE VEHICLES DO NOT HAVE TEXT AND FORMATTING ON THE WARNING LABEL ATTACHED TO THE AVAILABLE SECOND-ROW INTEGRAL CHILD RESTRAINT AS SPECIFIED BY AMENDMENTS TO THE STANDARD.
Consequence & remedy
Consequence: Not supplied
Remedy: OWNERS WILL BE PROVIDED WITH REPLACEMENT LABELS AND INSTALLATION INSTRUCTIONS. OWNER NOTIFICATION BEGAN ON JULY 23, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR PONTIAC AT 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE04064 · POWER-SLIDING Door
Opened Sep 17, 2004 · Closed Dec 22, 2004
Status: closed (inferred from source dates) · Structure:body:door
SUBJECT VEHICLES ARE AVAILABLE WITH AN OPTIONAL POWER SLIDING DOOR.THE INTERIOR HANDLE IS ORIENTED IN THE VERTICAL POSITION IN THE DOOR PANEL AND LINES UP AT THE ELBOW LEVEL WHEN THE OCCUPANT IS SEATED IN THE 2ND-ROW OUTBOARD POSITION.IF THE OCCUPANT HOLDS THE INTERIOR HANDLE IN THE THUMB UP POSITION DURING POWER-ASSISTED OPENING, THE ARM/WRIST CAN BE PUSH BACK WITH FORCE AGAINST THE 2ND-ROW BUCKET SEAT OR CAPTAIN'S CHAIR SEAT BACK CREATING A RISK OF INJURY (OTHER SEATING CONFIGURATIONS HAVE AMPLE SEAT TO DOOR CLEARANCE TO AVOID ENTRAPMENT OF THE LOWER ARM).AMONG THE 103 TOTAL REPORTS, THERE WERE 102 ALLEGED INJURIES INCLUDING ARM/WRIST, THUMB AND SHOULDER INJURIES.A COUNT OF INJURIES REVEALS THAT 76 INJURIES WERE A FRACTURED OR A BROKEN ARM/WRIST REQUIRING AN IMMOBILIZING CAST FOR FOUR-TO-SIX WEEKS.ALL INJURIES INVOLVE THE RIGHT SIDE POWER SLIDING DOOR.THE LEFT SIDE POWER SLIDING DOOR IS ON FAR FEWER VEHICLES, BUT MORE IMPORTANTLY, IT PRODUCES LESS FORCE.GM NOTIFIED THE AGENCY BY LETTER DATED DECEMBER 21, 2004, THAT IT WILL RECALL MODEL YEAR 1997 THOUGH EARLY 2005 GM U-VAN VEHICLES EQUIPPED WITH A RIGHT SIDE POWER SLIDING DOOR AND WITH 2ND-ROW BUCKET SEATS OR CAPTAIN CHAIRS (NHTSA RECALL #04V597).AS PART OF THE RECALL REMEDY, GM WILL REPLACE THE DOOR HANDLE WITH A FLUSH MOUNTED HANDLE THAT WILL PREVENT AN OCCUPANT FROM GRASPING THE HANDLE WITH THE PALM BETWEEN THE HANDLE AND DOOR PANEL (THUMB UP ORIENTATION) AND THUS ELIMINATE THE POTENTIAL FOR ARM/WRIST ENTRAPMENT.THIS INVESTIGATION IS CLOSED.
2004 Chevrolet Venture Problems, Complaints & Recalls | Skip That Year
Illustration