NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
222 reports160,000 miles · Apr 21, 2010
Fuel System, Gasoline
I HAVE A 2001 CHEVY VENTURE THAT HAD A RECALL ON THE FUEL TANK BECAUSE IT COULD LEAK FUEL AND A CAUSE A FIRE. ON APRIL 19TH MY WIFE TOOK THE VAN IN TO CHAPMAN CHEVROLET IN TEMPE,AZ TO GET THE TANK REPLACED BECAUSE IT HAS BEEN LEAKING FUEL FOR SOME TIME NOW. WE WERE NEVER NOTIFIED OF THIS RECALL. WE LOOKED IT UP ONLINE. WHEN SHE …
Read full complaint
I HAVE A 2001 CHEVY VENTURE THAT HAD A RECALL ON THE FUEL TANK BECAUSE IT COULD LEAK FUEL AND A CAUSE A FIRE. ON APRIL 19TH MY WIFE TOOK THE VAN IN TO CHAPMAN CHEVROLET IN TEMPE,AZ TO GET THE TANK REPLACED BECAUSE IT HAS BEEN LEAKING FUEL FOR SOME TIME NOW. WE WERE NEVER NOTIFIED OF THIS RECALL. WE LOOKED IT UP ONLINE. WHEN SHE GOT THERE SHE WAS TOLD THAT WE WERE OVER THE MILEAGE FOR THE FREE TANK REPLACEMENT AND WOULD HAVE TO PAY A $1000 TO HAVE IT REPLACED. THAT WAS OF COURSE OUT OF THE QUESTION AND IT IS NOT OUR FAULT THAT THEY MADE A DEFECTIVE TANK AND IS A FIRE HAZARD THAT THEY WANT PEOPLE TO DRIVE AROUND IN UNLESS THEY HAVE A THOUSAND DOLLARS TO SPEND ON REPLACING IT. PLEASE HELP IF YOU CAN. THIS CAN BE A SERIOUS PROBLEM AND GM NEEDS TO STAND BEHIND THEIR PRODUCTS. *TR
NHTSA ODI #10326799
Mileage unknown · Apr 19, 2010
Service Brakes, Hydraulic
INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) I OWN A 2001 GRAY CHEVROLET VENTURE MINIVAN & OFTEN TIMES FOR ABOUT THE LAST 5 YEARS NOW AND EVEN AT THE PRESENT TIME, THE ACCELERATOR SPEEDS UP WITHOUT ANY EXPLANATION AND I HAVE TO PUMP THE BRAKES SEVERAL TIMES BEFORE ATTEMPTING TO TU…
Read full complaint
INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) I OWN A 2001 GRAY CHEVROLET VENTURE MINIVAN & OFTEN TIMES FOR ABOUT THE LAST 5 YEARS NOW AND EVEN AT THE PRESENT TIME, THE ACCELERATOR SPEEDS UP WITHOUT ANY EXPLANATION AND I HAVE TO PUMP THE BRAKES SEVERAL TIMES BEFORE ATTEMPTING TO TURN THE CAR BACK ON AGAIN TO STOP IT FROM CONTINUOUSLY ACCELERATING. WHEN THE VEHICLE IS OFF AND WHEN I HAVE TO PUMP THE BRAKES, THE BRAKE PEDAL ACTUALLY PUMPS UP TO DEACTIVATE THE ACCELERATION PROCESS TEMPORARILY. THIS HAPPENS OFTEN DURING THE SUMMER MONTHS WHEN AIR CONDITION IS IN USE AND IT ALSO HAPPENS ALOT WHEN YOU ARE DRIVING AND THE ACCELERATOR WILL JUST SPEED UP SUDDENLY FOR NO REASON. I HAVE HAD IT INSPECTED BY THE DEALERSHIP ONCE ABOUT 5 YEARS AGO WHEN THIS FIRST STARTED AND THEY SAY THAT IT IS SOME KIND OF BRAKING SECURITY FEATURE ONCE THEY HOOKED IT UP TO THEIR COMPUTER SYSTEM AND SAID IT WAS NOTHING TO BE CONCERNED ABOUT BUT OTHER AUTO MECHANICS THAT HAVE INSPECTED MY BRAKES ON THE VEHICLE DON'T SEEM TO KNOW ANYMORE THAN THE DEALERSHIP KNOWS BECAUSE THE VEHICLE IS COMPUTERIZED. ALL THE OTHER MECHANICS DO IS CHANGE MY BRAKES PADS WHEN THEY WEAR DOWN BUT CAN'T EXPLAIN THE SUDDEN ACCELERATION NOW THAT I AM HEARING ABOUT ALL OF THE CONTROVERSIES WITH TOYOTA MOTORS BRAKING DEFAULTS AND THE DEATHS AND INJURIES ASSOCIATED WITH IT I AM REALLY GETTING CONCERNED ABOUT MY VEHICLE CONTINUOUSLY ACCELERATING FOR NO EXPLAINABLE REASON. I THINK CHEVROLET WILL PROBABLY TRY AND HID SOMETHING BECAUSE THEY DON'T WANT THE BAD EXPOSURE THAT TOYOTA IS GETTING SO I REALLY DON'T WANT TO DEAL WITH THEM RIGHT NOW ESPECIALLY AFTER THEM TELLING ME BASICALLY NOTHING IN THE PAST. CAN YOU PLEASE ADVICE ME WHAT TO DO??? [XXX] *TR
NHTSA ODI #10326303
Mileage unknown · Jan 17, 2010
Exterior Lighting
BRAKE LIGHT, TAIL LIGHT, SIGNAL LIGHTS FAILURE. *TR
NHTSA ODI #10300037
111,571 miles · Oct 9, 2009
Engine And Engine Cooling
OUR 2001 CHEVROLET VENTURE'S INTAKE MANIFOLD GASKET HAS FAILED, ALLOWING COOLANT INTO THE ENGINE OIL. WE STARTED HAVING TROUBLE WITH IT IN JANUARY 2007. THE CHECK ENGINE LIGHT CAME ON AND WE TOOK IT IN TO OUR MECHANIC. HE CHECKED THE COOLING SYSTEM AND FOUND THE THERMOSTAT WAS NOT WORKING PROPERLY. IT WAS REPLACED. IN JUNE 2008,…
Read full complaint
OUR 2001 CHEVROLET VENTURE'S INTAKE MANIFOLD GASKET HAS FAILED, ALLOWING COOLANT INTO THE ENGINE OIL. WE STARTED HAVING TROUBLE WITH IT IN JANUARY 2007. THE CHECK ENGINE LIGHT CAME ON AND WE TOOK IT IN TO OUR MECHANIC. HE CHECKED THE COOLING SYSTEM AND FOUND THE THERMOSTAT WAS NOT WORKING PROPERLY. IT WAS REPLACED. IN JUNE 2008, WE NOTICED A LOSS OF COOLANT. WE TOOK IT IN TO OUR MECHANIC AGAIN. HE DID A COOLANT SYSTEM CHECK AND FOUND NOTHING WRONG, REPLACED POSSIBLE LEAKING HOSE. ONCE AGAIN WE WERE LOSING COOLANT. WE TOOK INTO OUR MECHANIC AGAIN (THIRD TIMES A CHARM). COULD FINE NOTHING WRONG WITH COOLING SYSTEM, DID DIAGNOSTIC AND FOUND A LEAK IN THE INTAKE MANIFOLD GASKET. WE HAD NO WARNING, NO CHECK ENGINE LIGHT, NO OVER HEATING SINCE EARLIER TIME. THE MAIN PROBLEM IS THE COOLANT WAS GOING INSIDE THE ENGINE, NO OUTSIDE LEAKING TO WARN US. THE CAR STALLED AND DIED ON US, LUCKILY IT WAS AT A STOP LIGHT. IT COULD HAVE CAUSED A MAJOR ACCIDENT IF I WAS DRIVING ON FREEWAY GOING 65. IT HAS BEEN PARKED AT MY HOUSE, NON-OP WITH DMV. GM HAS ADMITTED TO ME DURING MORE THAN ONE CALL THAT THEY HAVE KNOWN ABOUT THIS PROBLEM FOR SOME TIME, BUT REFUSE TO FIX IT. THEY SAY THEY ARE WAITING FOR THE NHTSA TO PUT OUT A MANDATORY RECALL BEFORE THEY WILL FIX ANY PROBLEMS. THERE ARE THOUSANDS OF PEOPLE WITH THIS SAME PROBLEM. THE 3.1LL AND 3.4L V-6 ENGINES WERE PUT IN ALL BODY TYPES AND DIFFERENT GM MAKES AND MODELS. NOW SOME V-8'S AND NEWER MODELS ARE COMING DOWN WITH THE SAME PROBLEM. ACCORDING TO INTERNAL MEMO'S FROM GM, THEY HAVE KNOWN ABOUT THIS PROBLEM SINCE 2000. DEX-COOL SEEMS TO BE THE CULPRIT. IT IS A KNOWN PLASTICIZER (SOFTENS PLASTIC) AND IS CORROSIVE TO ALUMINUM. THE GASKET ON THE INTAKE MANIFOLD IS MADE OF PLASTIC AND THE SOME OF THE MANIFOLDS AND OR PARTS ARE MADE OF ALUMINUM. DEX-COOL DEGRADES HOSES, GASKETS AND ALSO RUSTS ALUMINUM, CAUSING A SLUDGE TO BUILD UP INTO THE ENGINE. WHY WOULD ANY ONE PUT THIS CORROSIVE MATERIAL INTO AN ENGINE ON PURPOSE? *TR
NHTSA ODI #10286848
78,000 miles · Jul 14, 2009
Equipment
1. NORMAL OPERATION 2. AIR CONDITION SYSTEM FAILURE. 3. HAD DYE, REFRIGERANT & SEAL CONDITIONER INSTALLED INITIALLY SYSTEM OK BUT, OVER NIGHT REFRIGERANT LEAKED DOWN. NO EVIDENCE OF DYE IN MOTOR COMPARTMENT. *TR
NHTSA ODI #10276781
80,000 miles · Jun 15, 2009
Equipment
AIR CONDITIONING CONDENSER LEAKING. DEALER WANTS $1000 TO REPAIR. THIS IS A KNOWN DEFECT ON THIS CONDENSER, BAD WELDS, YET GM TAKES NO FAULT EVEN THOUGH TENS OF THOUSANDS OF THESE HAVE FAILED. WITH ASTHMA, I NEED A/C AND THIS VEHICLE IS NO SAFE WITHOUT IT. *TR
NHTSA ODI #10273815
16,752 miles · May 25, 2009
Fuel System, Gasoline
FUEL TANK LEAK FROM "NECK" OR "STEM." DEALER DECLARED "UNREPAIRABLE." REPLACED TANK AT COST OF$834 (AFTER 10% DISCOUNT GRANTED BECAUSE OF LOW MILEAGE ON VEHICLE). *TR
NHTSA ODI #10269866
60,000 miles · May 18, 2009
Fuel System, Gasoline
TL*THE CONTACT OWNS A 2001 CHEVROLET VENTURE. THE CONTACT SMELLED GASOLINE AND NOTICED FLUID ON THE GROUND. HE THEN OBSERVED A CRACK IN THE FUEL INLET CHECK VALVE. THE DEALER STATED THAT THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 07V349000 (FUEL SYSTEM, GASOLINE:STORAGE), ALTHOUGH THE FAILURES WERE IDENTICAL. THE CON…
Read full complaint
TL*THE CONTACT OWNS A 2001 CHEVROLET VENTURE. THE CONTACT SMELLED GASOLINE AND NOTICED FLUID ON THE GROUND. HE THEN OBSERVED A CRACK IN THE FUEL INLET CHECK VALVE. THE DEALER STATED THAT THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 07V349000 (FUEL SYSTEM, GASOLINE:STORAGE), ALTHOUGH THE FAILURES WERE IDENTICAL. THE CONTACT MUST PAY $135 JUST TO HAVE THE VEHICLE INSPECTED. HE FEELS THAT SINCE THIS IS A DEFECT, HE SHOULD NOT HAVE TO PAY. THE VEHICLE WILL BE REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 60,000.
NHTSA ODI #10269097
50,000 miles · Mar 1, 2009
Engine And Engine CoolingEquipment
BAD/LEAKING MANIFOLD GASKET...... COOLANT LEAKS....CAUSING WATER PUMP TO BURN OUT...REPLACED TWICE ALREADY....AND COOLANT TO GET IN WITH OIL. *TR ESTIMATED REPAIR COST > $700
NHTSA ODI #10260372
Mileage unknown · Jan 4, 2009
Electrical SystemExterior Lighting
NO BRAKE LIGHTS ON MY VAN ALL FUSES ARE GOOD AND SO ARE THE BULBS. *TR
NHTSA ODI #10253736
Official recalls
9Aug 8, 2007
ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).
Consequence & remedy
Consequence: A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION INCLUDES BUICK RENDEZVOUS AND PONTIAC AZTEK VEHICLE BUILT IN MAY 2003; CHEVROLET VENTURE AND PONTIAC MONTANA VEHICLES BUILT FROM JUNE THROUGH AUGUST 2002; AND ALL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO, AND HAWAII.
Dec 22, 2004
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Consequence & remedy
Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
Jul 15, 2003
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Dec 9, 2002
ON CERTAIN PASSENGER, SPORT UTILITY VEHICLES AND MINI VANS, SOME OF THESE VEHICLES HAVE A PASSENGER AIR BAG THAT WAS MANUFACTURED WITHOUT A CHECK VALVE PIN. AN AIR BAG WITHOUT THE CHECK VALVE PIN COULD PRODUCE INCREASED PRESSURE AT THE ONSET OF THE AIR BAG DEPLOYMENT AND REDUCED PRESSURE AFTERWARD.
Consequence & remedy
Consequence: THIS COULD INCREASE THE SEVERITY OF INJURY TO A PERSON WHO WAS NOT PROPERLY RESTRAINED AND WHO WAS CLOSE TO THE PASSENGER AIR BAG AT THE TIME OF DEPLOYMENT. IT COULD ALSO REDUCE THE AB8ILITY OF THE AIR BAG TO PROTECT A RESTRAINED FRONT SEAT PASSENGER.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE PASSENGER AIR BAG. OWNER NOTIFICATION BEGAN DECEMBER 16, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OLDSMOBILE AT 1-800-442-6537, OR SATURN AT 1-800-553-6000, PROMPT #3.
Dec 13, 2001
VEHICLE DESCRIPTION: CERTAIN MINI VANS BUILT WITH SECOND ROW 50/50 SPLIT BENCH SEATS OR CAPTAIN'S CHAIRS, FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE SEAT LATCH ANCHOR WIRE DIAMETER IS GREATER THAN 6.1 MM.
Consequence & remedy
Consequence: IF THE CONNECTOR FOR A LATCH-TYPE CHILD RESTRAINT IS NOT ATTACHED CORRECTLY TO THE ANCHORAGE POINTS, THE RESTRAINT WILL NOT PROPERLY PROTECT A CHILD IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSPECT THE LATCH ANCHOR WIRES AND REPAIR THOSE WITH AN IMPROPER DIAMETER. OWNER NOTIFICATION BEGAN APRIL 10, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Aug 21, 2001
VEHICLE DESCRIPTION: 1997-2001 CHEVROLET VENTURE, PONTIAC MONTANA/TRANSPORT, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS THAT WERE SERVICED IN CAMPAIGN 01013 (01V-067) FROM APRIL TO AUGUST 2001. ALSO 2001 CHEVROLET VENTURE, PONTIAC MONTANA, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS ASSEMBLED IN JANUARY THROUGH APRIL 2001. THESE VEHICLES HAVE INADEQUATE FRONT WELDS. IF A FRONT WELD FAILS, THE ACTUATOR CAN JAM IN THE UNLATCHED POSITION AND, WHEN THE SLIDING DOOR CLOSES, IT WILL NOT BE LATCHED.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE. AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSPECT AND, IF REQUIRED, INSTALL A NEW POWER SLIDING DOOR UNLATCH ACTUATOR ASSEMBLY. OWNER NOTIFICATION BEGAN ON OCTOBER 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Mar 8, 2001
VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS. THE DOOR CLOSES BUT MAY NOT BE LATCHED. IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE.
Consequence & remedy
Consequence: AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSTALL A NEW UN-LATCH ACTUATOR ASSEMBLY TO THE POWER SLIDING DOOR. THIS RECALL HAS BEEN CONTINUED UNDER SAFETY RECALL 01V-264. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Feb 1, 2001
VEHICLE DESCRIPTION: PASSENGER, SPORT UTILITY VEHICLES AND MINIVANS. THE PASSENGER AIR BAG INFLATOR MODULES WERE BUILT WITHOUT THE CORRECT AMOUNT OF GENERANT, WHICH PRODUCES THE GAS THAT FILLS THE AIR BAG. SOME WERE BUILT WITH A DOUBLE LOAD OF GENERANT AND SOME WERE BUILT WITHOUT GENERANT.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH THAT WOULD TRIGGER A PASSENGER AIR BAG DEPLOYMENT, A DOUBLE LOAD OF GENERANT CAN CAUSE THE INFLATOR MODULE TO EXPLODE. IF THE AIR BAG MODULE EXPLODES, METAL AND PLASTIC DEBRIS COULD CAUSE SEVERE INJURY TO VEHICLE OCCUPANT. A MODULE WITH NO GENERANT WOULD NOT INFLATE THE AIR BAG, AND THE OCCUPANTS COULD RECEIVE MORE SEVERE INJURIES.
Remedy: DEALERS WILL REPLACE THE PASSENGER AIR BAG MODULE. TELEPHONE CALLS WERE MADE TO OWNERS ON JANUARY 29, 2001. FOLLOW UP OWNER MAILING BEGAN ON APRIL 17, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR SATURN AT 1-800-553-6000.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration