Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
670–25K
2225–50K
2950–75K
1475–100K
17100–150K
11150K+
160 reports with mileage · 36 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 57 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Latches/locks/linkages. Review the 45 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 45 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports1 fire reports16 injury reports
What owners actually said
196 reports
7,000 miles · Jun 27, 2005
Interior LightingLatches/locks/linkages
DT: CALLER SAID AUTOMATIC SLIDING DOOR WAS DEFECTIVE. CALLER HAD IT FIXED TWICE ALREADY, AND HAS AN APPOINTMENT FOR A THIRD TIME. THE CABLE BROKE, AND SHE WAS WAITING FOR THE PART. THE BELL THAT SIGNALED DOOR AJAR SOUNDED CONSTANTLY. ALSO, THE MOTOR FOR THE SLIDING DOOR WAS REPLACED TWICE, AND CURRENTLY WAS WAITING FOR ANO…
Read full complaint
DT: CALLER SAID AUTOMATIC SLIDING DOOR WAS DEFECTIVE. CALLER HAD IT FIXED TWICE ALREADY, AND HAS AN APPOINTMENT FOR A THIRD TIME. THE CABLE BROKE, AND SHE WAS WAITING FOR THE PART. THE BELL THAT SIGNALED DOOR AJAR SOUNDED CONSTANTLY. ALSO, THE MOTOR FOR THE SLIDING DOOR WAS REPLACED TWICE, AND CURRENTLY WAS WAITING FOR ANOTHER ONE. THIS WILL BE THE THIRD MOTOR IN THREE MONTHS.*AK
NHTSA ODI #10126692
6,926 miles · Jun 27, 2005
Service Brakes, Hydraulic
MAY 1, SERVICE STABILITRAK SYSTEM MESSAGE CAME ON, TRACTION CONTROL LIGHT CAME ON, VEHICLE STOPPED ON OWN. ABLE TO DRIVE ABOUT 20 FEET BEFORE IT STOPPED AGAIN. THIS REPEATED ABOUT 20 TIMES. THE BRAKES ENGAGED ALL 4 WHEELS WITHOUT PRESSING THE PEDAL EACH TIME. AFTER RESTARTING VEHICLE IT WORKS FINE. MAY 2 GOING 65 MPH ON I-275, T…
Read full complaint
MAY 1, SERVICE STABILITRAK SYSTEM MESSAGE CAME ON, TRACTION CONTROL LIGHT CAME ON, VEHICLE STOPPED ON OWN. ABLE TO DRIVE ABOUT 20 FEET BEFORE IT STOPPED AGAIN. THIS REPEATED ABOUT 20 TIMES. THE BRAKES ENGAGED ALL 4 WHEELS WITHOUT PRESSING THE PEDAL EACH TIME. AFTER RESTARTING VEHICLE IT WORKS FINE. MAY 2 GOING 65 MPH ON I-275, THE LIGHTS CAME BACK ON AND THE BRAKES ENGAGED WITHOUT NOTICE. MY WIFE WAS ABLE TO GET OFF THE ROAD (LUCKY). IT WAS LIKE SHE SLAMMED ON THE BRAKES ON A SLICK ROAD (WITHOUT USING THE PEDAL). DEALER COULD NOT LOCATE REASON, CALLED GM TECH ASSIT AND THEY FOUND A BAD CONNECTION WITH THE WIRING HARNESS. GOT VAN BACK MAY 3. MAY 11 LIGHTS BACK ON AND KEPT ENGAGING BRAKES IN DRIVEWAY. DEALER FOUND ANOTHER SUSPECT CONNECTION WITH GM TECH ASSIST AND GAVE US THE VAN BACK. JUNE 5 LIGHTS BACK ON UNTIL GETTING GAS. JUNE 8 LIGHTS BACK ON, ONSTAR RAN DIAGS AND REPORTED ANTI-LOCK BRAKE ISSUE. LIGHTS STAYED OFF AFTER RESTARTING VAN. EACH TIME WE TURN OFF THE VAN AND THEN RESTART IT, IT SEEMS FINE. JUNE 9 LIGHTS BACK ON, ONSTAR FOUND SAME ERROR REPORTED. JUNE 10 LIGHTS BACK ON. ON WAY TO DEALER THE BRAKES FAILED TO ENGANGE JUST YARDS FROM DEALER AND WIFE WENT THROUGH STOP SIGN. SERVICE ADVISOR TRIED 4 TIMES TO STOP VAN DRIVING IT TO THE STALL. DEALER FOUND TIRE GOING FLAT WHILE IN STALL. DEALER FOUND 17 CODES STORED SHOWING LOW VOLTAGE. WITH GM TECH ASSIST DEALER CLAIMS TO HAVE FOUND YET ANOTHER BAD CONNECTION. GAVE VAN BACK AFTER ONLY 4 HOURS. JUNE 12 LIGHTS BACK ON. JUNE 13 TOOK IT TO SELLING DEALER (45 MILES AWAY). DEALER STILL HAS VAN (2 WEEKS LATER-JUNE 27) CLAIMS ENGINEER CAME DOWN, COULD NOT FIND PROBLEM BUT SUGGESTED REPLACING BCM (17 CODES AGAIN). THEY ARE REPLACING THE COMPUTER HOPING IT IS THE CAUSE. WE DONT WANT THE VAN BACK AND ASKING FOR A REPLACEMENT UNDER THE LEMON LAW AND THE FACT THAT IT FAILS TO STOP IF A TIRE IS LOW ON AIR. REPLACED RADIO AND MOULDINGS. HAD BRAKE FAILURE, SLIDING DOOR FAILURE, AND MORE. I WOULD NOT BUY ANOTHER UPLANDER.
NHTSA ODI #10126663
Mileage unknown · Jun 17, 2005
Electrical System
ACTUATING BAR FOR WINDSHIELD WIPERS CUTTING INTO WIRING HARNESS CAUSING FAILURES TO WIRES CUT, PRIMARILY HEADLIGHTS. A TOTAL OF SEVEN WIRES WERE CUT. DEALERSHIP FIXED WIRES AND HAD TO FASTEN WIRING HARNESS TO WINSHIELD WIPER FLUID TANK NECK WITH ELECTRICAL TIES.
NHTSA ODI #10125600
1,000 miles · Jun 9, 2005
Electrical System
WE WERE TAKING VACATION LAST DECEMBER GOING THRU THE MOUNTAINS AND IT WAS VERY FOGGY. YOU COULD BARELY SEE THE ROAD AND WE NOTICED THE HEADLIGHTS AND INTERIOR LIGHTS WERE FLICKERING. THE FOLLOWING WEEK I TOOK IT TO MY DEALERSHIP TO LET THEM FIX THE PROBLEM THEY DID LET ME KNOW THAT THEY WERE AWARE OF A PROBLEM. THEY SHOWED ME A …
Read full complaint
WE WERE TAKING VACATION LAST DECEMBER GOING THRU THE MOUNTAINS AND IT WAS VERY FOGGY. YOU COULD BARELY SEE THE ROAD AND WE NOTICED THE HEADLIGHTS AND INTERIOR LIGHTS WERE FLICKERING. THE FOLLOWING WEEK I TOOK IT TO MY DEALERSHIP TO LET THEM FIX THE PROBLEM THEY DID LET ME KNOW THAT THEY WERE AWARE OF A PROBLEM. THEY SHOWED ME A PAPER STATING THAT GMAC WAS TRYING TO CORRECT THE PROBLEM. THIS WAS LAST DECEMBER AND IT IS NOW JUNE AND STILL NO SOLUTION. THIS COULD CAUSE A ACCIDENT ESPECIALLY WHEN YOU ARE DRIVING IN FOGGY WEATHER. I REALLY HOPE SOMEONE CAN FIND A THE SOLUTION TO THE PROBLEM OR I MIGHT JUST TAKE THE VEHICLE TO THE DEALER PARKING LOT AND PARK IT UNTIL THE SOLUTION IS FIXED.
NHTSA ODI #10124855
Mileage unknown · May 27, 2005
SeatsCrashInjury
I AM ENTERING THIS CONCERN ON BEHALF OF MY FAMILY MEMBERS THAT WERE INJURED WITH ONE FATALITY IN A SINGLE VEHICLE INCIDENT. THE VEHICLE INCIDENT OCURRED ON I65 SOUTHBOUND BETWEEN MONTGOMERY, ALABAMA AND MOBILE, ALABAMA ON MAY 17, 2005. MY AUNT [XXX] DIED AS A RESULT OF INJURIES. MY MOTHER [XXX] REMAINS IN CRITICAL CONDITION…
Read full complaint
I AM ENTERING THIS CONCERN ON BEHALF OF MY FAMILY MEMBERS THAT WERE INJURED WITH ONE FATALITY IN A SINGLE VEHICLE INCIDENT. THE VEHICLE INCIDENT OCURRED ON I65 SOUTHBOUND BETWEEN MONTGOMERY, ALABAMA AND MOBILE, ALABAMA ON MAY 17, 2005. MY AUNT [XXX] DIED AS A RESULT OF INJURIES. MY MOTHER [XXX] REMAINS IN CRITICAL CONDITION AT THE UNIV. OF SOUTH ALABAMA MEDICAL CENTER IN MOBILE, AL. MY COUSIN [XXX] HAS NECK INJURIES AND HAS BEEN RELEASED. MY FATHER [XXX] AND NEPHEWS ([XXX] AND [XXX]) SUFFERED MINOR INJURIES. MY FATHER WAS DRIVING THE VEHICLE. [XXX] AND [XXX] WERE RIDING IN THE 2ND ROW SEATS IN AN AVIS RENTAL 2005MY CHEVY UPLANDER. ACCORDING TO MY SISTER [XXX] AND HER CONVERSATIONS WITH THE ICU SURGEONS, BOTH [XXX] AND [XXX] SUFFERED INTESTINAL DAMAGE AND INJURIES WERE SIMILAR. ACCORDING TO MY FATHER'S RECOLLECTION, MY MOTHER WAS SITTING ON THE 2ND ROW -DRIVER'S SIDE AND MY AUNT WAS SEATED ON THE 2ND ROW - PASSENGER SIDE. BASED ON PHOTOS OF THE VEHICLE , THE PASSENGER- SIDE RESEMBLES A SIDE-IMPACT DAMAGE. MY FATHER RECALLS A ROLL-OVER EVENT. HE DID NOT RECALL MAKING A MAJOR TURN IN THE STEERING WHEEL. PER RECALL NHTSA ID#05V061000 AND GM RECALL#05015, IT STATES THAT THE 2ND ROW SEAT CAN BECOME DETACHED AS A RESULT OF SIDE - IMPACT. THE RECALL BEGAN IN 04/05/2005. ACCORDING TO GM RECORDS, THE VEHICLE [XXX] WAS NOT INCLUDED IN THE RECALL. MY CONVERSATION WITH THE TOW COMPANY LEADS ME TO SUSPECT 2ND ROW SEAT PERFORMANCE IN THE INCIDENT. I HAVE THE FOLLOWING QUESTIONS AND SUSPICIONS: (1) 2ND ROW SEATS TEMPORARILY OR PERMANENTLY DETACHED (2) THE BODY FRAME SUPPORT ALLOWED FOR THE 2ND ROW SEATS TO DETACH (3) THE 2ND ROW SEAT BACK SUPPORT MAY HAVE FAILED (4) THE 2ND ROW SEAT BELTS MAY HAVE FALTERED. (5) VEHICLE CHASSIS DESIGN ALLOWED A GREATER CHANCE FOR TIP OVER. AVIS DENIED MY REQUEST TO VIEW THE VEHICLE. NOW, I AM MORE CONCERNED. *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #10122339
1,800 miles · Apr 25, 2005
Latches/locks/linkages
PASSENGER POWER SLIDING DOOR WAS STUCK IN THE OPEN POSITION. PRESSED THE POWER BUTTON AND THE DOOR CLOSED 30% AND JAMMED. I CHECKED FOR ANY BLOCKAGES AND DID NOT SEE ANY. I PUSHED THE POWER BUTTON AGAIN AND THE MOTOR SOUNDED ABNORMAL. I REMOVED THE KEY FROM THE IGNITION TOOK THE DOOR HANDLE AND TRIED TO MANUALLY CLOSE THE DOOR. …
Read full complaint
PASSENGER POWER SLIDING DOOR WAS STUCK IN THE OPEN POSITION. PRESSED THE POWER BUTTON AND THE DOOR CLOSED 30% AND JAMMED. I CHECKED FOR ANY BLOCKAGES AND DID NOT SEE ANY. I PUSHED THE POWER BUTTON AGAIN AND THE MOTOR SOUNDED ABNORMAL. I REMOVED THE KEY FROM THE IGNITION TOOK THE DOOR HANDLE AND TRIED TO MANUALLY CLOSE THE DOOR. AT THAT POINT THE BRACKET ,BEARINGS AND CABLE CAME OFF WITH THE BACK OF THE DOOR. THE BACK OF THE VAN IS NOW DAMAGED ALONG THE BRACKET.*AK
THE BRAUN CORPORATION HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2005-2008 GENERAL MOTORS MOBILITY CONVERSION, HANDICAPPED ACCESSIBLE LOW FLOOR MINIVANS. DURING CONVERSION, THE DRIVER OR PASSENGER SIDE TRAILING ARM MODIFICATION MAY NOT HAVE BEEN ADEQUATELY WELDED.
Consequence & remedy
Consequence: A SQUEAKING OR CLUNKING NOISE MAY DEVELOP. THE TRAILING ARM BUSHINGS MAY PREMATURELY WEAR AND THE TRAILING ARM MAY FRACTURE OR SEPARATE, ALLOWING THE REAR AXLE TO BECOME PARTIALLY SEPARATED FROM THE CHASSIS INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND WILL HAVE A SUPPLY OF RETROFIT PARTS AVAILABLE TO REMEDY THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 4, 2010. OWNERS MAY CONTACT BRAUN AT 1-800-488-0359.
CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' TO MEET THE STANDARD, THE VEHICLE MUST NOT MOVE FOR FIVE MINUTES WHEN STOPPED ON A STEEP HILL WITH THE PARKING BRAKE APPLIED AND THE VEHICLE IN NEUTRAL (N). SOME OF THESE VEHICLES FAILED THIS TEST.
Consequence & remedy
Consequence: WHEN THE PARKING BRAKE IS RELEASED, THE DRIVER MAY NOTICE UNINTENDED BRAKING WHEN ACCELERATING, DECELERATING, OR COASTING, AND A NOISE COMING FROM THE REAR OF THE VEHICLE. UNINTENDED VEHICLE MOVEMENT COULD OCCUR INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT FOR PARKING BRAKE LEVER SLIPPAGE AT EACH REAR BRAKE CALIPER AND REPLACE THE CALIPER IF LEVER SLIPPAGE IS IDENTIFIED. THE RECALL BEGAN ON NOVEMBER 14, 2005. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR SATURN AT 1-800-972-8876.
ON CERTAIN MINIVANS, THE OUTBOARD RELEASE HANDLE ON THE IMPACT-SIDE SECOND-ROW BUCKET SEAT MAY BE ACTUATED AND THE REAR LATCHES MAY UNLATCH EARLY IN A SIDE IMPACT CRASH. THIS WAS DISCOVERED IN A SIDE IMPACT TEST RUN BY GM, UNDER CONDITIONS SIMILAR TO NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) SIDE IMPACT TEST.
Consequence & remedy
Consequence: IF THE REAR LATCHES OF THE SEAT RELEASE EARLY IN A SEVERE SIDE IMPACT, THE FRONT OUTBOARD LATCH MAY DISENGAGE AND INCREASE THE POTENTIAL FOR INJURY TO THE OCCUPANT OF THE SEAT.
Remedy: DEALERS WILL REMOVE THE SEAT LATCH RELEASE HANDLE AND INSTALL A BLACK PLASTIC CAP OVER THE EXPOSED METAL STUD TO ELIMINATE THE SIDE IMPACT SAFETY CONCERN FREE OF CHARGE. THE RECALL BEGAN ON APRIL 5, 2005. OWNERS MAY CONTACT SATURN AT 1-800-972-8876, CHEVROLET AT 1-800-630-2438, AND PONTIAC AT 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA07019 · Power Sliding Door
Opened Dec 11, 2007 · Closed Feb 23, 2009
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
PE07044 · Power Sliding Door Opening
Opened Aug 16, 2007 · Closed Dec 11, 2007
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
PE05063 · Electrical Harness Damage
Opened Nov 29, 2005 · Closed Mar 6, 2006
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Electrical System:wiring:front Underhood
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Electrical System:wiring:fuses And Circuit Breakers
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
2005 Chevrolet Uplander Problems, Complaints & Recalls | Skip That Year
Illustration