NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
20 reportsClear category filterMileage unknown · Nov 4, 2004
Electrical System
VAN WAS MAKING SCRATCHING NOISE UPON CRANKING. TOOK VAN IN FOR SERVICE AND WAS NOTIFIED THAT THE BATTERY WAS LEAKING ACID AND NEEDED TO BE REPLACED. THE VAN HAD 48,000 MILES AT THE TIME. BATTERY WAS REPLACED. SAME THING HAPPENED 2 WEEKS AGO, TOOK VAN IN, NEW BATTERY WAS LEAKING ACID. THE SECOND BATTERY ONLY HAD 42,000 MILES…
Read full complaint
VAN WAS MAKING SCRATCHING NOISE UPON CRANKING. TOOK VAN IN FOR SERVICE AND WAS NOTIFIED THAT THE BATTERY WAS LEAKING ACID AND NEEDED TO BE REPLACED. THE VAN HAD 48,000 MILES AT THE TIME. BATTERY WAS REPLACED. SAME THING HAPPENED 2 WEEKS AGO, TOOK VAN IN, NEW BATTERY WAS LEAKING ACID. THE SECOND BATTERY ONLY HAD 42,000 MILES ON IT AT THIS TIME. BATTERY HAD TO BE REPLACED ONCE AGAIN.*AK
NHTSA ODI #10098243
22,531 miles · Aug 20, 2004
Electrical SystemEngine And Engine CoolingService Brakes, Hydraulic
CONSUMER COMPLAINED ABOUT AN ABS BRAKE SYSTEM PROBLEM. THE REAR BRAKE CYLINDER BROKE, AND VEHICLE LEAKED BRAKE FLUID. ALSO, INTAKE MANIFOLD LEAKED COOLANT INTO THE ENGINE. IN ADDITION, DELCO BATTERY BROKE, AND LEAKED ACID. THE BATTERY WAS REPLACED TWICE, BUT PROBLEM RECURRED. *AK MARCH 2002 COMPUTER MALFUNCTIONED. JULY 200…
Read full complaint
CONSUMER COMPLAINED ABOUT AN ABS BRAKE SYSTEM PROBLEM. THE REAR BRAKE CYLINDER BROKE, AND VEHICLE LEAKED BRAKE FLUID. ALSO, INTAKE MANIFOLD LEAKED COOLANT INTO THE ENGINE. IN ADDITION, DELCO BATTERY BROKE, AND LEAKED ACID. THE BATTERY WAS REPLACED TWICE, BUT PROBLEM RECURRED. *AK MARCH 2002 COMPUTER MALFUNCTIONED. JULY 2002 VCR FAILED AND REQUIRED REPLACEMENT. DEC 2, 2002 DEFECTIVE BATTERY, DEC 10, 2003 ELECTRICAL CONTROLS FOR OUTSIDE MIRRORS. JAN 10, 2003 TRUE;">AUTOMATIC TRANSMISSION</A> REPLACED. JULY 7, 2003BOTH REAR BRAKE CYLINDERS FAILED. AUG 12, 2004 GASKET LEAKS ON <A ONMOUSEOVER="WINDOW.STATUS='WATER PUMP'; RETURN TRUE;" ONMOUSEOUT="WINDOW.STATUS=''; RETURN TRUE;">WATER PUMP</A>'; RETURN TRUE;" ONMOUSEOUT="WINDOW.STATUS=''; RETURN TRUE;">WATER PUMP</A>'; RETURN TRUE;" ONMOUSEOUT="WINDOW.STATUS=''; RETURN TRUE;">WATER PUMP</A>'; RETURN TRUE;" ONMOUSEOUT="WINDOW.STATUS=''; RETURN TRUE;">WATER PUMP</A>/INTAKE MANIFOLD. AUG BATTERY REPLACED DUE TO BEING CRACKED. THE CONSUMER STATED THAT THIS WILL BE BATTERY NUMBER THREE FOR THIS VEHICLE. *TC
NHTSA ODI #10089365
Mileage unknown · Aug 12, 2004
Electrical SystemEngine And Engine CoolingPower Train
A/C QUIT WORKING. TOOK IT TO THE DEALERSHIP AND THEY SAID THERE WAS A CRACK IN THE CONDENCER. ON SEVERAL DIFFERENT OCCASIONS THE HORN HAS HONKED WHILE DRIVING DOWN THE ROAD. WHEN THE VAN IS IN DRIVE YOU LET OFF THE BRAKE AND IT ROLLS FORWARD AND THE SAME IN REVERSE, IT ROLLS. AK
NHTSA ODI #10086755
Mileage unknown · Jul 30, 2004
Electrical SystemEngine And Engine Cooling
VEHICLE STALLED INTERMITTENTLY WITHOUT WARNING WHILE DRIVING. VEHICLE WAS TAKEN TO THE DEALER AND THEY FOUNDED THAT THE INTAKE MANIFOLD WAS CRACKED AND CAUSED COOLANT TO LEAKS INSIDE THE ENGINE. ALSO HAS PROBLEM WHIT THE ALTERNATOR. *AK
NHTSA ODI #10083856
30,000 miles · Nov 4, 2003
Electrical SystemEngine And Engine CoolingPower Train
TRANSMISSION SLIPS AFTER SITTING WHEN FIRST STARTING OUT;HORN HONKS OCCASIONALLY WHILE DRIVING; POWER SLIDING DOOR ON DRIVER'S SIDE WON'T OPEN/CLOSE WHEN ACTIVATED BY BUTTON OR REMOTE SWITCHES; HARD STARTS AFTER DRIVING AND SITTING BRIEFLY (ESPECIALLY AFTER HIGHWAY DRIVING--TRIED DIFFERENT GAS STATIONS GASSES). TAKEN TO TWO …
Read full complaint
TRANSMISSION SLIPS AFTER SITTING WHEN FIRST STARTING OUT;HORN HONKS OCCASIONALLY WHILE DRIVING; POWER SLIDING DOOR ON DRIVER'S SIDE WON'T OPEN/CLOSE WHEN ACTIVATED BY BUTTON OR REMOTE SWITCHES; HARD STARTS AFTER DRIVING AND SITTING BRIEFLY (ESPECIALLY AFTER HIGHWAY DRIVING--TRIED DIFFERENT GAS STATIONS GASSES). TAKEN TO TWO DIFFERENT DEALERS MOSTLY ABOUT TRANSMISSION AND THEY CLAIM UNLESS THE CHECK ENGINE LIGHT COMES ON, THEY CAN'T DO ANYTHING ABOUT IT. GOING TO TAKE BACK AND HAVE IT STAY THERE UNTIL THEY REPRODUCE THIS WEEK. *AK
NHTSA ODI #10045436
Mileage unknown · Oct 14, 2003
Electrical System
CONSUMER HAS BEEN HAVING DASH PANEL LIGHT PROBLEMS. SHE STATED THAT VEHICLE HAD BEEN IN REPAIR SHOP 5 TIMES. ONCE THE MECHANIC REPLACED THE SWITCH THAT TURNED ON THE LIGHTS BECAUSE THERE WAS AN ELECTRICAL SHORT IN THE SWITCH. THEN, SHE WAS TOLD THAT A LOT OF PROBLEMS OCCURRED BECAUSE LEFT TURN SIGNAL WAS LOCKING UP. *A…
Read full complaint
CONSUMER HAS BEEN HAVING DASH PANEL LIGHT PROBLEMS. SHE STATED THAT VEHICLE HAD BEEN IN REPAIR SHOP 5 TIMES. ONCE THE MECHANIC REPLACED THE SWITCH THAT TURNED ON THE LIGHTS BECAUSE THERE WAS AN ELECTRICAL SHORT IN THE SWITCH. THEN, SHE WAS TOLD THAT A LOT OF PROBLEMS OCCURRED BECAUSE LEFT TURN SIGNAL WAS LOCKING UP. *AK
NHTSA ODI #10042900
36,000 miles · Oct 1, 2003
Electrical System
WHILE DRIVING DASH BOARD LIGHTS WOULD START FLASHING OFF AND ON. CONSUMER WOULD HAVE NO IDEA HOW FAST SHE WAS GOING. VEHICLE WAS TAKEN TO THE DEALER, AND CONTROL PANEL CLUSTER WAS REPLACED. LESS THAN SIX MONTHS LATER, PROBLEM OCCURRED AGAIN. CURRENTLY, VEHICLE IS IN THE SHOP AGAIN FOR THE SAME THING. *AK
NHTSA ODI #10042125
Mileage unknown · May 12, 2003
Electrical SystemEquipmentSeat Belts
PURCHASED VAN JULY 2001. I HAVE DISCONTINUED PUTTING MY SON IN INSTALLED CHILD SEAT BECAUSE HE COMPLAINS IT HURTS HIS LEGS; WHEN HE GOES TO GET OUT HE CAN'T HARDLY WALK;I THINK THE POSITION OF THE SEAT CAUSES HIS LEGS TO GO TO SLEEP. SINCE PURCHASE OF VAN I HAVE HAD IT IN FOR SERVICE SEVERAL TIMES. (1) I COMPLAINED OF VIBRAT…
Read full complaint
PURCHASED VAN JULY 2001. I HAVE DISCONTINUED PUTTING MY SON IN INSTALLED CHILD SEAT BECAUSE HE COMPLAINS IT HURTS HIS LEGS; WHEN HE GOES TO GET OUT HE CAN'T HARDLY WALK;I THINK THE POSITION OF THE SEAT CAUSES HIS LEGS TO GO TO SLEEP. SINCE PURCHASE OF VAN I HAVE HAD IT IN FOR SERVICE SEVERAL TIMES. (1) I COMPLAINED OF VIBRATION IN THE FRONT WHEN I GOT UP TO A SPEED OVER 50 MPH; THE SERVICE TECHS COULD NOT FIND ANYTHING WRONG. (2) I COMPLAINED OF (WHILE TRAVELING) HEARING AIR VENTILATION (LIKE A WINDOW WAS DOWN) ON THE PASSENGER SIDE; NOTHING WAS FOUND. (3) WHEN PURCHASED THE VEHICLE WE STATED OUR CONCERN THAT DOOR DID NOT RETRACT IMMEDIATELY. I PUT MY ARM IN TO DEMONSTRATE; IT PINCHED MY ARM AND BRUISED IT BEFORE IT FINALLY RETRACTED (4) I HAVE ALSO HAD MY VAN IN COMPLAINING THAT THE CD PLAYER DID NOT OPERATE PROPERLY. THEY SAID IT WAS DEFECTIVE AND REPLACED MY ENTIRE RADIO/CD. (5) COMPLAINED THAT WHILE DRIVING (NOTICING AT NIGHT) MY HEADLIGHTS WOULD DIM AND COME BACK ON. AFTER NOT FINDING ANYTHING THEY REPLACED THE ALTERNATOR. IT IS AGAIN HAPPENING. (6) RECENT CONCERN IS WHILE ON AN UPWARD HILL AT A RED LIGHT WATER STARTED COMING IN THROUGH THE STORAGE COMPARTMENT BETWEEN THE VISORS. NOW THEY ARE DECLARING THAT THE WINDSHIELD WAS NOT PROPERLY SEALED WHEN IT WAS INSTALLED. I HAVE HAD THIS VEHICLE NOW FOR ALMOST TWO YEARS. MY THOUGHT IS THAT IT MAY HAVE BEEN LEAKING BUT NOW JUST TO THE POINT THAT I AM NOTICING IT. HOW MUCH DAMAGE HAS IT CAUSED IN MY HEAD LINER, ETC. THAT THEY WILL NOT BE ABLE TO DETECT WITH THE NAKED EYE AND IS THE AIR VENTILATION THAT I WAS HEARING A RESULT OF THE WINDSHIELD NOT BEING SEALED; AND IS THE WATER LEAKAGE CAUSING MY SHORTAGE IN THE WIRING OF THE LIGHTS AND RADIO, ETC. MY CONCERN IS LATER DOWN THE ROAD WILL I HAVE MORE DETERIORATING PROBLEMS BECAUSE OF WATER DAMAGE THAT COULD NOT BE SEEN AT THIS POINT. *NLM
NHTSA ODI #10018556
Mileage unknown · Aug 1, 2002
Electrical SystemEngine And Engine Cooling
VEHICLE HAS STALLED 3 TIMES AT 60 MPH. DEALER HAS REPLACED COMPUTER TWICE.BUT IT DID NOT SOLVE PROBLEM.*AK
NHTSA ODI #8015312
Mileage unknown · Jun 12, 2002
Electrical SystemExterior Lighting
CONSUMER STATES THE BRAKE LIGHT FUSES BEGAN TO BURN OUT. *JG WHEN THIS OCCURRED THE VEHICLE HAD NOT BRAKE LIGHTS. THE VEHICLE WAS RETURNED TO THE DEALER FOR REPAIRS. AFTER THE VEHICLE WAS RETURNED TOT HE CONSUMER THE FUSE BLEW AGAIN. THE VEHICLE WAS RETURNED TO THE DEALER SEVERAL MORE TIMES BUT SEARCH TIME THE PROBLEM RECUR…
Read full complaint
CONSUMER STATES THE BRAKE LIGHT FUSES BEGAN TO BURN OUT. *JG WHEN THIS OCCURRED THE VEHICLE HAD NOT BRAKE LIGHTS. THE VEHICLE WAS RETURNED TO THE DEALER FOR REPAIRS. AFTER THE VEHICLE WAS RETURNED TOT HE CONSUMER THE FUSE BLEW AGAIN. THE VEHICLE WAS RETURNED TO THE DEALER SEVERAL MORE TIMES BUT SEARCH TIME THE PROBLEM RECURRED. THE CONSUMER DECIDED TO TAKE THE VEHICLE TO A LOCAL DEALER. WHILE DRIVING TO THE LOCAL DEALER SMOKE BECAME TO COME FROM UNDERNEATH THE DASH. IT WAS LATER DETERMINED THAT BOTH BRAE LAMP SWITCHES HAD BURNED OFF. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER. AFTER SEVERAL ATTEMPTS THEY WERE UNABLE TO RECTIFY THE PROBLEM. *NM
NHTSA ODI #565429
Official recalls
9Aug 8, 2007
ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).
Consequence & remedy
Consequence: A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION INCLUDES BUICK RENDEZVOUS AND PONTIAC AZTEK VEHICLE BUILT IN MAY 2003; CHEVROLET VENTURE AND PONTIAC MONTANA VEHICLES BUILT FROM JUNE THROUGH AUGUST 2002; AND ALL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO, AND HAWAII.
Dec 22, 2004
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Consequence & remedy
Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
Jul 15, 2003
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Dec 9, 2002
ON CERTAIN PASSENGER, SPORT UTILITY VEHICLES AND MINI VANS, SOME OF THESE VEHICLES HAVE A PASSENGER AIR BAG THAT WAS MANUFACTURED WITHOUT A CHECK VALVE PIN. AN AIR BAG WITHOUT THE CHECK VALVE PIN COULD PRODUCE INCREASED PRESSURE AT THE ONSET OF THE AIR BAG DEPLOYMENT AND REDUCED PRESSURE AFTERWARD.
Consequence & remedy
Consequence: THIS COULD INCREASE THE SEVERITY OF INJURY TO A PERSON WHO WAS NOT PROPERLY RESTRAINED AND WHO WAS CLOSE TO THE PASSENGER AIR BAG AT THE TIME OF DEPLOYMENT. IT COULD ALSO REDUCE THE AB8ILITY OF THE AIR BAG TO PROTECT A RESTRAINED FRONT SEAT PASSENGER.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE PASSENGER AIR BAG. OWNER NOTIFICATION BEGAN DECEMBER 16, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OLDSMOBILE AT 1-800-442-6537, OR SATURN AT 1-800-553-6000, PROMPT #3.
Dec 13, 2001
VEHICLE DESCRIPTION: CERTAIN MINI VANS BUILT WITH SECOND ROW 50/50 SPLIT BENCH SEATS OR CAPTAIN'S CHAIRS, FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE SEAT LATCH ANCHOR WIRE DIAMETER IS GREATER THAN 6.1 MM.
Consequence & remedy
Consequence: IF THE CONNECTOR FOR A LATCH-TYPE CHILD RESTRAINT IS NOT ATTACHED CORRECTLY TO THE ANCHORAGE POINTS, THE RESTRAINT WILL NOT PROPERLY PROTECT A CHILD IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSPECT THE LATCH ANCHOR WIRES AND REPAIR THOSE WITH AN IMPROPER DIAMETER. OWNER NOTIFICATION BEGAN APRIL 10, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Aug 21, 2001
VEHICLE DESCRIPTION: 1997-2001 CHEVROLET VENTURE, PONTIAC MONTANA/TRANSPORT, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS THAT WERE SERVICED IN CAMPAIGN 01013 (01V-067) FROM APRIL TO AUGUST 2001. ALSO 2001 CHEVROLET VENTURE, PONTIAC MONTANA, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS ASSEMBLED IN JANUARY THROUGH APRIL 2001. THESE VEHICLES HAVE INADEQUATE FRONT WELDS. IF A FRONT WELD FAILS, THE ACTUATOR CAN JAM IN THE UNLATCHED POSITION AND, WHEN THE SLIDING DOOR CLOSES, IT WILL NOT BE LATCHED.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE. AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSPECT AND, IF REQUIRED, INSTALL A NEW POWER SLIDING DOOR UNLATCH ACTUATOR ASSEMBLY. OWNER NOTIFICATION BEGAN ON OCTOBER 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Mar 8, 2001
VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS. THE DOOR CLOSES BUT MAY NOT BE LATCHED. IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE.
Consequence & remedy
Consequence: AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSTALL A NEW UN-LATCH ACTUATOR ASSEMBLY TO THE POWER SLIDING DOOR. THIS RECALL HAS BEEN CONTINUED UNDER SAFETY RECALL 01V-264. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Feb 1, 2001
VEHICLE DESCRIPTION: PASSENGER, SPORT UTILITY VEHICLES AND MINIVANS. THE PASSENGER AIR BAG INFLATOR MODULES WERE BUILT WITHOUT THE CORRECT AMOUNT OF GENERANT, WHICH PRODUCES THE GAS THAT FILLS THE AIR BAG. SOME WERE BUILT WITH A DOUBLE LOAD OF GENERANT AND SOME WERE BUILT WITHOUT GENERANT.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH THAT WOULD TRIGGER A PASSENGER AIR BAG DEPLOYMENT, A DOUBLE LOAD OF GENERANT CAN CAUSE THE INFLATOR MODULE TO EXPLODE. IF THE AIR BAG MODULE EXPLODES, METAL AND PLASTIC DEBRIS COULD CAUSE SEVERE INJURY TO VEHICLE OCCUPANT. A MODULE WITH NO GENERANT WOULD NOT INFLATE THE AIR BAG, AND THE OCCUPANTS COULD RECEIVE MORE SEVERE INJURIES.
Remedy: DEALERS WILL REPLACE THE PASSENGER AIR BAG MODULE. TELEPHONE CALLS WERE MADE TO OWNERS ON JANUARY 29, 2001. FOLLOW UP OWNER MAILING BEGAN ON APRIL 17, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR SATURN AT 1-800-553-6000.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration