NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
44 reportsClear category filterMileage unknown · May 25, 2004
Engine And Engine Cooling
I HAVE A 2001 CHEVROLET VENTURE. THE END OF LAST SUMMER THE REAR AIR CONDITIONER NEEDED TO BE FIXED. NOW THE CONDENSER NEEDS TO BE REPLACED WHICH IS A $500.00 PART A FEW MONTHS AFTER THE WARRANTY EXPIRED. A CO-WORKER OWNS A 2002 VENTURE. SHE HAD TO REPLACE THE CONDENSER LAST WEEK AND WHILE SHE WAS THERE THERE WERE OTHER VENT…
Read full complaint
I HAVE A 2001 CHEVROLET VENTURE. THE END OF LAST SUMMER THE REAR AIR CONDITIONER NEEDED TO BE FIXED. NOW THE CONDENSER NEEDS TO BE REPLACED WHICH IS A $500.00 PART A FEW MONTHS AFTER THE WARRANTY EXPIRED. A CO-WORKER OWNS A 2002 VENTURE. SHE HAD TO REPLACE THE CONDENSER LAST WEEK AND WHILE SHE WAS THERE THERE WERE OTHER VENTURES THERE WITH THE SAME PROBLEM. I CALLED MY DEALERSHIP AND WAS INFORMED THAT THEY HAVE HAD SEVERAL IN WITH THE SAME PROBLEM. WHEN I CONTACTED GENERAL MOTORS, I WAS NOTIFIED THAT THERE IS NO RECALL. ABVIOUSLY THERE'S A PROBLEM. THERE'S NO REASON WHY A THREE YEAR OLD VEHICLE NEEDS TO HAVE THE AIR CONDITIONING REPAIRED.
NHTSA ODI #10073116
50,000 miles · May 22, 2004
Engine And Engine Cooling
I HAVE BEEN TRYING TO GET MY A/C CONDENSER FIXED WITH GM. I HAVE GONE THROUGH MANY DIFFERENT REPRESENTATIVES AND ALL THEY SAY IS THAT THERE IS NOTHING WRONG WITH THE VEHICLE THAT ARE NO RECALLS OR NOTHING, BUT WOULD LIKE TO GIVE ME A $2000 GM CERTIFICATE TO THE NEXT PURCHASE OF A GM VEHICLE. I HAVE BEEN RESEARCHING MY 2001 CHE…
Read full complaint
I HAVE BEEN TRYING TO GET MY A/C CONDENSER FIXED WITH GM. I HAVE GONE THROUGH MANY DIFFERENT REPRESENTATIVES AND ALL THEY SAY IS THAT THERE IS NOTHING WRONG WITH THE VEHICLE THAT ARE NO RECALLS OR NOTHING, BUT WOULD LIKE TO GIVE ME A $2000 GM CERTIFICATE TO THE NEXT PURCHASE OF A GM VEHICLE. I HAVE BEEN RESEARCHING MY 2001 CHEVROLET VENTURE VAN AND HAVE FOUND THAT THERE ARE MANY OTHERS WITH THE SAME PROBLEM AS MINE. THE CONDENSER IS CRACKED ON THE RIGHT SIDE. A FAULTY PART. THE SERVICE BULLETIN THAT I FOUND ON THIS PART, THAT GM STATES THAT THERE IS NO SUCH THING, STATES THAT THERE IS AN UPDATED PART FOR THIS CONDENSER. WOULD YOU NOT THINK IF THERE IS AN "UPDATED" PART THERE MIGHT BE SOMETHING WRONG??? ALSO IT STATES THAT IT TAKES 2 HOURS TO FIX, THE DEALERSHIP STATES IT TAKES 5 HOURS PRETTY BIG DIFFERENCE. I LIKE MY VAN AND HAVE NO OTHER PROBLEMS WITH IT. THE A/C WENT OUT AFTER ONLY HAVING THE VAN 2 YEARS, IN WHICH MY WARRANTY HAD ALREADY EXPIRED LIKE MOST PEOPLES DO. I TRAVEL EXTENSIVELY, SO WARRANTIES DO NOT LAST LONG. I ENJOY MY VAN. THE ONLY THING I'M ASKING IS FOR A REPLACED CONDENSER. I THINK IF GM KNEW THERE WAS A PROBLEM THEY SHOULD RECALL THIS PART AND BE HONEST WHEN YOU TRY TO CONTACT THEM.*AK
NHTSA ODI #10073001
34,000 miles · Mar 16, 2004
Engine And Engine Cooling
THE GAS LINE WAS UNDER PRESSURE AT ALL TIMES. CONNECTOR CRACKED AND SHOT GAS BENEATH VEHICLE AND UPON THE HOOD. DRIVER FELT LUCKY THE VEHICLE DIDN'T BLOW UP. *AK
NHTSA ODI #10063253
41,900 miles · Mar 11, 2004
Engine And Engine Cooling
TEMPERATURE GAUGE FLUCTUATED UP AND DOWN. ENGINE TOOK LONG TO WARM UP. CONSUMER TOOK VEHICLE TO THE DEALER, AND DEALER DETERMINED LOWER INTAKE GASKETS LEAKED. *AK DEALER REPLACED INTAKE GASKETS. *LA
NHTSA ODI #10057962
16,042 miles · Feb 24, 2004
Engine And Engine Cooling
POSSIBLE SAFETY DEFECT IN THE WAY VENT LINE IS ATTACHED IN THE GAS TANK AND POSSIBLE DEFICIENCY IN THE WAY EMISSION SERVICE WAS PERFORMED. THIS IS BECAUSE CONSUMER NOTICED ODOR OF GAS IN VEHICLE. (NAR) *LA *CB
NHTSA ODI #10061135
Mileage unknown · Jan 15, 2004
Engine And Engine CoolingEquipmentService Brakes, Hydraulic
I PURCHASED THE VEHICLE BRAND NEW IN 2001. SINCE THEN, MY VCR THAT IS INSTALLED IN THE VENTURE WAS DEFECTIVE AND REPAIRED FOUR TIMES. EACH TIME UNDER WARRANTY BUT IT WAS INCONVIENENT FOR ME. THE BRAKES WENT OUT ON ME TWICE THAT I REPAIRED AT A MECHANIC, THEN THE A/C WOULDN'T COOL (THIS IS RECENTLY), NOW THE OXYGEN SENSOR IS C…
Read full complaint
I PURCHASED THE VEHICLE BRAND NEW IN 2001. SINCE THEN, MY VCR THAT IS INSTALLED IN THE VENTURE WAS DEFECTIVE AND REPAIRED FOUR TIMES. EACH TIME UNDER WARRANTY BUT IT WAS INCONVIENENT FOR ME. THE BRAKES WENT OUT ON ME TWICE THAT I REPAIRED AT A MECHANIC, THEN THE A/C WOULDN'T COOL (THIS IS RECENTLY), NOW THE OXYGEN SENSOR IS CAUSING THE "SERVICE ENGINE" MESSAGE ON MY DASH BOARD TO LIGHT UP. THIS CAR IS ONLY 2 YEARS OLD!!! I MAINTAIN MY CAR WELL, THE MANAGER OF THE CHEVROLET DEALERSHIP TRIED TO ACCOMODATE ME (ONCE) SO THAT I WON'T MAKE A FUSS AND CALL THE MEDIA ON THEM. I WAS NOT AWARE OF THE LEMON LAW UNTIL RECENTLY.
NHTSA ODI #10071200
Mileage unknown · Dec 5, 2003
Engine And Engine Cooling
CAR WAS BOUGHT NEW, SERVICED AS PER MANUFACTURER'S RECOMMENDATIONS. THE LOWER INTAKE GASKET WAS LEAKING ANTIFREEZE. HAD TO REPLACE INTAKE GASKETS AND SEALS, REPLACE OIL PUMP DRIVE SEAL, FLUSHED CRANK CASE. *JB
NHTSA ODI #10049253
39,000 miles · Nov 21, 2003
Engine And Engine Cooling
THE SERVICE ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A REPAIR SHOP WHERE A MECHANIC DETERMINED NOTHING WAS WRONG. THE MANUFACTURER IS AWARE OF THE PROBLEM. PLEASE PROVIDE FURTHER DETAILS. *NLM
NHTSA ODI #10048509
30,000 miles · Nov 4, 2003
Electrical SystemEngine And Engine CoolingPower Train
TRANSMISSION SLIPS AFTER SITTING WHEN FIRST STARTING OUT;HORN HONKS OCCASIONALLY WHILE DRIVING; POWER SLIDING DOOR ON DRIVER'S SIDE WON'T OPEN/CLOSE WHEN ACTIVATED BY BUTTON OR REMOTE SWITCHES; HARD STARTS AFTER DRIVING AND SITTING BRIEFLY (ESPECIALLY AFTER HIGHWAY DRIVING--TRIED DIFFERENT GAS STATIONS GASSES). TAKEN TO TWO …
Read full complaint
TRANSMISSION SLIPS AFTER SITTING WHEN FIRST STARTING OUT;HORN HONKS OCCASIONALLY WHILE DRIVING; POWER SLIDING DOOR ON DRIVER'S SIDE WON'T OPEN/CLOSE WHEN ACTIVATED BY BUTTON OR REMOTE SWITCHES; HARD STARTS AFTER DRIVING AND SITTING BRIEFLY (ESPECIALLY AFTER HIGHWAY DRIVING--TRIED DIFFERENT GAS STATIONS GASSES). TAKEN TO TWO DIFFERENT DEALERS MOSTLY ABOUT TRANSMISSION AND THEY CLAIM UNLESS THE CHECK ENGINE LIGHT COMES ON, THEY CAN'T DO ANYTHING ABOUT IT. GOING TO TAKE BACK AND HAVE IT STAY THERE UNTIL THEY REPRODUCE THIS WEEK. *AK
NHTSA ODI #10045436
14,000 miles · May 15, 2003
Engine And Engine CoolingEquipment
2001 CHEVY VENTURE 12 MONTHS OLD APPROX 14,000 MILES, RADIATOR SEAM SPLIT RIGHT LOWER CORNER LEAKING ANTIFREEZE. AC ALSO STOPPED WORKING, CONDENSER SEAM SPLIT, RIGHT LOWER CORNER. REPLACED BY DEALER. VEHICLE NOW 18 MONTHS OLD APPROX 21,000 MILES, AC STOPPED WORKING. CONDENSER SEAM SPLIT LOWER RIGHT FRONT CORNER. DEALER REPL…
Read full complaint
2001 CHEVY VENTURE 12 MONTHS OLD APPROX 14,000 MILES, RADIATOR SEAM SPLIT RIGHT LOWER CORNER LEAKING ANTIFREEZE. AC ALSO STOPPED WORKING, CONDENSER SEAM SPLIT, RIGHT LOWER CORNER. REPLACED BY DEALER. VEHICLE NOW 18 MONTHS OLD APPROX 21,000 MILES, AC STOPPED WORKING. CONDENSER SEAM SPLIT LOWER RIGHT FRONT CORNER. DEALER REPLACED. APPEARS TO BE A STRUCTURAL DEFECT IN DESIGN STRESSING THE RADIATOR AND CONDENSER VIA THE MOUNTING SCHEME. VEHICLE IS A LEMON. FIRST TIME REPAIRED DEALER HAD TO ORDER CONDENSER. THIS TIME REPAIRED HE HAD 3 IN STOCK! *JB
NHTSA ODI #10018737
Official recalls
9Aug 8, 2007
ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).
Consequence & remedy
Consequence: A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION INCLUDES BUICK RENDEZVOUS AND PONTIAC AZTEK VEHICLE BUILT IN MAY 2003; CHEVROLET VENTURE AND PONTIAC MONTANA VEHICLES BUILT FROM JUNE THROUGH AUGUST 2002; AND ALL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO, AND HAWAII.
Dec 22, 2004
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Consequence & remedy
Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
Jul 15, 2003
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Dec 9, 2002
ON CERTAIN PASSENGER, SPORT UTILITY VEHICLES AND MINI VANS, SOME OF THESE VEHICLES HAVE A PASSENGER AIR BAG THAT WAS MANUFACTURED WITHOUT A CHECK VALVE PIN. AN AIR BAG WITHOUT THE CHECK VALVE PIN COULD PRODUCE INCREASED PRESSURE AT THE ONSET OF THE AIR BAG DEPLOYMENT AND REDUCED PRESSURE AFTERWARD.
Consequence & remedy
Consequence: THIS COULD INCREASE THE SEVERITY OF INJURY TO A PERSON WHO WAS NOT PROPERLY RESTRAINED AND WHO WAS CLOSE TO THE PASSENGER AIR BAG AT THE TIME OF DEPLOYMENT. IT COULD ALSO REDUCE THE AB8ILITY OF THE AIR BAG TO PROTECT A RESTRAINED FRONT SEAT PASSENGER.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE PASSENGER AIR BAG. OWNER NOTIFICATION BEGAN DECEMBER 16, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OLDSMOBILE AT 1-800-442-6537, OR SATURN AT 1-800-553-6000, PROMPT #3.
Dec 13, 2001
VEHICLE DESCRIPTION: CERTAIN MINI VANS BUILT WITH SECOND ROW 50/50 SPLIT BENCH SEATS OR CAPTAIN'S CHAIRS, FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE SEAT LATCH ANCHOR WIRE DIAMETER IS GREATER THAN 6.1 MM.
Consequence & remedy
Consequence: IF THE CONNECTOR FOR A LATCH-TYPE CHILD RESTRAINT IS NOT ATTACHED CORRECTLY TO THE ANCHORAGE POINTS, THE RESTRAINT WILL NOT PROPERLY PROTECT A CHILD IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSPECT THE LATCH ANCHOR WIRES AND REPAIR THOSE WITH AN IMPROPER DIAMETER. OWNER NOTIFICATION BEGAN APRIL 10, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Aug 21, 2001
VEHICLE DESCRIPTION: 1997-2001 CHEVROLET VENTURE, PONTIAC MONTANA/TRANSPORT, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS THAT WERE SERVICED IN CAMPAIGN 01013 (01V-067) FROM APRIL TO AUGUST 2001. ALSO 2001 CHEVROLET VENTURE, PONTIAC MONTANA, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS ASSEMBLED IN JANUARY THROUGH APRIL 2001. THESE VEHICLES HAVE INADEQUATE FRONT WELDS. IF A FRONT WELD FAILS, THE ACTUATOR CAN JAM IN THE UNLATCHED POSITION AND, WHEN THE SLIDING DOOR CLOSES, IT WILL NOT BE LATCHED.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE. AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSPECT AND, IF REQUIRED, INSTALL A NEW POWER SLIDING DOOR UNLATCH ACTUATOR ASSEMBLY. OWNER NOTIFICATION BEGAN ON OCTOBER 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Mar 8, 2001
VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS. THE DOOR CLOSES BUT MAY NOT BE LATCHED. IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE.
Consequence & remedy
Consequence: AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSTALL A NEW UN-LATCH ACTUATOR ASSEMBLY TO THE POWER SLIDING DOOR. THIS RECALL HAS BEEN CONTINUED UNDER SAFETY RECALL 01V-264. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Feb 1, 2001
VEHICLE DESCRIPTION: PASSENGER, SPORT UTILITY VEHICLES AND MINIVANS. THE PASSENGER AIR BAG INFLATOR MODULES WERE BUILT WITHOUT THE CORRECT AMOUNT OF GENERANT, WHICH PRODUCES THE GAS THAT FILLS THE AIR BAG. SOME WERE BUILT WITH A DOUBLE LOAD OF GENERANT AND SOME WERE BUILT WITHOUT GENERANT.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH THAT WOULD TRIGGER A PASSENGER AIR BAG DEPLOYMENT, A DOUBLE LOAD OF GENERANT CAN CAUSE THE INFLATOR MODULE TO EXPLODE. IF THE AIR BAG MODULE EXPLODES, METAL AND PLASTIC DEBRIS COULD CAUSE SEVERE INJURY TO VEHICLE OCCUPANT. A MODULE WITH NO GENERANT WOULD NOT INFLATE THE AIR BAG, AND THE OCCUPANTS COULD RECEIVE MORE SEVERE INJURIES.
Remedy: DEALERS WILL REPLACE THE PASSENGER AIR BAG MODULE. TELEPHONE CALLS WERE MADE TO OWNERS ON JANUARY 29, 2001. FOLLOW UP OWNER MAILING BEGAN ON APRIL 17, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR SATURN AT 1-800-553-6000.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration