NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
349 reports114,500 miles · Jun 3, 2007
SeatsInjury
DAUGHTER ENTERED PASSENGER SIDE OF VAN THROUGH LARGE SLIDING DOOR. FRONT PASSENGER SEAT WAS FULLY FORWARD. FELL ON EXPOSED SEAT ADJUSTMENT RAILS. REQUIRED 13 STITCHES TO CLOSE WOUND JUST BELOW KNEE. RAILS WERE MANUFACTURED WITH SHARP 90 DEG CORNERS AND NO PROTECTION. RAILS ARE EXPOSED BY APPROX 4 INCHES WHEN FRONT PASSENGER SEA…
Read full complaint
DAUGHTER ENTERED PASSENGER SIDE OF VAN THROUGH LARGE SLIDING DOOR. FRONT PASSENGER SEAT WAS FULLY FORWARD. FELL ON EXPOSED SEAT ADJUSTMENT RAILS. REQUIRED 13 STITCHES TO CLOSE WOUND JUST BELOW KNEE. RAILS WERE MANUFACTURED WITH SHARP 90 DEG CORNERS AND NO PROTECTION. RAILS ARE EXPOSED BY APPROX 4 INCHES WHEN FRONT PASSENGER SEAT IS FULLY FORWARD. SAME PROBLEM EXISTS ON DRIVER'S SIDE. *TR
NHTSA ODI #10192318
136,000 miles · May 30, 2007
Electrical System
THE PASSENGER POWER SLIDING DOOR OF MY 1999 CHEVY VENTURE STOPPED WORKING IN THE CLOSED POSITION. WHEN THIS HAPPENED THE HORN QUIT, AND THE LOW COOLANT LIGHT BLINKS ON FREQUENTLY. A LOCAL MECHANIC SAID THAT THERE WAS A BULATIN OUT TO REPROGRAM THE COMPUTER ON THIS VEHICLE, AND THAT IT WAS A PROGRAMMING ERROR. I AM DISABLED AND …
Read full complaint
THE PASSENGER POWER SLIDING DOOR OF MY 1999 CHEVY VENTURE STOPPED WORKING IN THE CLOSED POSITION. WHEN THIS HAPPENED THE HORN QUIT, AND THE LOW COOLANT LIGHT BLINKS ON FREQUENTLY. A LOCAL MECHANIC SAID THAT THERE WAS A BULATIN OUT TO REPROGRAM THE COMPUTER ON THIS VEHICLE, AND THAT IT WAS A PROGRAMMING ERROR. I AM DISABLED AND I DEPEND ON THIS DOOR FOR MY WHEELCHAIR RAMP, ETC. *TR
NHTSA ODI #10192014
98,000 miles · Apr 18, 2007
Structure
TL*- THE CONTACT STATED THAT WHILE REVERSING OUT THE DRIVEWAY, THE SLIDING DOOR OPENED ON HER 1999 CHEVROLET VENTURE. WHEN THE CONTACT STOPPED THE VEHICLE TO CLOSE THE SLIDING DOOR, THE DOOR FELL OFF THE TRACK. TWO OF THE DOOR HINGES HAD FALLEN OFF. THE FAILURE MILEAGE WAS 98,000 MILES.
NHTSA ODI #10188281
101,050 miles · Mar 22, 2007
Engine And Engine Cooling
INTAKE GASKETS LEAKING, UPPER AND LOWER. CAUSED OIL TO BE CONTAMINATED WITH ANTI FREEZE AND ANTI FFREEZE TO BE CONTAMINATED WITH OIL. GM HAS SINCE CHANGED THE GASKETS TO A DIFFERENT TYPE OF MATERIAL. MECHANIC STATED THAT THIS PROBLEM IS COMMON WITH THIS TYPE OF VEHICLE.
NHTSA ODI #10185904
Mileage unknown · Jan 25, 2007
Exterior Lighting
THERE IS MOISTURE IN THE HEAD LAMP HOUSING. THIS MOISTURE CAUSES THE INSIDE TO FOG OVER REDUCING THE AMOUNT OF LIGHT. THE LACK OF LIGHT MAKES IT HARD TO SEE OBJECTS AT NIGHT. *JB
NHTSA ODI #10180746
97,900 miles · Nov 3, 2006
Electrical System
I HAVE EXPERIENCED NUMEROUS ELECTRICAL PROBLEMS, INCLUDING THE ABS, TCS, AND AIR BAG LIGHTS COMING ON INTERMITTENTLY, AND THE DEALER HAS SAID THERE'S NOTHING WRONG AND RESET IT. MY ELECTRIC PASSENGER SIDE DOOR WOULD OPEN FOR NO REASON WHEN I'M TRYING TO SHUT IT. NOW, MY BRAKE LIGHT WAS OUT, SO I REPLACED THE BULB. THAT DID NO…
Read full complaint
I HAVE EXPERIENCED NUMEROUS ELECTRICAL PROBLEMS, INCLUDING THE ABS, TCS, AND AIR BAG LIGHTS COMING ON INTERMITTENTLY, AND THE DEALER HAS SAID THERE'S NOTHING WRONG AND RESET IT. MY ELECTRIC PASSENGER SIDE DOOR WOULD OPEN FOR NO REASON WHEN I'M TRYING TO SHUT IT. NOW, MY BRAKE LIGHT WAS OUT, SO I REPLACED THE BULB. THAT DID NOT SOLVE THE PROBLEM. MY HUSBAND THEN LOOKED AT IT AND DETERMINED THAT THE WIRE PINS/PLUGS ARE BURNT AND EXPOSED ON BOTH SIDES. NOW I HAVE NO BRAKE OR TAIL LIGHTS, NO BLINKERS, NO REVERSE LIGHTS, AND AT NIGHT THE TOP BRAKE LIGHT IS THE ONLY LIGHT AND IT STAYS ON ALL THE TIME. WHEN I PUT THE BRAKES ON THE DASH LIGHTS DIM AND THE RADIO LIGHTS TURN OFF, THE EMERGENCY LIGHTS COME ON, AND THE BLINKER GOES AT DIFFERENT SPEEDS. WHEN I CALLED THE DEALER, THEY TOLD ME TO CALL GM. WHEN I CALLED GM I EXPLAINED EVEN THOUGH IT'S OUT OF WARRANTY, I FEEL ELECTRICAL PROBLEMS THAT I HAVEN'T DONE ANYTHING TO MAKE, SHOULD BE COVERED BY THE MANUFACTURER. THEY SAID I NEED TO PAY FOR A DIAGNOSIS, AND THEY MAY REIMBURSE ME, IF THEY FEEL IT'S A MANUFACTURERS DEFECT. THEN CALL THEM BACK AND THEY'LL DETERMINE IF THEY WILL COVER ANY REPAIRS. IN THE MEAN TIME, I'M CONCERNED ABOUT A FIRE IF THE WIRE PLUGS/PINS ARE BURNT AND EXPOSED. *JB
NHTSA ODI #10172581
Mileage unknown · Nov 1, 2006
Suspension
THE STABILIZER BAR ON BOTH SIDES (FRONT)WAS FOUND TO BE BROKE COMPLETELY THROUGH. SEARCHED ON THE INTERNET AND FOUND THAT THIS IS A VERY COMMON PROBLEM WITH THE CHEVY VENTURE. THIS PROBLEM WAS JUST IDENTIFIED TODAY, SO I HAVE NOT YET ATTEMPTED TO OBTAIN REPAIRS. *NM
NHTSA ODI #10172384
85,000 miles · Oct 19, 2006
Air BagsCrashInjury
DT*: THE CONTACT STATED WHILE STOPPED AT A STOP LIGHT DURING WET ROAD CONDITIONS, THE VEHICLE WAS IMPACTED ON THE FRONT DRIVER SIDE BY ANOTHER VEHICLE TRAVELING 45 MPH. THE CONTACT'S VEHICLE WAS PUSHED INTO ONCOMING TRAFFIC AND COLLIDED WITH 3 OTHER VEHICLES CAUSING DAMAGE TO THE WHOLE FRONT END AND FRONT PASSENGER DOOR. NONE …
Read full complaint
DT*: THE CONTACT STATED WHILE STOPPED AT A STOP LIGHT DURING WET ROAD CONDITIONS, THE VEHICLE WAS IMPACTED ON THE FRONT DRIVER SIDE BY ANOTHER VEHICLE TRAVELING 45 MPH. THE CONTACT'S VEHICLE WAS PUSHED INTO ONCOMING TRAFFIC AND COLLIDED WITH 3 OTHER VEHICLES CAUSING DAMAGE TO THE WHOLE FRONT END AND FRONT PASSENGER DOOR. NONE OF THE AIR BAGS DEPLOYED, AND THE CONTACT SUSTAINED INJURIES TO THE LEG, SHOULDER, AND CHEST. THE SEAT BELT WAS WORN, AND THE AIRBAG WARNING LIGHT WAS NOT ILLUMINATED PRIOR TO THE INCIDENT. A POLICE REPORT WAS TAKEN AND PICTURES WERE AVAILABLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP, AND WAS DEEMED TOTALED. UPDATED 1/26/2007 - *NM
NHTSA ODI #10171335
108,000 miles · Oct 4, 2006
StructureInjury
THE PINCH WELDS BEHIND THE SIDE SLIDING DOORS (LEFT AND RIGHT) ARE BADLY CORRODED COMPROMISING THE OVERALL STRUCTURAL INTEGRITY OF THIS UNIBODY VEHICLE. WHENEVER A PASSENGER WEIGHING OVER 150 LBS. SITS IN THE PASSENGER FRONT SEAT, THE RIGHT SIDE POWER SLIDING DOOR ALARM SOUNDS. WHEN THIS HAPPENS THE DOOR SOMETIMES NOT CLOSE OR W…
Read full complaint
THE PINCH WELDS BEHIND THE SIDE SLIDING DOORS (LEFT AND RIGHT) ARE BADLY CORRODED COMPROMISING THE OVERALL STRUCTURAL INTEGRITY OF THIS UNIBODY VEHICLE. WHENEVER A PASSENGER WEIGHING OVER 150 LBS. SITS IN THE PASSENGER FRONT SEAT, THE RIGHT SIDE POWER SLIDING DOOR ALARM SOUNDS. WHEN THIS HAPPENS THE DOOR SOMETIMES NOT CLOSE OR WILL OPEN UNEXPECTEDLY EVEN WHILE THE VEHICLE IS IN MOTION. WITH THE INTEGRITY OF THE STRUCTURE COMPROMISED, IT HAS ALSO RESULTED IN A CRACKED WINDSHIELD. THIS IS NOT ONLY DANGEROUS BUT COULD POTENTIALLY RESULT IN A FATALITY. THE DEFECT HAS BEEN BROUGHT TO THE ATTENTION OF A COUPLE OF DIFFERENT GM DEALERSHIPS OF WHICH NONE WERE OF ANY ASSISTANCE. *NM
NHTSA ODI #10169944
20,000 miles · Jul 31, 2006
Air BagsElectrical SystemEngine And Engine Cooling
THIS WILL BE A LIST OF MOST OF THE PROBLEMS. I HAVE COMPLAINED OF SMELLING ANTI-FREEZE SINCE I PURCHASED THE VAN NEW. IT CURRENTLY HAS 94K ON IT AND I HAVE DONE ALL SCHEDULED MAINTENANCE ON IT. I THINK THE CLOCK WORK OIL CHANGES IS THE ONLY REASON IT STILL RUNS. MANIFOLD GASKETS, INTAKE, HEAD...HAVE BEEN REPLACED TWICE AND NEED…
Read full complaint
THIS WILL BE A LIST OF MOST OF THE PROBLEMS. I HAVE COMPLAINED OF SMELLING ANTI-FREEZE SINCE I PURCHASED THE VAN NEW. IT CURRENTLY HAS 94K ON IT AND I HAVE DONE ALL SCHEDULED MAINTENANCE ON IT. I THINK THE CLOCK WORK OIL CHANGES IS THE ONLY REASON IT STILL RUNS. MANIFOLD GASKETS, INTAKE, HEAD...HAVE BEEN REPLACED TWICE AND NEED IT AGAIN, REALLY BAD. BUT I JUST DO NOT HAVE 5-800 BUCKS LAYING AROUND TO DO A GASKET JOB AGAIN SINCE I JUST DID IT A YEAR AGO. THE ANTI-FREEZE DILUTING THE OIL HAS MESSED UP A COUPLE PISTONS. THEY SLAP VERY BAD OK HERE IS MY LIST (I HAVE DEALER INVOICES FOR EVERYTHING FIXED THE FIRST TIME AND RECEIPTS FOR PARTS AND LABOR THE SECOND TIME, OR MY HUSBAND GOT SICK OF PAYING FOR THE SAME CRAP SO HE WOULD FIX THINGS) (HE IS IN THE AUTOMOTIVE TESTING AND DESIGN FIELD) *JB
NHTSA ODI #10163941
Official recalls
4Dec 22, 2004
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Consequence & remedy
Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
Aug 21, 2001
VEHICLE DESCRIPTION: 1997-2001 CHEVROLET VENTURE, PONTIAC MONTANA/TRANSPORT, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS THAT WERE SERVICED IN CAMPAIGN 01013 (01V-067) FROM APRIL TO AUGUST 2001. ALSO 2001 CHEVROLET VENTURE, PONTIAC MONTANA, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS ASSEMBLED IN JANUARY THROUGH APRIL 2001. THESE VEHICLES HAVE INADEQUATE FRONT WELDS. IF A FRONT WELD FAILS, THE ACTUATOR CAN JAM IN THE UNLATCHED POSITION AND, WHEN THE SLIDING DOOR CLOSES, IT WILL NOT BE LATCHED.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE. AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSPECT AND, IF REQUIRED, INSTALL A NEW POWER SLIDING DOOR UNLATCH ACTUATOR ASSEMBLY. OWNER NOTIFICATION BEGAN ON OCTOBER 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Mar 8, 2001
VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS. THE DOOR CLOSES BUT MAY NOT BE LATCHED. IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE.
Consequence & remedy
Consequence: AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSTALL A NEW UN-LATCH ACTUATOR ASSEMBLY TO THE POWER SLIDING DOOR. THIS RECALL HAS BEEN CONTINUED UNDER SAFETY RECALL 01V-264. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Apr 12, 1999
VEHICLE DESCRIPTION: PASSENGER MINI VANS. THE LEFT AND/OR RIGHT FRONT LOWER INSULATOR TO CRADLE CENTER METAL SLEEVE IS COLLAPSED, WHICH CAN RESULT IN LOSS OF CLAMP LOAD IN THE JOINT. IF THE CLAMP LOAD IS REDUCED OR LOST, THE BOLT CAN BE LOST OR BROKEN AND THE JOINT CAN SEPARATE.
Consequence & remedy
Consequence: IF NOT REPAIRED, SEPARATION OF THE OPPOSITE SIDE JOINT COULD OCCUR RESULTING IN STEERING SHAFT SEPARATION.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT FRONT LOWER CRADLE-TO-SUSPENSION INSULATORS AND THE ATTACHING BOLTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6PE04064 · POWER-SLIDING Door
Opened Sep 17, 2004 · Closed Dec 22, 2004
Status: closed (inferred from source dates) · Structure:body:door
SUBJECT VEHICLES ARE AVAILABLE WITH AN OPTIONAL POWER SLIDING DOOR.THE INTERIOR HANDLE IS ORIENTED IN THE VERTICAL POSITION IN THE DOOR PANEL AND LINES UP AT THE ELBOW LEVEL WHEN THE OCCUPANT IS SEATED IN THE 2ND-ROW OUTBOARD POSITION.IF THE OCCUPANT HOLDS THE INTERIOR HANDLE IN THE THUMB UP POSITION DURING POWER-ASSISTED OPENING, THE ARM/WRIST CAN BE PUSH BACK WITH FORCE AGAINST THE 2ND-ROW BUCKET SEAT OR CAPTAIN'S CHAIR SEAT BACK CREATING A RISK OF INJURY (OTHER SEATING CONFIGURATIONS HAVE AMPLE SEAT TO DOOR CLEARANCE TO AVOID ENTRAPMENT OF THE LOWER ARM).AMONG THE 103 TOTAL REPORTS, THERE WERE 102 ALLEGED INJURIES INCLUDING ARM/WRIST, THUMB AND SHOULDER INJURIES.A COUNT OF INJURIES REVEALS THAT 76 INJURIES WERE A FRACTURED OR A BROKEN ARM/WRIST REQUIRING AN IMMOBILIZING CAST FOR FOUR-TO-SIX WEEKS.ALL INJURIES INVOLVE THE RIGHT SIDE POWER SLIDING DOOR.THE LEFT SIDE POWER SLIDING DOOR IS ON FAR FEWER VEHICLES, BUT MORE IMPORTANTLY, IT PRODUCES LESS FORCE.GM NOTIFIED THE AGENCY BY LETTER DATED DECEMBER 21, 2004, THAT IT WILL RECALL MODEL YEAR 1997 THOUGH EARLY 2005 GM U-VAN VEHICLES EQUIPPED WITH A RIGHT SIDE POWER SLIDING DOOR AND WITH 2ND-ROW BUCKET SEATS OR CAPTAIN CHAIRS (NHTSA RECALL #04V597).AS PART OF THE RECALL REMEDY, GM WILL REPLACE THE DOOR HANDLE WITH A FLUSH MOUNTED HANDLE THAT WILL PREVENT AN OCCUPANT FROM GRASPING THE HANDLE WITH THE PALM BETWEEN THE HANDLE AND DOOR PANEL (THUMB UP ORIENTATION) AND THUS ELIMINATE THE POTENTIAL FOR ARM/WRIST ENTRAPMENT.THIS INVESTIGATION IS CLOSED.
EA03005 · Rear Axle Trailing Arm Failure
Opened Apr 23, 2003 · Closed Jan 12, 2004
Status: closed (inferred from source dates) · Suspension; Suspension:rear
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (2)
Suspension
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:rear
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02086 · Rear Axle Trailing Arm Failure
Opened Nov 18, 2002 · Closed Apr 9, 2003
Status: closed (inferred from source dates) · Suspension; Suspension:rear
ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 14 INCIDENTS OF REAR TRAILING ARM FAILURES IN MODEL YEAR (MY) 1997 THROUGH 1999 GM U-VANS, INCLUDING TWO THAT ALLEGEDLY RESULTED IN CRASHES. THE TRAILING ARM DESIGN IN THESE VEHICLES IS USED IN THE U-VANS FROM MY 1997 THROUGH 2003.ACCORDING TO GM, THE SUBJECT TRAILING ARMS CAN CRACK OR BUCKLE IF THEY HAVE BEEN DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR CERTAIN SERVICE RELATED ABUSE CONDITIONS (E.G., IMPROPER TOWING OR JACKING).GM IDENTIFIED A PARTS HANDLING CONCERN THAT WAS CAUSING SOME TRAILING ARMS TO BE DAMAGED PRIOR TO INSTALLATION.TO ADDRESS THIS CONCERN, GM IMPLEMENTED CHANGES TO THE SHIPPING CONTAINERS FROM JANUARY 1999 THROUGH SEPTEMBER 1999. EIGHT (8) OF THE REPORTED INCIDENTS IN MY 1997-99 U-VANS, INCLUDING THE TWO CRASHES, OCCURRED IN THE LAST 2 YEARS.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO ASSESS THE TREND AND SAFETY RISK ASSOCIATED WITH THE ALLEGED DEFECT.
Additional source detail variants (2)
Suspension
ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 14 INCIDENTS OF REAR TRAILING ARM FAILURES IN MODEL YEAR (MY) 1997 THROUGH 1999 GM U-VANS, INCLUDING TWO THAT ALLEGEDLY RESULTED IN CRASHES. THE TRAILING ARM DESIGN IN THESE VEHICLES IS USED IN THE U-VANS FROM MY 1997 THROUGH 2003.ACCORDING TO GM, THE SUBJECT TRAILING ARMS CAN CRACK OR BUCKLE IF THEY HAVE BEEN DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR CERTAIN SERVICE RELATED ABUSE CONDITIONS (E.G., IMPROPER TOWING OR JACKING).GM IDENTIFIED A PARTS HANDLING CONCERN THAT WAS CAUSING SOME TRAILING ARMS TO BE DAMAGED PRIOR TO INSTALLATION.TO ADDRESS THIS CONCERN, GM IMPLEMENTED CHANGES TO THE SHIPPING CONTAINERS FROM JANUARY 1999 THROUGH SEPTEMBER 1999. EIGHT (8) OF THE REPORTED INCIDENTS IN MY 1997-99 U-VANS, INCLUDING THE TWO CRASHES, OCCURRED IN THE LAST 2 YEARS.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO ASSESS THE TREND AND SAFETY RISK ASSOCIATED WITH THE ALLEGED DEFECT.
Suspension:rear
ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 14 INCIDENTS OF REAR TRAILING ARM FAILURES IN MODEL YEAR (MY) 1997 THROUGH 1999 GM U-VANS, INCLUDING TWO THAT ALLEGEDLY RESULTED IN CRASHES. THE TRAILING ARM DESIGN IN THESE VEHICLES IS USED IN THE U-VANS FROM MY 1997 THROUGH 2003.ACCORDING TO GM, THE SUBJECT TRAILING ARMS CAN CRACK OR BUCKLE IF THEY HAVE BEEN DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR CERTAIN SERVICE RELATED ABUSE CONDITIONS (E.G., IMPROPER TOWING OR JACKING).GM IDENTIFIED A PARTS HANDLING CONCERN THAT WAS CAUSING SOME TRAILING ARMS TO BE DAMAGED PRIOR TO INSTALLATION.TO ADDRESS THIS CONCERN, GM IMPLEMENTED CHANGES TO THE SHIPPING CONTAINERS FROM JANUARY 1999 THROUGH SEPTEMBER 1999. EIGHT (8) OF THE REPORTED INCIDENTS IN MY 1997-99 U-VANS, INCLUDING THE TWO CRASHES, OCCURRED IN THE LAST 2 YEARS.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO ASSESS THE TREND AND SAFETY RISK ASSOCIATED WITH THE ALLEGED DEFECT.
PE02017 · Shoulder Harness Clip
Opened Feb 11, 2002 · Closed Aug 2, 2002
Status: closed (inferred from source dates) · Seat Belts
No summary supplied.
PE00045 · Air Bag Tear During Deployment
Opened Nov 3, 2000 · Closed Jan 11, 2001
Status: closed (inferred from source dates) · Air Bags
No summary supplied.
SQ00014 · Unexpected Opening Of Sliding Door
Opened Jul 25, 2000 · Closed Oct 22, 2001
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Illustration