NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
27 reportsClear category filter125,000 miles · Apr 2, 2008
Service Brakes, Hydraulic
WHEN ENTERING AN INTERSECTION AFTER LEAVING A STOP SIGN THE TRACTION CONTROL LIGHT AND ABS LIGHT ON THE DASH CAME ON AND THE VAN BEGAN JERKING AND LURCHING IN INTERSECTION UNABLE TO MOVE THROUGH INTERSECTION FOR ATLEAST 10 SECONDS BEFORE THE LURCHING STOPPED. ALWAYS HAPPENS WHEN COMING FROM A STOP SUCH AS A RED LIGHT, WHEN ENTER…
Read full complaint
WHEN ENTERING AN INTERSECTION AFTER LEAVING A STOP SIGN THE TRACTION CONTROL LIGHT AND ABS LIGHT ON THE DASH CAME ON AND THE VAN BEGAN JERKING AND LURCHING IN INTERSECTION UNABLE TO MOVE THROUGH INTERSECTION FOR ATLEAST 10 SECONDS BEFORE THE LURCHING STOPPED. ALWAYS HAPPENS WHEN COMING FROM A STOP SUCH AS A RED LIGHT, WHEN ENTERING STREET FROM SIDE ROAD. HAPPENS INTERMITTENTLY, MORE OFTEN WHEN ENGINE IS COLD. HAVE COME CLOSE TO BEING HIT MANY TIMES, OTHER DRIVERS HAVE HAD TO SLAM THEIR BRAKES TO STOP FROM HITTING ME BECAUSE IT CAN LURCH AND JERK NOT GOING ANYWHERE FOR UP TO 30 SECONDS AT TIMES WHILE VAN IS IN INTERSECTION OR ENTERING A ROAD. ABS MOTOR WAS FOUND TO BE WEAK, BUT MECHANIC CANNOT FIND PROBLEM WITH THE TRACTION CONTROL SYSTEM IN ORDER TO FIX IT. *TR
NHTSA ODI #10223153
3,000 miles · May 17, 2006
Electrical SystemEngine And Engine CoolingEquipment
I HAVE HAD SO MANY PROBLEMS 1. THE INNER BRAKE PADS WORE DOWN TO THE STEEL RUINING THE INSIDE OF BOTH ROTORS ABOUT 3,000 MILES. UNDER WARRANTY. BUT THE BRAKE PADS. 2. BATTERY ACID IS CORRODING ABOUT 4,000 MILES THE DEALERSHIP PAY ALL STILL UNDER WARRANTY 3. BATTERY AGAIN BUT IT TURN OUT TO BE THE ALTERNATOR ABOUT 6,500 TH…
Read full complaint
I HAVE HAD SO MANY PROBLEMS 1. THE INNER BRAKE PADS WORE DOWN TO THE STEEL RUINING THE INSIDE OF BOTH ROTORS ABOUT 3,000 MILES. UNDER WARRANTY. BUT THE BRAKE PADS. 2. BATTERY ACID IS CORRODING ABOUT 4,000 MILES THE DEALERSHIP PAY ALL STILL UNDER WARRANTY 3. BATTERY AGAIN BUT IT TURN OUT TO BE THE ALTERNATOR ABOUT 6,500 THE DEALERSHIP PAY UNDER WARRANTY. 4. THE TREAD COMPLETELY SEPARATED FROM THE SIDEWALL. P215/70R15, FIRE STONE ON ALL FOUR TIRES. DEALERSHIP DID NOT COVER TIRE HAVE NO WARRANTY ON NEW VEHICLE 7,000 MILES 5. WATER LEAK, AND CARPET IS WET EVERY TIME IT RAINS I FEEL IT IS COMING FROM THE WINDSHIELD. WARRANTY DOES NOT COVER. 8,000 STILL DOES IT AT 50,256. 6. LIGHTER KEEP SHORTING OUT AND AC KEEP MESS UP UNDER THE WARRANTY 7. WHILE DRIVING THE CHECK OIL LIGHT AND THE BATTERY LINE CAME ON. THE VEHICLE SHUT OFF, LOOSING ALL POWER THE INTAKE MANIFOLD UNDER WARRANTY 38,000 MILES. 8. INTAKE MANIFOLD FIX CAME HOME MY LIGHTS WAS MESS UP WHEN PUT ON MY BRAKES THE FOUR WAY FLASHER CAME ON WHEN I PUT MY LEFT TURN SIGNALS THE RIGHT ONE WOULD CAME ON PUT THE RIGHT TURN SIGNALS THE LEFT ONE WOULD COME ON TOOK IT BACK THEY HAD TO REPAIRED ENTIRE WIRING SYSTEM BECAUSE OF OVER HEARTED BURN IT UP UNDER WARRANT 9. BATTERY ACID IS CORRODING THE BATTERY PAN AND SURROUNDING COMPONENTS, POSITIVE CABLE CONNECTED TO BATTERY HAS FALLEN OFF,38,500 NOT COVER 6 YEAR WAS UP. 10. POWER STEERING FLUID SPRAYING FLUID ONTO THE ENGINE AND SERPENTINE BELT THE DEALERSHIP DID NOT PUT CAP BACK ON POWER STEERING. 11. POWER LOCKS WILL NOT OPERATE FROM DOOR SWITCHES ONLY FROM THE REMOTE POWER WINDOW. BACK AC DOES NOT WORK. 12. CONNECTOR LEFT AND RIGHT MELT TAIL LIGHTS, STOP LIGHTS, TURN SIGNALS ABOUT 42,000. 13. THERE IS A THUMP NOISE WHEN STOPPING AND TAKING OFF. 14. STRONG SMELL OF FUEL WHEN PARKED. 15. CLOUDING OF LENS 16. SERPENTINE BELT REPLACE AT 50,256 17. LEAKING FROM LOWER INTAKE MANIFOLD GASKET. AT 50,000. *NM
NHTSA ODI #10157702
Mileage unknown · Aug 19, 2005
Service Brakes, HydraulicSteeringStructureInjury
CONSUMER STATES THAT AFTER DEALERSHIP REPAIRED THE RECALL FOR THE SLIDING DOOR FOR THE 3RD TIME,THE DOOR SLIDE OPEN, AND CHILD FELL OUT OFF VEHICLE.DEALER/MANUFACTURER CONTACTED.THEY ARE NOT HELPFUL, DO NOT WANT TO TAKE RESPONSIBILITY. MR ALSO HAVING PROBLEMS WITH STEERING, ABS BRAKES LIGHTS ARE ON AND THE FIRESTONE TIRES…
Read full complaint
CONSUMER STATES THAT AFTER DEALERSHIP REPAIRED THE RECALL FOR THE SLIDING DOOR FOR THE 3RD TIME,THE DOOR SLIDE OPEN, AND CHILD FELL OUT OFF VEHICLE.DEALER/MANUFACTURER CONTACTED.THEY ARE NOT HELPFUL, DO NOT WANT TO TAKE RESPONSIBILITY. MR ALSO HAVING PROBLEMS WITH STEERING, ABS BRAKES LIGHTS ARE ON AND THE FIRESTONE TIRES BLEW OUT. *TT
NHTSA ODI #8021363
Mileage unknown · Jan 31, 2005
Service Brakes, Hydraulic
I WAS PARKING MY CAR AT A MALL, I PUT ON THE BRAKE AND HIT BRAKE PEDAL AND ACCELERATOR PEDAL TOGETHER, THE ACCELERATOR ALMOST TOOK MY CAR INTO THE CEMENT PARKING BOLLARD, BUT I MANAGED TO STOP THE CAR 1 1/2 " FROM DAMAGING THE CAR. I HAVE COMPLAINED IN THE PAST ABOUT THIS PROBLEM OF THE HEIGHT OF THE PEDALS TO CHEVROLET DEALER W…
Read full complaint
I WAS PARKING MY CAR AT A MALL, I PUT ON THE BRAKE AND HIT BRAKE PEDAL AND ACCELERATOR PEDAL TOGETHER, THE ACCELERATOR ALMOST TOOK MY CAR INTO THE CEMENT PARKING BOLLARD, BUT I MANAGED TO STOP THE CAR 1 1/2 " FROM DAMAGING THE CAR. I HAVE COMPLAINED IN THE PAST ABOUT THIS PROBLEM OF THE HEIGHT OF THE PEDALS TO CHEVROLET DEALER WITH NO SATISFACTION. "THAT'S THEY WAY THEY ARE BUILT, THERE IS NO DEFECT". THIS SITUATION HAS CAUSED ME PROBLEMS IN THE PAST, ALMOST HITTING A CURBSTONE AND THE LIKE. I COULD BE BLAMED FOR HITTING A PEDESTRIAN BECAUSE THE ACCELERATOR TAKES OVER BEFORE THE BRAKE PEDAL IF BOTH ARE PUSHED SIMULTANEOUSLY. THE BRAKE PEDAL SHOULD BE MOUNTED SO THAT IT WILL BE PUSHED FIRST SO AS TO STOP THE CAR AND NOT ALLOW THE ACCELERATOR PEDAL TO BE PUSHED. I GOT NO HELP FROM THE DEALER. I AM AFRAID THAT I COULD GET INTO A SERIOUS ACCIDENT BECAUSE OF THIS SITUATION. IN A GREAT HURRY, MY FOOT STRUCK BOTH PEDALS AT THE SAME TIME. THE BRAKE PEDAL SHOULD BE HIGH ENOUGH TO TAKE OVER. I HAVE HAD THE BRAKES CHECKED REGULARLY, I KEEP NEW TIRES ON MY CAR. MY CAR ALWAYS PASSES INSPECTION. I DRIVE A 1999 CHEVROLET VENTURE. I BOUGHT IT AT CLAY CHEVROLET ON SEPTEMBER 15, 2002, USED WITH 33963 MILES ON THE ODOMETER. IT NOW HAS 66650 MILES. *AK
NHTSA ODI #10108301
Mileage unknown · Aug 4, 2004
Air BagsExterior LightingService Brakes, Hydraulic
WHILE DRIVING TURN SIGNAL LIGHTS/ABS, AND SRS LIGHTS FLASHED ON AND OFF THE DASHBOARD. CONSUMER WAS ABLE TO DRIVE THE VEHICLE TO DEALER FOR INSPECTION, AND THE MECHANIC COULD NOT BE DUPLICATE THE PROBLEM. *AK
NHTSA ODI #10087239
Mileage unknown · Jan 15, 2004
Engine And Engine CoolingService Brakes, Hydraulic
MAIN PROBLEM: JAN 03 CAM SHAFT BROKE, ENGINE MUST BE REPLACED. MAR 02 : INTAKE MANIFOLD GASKET REPLACED. LEAKING COOLANT INTO ENGINE. OCT 02 BRAKE ROTORS WARPED. SHAKES VIOLENTLY WHILE BRAKING.
NHTSA ODI #10069477
59,000 miles · Jan 13, 2004
Service Brakes, Hydraulic
WHILE DRIVING OUTSIDE BRAKE PAD ON THE LEFT ROTOR FELL OFF. VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO FOUND THE LEFT ROTOR AND INSIDE PAD WERE RUSTED. THE MECHANIC INSTALLED ANEW LEFT ROTORS AND PADS. *AK RIGHT PAD AND ROTOR WAS REPLACED. MECHANIC STATED THE RUST ON THE LEFT PAD AND ROTOR WAS NORMAL, CONSUM…
Read full complaint
WHILE DRIVING OUTSIDE BRAKE PAD ON THE LEFT ROTOR FELL OFF. VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO FOUND THE LEFT ROTOR AND INSIDE PAD WERE RUSTED. THE MECHANIC INSTALLED ANEW LEFT ROTORS AND PADS. *AK RIGHT PAD AND ROTOR WAS REPLACED. MECHANIC STATED THE RUST ON THE LEFT PAD AND ROTOR WAS NORMAL, CONSUMER DISAGREED. *PH
NHTSA ODI #10047991
48,000 miles · Dec 4, 2003
Air BagsPower TrainService Brakes, Hydraulic
MY 1999 CHEVROLET VENTURE MINIVAN HAS HAD NUMEROUS PROBLEMS. THE ONE I AM MOST CONCERNED WITH IS THE AUTOMATIC TRANSMISSION. THE TRANSMISSION MAKES THE CAR JERK WHEN I EITHER SLOW DOWN OR STOP IN HEAVY TRAFFIC. THIS HAPPENS WHEN I PRESS ON THE ACCELERATOR TO GAIN SPEED AGAIN. IT DOESN'T HAPPEN EVERY TIME BUT MORE OFTEN THAN …
Read full complaint
MY 1999 CHEVROLET VENTURE MINIVAN HAS HAD NUMEROUS PROBLEMS. THE ONE I AM MOST CONCERNED WITH IS THE AUTOMATIC TRANSMISSION. THE TRANSMISSION MAKES THE CAR JERK WHEN I EITHER SLOW DOWN OR STOP IN HEAVY TRAFFIC. THIS HAPPENS WHEN I PRESS ON THE ACCELERATOR TO GAIN SPEED AGAIN. IT DOESN'T HAPPEN EVERY TIME BUT MORE OFTEN THAN NOT. THERE ARE ALSO TIMES WHEN DRIVING DOWN THE ROAD IT WHINES. ALSO HAVE A PROBLEM WITH WHAT I FIGURE IS ELECTRICAL. SOMETIMES THE ABS LIGHT STAYS ON AND THEN EVENTUALLY GOES OFF. ALSO, THE AIR BAG LIGHT COMES ON INTERMITTENTLY. *NLM
NHTSA ODI #10049196
Mileage unknown · Nov 20, 2002
Service Brakes, Hydraulic
CONSUMER STATED THAT WHEN APPLYING THE BRAKES THE BRAKE LIGHT WILL COME ON AND STAY ON THE REMAINDER OF THE TIME VEHICLE IS BEING OPERATED. DEALER NOTIFIED. TS
NHTSA ODI #8023052
Mileage unknown · Jul 23, 2002
Electrical SystemService Brakes, Hydraulic
WHILE DRIVING ABS LIGHT ILLUMINATED, TURN SIGNAL PERFORMED ERRATICALLY DUE TO PIG-TAIL, CIRCUIT BOARD SOCKET FAILURE. *AK CONSUMER STATED THAT BAD SEAL ON PIG TAIL CAUSED MOISTURE TO ENTER CIRCUIT BOARD. *YH
NHTSA ODI #8014523
Official recalls
4Dec 22, 2004
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Consequence & remedy
Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
Aug 21, 2001
VEHICLE DESCRIPTION: 1997-2001 CHEVROLET VENTURE, PONTIAC MONTANA/TRANSPORT, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS THAT WERE SERVICED IN CAMPAIGN 01013 (01V-067) FROM APRIL TO AUGUST 2001. ALSO 2001 CHEVROLET VENTURE, PONTIAC MONTANA, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS ASSEMBLED IN JANUARY THROUGH APRIL 2001. THESE VEHICLES HAVE INADEQUATE FRONT WELDS. IF A FRONT WELD FAILS, THE ACTUATOR CAN JAM IN THE UNLATCHED POSITION AND, WHEN THE SLIDING DOOR CLOSES, IT WILL NOT BE LATCHED.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE. AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSPECT AND, IF REQUIRED, INSTALL A NEW POWER SLIDING DOOR UNLATCH ACTUATOR ASSEMBLY. OWNER NOTIFICATION BEGAN ON OCTOBER 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Mar 8, 2001
VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS. THE DOOR CLOSES BUT MAY NOT BE LATCHED. IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE.
Consequence & remedy
Consequence: AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSTALL A NEW UN-LATCH ACTUATOR ASSEMBLY TO THE POWER SLIDING DOOR. THIS RECALL HAS BEEN CONTINUED UNDER SAFETY RECALL 01V-264. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Apr 12, 1999
VEHICLE DESCRIPTION: PASSENGER MINI VANS. THE LEFT AND/OR RIGHT FRONT LOWER INSULATOR TO CRADLE CENTER METAL SLEEVE IS COLLAPSED, WHICH CAN RESULT IN LOSS OF CLAMP LOAD IN THE JOINT. IF THE CLAMP LOAD IS REDUCED OR LOST, THE BOLT CAN BE LOST OR BROKEN AND THE JOINT CAN SEPARATE.
Consequence & remedy
Consequence: IF NOT REPAIRED, SEPARATION OF THE OPPOSITE SIDE JOINT COULD OCCUR RESULTING IN STEERING SHAFT SEPARATION.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT FRONT LOWER CRADLE-TO-SUSPENSION INSULATORS AND THE ATTACHING BOLTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6PE04064 · POWER-SLIDING Door
Opened Sep 17, 2004 · Closed Dec 22, 2004
Status: closed (inferred from source dates) · Structure:body:door
SUBJECT VEHICLES ARE AVAILABLE WITH AN OPTIONAL POWER SLIDING DOOR.THE INTERIOR HANDLE IS ORIENTED IN THE VERTICAL POSITION IN THE DOOR PANEL AND LINES UP AT THE ELBOW LEVEL WHEN THE OCCUPANT IS SEATED IN THE 2ND-ROW OUTBOARD POSITION.IF THE OCCUPANT HOLDS THE INTERIOR HANDLE IN THE THUMB UP POSITION DURING POWER-ASSISTED OPENING, THE ARM/WRIST CAN BE PUSH BACK WITH FORCE AGAINST THE 2ND-ROW BUCKET SEAT OR CAPTAIN'S CHAIR SEAT BACK CREATING A RISK OF INJURY (OTHER SEATING CONFIGURATIONS HAVE AMPLE SEAT TO DOOR CLEARANCE TO AVOID ENTRAPMENT OF THE LOWER ARM).AMONG THE 103 TOTAL REPORTS, THERE WERE 102 ALLEGED INJURIES INCLUDING ARM/WRIST, THUMB AND SHOULDER INJURIES.A COUNT OF INJURIES REVEALS THAT 76 INJURIES WERE A FRACTURED OR A BROKEN ARM/WRIST REQUIRING AN IMMOBILIZING CAST FOR FOUR-TO-SIX WEEKS.ALL INJURIES INVOLVE THE RIGHT SIDE POWER SLIDING DOOR.THE LEFT SIDE POWER SLIDING DOOR IS ON FAR FEWER VEHICLES, BUT MORE IMPORTANTLY, IT PRODUCES LESS FORCE.GM NOTIFIED THE AGENCY BY LETTER DATED DECEMBER 21, 2004, THAT IT WILL RECALL MODEL YEAR 1997 THOUGH EARLY 2005 GM U-VAN VEHICLES EQUIPPED WITH A RIGHT SIDE POWER SLIDING DOOR AND WITH 2ND-ROW BUCKET SEATS OR CAPTAIN CHAIRS (NHTSA RECALL #04V597).AS PART OF THE RECALL REMEDY, GM WILL REPLACE THE DOOR HANDLE WITH A FLUSH MOUNTED HANDLE THAT WILL PREVENT AN OCCUPANT FROM GRASPING THE HANDLE WITH THE PALM BETWEEN THE HANDLE AND DOOR PANEL (THUMB UP ORIENTATION) AND THUS ELIMINATE THE POTENTIAL FOR ARM/WRIST ENTRAPMENT.THIS INVESTIGATION IS CLOSED.
EA03005 · Rear Axle Trailing Arm Failure
Opened Apr 23, 2003 · Closed Jan 12, 2004
Status: closed (inferred from source dates) · Suspension; Suspension:rear
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (2)
Suspension
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:rear
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02086 · Rear Axle Trailing Arm Failure
Opened Nov 18, 2002 · Closed Apr 9, 2003
Status: closed (inferred from source dates) · Suspension; Suspension:rear
ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 14 INCIDENTS OF REAR TRAILING ARM FAILURES IN MODEL YEAR (MY) 1997 THROUGH 1999 GM U-VANS, INCLUDING TWO THAT ALLEGEDLY RESULTED IN CRASHES. THE TRAILING ARM DESIGN IN THESE VEHICLES IS USED IN THE U-VANS FROM MY 1997 THROUGH 2003.ACCORDING TO GM, THE SUBJECT TRAILING ARMS CAN CRACK OR BUCKLE IF THEY HAVE BEEN DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR CERTAIN SERVICE RELATED ABUSE CONDITIONS (E.G., IMPROPER TOWING OR JACKING).GM IDENTIFIED A PARTS HANDLING CONCERN THAT WAS CAUSING SOME TRAILING ARMS TO BE DAMAGED PRIOR TO INSTALLATION.TO ADDRESS THIS CONCERN, GM IMPLEMENTED CHANGES TO THE SHIPPING CONTAINERS FROM JANUARY 1999 THROUGH SEPTEMBER 1999. EIGHT (8) OF THE REPORTED INCIDENTS IN MY 1997-99 U-VANS, INCLUDING THE TWO CRASHES, OCCURRED IN THE LAST 2 YEARS.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO ASSESS THE TREND AND SAFETY RISK ASSOCIATED WITH THE ALLEGED DEFECT.
Additional source detail variants (2)
Suspension
ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 14 INCIDENTS OF REAR TRAILING ARM FAILURES IN MODEL YEAR (MY) 1997 THROUGH 1999 GM U-VANS, INCLUDING TWO THAT ALLEGEDLY RESULTED IN CRASHES. THE TRAILING ARM DESIGN IN THESE VEHICLES IS USED IN THE U-VANS FROM MY 1997 THROUGH 2003.ACCORDING TO GM, THE SUBJECT TRAILING ARMS CAN CRACK OR BUCKLE IF THEY HAVE BEEN DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR CERTAIN SERVICE RELATED ABUSE CONDITIONS (E.G., IMPROPER TOWING OR JACKING).GM IDENTIFIED A PARTS HANDLING CONCERN THAT WAS CAUSING SOME TRAILING ARMS TO BE DAMAGED PRIOR TO INSTALLATION.TO ADDRESS THIS CONCERN, GM IMPLEMENTED CHANGES TO THE SHIPPING CONTAINERS FROM JANUARY 1999 THROUGH SEPTEMBER 1999. EIGHT (8) OF THE REPORTED INCIDENTS IN MY 1997-99 U-VANS, INCLUDING THE TWO CRASHES, OCCURRED IN THE LAST 2 YEARS.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO ASSESS THE TREND AND SAFETY RISK ASSOCIATED WITH THE ALLEGED DEFECT.
Suspension:rear
ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 14 INCIDENTS OF REAR TRAILING ARM FAILURES IN MODEL YEAR (MY) 1997 THROUGH 1999 GM U-VANS, INCLUDING TWO THAT ALLEGEDLY RESULTED IN CRASHES. THE TRAILING ARM DESIGN IN THESE VEHICLES IS USED IN THE U-VANS FROM MY 1997 THROUGH 2003.ACCORDING TO GM, THE SUBJECT TRAILING ARMS CAN CRACK OR BUCKLE IF THEY HAVE BEEN DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR CERTAIN SERVICE RELATED ABUSE CONDITIONS (E.G., IMPROPER TOWING OR JACKING).GM IDENTIFIED A PARTS HANDLING CONCERN THAT WAS CAUSING SOME TRAILING ARMS TO BE DAMAGED PRIOR TO INSTALLATION.TO ADDRESS THIS CONCERN, GM IMPLEMENTED CHANGES TO THE SHIPPING CONTAINERS FROM JANUARY 1999 THROUGH SEPTEMBER 1999. EIGHT (8) OF THE REPORTED INCIDENTS IN MY 1997-99 U-VANS, INCLUDING THE TWO CRASHES, OCCURRED IN THE LAST 2 YEARS.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO ASSESS THE TREND AND SAFETY RISK ASSOCIATED WITH THE ALLEGED DEFECT.
PE02017 · Shoulder Harness Clip
Opened Feb 11, 2002 · Closed Aug 2, 2002
Status: closed (inferred from source dates) · Seat Belts
No summary supplied.
PE00045 · Air Bag Tear During Deployment
Opened Nov 3, 2000 · Closed Jan 11, 2001
Status: closed (inferred from source dates) · Air Bags
No summary supplied.
SQ00014 · Unexpected Opening Of Sliding Door
Opened Jul 25, 2000 · Closed Oct 22, 2001
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Illustration