NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
30 reportsClear category filter162,000 miles · May 1, 2015
Power Train
TL* THE CONTACT OWNS A 2001 CHEVROLET VENTURE. WHILE DRIVING APPROXIMATELY 65 MPH, A LOUD NOISE WAS COMING FROM THE ENGINE. IN ADDITION, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. AND THE VEHICLE FAILED TO CHANGE GEARS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE OXYGEN SENSOR NEEDED TO BE REPLACED.…
Read full complaint
TL* THE CONTACT OWNS A 2001 CHEVROLET VENTURE. WHILE DRIVING APPROXIMATELY 65 MPH, A LOUD NOISE WAS COMING FROM THE ENGINE. IN ADDITION, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. AND THE VEHICLE FAILED TO CHANGE GEARS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE OXYGEN SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 162,000.
NHTSA ODI #10714015
266,000 miles · Apr 2, 2013
EnginePower TrainVehicle Speed Control
CAR WILL SPEED UP ON ITS OWN AND ACCELERATE. THE VENTURE WILL ALSO OVER HEAT AFTER RUNNING FOR 10 MIN. OR SO. THIS VAN LIKES TO STALL WHILE DRIVING AND YOU MUST KEEP YOUR FOOT ON THE BRAKE OR GAS TO PREVENT THIS FROM HAPPENING WHILE DRIVING. TRANSMISSION HAS BEEN SLIPPING SINCE I GOT THE CAR. ONLY OWNED IT LESS THAN A YEAR, NOW …
Read full complaint
CAR WILL SPEED UP ON ITS OWN AND ACCELERATE. THE VENTURE WILL ALSO OVER HEAT AFTER RUNNING FOR 10 MIN. OR SO. THIS VAN LIKES TO STALL WHILE DRIVING AND YOU MUST KEEP YOUR FOOT ON THE BRAKE OR GAS TO PREVENT THIS FROM HAPPENING WHILE DRIVING. TRANSMISSION HAS BEEN SLIPPING SINCE I GOT THE CAR. ONLY OWNED IT LESS THAN A YEAR, NOW IT MADE A LOUD CLANKING NOISE LAST NIGHT AND NOW IT WILL NOT GO IN DRIVE ONLY IN REVERSE. YOU HAVE TO SHIFT GEARS ON THE STEERING COLUMN ONLY AND EVEN THEN IT'S DEBATABLE IF IT WILL RUN. *TR
NHTSA ODI #10505442
68,900 miles · Sep 20, 2010
Latches/locks/linkagesPower Train
SHIFT CABLE BROKEN AT TRANSMISSION. TRANSMISSION WILL NOT SHIFT TO ANOTHER GEAR CAUSING VEHICLE REMAIN IN LAST GEAR SELECTED. PART IS PLASTIC AND LOW QUALITY. *TR
NHTSA ODI #10356657
96,000 miles · Feb 15, 2008
Engine And Engine CoolingPower TrainService Brakes, Hydraulic
TL*THE CONTACT OWNS A 2001 CHEVROLET VENTURE. THE CONTACT STATED THAT THE BRAKE PEDAL EXTENDED TO THE FLOOR WHEN DEPRESSED. THE VEHICLE WAS TAKEN TO A BRAKE SHOP (ALL TUNE AND LUBE) AND THEY REPLACED THE BRAKE PADS, CYLINDER, AND ROTORS. THE CONTACT ALSO STATED THAT THE TEMPERATURE GAUGE WOULD MOVE TO HOT. THE CONTACT HAD TH…
Read full complaint
TL*THE CONTACT OWNS A 2001 CHEVROLET VENTURE. THE CONTACT STATED THAT THE BRAKE PEDAL EXTENDED TO THE FLOOR WHEN DEPRESSED. THE VEHICLE WAS TAKEN TO A BRAKE SHOP (ALL TUNE AND LUBE) AND THEY REPLACED THE BRAKE PADS, CYLINDER, AND ROTORS. THE CONTACT ALSO STATED THAT THE TEMPERATURE GAUGE WOULD MOVE TO HOT. THE CONTACT HAD THE VEHICLE INSPECTED AND WAS INFORMED THAT THE MANIFOLD GASKET NEEDED TO BE REPLACED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THE REPAIR WAS PERFORMED. THE TRANSMISSION WAS ALSO SLIPPING GEARS. THE CONTACT HAD THE TRANSMISSION FLUID FLUSHED, BUT THAT DID NOT CORRECT THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE 96,000.
NHTSA ODI #10218127
52,000 miles · Aug 22, 2005
Power Train
FRONT LEFT AXLE OF 01 CHEVY VENTURE IS MAKING A BAD GRINDING TYPE NOISE WHICH GETS LOUDER THE FASTER YOU DRIVE. AFRAID IT MAY CAUSE AN ACCIDENT OR DAMAGE VEHICLE.
NHTSA ODI #10133816
70,000 miles · Jun 21, 2005
Power Train
DT: WHILE ON A TRIP THE CALLER HEARD A NOISE AND THE ENGINE OVERHEATED. SHE PULLED OVER, AND SAW WHAT SHE THOUGHT IT WAS LACK OF ANTIFREEZE. SHE PUT SOME ANTI-FREEZE IN ENGINE AND TRIED TO DRIVE, BUT IT WOULD NOT RUN. HAD VEHICLE TOWED TO DEALER, AND DEALER SAID IT WAS TRANSMISSION , AND HE WAS REPLACING TRANSMISSION…
Read full complaint
DT: WHILE ON A TRIP THE CALLER HEARD A NOISE AND THE ENGINE OVERHEATED. SHE PULLED OVER, AND SAW WHAT SHE THOUGHT IT WAS LACK OF ANTIFREEZE. SHE PUT SOME ANTI-FREEZE IN ENGINE AND TRIED TO DRIVE, BUT IT WOULD NOT RUN. HAD VEHICLE TOWED TO DEALER, AND DEALER SAID IT WAS TRANSMISSION , AND HE WAS REPLACING TRANSMISSIONS IN OTHER VANS LIKE HERS. MANUFACTURER HAS NOT BEEN CONTACTED YET. *AK
NHTSA ODI #10126091
54,000 miles · Jun 4, 2005
Power Train
TRANSMISSION FAILS AT 54,000 MILES DUE TO DEFECTIVE PARTS. REBUILT TRANSMISSION WILL COST $2000.
NHTSA ODI #10124170
83,900 miles · Mar 28, 2005
Power TrainWheels
THE RIGHT REAR WHEEL LOCKED UP AFTER SHIFTING THE VEHICLE INTO REVERSE. VEHICLE WAS TOWED TO A REPAIRED SHOP. THE CAUSE OF THE PROBLEM WAS NOT DETERMINED AT THIS TIME.*AK
NHTSA ODI #10116953
42,000 miles · Jan 26, 2005
Power Train
VACATIONING 500 MILES OUT OF MY HOME STATE, I SUDDENLY DISCOVERED I COULD NOT BACK UP MY VEHICLE -- REVERSE GEAR WOULD NOT WORK. I SHUT DOWN THE ENGINE AND RESTARTED AND DROVE IMMEDIATELY TO AN AUTHORIZED CHEVROLET DEALER. UPON INITIAL EXAMINATION OF THE TRANSAXLE/TRANSMISSION, IT WAS DISCOVERED THAT THERE WAS SHREDDDED METAL…
Read full complaint
VACATIONING 500 MILES OUT OF MY HOME STATE, I SUDDENLY DISCOVERED I COULD NOT BACK UP MY VEHICLE -- REVERSE GEAR WOULD NOT WORK. I SHUT DOWN THE ENGINE AND RESTARTED AND DROVE IMMEDIATELY TO AN AUTHORIZED CHEVROLET DEALER. UPON INITIAL EXAMINATION OF THE TRANSAXLE/TRANSMISSION, IT WAS DISCOVERED THAT THERE WAS SHREDDDED METAL IN THE FLUID AND PAN. A SUBSEQUENT TEARDOWN OF THE ASSEMBLY REVEALED THAT MAJOR COMPONENTS WERE DESTROYED, REQUIRING A REPLACEMENT OF THE ENTIRE ASSEMBLY. THE CARE HAD BEEN MAINTAINED BY THE SELLING DEALERSHIP AT HOME, ACCORDING TO MAINTENANCE SCHEDULES, AND HAD ONLY 42,000 MILES ON IT. WE HAD NEVER HAD ANY PROBLEMS BEFORE THIS OR WARNING OF ANY DAMAGE OCCURRING TO THE TRANSAXLE/TRANSMISSION -- NO OPERATING PROBLEMS, NO NOISES, NO LEAKAGE, NO SMOKING ENGINE, ETC. WE HAD TO EXTEND OUR VACATION FOR ABOUT 5 DAYS AT CONSIDERABLE LODGING AND VEHICLE RENTAL COST, BUT FORTUNATELY THE REPLACEMENT OF THE TRANSAXLE/TRANSMISSION ITSELF WAS COVERED UNDER EXTENDED VEHICLE WARRANTY WHICH I HAD PURCHASED WITH THE VEHICLE IN 2001 (LESS A $100 DEDUCTIBLE). WE KNOW OTHER CHEVROLET OWNERS WHO REPORTED TO US LATER THAT THEY HAD HAD TO REPLACE FRONT WHEEL TRANSAXLES/TRANSMISSIONS, ONE ALSO IN A VENTURE SEVERAL YEARS OLDER THAN OURS AND ONE IN A SUBURBAN ABOUT THE SAME YEAR AS OURS. OUR HOME DEALERSHIP TOLD US THEY THOUGHT OUR EXPERIENCE WAS UNUSUAL BUT WE ARE NOT SO SURE.*AK
NHTSA ODI #10107981
22,000 miles · Dec 21, 2004
Power Train
INTERMITTENT TRANSMISSION SLIP, INABILITY TO USE REVERSE AND/OR DRIVE. MY 2001 CHEVROLET VENTURE HAS BEEN IN FOR SERVICE AT MY LOCAL CHVROLET DEALERSHIP NUMEROUS TIMES FOR THIS PROBLEM OVER THE PAST 3-4 MONTHS. THE VEHICLE HAS 22000 MILES. GUESS WHAT THE SERVICE MANAGER TOLD ME AFTER TODAY'S TOW TO THE DEALER ?? NO PROBLEM COULD…
Read full complaint
INTERMITTENT TRANSMISSION SLIP, INABILITY TO USE REVERSE AND/OR DRIVE. MY 2001 CHEVROLET VENTURE HAS BEEN IN FOR SERVICE AT MY LOCAL CHVROLET DEALERSHIP NUMEROUS TIMES FOR THIS PROBLEM OVER THE PAST 3-4 MONTHS. THE VEHICLE HAS 22000 MILES. GUESS WHAT THE SERVICE MANAGER TOLD ME AFTER TODAY'S TOW TO THE DEALER ?? NO PROBLEM COULD BE FOUND - THE VEHICLE -"OPERATES AS DESIGNED" AMAZINGLY ENOUGH WHEN MY WIFE WENT TO BACK OUT OF THE PARKING SPOT WE WERE IN WE COULD NOT MOVE. THE VEHICLE WAS MAKING A LOUD GRINDING NOISE AND SOUNDED AS IF SOMETHING WAS SPINNING INSIDE THE TRANSMISSION. THE VEHICLE AND ONE POINT LURCHED BACKWARD AS MY WIFE CONTINUED IN AN ATTEMPT TO BACK THE VEHICLE UP TO NO AVAIL -AND STOPPED ABRUPTLY. WE COULD NOT USE DRIVE EITHER IT WOULD ONLY MOVE AT A SNAILS PACE. UNFORTUNATELY THE VEHICLE HAS BEEN REPAIRED AND I'M STILL HAVING INTERMITTENT PROBLEMS. THE LAST TIME IT WAS IN FOR THIS PROBLEM I ALMOST INSTANTLY HAD THE PROBLEM AGAIN. WHEN I BROUGHT IT BACK FOR REPAIR - THEY SAID THEY FILLED THE FLUID AND EVERYTHING WAS FINE AND IT WAS UNTIL TODAY! - FOR THE AMOUNT OF SIMILAR COMPLAINTS ON THIS VEHICLE - I WOULD HOPE FOR A RECALL SOON! ISN'T IT STRANGE HOW A LOT OF PEOPLE ARE HAVING THIS PROBLEM HOWEVER MOST OF WHAT I'VE READ IN OTHER POSTS SAY "DEALER SERVICE COULD NOT DUPLICATE THE PROBLEM" ?? *JD. *AK
NHTSA ODI #10104211
Official recalls
9Aug 8, 2007
ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).
Consequence & remedy
Consequence: A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION INCLUDES BUICK RENDEZVOUS AND PONTIAC AZTEK VEHICLE BUILT IN MAY 2003; CHEVROLET VENTURE AND PONTIAC MONTANA VEHICLES BUILT FROM JUNE THROUGH AUGUST 2002; AND ALL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO, AND HAWAII.
Dec 22, 2004
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Consequence & remedy
Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
Jul 15, 2003
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Dec 9, 2002
ON CERTAIN PASSENGER, SPORT UTILITY VEHICLES AND MINI VANS, SOME OF THESE VEHICLES HAVE A PASSENGER AIR BAG THAT WAS MANUFACTURED WITHOUT A CHECK VALVE PIN. AN AIR BAG WITHOUT THE CHECK VALVE PIN COULD PRODUCE INCREASED PRESSURE AT THE ONSET OF THE AIR BAG DEPLOYMENT AND REDUCED PRESSURE AFTERWARD.
Consequence & remedy
Consequence: THIS COULD INCREASE THE SEVERITY OF INJURY TO A PERSON WHO WAS NOT PROPERLY RESTRAINED AND WHO WAS CLOSE TO THE PASSENGER AIR BAG AT THE TIME OF DEPLOYMENT. IT COULD ALSO REDUCE THE AB8ILITY OF THE AIR BAG TO PROTECT A RESTRAINED FRONT SEAT PASSENGER.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE PASSENGER AIR BAG. OWNER NOTIFICATION BEGAN DECEMBER 16, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OLDSMOBILE AT 1-800-442-6537, OR SATURN AT 1-800-553-6000, PROMPT #3.
Dec 13, 2001
VEHICLE DESCRIPTION: CERTAIN MINI VANS BUILT WITH SECOND ROW 50/50 SPLIT BENCH SEATS OR CAPTAIN'S CHAIRS, FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE SEAT LATCH ANCHOR WIRE DIAMETER IS GREATER THAN 6.1 MM.
Consequence & remedy
Consequence: IF THE CONNECTOR FOR A LATCH-TYPE CHILD RESTRAINT IS NOT ATTACHED CORRECTLY TO THE ANCHORAGE POINTS, THE RESTRAINT WILL NOT PROPERLY PROTECT A CHILD IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSPECT THE LATCH ANCHOR WIRES AND REPAIR THOSE WITH AN IMPROPER DIAMETER. OWNER NOTIFICATION BEGAN APRIL 10, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Aug 21, 2001
VEHICLE DESCRIPTION: 1997-2001 CHEVROLET VENTURE, PONTIAC MONTANA/TRANSPORT, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS THAT WERE SERVICED IN CAMPAIGN 01013 (01V-067) FROM APRIL TO AUGUST 2001. ALSO 2001 CHEVROLET VENTURE, PONTIAC MONTANA, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS ASSEMBLED IN JANUARY THROUGH APRIL 2001. THESE VEHICLES HAVE INADEQUATE FRONT WELDS. IF A FRONT WELD FAILS, THE ACTUATOR CAN JAM IN THE UNLATCHED POSITION AND, WHEN THE SLIDING DOOR CLOSES, IT WILL NOT BE LATCHED.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE. AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSPECT AND, IF REQUIRED, INSTALL A NEW POWER SLIDING DOOR UNLATCH ACTUATOR ASSEMBLY. OWNER NOTIFICATION BEGAN ON OCTOBER 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Mar 8, 2001
VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS. THE DOOR CLOSES BUT MAY NOT BE LATCHED. IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE.
Consequence & remedy
Consequence: AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSTALL A NEW UN-LATCH ACTUATOR ASSEMBLY TO THE POWER SLIDING DOOR. THIS RECALL HAS BEEN CONTINUED UNDER SAFETY RECALL 01V-264. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Feb 1, 2001
VEHICLE DESCRIPTION: PASSENGER, SPORT UTILITY VEHICLES AND MINIVANS. THE PASSENGER AIR BAG INFLATOR MODULES WERE BUILT WITHOUT THE CORRECT AMOUNT OF GENERANT, WHICH PRODUCES THE GAS THAT FILLS THE AIR BAG. SOME WERE BUILT WITH A DOUBLE LOAD OF GENERANT AND SOME WERE BUILT WITHOUT GENERANT.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH THAT WOULD TRIGGER A PASSENGER AIR BAG DEPLOYMENT, A DOUBLE LOAD OF GENERANT CAN CAUSE THE INFLATOR MODULE TO EXPLODE. IF THE AIR BAG MODULE EXPLODES, METAL AND PLASTIC DEBRIS COULD CAUSE SEVERE INJURY TO VEHICLE OCCUPANT. A MODULE WITH NO GENERANT WOULD NOT INFLATE THE AIR BAG, AND THE OCCUPANTS COULD RECEIVE MORE SEVERE INJURIES.
Remedy: DEALERS WILL REPLACE THE PASSENGER AIR BAG MODULE. TELEPHONE CALLS WERE MADE TO OWNERS ON JANUARY 29, 2001. FOLLOW UP OWNER MAILING BEGAN ON APRIL 17, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR SATURN AT 1-800-553-6000.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration