IllustrationTHE WINDSHIELD WIPER PAWL WILL CEASE TO FUNCTION AND BREAK WHILE USING IN SNOWY CONDITIONS. OWNER HAD TO REPLACE THE ENTIRE WINDSHIELD WIPER SYSTEM DUE TO THIS SMALL PLASTIC PIECE BREAKING EVERY YEAR SINCE OWNERSHIP. *AK
1999 Chevrolet Venture
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1999 Chevrolet Venture do not stand out strongly from the model-year median of 220.
About this comparison →How this year compares
Owner complaints by model year
Compare all Venture years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
80–25K
3225–50K
5250–75K
3275–100K
17100–150K
2150K+
143 reports with mileage · 206 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 114 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
22 crash reports5 fire reports27 injury reports
What owners actually said
349 reportsTAIL LIGHTS WOULD FLICKER ON/OFF WHILE IN USE. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK CONSUMER WANTS TO KNOW IF THERE IS A 'RECALL CAMPAIGN', ON 2001 MODEL FOR THE DEFECTIVE EQUIPMENT. CONSUMER BELIEVE A RECALL IS NEEDED FOR SAFETY. REAR MODULES REPLACED AND WIRE HARNESS FOR TAIL LIGHTS BURNT. REPLACE…
Read full complaint
TAIL LIGHTS WOULD FLICKER ON/OFF WHILE IN USE. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK CONSUMER WANTS TO KNOW IF THERE IS A 'RECALL CAMPAIGN', ON 2001 MODEL FOR THE DEFECTIVE EQUIPMENT. CONSUMER BELIEVE A RECALL IS NEEDED FOR SAFETY. REAR MODULES REPLACED AND WIRE HARNESS FOR TAIL LIGHTS BURNT. REPLACE BOTH REAR LIGHT MODULES AND WIRING HARNESS HAD TO BE REPAIRED OF BURNT WIRING. CUSTOMER STATES BRAKE LIGHTS ARE SURGING BRIGHT TO DIM. ADVISE TO REPAIRS NEEDED/PERFORMED ELECTRICAL TEST FOUND BOTH CIRCUIT BOARDS BURNT AND OPEN WIRES SHOWING/REPAIRED WIRES AND REPLACED BOTH TAIL LIGHT CIRCUIT BOARDS. *BF
THE CAR HAS BEEN RUNNING LOW ON RADIATOR FLUID, BUT WE COULD NOT FIND ANY VISIBLE LEAKAGES. WE HAVE BEEN REPLINISHING THE FLUID. WE DID NOT THINK ANYTHING MAJOR. ON A FRIDAY, WE STARTED TO HEAR A KNOCK IN THE ENGINE. WE WERE TOLD TO HAVE THE OIL CHANGED/LOOKED AT. AFTERWARDS, THE NOISE CONTINUED EVEN LOUDER. WE HAD THE CAR…
Read full complaint
THE CAR HAS BEEN RUNNING LOW ON RADIATOR FLUID, BUT WE COULD NOT FIND ANY VISIBLE LEAKAGES. WE HAVE BEEN REPLINISHING THE FLUID. WE DID NOT THINK ANYTHING MAJOR. ON A FRIDAY, WE STARTED TO HEAR A KNOCK IN THE ENGINE. WE WERE TOLD TO HAVE THE OIL CHANGED/LOOKED AT. AFTERWARDS, THE NOISE CONTINUED EVEN LOUDER. WE HAD THE CAR IMMEDIATELY TOWED. THE PROBLEM INVOLVED THE LIFTERS AND THE INTAKE GASKET. (BOTH PROBLEMS ARE RELATED.) I RESEARCHED AND MANY OTHERS HAD THE SIMILAR PROBLEMS WITH THE INTAKE GASKET. REPAIR FOR ALL WILL BE $1,000.*AK
THE LATCH ON OUR POWER SLIDING DOOR IS NOT LATCHING. I WAS ADVISED THAT THIS PROBLEM HAS ALREADY BEEN FIXED, BUT THE SAME PROBLEM THAT THE RECALL WAS SENT OUT FOR IS WHAT THE LATCH IS DOING AGAIN. THE DOOR HAS OPENED UP ON US WHEN WE WAS DRIVING ON THE ROAD. WE SHUT THE POWER OFF TO THE DOOR, LOCKED THE DOOR AND DO NOT ALLOW ANY…
Read full complaint
THE LATCH ON OUR POWER SLIDING DOOR IS NOT LATCHING. I WAS ADVISED THAT THIS PROBLEM HAS ALREADY BEEN FIXED, BUT THE SAME PROBLEM THAT THE RECALL WAS SENT OUT FOR IS WHAT THE LATCH IS DOING AGAIN. THE DOOR HAS OPENED UP ON US WHEN WE WAS DRIVING ON THE ROAD. WE SHUT THE POWER OFF TO THE DOOR, LOCKED THE DOOR AND DO NOT ALLOW ANY ONE OF THE KIDS TO USE THE DOOR. *AK
VEHICLE WAS LOSING COOLANT DUE TO DEFECTIVE INTAKE MANIFOLD, BUT THERE WAS NO LEAK. *AK ALL OF THE REPAIR SHOPS AND DEALERSHIP CLAIMED THIS INTAKE PROBLEM WAS COMMON WITH THIS ENGINE. IT TOOK DEALERSHIP TWO MONTHS TO REPAIR VEHICLE. *AK
I'VE HAD A 1999 CHEVY VENTURE SINCE NEW. I'VE HAD TO REPLACE THE INTAKE MANIFOLD GASKET, UPPER AND LOWER RADIATOR HOSES AT 69500 MILES. REPLACED THE THERMOSTAT AT 78400 MILES. AT 78500 MILES I HAD TO REPLACE BOTH HEAD GASKETS,INTAKE GASKET AND PLENUM GASKET, BOTH VALVE COVER GASKETS AND SEVERAL COLLAPSED LIFTERS, AND THE CYLIN…
Read full complaint
I'VE HAD A 1999 CHEVY VENTURE SINCE NEW. I'VE HAD TO REPLACE THE INTAKE MANIFOLD GASKET, UPPER AND LOWER RADIATOR HOSES AT 69500 MILES. REPLACED THE THERMOSTAT AT 78400 MILES. AT 78500 MILES I HAD TO REPLACE BOTH HEAD GASKETS,INTAKE GASKET AND PLENUM GASKET, BOTH VALVE COVER GASKETS AND SEVERAL COLLAPSED LIFTERS, AND THE CYLINDER HEADS NEEDED TO BE RECONDITIONED. THESE REPAIRS COST ME THOUSANDS OF DOLLARS. SOMETHING IS SURELY NOT RIGHT WITH THIS ENGINE. *NM
WE OWN A 1999 CHEVY VENTURE. THE INTAKE MANIFOLD GASKET HAS FAILED THREE TIMES. THE FIRST TIME WAS 1-28-03 AT 55385 MILES. IT WAS LEAKING FLUID IN THE FRONT. IT WAS DIAGNOSED AS THE INTAKE MANIFOLD GASKET AND REPAIRED. THE SECOND TIME WAS ON 10-30-03 AT 67823 MILES. THIS TIME, THE REPAIR SHOP TOOK RESPONSIBILITY FOR THE CH…
Read full complaint
WE OWN A 1999 CHEVY VENTURE. THE INTAKE MANIFOLD GASKET HAS FAILED THREE TIMES. THE FIRST TIME WAS 1-28-03 AT 55385 MILES. IT WAS LEAKING FLUID IN THE FRONT. IT WAS DIAGNOSED AS THE INTAKE MANIFOLD GASKET AND REPAIRED. THE SECOND TIME WAS ON 10-30-03 AT 67823 MILES. THIS TIME, THE REPAIR SHOP TOOK RESPONSIBILITY FOR THE CHARGES AS THEY FELT THE ADHESIVE FAILED. THE THIRD FAILURE JUST HAPPENED ON 2-11-05 AT 85500 MILES. *JB
I HAVE MY OIL CHANGED EVERY 3,000 MILES. THE INTAKE GASKET STARTED LEAKING AND GOT IN MY OIL AND CAUSED IT TO DIE ON ME. THE DEALER SAID IT WAS THE WORST ONE THAT HE HAD SEEN. I HAVE TO REPLACE THE MOTOR, BUT WHAT IS TO SAY THAT THIS ONE WILL NOT DO THE SAME THING? *JB
VENTURE WITH 89,800 MILES HAS BEEN HARD, HARSH SHIFTING FOR SOME TIME, ALSO WHINES. DEALER SAID POSSIBLE PRESSURE CONTROL SOLENOID EPC NEEDS REPLACED, NO ESTIMATE. DEALER SUGGESTED TO RUN VEHICLE UNTIL IT BECOMES A REAL PROBLEM. ALSO DISCUSSED WITH TRANNY SHOP, THEY EXPERIENCED MANY OF THESE TRANNY PROBLEMS, USUALLY CODE 1811…
Read full complaint
VENTURE WITH 89,800 MILES HAS BEEN HARD, HARSH SHIFTING FOR SOME TIME, ALSO WHINES. DEALER SAID POSSIBLE PRESSURE CONTROL SOLENOID EPC NEEDS REPLACED, NO ESTIMATE. DEALER SUGGESTED TO RUN VEHICLE UNTIL IT BECOMES A REAL PROBLEM. ALSO DISCUSSED WITH TRANNY SHOP, THEY EXPERIENCED MANY OF THESE TRANNY PROBLEMS, USUALLY CODE 1811, REPLACE PRESSURE CONTROL SOLENOID (EPC) BUT TO CORRECT PROBLEM TRANNY NEEDS TO BE REBUILT, ESTIMATE $1,600 TO $1,900 TO DO. *JB
I WAS PARKING MY CAR AT A MALL, I PUT ON THE BRAKE AND HIT BRAKE PEDAL AND ACCELERATOR PEDAL TOGETHER, THE ACCELERATOR ALMOST TOOK MY CAR INTO THE CEMENT PARKING BOLLARD, BUT I MANAGED TO STOP THE CAR 1 1/2 " FROM DAMAGING THE CAR. I HAVE COMPLAINED IN THE PAST ABOUT THIS PROBLEM OF THE HEIGHT OF THE PEDALS TO CHEVROLET DEALER W…
Read full complaint
I WAS PARKING MY CAR AT A MALL, I PUT ON THE BRAKE AND HIT BRAKE PEDAL AND ACCELERATOR PEDAL TOGETHER, THE ACCELERATOR ALMOST TOOK MY CAR INTO THE CEMENT PARKING BOLLARD, BUT I MANAGED TO STOP THE CAR 1 1/2 " FROM DAMAGING THE CAR. I HAVE COMPLAINED IN THE PAST ABOUT THIS PROBLEM OF THE HEIGHT OF THE PEDALS TO CHEVROLET DEALER WITH NO SATISFACTION. "THAT'S THEY WAY THEY ARE BUILT, THERE IS NO DEFECT". THIS SITUATION HAS CAUSED ME PROBLEMS IN THE PAST, ALMOST HITTING A CURBSTONE AND THE LIKE. I COULD BE BLAMED FOR HITTING A PEDESTRIAN BECAUSE THE ACCELERATOR TAKES OVER BEFORE THE BRAKE PEDAL IF BOTH ARE PUSHED SIMULTANEOUSLY. THE BRAKE PEDAL SHOULD BE MOUNTED SO THAT IT WILL BE PUSHED FIRST SO AS TO STOP THE CAR AND NOT ALLOW THE ACCELERATOR PEDAL TO BE PUSHED. I GOT NO HELP FROM THE DEALER. I AM AFRAID THAT I COULD GET INTO A SERIOUS ACCIDENT BECAUSE OF THIS SITUATION. IN A GREAT HURRY, MY FOOT STRUCK BOTH PEDALS AT THE SAME TIME. THE BRAKE PEDAL SHOULD BE HIGH ENOUGH TO TAKE OVER. I HAVE HAD THE BRAKES CHECKED REGULARLY, I KEEP NEW TIRES ON MY CAR. MY CAR ALWAYS PASSES INSPECTION. I DRIVE A 1999 CHEVROLET VENTURE. I BOUGHT IT AT CLAY CHEVROLET ON SEPTEMBER 15, 2002, USED WITH 33963 MILES ON THE ODOMETER. IT NOW HAS 66650 MILES. *AK
Official recalls
404V597000 · Latches/locks/linkages:doors:latch
Dec 22, 2004
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Consequence & remedy
Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
01V264000 · Latches/locks/linkages:doors:latch
Aug 21, 2001
VEHICLE DESCRIPTION: 1997-2001 CHEVROLET VENTURE, PONTIAC MONTANA/TRANSPORT, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS THAT WERE SERVICED IN CAMPAIGN 01013 (01V-067) FROM APRIL TO AUGUST 2001. ALSO 2001 CHEVROLET VENTURE, PONTIAC MONTANA, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS ASSEMBLED IN JANUARY THROUGH APRIL 2001. THESE VEHICLES HAVE INADEQUATE FRONT WELDS. IF A FRONT WELD FAILS, THE ACTUATOR CAN JAM IN THE UNLATCHED POSITION AND, WHEN THE SLIDING DOOR CLOSES, IT WILL NOT BE LATCHED.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE. AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSPECT AND, IF REQUIRED, INSTALL A NEW POWER SLIDING DOOR UNLATCH ACTUATOR ASSEMBLY. OWNER NOTIFICATION BEGAN ON OCTOBER 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
01V067000 · Latches/locks/linkages:doors:latch
Mar 8, 2001
VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS. THE DOOR CLOSES BUT MAY NOT BE LATCHED. IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE.
Consequence & remedy
Consequence: AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSTALL A NEW UN-LATCH ACTUATOR ASSEMBLY TO THE POWER SLIDING DOOR. THIS RECALL HAS BEEN CONTINUED UNDER SAFETY RECALL 01V-264. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
99V071000 · Steering:gear Box:shaft Sector
Apr 12, 1999
VEHICLE DESCRIPTION: PASSENGER MINI VANS. THE LEFT AND/OR RIGHT FRONT LOWER INSULATOR TO CRADLE CENTER METAL SLEEVE IS COLLAPSED, WHICH CAN RESULT IN LOSS OF CLAMP LOAD IN THE JOINT. IF THE CLAMP LOAD IS REDUCED OR LOST, THE BOLT CAN BE LOST OR BROKEN AND THE JOINT CAN SEPARATE.
Consequence & remedy
Consequence: IF NOT REPAIRED, SEPARATION OF THE OPPOSITE SIDE JOINT COULD OCCUR RESULTING IN STEERING SHAFT SEPARATION.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT FRONT LOWER CRADLE-TO-SUSPENSION INSULATORS AND THE ATTACHING BOLTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6PE04064 · POWER-SLIDING Door
Opened Sep 17, 2004 · Closed Dec 22, 2004
Status: closed (inferred from source dates) · Structure:body:door
SUBJECT VEHICLES ARE AVAILABLE WITH AN OPTIONAL POWER SLIDING DOOR.THE INTERIOR HANDLE IS ORIENTED IN THE VERTICAL POSITION IN THE DOOR PANEL AND LINES UP AT THE ELBOW LEVEL WHEN THE OCCUPANT IS SEATED IN THE 2ND-ROW OUTBOARD POSITION.IF THE OCCUPANT HOLDS THE INTERIOR HANDLE IN THE THUMB UP POSITION DURING POWER-ASSISTED OPENING, THE ARM/WRIST CAN BE PUSH BACK WITH FORCE AGAINST THE 2ND-ROW BUCKET SEAT OR CAPTAIN'S CHAIR SEAT BACK CREATING A RISK OF INJURY (OTHER SEATING CONFIGURATIONS HAVE AMPLE SEAT TO DOOR CLEARANCE TO AVOID ENTRAPMENT OF THE LOWER ARM).AMONG THE 103 TOTAL REPORTS, THERE WERE 102 ALLEGED INJURIES INCLUDING ARM/WRIST, THUMB AND SHOULDER INJURIES.A COUNT OF INJURIES REVEALS THAT 76 INJURIES WERE A FRACTURED OR A BROKEN ARM/WRIST REQUIRING AN IMMOBILIZING CAST FOR FOUR-TO-SIX WEEKS.ALL INJURIES INVOLVE THE RIGHT SIDE POWER SLIDING DOOR.THE LEFT SIDE POWER SLIDING DOOR IS ON FAR FEWER VEHICLES, BUT MORE IMPORTANTLY, IT PRODUCES LESS FORCE.GM NOTIFIED THE AGENCY BY LETTER DATED DECEMBER 21, 2004, THAT IT WILL RECALL MODEL YEAR 1997 THOUGH EARLY 2005 GM U-VAN VEHICLES EQUIPPED WITH A RIGHT SIDE POWER SLIDING DOOR AND WITH 2ND-ROW BUCKET SEATS OR CAPTAIN CHAIRS (NHTSA RECALL #04V597).AS PART OF THE RECALL REMEDY, GM WILL REPLACE THE DOOR HANDLE WITH A FLUSH MOUNTED HANDLE THAT WILL PREVENT AN OCCUPANT FROM GRASPING THE HANDLE WITH THE PALM BETWEEN THE HANDLE AND DOOR PANEL (THUMB UP ORIENTATION) AND THUS ELIMINATE THE POTENTIAL FOR ARM/WRIST ENTRAPMENT.THIS INVESTIGATION IS CLOSED.
EA03005 · Rear Axle Trailing Arm Failure
Opened Apr 23, 2003 · Closed Jan 12, 2004
Status: closed (inferred from source dates) · Suspension; Suspension:rear
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (2)
Suspension
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:rear
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02086 · Rear Axle Trailing Arm Failure
Opened Nov 18, 2002 · Closed Apr 9, 2003
Status: closed (inferred from source dates) · Suspension; Suspension:rear
ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 14 INCIDENTS OF REAR TRAILING ARM FAILURES IN MODEL YEAR (MY) 1997 THROUGH 1999 GM U-VANS, INCLUDING TWO THAT ALLEGEDLY RESULTED IN CRASHES. THE TRAILING ARM DESIGN IN THESE VEHICLES IS USED IN THE U-VANS FROM MY 1997 THROUGH 2003.ACCORDING TO GM, THE SUBJECT TRAILING ARMS CAN CRACK OR BUCKLE IF THEY HAVE BEEN DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR CERTAIN SERVICE RELATED ABUSE CONDITIONS (E.G., IMPROPER TOWING OR JACKING).GM IDENTIFIED A PARTS HANDLING CONCERN THAT WAS CAUSING SOME TRAILING ARMS TO BE DAMAGED PRIOR TO INSTALLATION.TO ADDRESS THIS CONCERN, GM IMPLEMENTED CHANGES TO THE SHIPPING CONTAINERS FROM JANUARY 1999 THROUGH SEPTEMBER 1999. EIGHT (8) OF THE REPORTED INCIDENTS IN MY 1997-99 U-VANS, INCLUDING THE TWO CRASHES, OCCURRED IN THE LAST 2 YEARS.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO ASSESS THE TREND AND SAFETY RISK ASSOCIATED WITH THE ALLEGED DEFECT.
Additional source detail variants (2)
Suspension
ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 14 INCIDENTS OF REAR TRAILING ARM FAILURES IN MODEL YEAR (MY) 1997 THROUGH 1999 GM U-VANS, INCLUDING TWO THAT ALLEGEDLY RESULTED IN CRASHES. THE TRAILING ARM DESIGN IN THESE VEHICLES IS USED IN THE U-VANS FROM MY 1997 THROUGH 2003.ACCORDING TO GM, THE SUBJECT TRAILING ARMS CAN CRACK OR BUCKLE IF THEY HAVE BEEN DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR CERTAIN SERVICE RELATED ABUSE CONDITIONS (E.G., IMPROPER TOWING OR JACKING).GM IDENTIFIED A PARTS HANDLING CONCERN THAT WAS CAUSING SOME TRAILING ARMS TO BE DAMAGED PRIOR TO INSTALLATION.TO ADDRESS THIS CONCERN, GM IMPLEMENTED CHANGES TO THE SHIPPING CONTAINERS FROM JANUARY 1999 THROUGH SEPTEMBER 1999. EIGHT (8) OF THE REPORTED INCIDENTS IN MY 1997-99 U-VANS, INCLUDING THE TWO CRASHES, OCCURRED IN THE LAST 2 YEARS.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO ASSESS THE TREND AND SAFETY RISK ASSOCIATED WITH THE ALLEGED DEFECT.
Suspension:rear
ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 14 INCIDENTS OF REAR TRAILING ARM FAILURES IN MODEL YEAR (MY) 1997 THROUGH 1999 GM U-VANS, INCLUDING TWO THAT ALLEGEDLY RESULTED IN CRASHES. THE TRAILING ARM DESIGN IN THESE VEHICLES IS USED IN THE U-VANS FROM MY 1997 THROUGH 2003.ACCORDING TO GM, THE SUBJECT TRAILING ARMS CAN CRACK OR BUCKLE IF THEY HAVE BEEN DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR CERTAIN SERVICE RELATED ABUSE CONDITIONS (E.G., IMPROPER TOWING OR JACKING).GM IDENTIFIED A PARTS HANDLING CONCERN THAT WAS CAUSING SOME TRAILING ARMS TO BE DAMAGED PRIOR TO INSTALLATION.TO ADDRESS THIS CONCERN, GM IMPLEMENTED CHANGES TO THE SHIPPING CONTAINERS FROM JANUARY 1999 THROUGH SEPTEMBER 1999. EIGHT (8) OF THE REPORTED INCIDENTS IN MY 1997-99 U-VANS, INCLUDING THE TWO CRASHES, OCCURRED IN THE LAST 2 YEARS.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO ASSESS THE TREND AND SAFETY RISK ASSOCIATED WITH THE ALLEGED DEFECT.
PE02017 · Shoulder Harness Clip
Opened Feb 11, 2002 · Closed Aug 2, 2002
Status: closed (inferred from source dates) · Seat Belts
No summary supplied.
PE00045 · Air Bag Tear During Deployment
Opened Nov 3, 2000 · Closed Jan 11, 2001
Status: closed (inferred from source dates) · Air Bags
No summary supplied.
SQ00014 · Unexpected Opening Of Sliding Door
Opened Jul 25, 2000 · Closed Oct 22, 2001
Status: closed (inferred from source dates) · Structure
There is no summary currently available