IllustrationVEHICLE WINDSHIELD WIPERS OPERATE OUT OF "SYNC" AND JAM IN THE MIDDLE OF THE WINDSHIELD. THIS HAS HAPPENED 3 TIMES. THE WINDSHIELD WIPER MOTOR MODULE HAS BEEN REPLACED ONCE. I HAVE SCHEDULED REPAIRS FOR 12/8/2005, AT THE CHEVROLET DEALER WHERE I PURCHASED THE VEHICLE. *JB
2001 Chevrolet Venture
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2001 Chevrolet Venture do not stand out strongly from the model-year median of 220.
About this comparison →How this year compares
Owner complaints by model year
Compare all Venture years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
150–25K
4025–50K
2950–75K
1975–100K
13100–150K
14150K+
130 reports with mileage · 92 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 44 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 25 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
17 crash reports3 fire reports23 injury reports
What owners actually said
222 reportsTAIL LIGHTS WOULD ILLUMINATE DIMLY ON THE DASH AND THEN FAIL TO OPERATE. THIS CREATED A DANGEROUS SITUATION WHEN TURNING. REPLACED BOTH TAIL LIGHT CIRCUIT BOARDS AND PIGTAILS. *NM
DT: THE CONTACT STATED TEMPERATURE GAUGE WAS GOING UP AND DOWN. THE DEALER TOLD HIM THE THERMOMETER WAS NOT WORKING. HE PICKED UP THE CAR AND IN 3 THREE DAYS LATER THE CAR BLEW UP. HE HAD IT TOWED A WEEK LATER THEY TOLD HIM A NEW ENGINE WAS NEEDED. IT HAS BEEN 5 WEEKS SINCE HE TOOK THE VEHICLE TO THE DEALER, THEY STILL HAVE N…
Read full complaint
DT: THE CONTACT STATED TEMPERATURE GAUGE WAS GOING UP AND DOWN. THE DEALER TOLD HIM THE THERMOMETER WAS NOT WORKING. HE PICKED UP THE CAR AND IN 3 THREE DAYS LATER THE CAR BLEW UP. HE HAD IT TOWED A WEEK LATER THEY TOLD HIM A NEW ENGINE WAS NEEDED. IT HAS BEEN 5 WEEKS SINCE HE TOOK THE VEHICLE TO THE DEALER, THEY STILL HAVE NOT FIXED IT. ON THE 2ND DAY AFTER HE BOUGHT THE CAR THE AIR CONDITIONER WAS NOT WORKING.*AK *JB
SIMILAR PROBLEMS WITH COOLING SYSTEM AS REPORTED BY OTHER POSTS. PURCHASED VEHICLE NEW. SERVICED AT SHOP REGULARLY. AT 60,000 MILES THE SUPPOSED "100,000 MILE" COOLING SYSTEM SUDDENLY DEVELOPED LEAK IN LOWER INTAKE. AS THE TEMPERATURE GAUGE ROSE INTO THE HOT, I TURNED THE ENGINE OFF TO LET IT COOL OFF. WHEN I DROVE IT TO TH…
Read full complaint
SIMILAR PROBLEMS WITH COOLING SYSTEM AS REPORTED BY OTHER POSTS. PURCHASED VEHICLE NEW. SERVICED AT SHOP REGULARLY. AT 60,000 MILES THE SUPPOSED "100,000 MILE" COOLING SYSTEM SUDDENLY DEVELOPED LEAK IN LOWER INTAKE. AS THE TEMPERATURE GAUGE ROSE INTO THE HOT, I TURNED THE ENGINE OFF TO LET IT COOL OFF. WHEN I DROVE IT TO THE SHOP (MAYBE DRIVING A TOTAL OF 10 MILES AFTER PROBLEM STARTED), SHOP DIAGNOSED IT AS LOWER INTAKE GASKET LEAK. THE MANUAL SAYS IT HAS A ENGINE SAFETY FEATURE TO ALTERNATELY FIRE THE CYLINDERS TO KEEP HEADS FROM BLOWING. DIDN'T WORK FOR ME. BOTH HEAD GASKETS BLOWN. WARPED HEADS. HAD TO HAVE HEADS SHAVED. $2000 REPAIR BILL DURING A VACATION AT A GM SHOP. THE SHOP PUT ON "NEWER GASKETS" THIS ISN'T RIGHT! *JB
DT: WHILE DRIVING 20 MPH THEN STOPPING AT A RED LIGHT THERE WAS A POPPING NOISE. THE CONSUMER THOUGHT THERE WAS A FLAT TIRE ON THE LEFT FRONT. CONSUMER PULLED TO THE SIDE OF THE ROAD. UPON INSPECTION HE SAW THAT THE ENGINE HAD DROPPED AND WAS HANGING FROM UNDERNEATH THE VEHICLE ABOUT 2 INCHES FROM THE GROUND. HAD THE VE…
Read full complaint
DT: WHILE DRIVING 20 MPH THEN STOPPING AT A RED LIGHT THERE WAS A POPPING NOISE. THE CONSUMER THOUGHT THERE WAS A FLAT TIRE ON THE LEFT FRONT. CONSUMER PULLED TO THE SIDE OF THE ROAD. UPON INSPECTION HE SAW THAT THE ENGINE HAD DROPPED AND WAS HANGING FROM UNDERNEATH THE VEHICLE ABOUT 2 INCHES FROM THE GROUND. HAD THE VEHICLE TOWED TO GM DEALER FOR REPAIRS. BASICALLY, THE BOLTS THAT HELD THE ENGINE MOUNT BROKE. THE DEALER SUGGESTED SOMEONE HAD DONE THIS TO THE VEHICLE BECAUSE THE ENGINE COMPLETELY BROKE OFF. THE CONSUMER KEPT VEHICLE GARAGED. THE REPAIRS WERE DONE AT CONSUMER'S EXPENSE. GM OFFERED NO FINANCIAL ASSISTANCE OR COVERAGE. *AK *NM
DT: CONSUMER HAD A 2001 CHEVROLET VENTURE. THE AIR CONDITIONER CONDENSER CRACKED AND FREON LEAKED OUT. CONSUMER FOUND A TECHNICAL SERVICE BULLETIN CONCERNING THIS PROBLEM. CONSUMER FELT THAT BECAUSE HE TRANSPORTS HIS CHILDREN IT WAS A SAFETY ISSUE. DEALERSHIP STATED THIS HAPPENED IN MANY OF THESE VEHICLES. *AK.*JB
2001 CHEVROLET VENTURE HOOD FLEW UP ON THE CAR WHILE DRIVING SMASHING THE FRONT WINDSHIELD.*MR THE DEALER TOLD THE CONSUMER THE HOOD RELEASE MAY HAVE BEEN PULLED INADVERTENTLY. *JB
FRONT LEFT AXLE OF 01 CHEVY VENTURE IS MAKING A BAD GRINDING TYPE NOISE WHICH GETS LOUDER THE FASTER YOU DRIVE. AFRAID IT MAY CAUSE AN ACCIDENT OR DAMAGE VEHICLE.
JULY 16, 2005 I WAS DRIVING MY 2001 CHEVROLET VENTURE ALONG MY LOCAL STREET SMITHTOWN NY WHEN I HEARD A EXTREMELY LOUD BANG. WITH GREAT DIFFICULTY I PULLED MY CAR OVER AND CONTACTED MY HUSBAND. WHEN HE OPENED THE HOOD THE ENGINE HAD FALLEN OUT OF THE VEHICLE. UPON TOWING THE VEHICLE TO A LICENSED GM MECHANIC I LEARNED THAT TH…
Read full complaint
JULY 16, 2005 I WAS DRIVING MY 2001 CHEVROLET VENTURE ALONG MY LOCAL STREET SMITHTOWN NY WHEN I HEARD A EXTREMELY LOUD BANG. WITH GREAT DIFFICULTY I PULLED MY CAR OVER AND CONTACTED MY HUSBAND. WHEN HE OPENED THE HOOD THE ENGINE HAD FALLEN OUT OF THE VEHICLE. UPON TOWING THE VEHICLE TO A LICENSED GM MECHANIC I LEARNED THAT THE CV KNUCKLE AND THE RACK AND PINION STEERING SYSTEM SNAPPED WHEN THE ENGINE FELL. UPON CONTACTING GM/CHEVROLET CUSTOMER SERVICE THEY OFFERED TO PAY FIFTY PERCENT OF THE REPAIR COSTS, I FEEL THIS IS UNACCEPTABLE AND THEY SHOULD PAY ONE HUNDRED PERCENT OF MY REPAIR COSTS. THIS VEHICLE IS ACCIDENT FREE. AN ENGINE SHOULD NOT FALL OUT OF A FOUR YEAR OLD CAR. *NM
DT: CONTACT STATED WHEN PUSHING THE BUTTON ON THE AUTOMATIC SLIDING DOOR TO SHUT IT DOOR DID NOT SHUT. IT REOPENED. HAD THIS PROBLEM FOR A LONG TIME. CALLER HAS NOT TALKED TO A DEALER ABOUT THE PROBLEM. THE BUTTON FOR THE POWER WINDOWS DID NOT WORK ALL OF THE TIME. .SHE RECEIVED A RECALL NOTICE FOR A 1999 MODEL REGARDING…
Read full complaint
DT: CONTACT STATED WHEN PUSHING THE BUTTON ON THE AUTOMATIC SLIDING DOOR TO SHUT IT DOOR DID NOT SHUT. IT REOPENED. HAD THIS PROBLEM FOR A LONG TIME. CALLER HAS NOT TALKED TO A DEALER ABOUT THE PROBLEM. THE BUTTON FOR THE POWER WINDOWS DID NOT WORK ALL OF THE TIME. .SHE RECEIVED A RECALL NOTICE FOR A 1999 MODEL REGARDING THE SLIDING DOORS. THERE WAS NO RECALL NUMBER AVAILABLE. SHE NO LONGER HAS THE 1999 VEHICLE. WAS CALLING TO COMPLAIN THAT SHE WAS HAVING THE SAME PROBLEM WITH HER 2001 MODEL AND SHE HAS NOT RECEIVED A RECALL LETTER. *AK *TT
Official recalls
907V349000 · Fuel System, Gasoline:storage
Aug 8, 2007
ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).
Consequence & remedy
Consequence: A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION INCLUDES BUICK RENDEZVOUS AND PONTIAC AZTEK VEHICLE BUILT IN MAY 2003; CHEVROLET VENTURE AND PONTIAC MONTANA VEHICLES BUILT FROM JUNE THROUGH AUGUST 2002; AND ALL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO, AND HAWAII.
04V597000 · Latches/locks/linkages:doors:latch
Dec 22, 2004
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Consequence & remedy
Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
03V250000 · Equipment:other:owners/service/other Manual
Jul 15, 2003
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
02V329000 · Air Bags:frontal
Dec 9, 2002
ON CERTAIN PASSENGER, SPORT UTILITY VEHICLES AND MINI VANS, SOME OF THESE VEHICLES HAVE A PASSENGER AIR BAG THAT WAS MANUFACTURED WITHOUT A CHECK VALVE PIN. AN AIR BAG WITHOUT THE CHECK VALVE PIN COULD PRODUCE INCREASED PRESSURE AT THE ONSET OF THE AIR BAG DEPLOYMENT AND REDUCED PRESSURE AFTERWARD.
Consequence & remedy
Consequence: THIS COULD INCREASE THE SEVERITY OF INJURY TO A PERSON WHO WAS NOT PROPERLY RESTRAINED AND WHO WAS CLOSE TO THE PASSENGER AIR BAG AT THE TIME OF DEPLOYMENT. IT COULD ALSO REDUCE THE AB8ILITY OF THE AIR BAG TO PROTECT A RESTRAINED FRONT SEAT PASSENGER.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE PASSENGER AIR BAG. OWNER NOTIFICATION BEGAN DECEMBER 16, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OLDSMOBILE AT 1-800-442-6537, OR SATURN AT 1-800-553-6000, PROMPT #3.
01V383000 · Seats:front Assembly:recliner
Dec 13, 2001
VEHICLE DESCRIPTION: CERTAIN MINI VANS BUILT WITH SECOND ROW 50/50 SPLIT BENCH SEATS OR CAPTAIN'S CHAIRS, FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE SEAT LATCH ANCHOR WIRE DIAMETER IS GREATER THAN 6.1 MM.
Consequence & remedy
Consequence: IF THE CONNECTOR FOR A LATCH-TYPE CHILD RESTRAINT IS NOT ATTACHED CORRECTLY TO THE ANCHORAGE POINTS, THE RESTRAINT WILL NOT PROPERLY PROTECT A CHILD IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSPECT THE LATCH ANCHOR WIRES AND REPAIR THOSE WITH AN IMPROPER DIAMETER. OWNER NOTIFICATION BEGAN APRIL 10, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
01V264000 · Latches/locks/linkages:doors:latch
Aug 21, 2001
VEHICLE DESCRIPTION: 1997-2001 CHEVROLET VENTURE, PONTIAC MONTANA/TRANSPORT, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS THAT WERE SERVICED IN CAMPAIGN 01013 (01V-067) FROM APRIL TO AUGUST 2001. ALSO 2001 CHEVROLET VENTURE, PONTIAC MONTANA, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS ASSEMBLED IN JANUARY THROUGH APRIL 2001. THESE VEHICLES HAVE INADEQUATE FRONT WELDS. IF A FRONT WELD FAILS, THE ACTUATOR CAN JAM IN THE UNLATCHED POSITION AND, WHEN THE SLIDING DOOR CLOSES, IT WILL NOT BE LATCHED.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE. AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSPECT AND, IF REQUIRED, INSTALL A NEW POWER SLIDING DOOR UNLATCH ACTUATOR ASSEMBLY. OWNER NOTIFICATION BEGAN ON OCTOBER 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
01V067000 · Latches/locks/linkages:doors:latch
Mar 8, 2001
VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS. THE DOOR CLOSES BUT MAY NOT BE LATCHED. IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE.
Consequence & remedy
Consequence: AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSTALL A NEW UN-LATCH ACTUATOR ASSEMBLY TO THE POWER SLIDING DOOR. THIS RECALL HAS BEEN CONTINUED UNDER SAFETY RECALL 01V-264. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
01V026000 · Air Bags:frontal
Feb 1, 2001
VEHICLE DESCRIPTION: PASSENGER, SPORT UTILITY VEHICLES AND MINIVANS. THE PASSENGER AIR BAG INFLATOR MODULES WERE BUILT WITHOUT THE CORRECT AMOUNT OF GENERANT, WHICH PRODUCES THE GAS THAT FILLS THE AIR BAG. SOME WERE BUILT WITH A DOUBLE LOAD OF GENERANT AND SOME WERE BUILT WITHOUT GENERANT.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH THAT WOULD TRIGGER A PASSENGER AIR BAG DEPLOYMENT, A DOUBLE LOAD OF GENERANT CAN CAUSE THE INFLATOR MODULE TO EXPLODE. IF THE AIR BAG MODULE EXPLODES, METAL AND PLASTIC DEBRIS COULD CAUSE SEVERE INJURY TO VEHICLE OCCUPANT. A MODULE WITH NO GENERANT WOULD NOT INFLATE THE AIR BAG, AND THE OCCUPANTS COULD RECEIVE MORE SEVERE INJURIES.
Remedy: DEALERS WILL REPLACE THE PASSENGER AIR BAG MODULE. TELEPHONE CALLS WERE MADE TO OWNERS ON JANUARY 29, 2001. FOLLOW UP OWNER MAILING BEGAN ON APRIL 17, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR SATURN AT 1-800-553-6000.
00V228003 · Seat Belts
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE04064 · POWER-SLIDING Door
Opened Sep 17, 2004 · Closed Dec 22, 2004
Status: closed (inferred from source dates) · Structure:body:door
SUBJECT VEHICLES ARE AVAILABLE WITH AN OPTIONAL POWER SLIDING DOOR.THE INTERIOR HANDLE IS ORIENTED IN THE VERTICAL POSITION IN THE DOOR PANEL AND LINES UP AT THE ELBOW LEVEL WHEN THE OCCUPANT IS SEATED IN THE 2ND-ROW OUTBOARD POSITION.IF THE OCCUPANT HOLDS THE INTERIOR HANDLE IN THE THUMB UP POSITION DURING POWER-ASSISTED OPENING, THE ARM/WRIST CAN BE PUSH BACK WITH FORCE AGAINST THE 2ND-ROW BUCKET SEAT OR CAPTAIN'S CHAIR SEAT BACK CREATING A RISK OF INJURY (OTHER SEATING CONFIGURATIONS HAVE AMPLE SEAT TO DOOR CLEARANCE TO AVOID ENTRAPMENT OF THE LOWER ARM).AMONG THE 103 TOTAL REPORTS, THERE WERE 102 ALLEGED INJURIES INCLUDING ARM/WRIST, THUMB AND SHOULDER INJURIES.A COUNT OF INJURIES REVEALS THAT 76 INJURIES WERE A FRACTURED OR A BROKEN ARM/WRIST REQUIRING AN IMMOBILIZING CAST FOR FOUR-TO-SIX WEEKS.ALL INJURIES INVOLVE THE RIGHT SIDE POWER SLIDING DOOR.THE LEFT SIDE POWER SLIDING DOOR IS ON FAR FEWER VEHICLES, BUT MORE IMPORTANTLY, IT PRODUCES LESS FORCE.GM NOTIFIED THE AGENCY BY LETTER DATED DECEMBER 21, 2004, THAT IT WILL RECALL MODEL YEAR 1997 THOUGH EARLY 2005 GM U-VAN VEHICLES EQUIPPED WITH A RIGHT SIDE POWER SLIDING DOOR AND WITH 2ND-ROW BUCKET SEATS OR CAPTAIN CHAIRS (NHTSA RECALL #04V597).AS PART OF THE RECALL REMEDY, GM WILL REPLACE THE DOOR HANDLE WITH A FLUSH MOUNTED HANDLE THAT WILL PREVENT AN OCCUPANT FROM GRASPING THE HANDLE WITH THE PALM BETWEEN THE HANDLE AND DOOR PANEL (THUMB UP ORIENTATION) AND THUS ELIMINATE THE POTENTIAL FOR ARM/WRIST ENTRAPMENT.THIS INVESTIGATION IS CLOSED.