NHTSA owner reports · September 18, 2026 snapshot.
Suspension complaints
13 reportsClear category filter250,000 miles · Mar 5, 2019
StructureSuspension
WHILE DRIVING DOWN I-75 IN MICHIGAN DOING ~75MPH, I FEEL A SHARP TUG THEN A SWAY. WE TOOK THE VEHICLE HOME AND INSPECTED IT. THE WELDS ON THE BODY TO THE ATTACHING POINT OF THE REAR AXLE HAD BROKEN AND THE REAR END OF THE VEHICLE WAS TRACKING SIDEWAYS. THANK GOD NOTHING BAD HAPPENED, WE HAD ALL SIX OF OUR KIDS WITH US WHEN IT WE…
Read full complaint
WHILE DRIVING DOWN I-75 IN MICHIGAN DOING ~75MPH, I FEEL A SHARP TUG THEN A SWAY. WE TOOK THE VEHICLE HOME AND INSPECTED IT. THE WELDS ON THE BODY TO THE ATTACHING POINT OF THE REAR AXLE HAD BROKEN AND THE REAR END OF THE VEHICLE WAS TRACKING SIDEWAYS. THANK GOD NOTHING BAD HAPPENED, WE HAD ALL SIX OF OUR KIDS WITH US WHEN IT WENT OUT AT 75MPH.
NHTSA ODI #11184428
198,000 miles · Mar 20, 2018
StructureSuspension
2005 CHEVY UPLANDER LT. UNDERCARRIAGE RUSTED ON BACK PASSENGER SIDE WITHIN 9 MONTHS AFTER PURCHASE, CAUSING SEPARATION OF THE REAR PASSENGER WHEEL FROM THE BODY OF VEHICLE. WHEN DRIVING, YOU CAN HEAR/FEEL CLUNKING/SQUEAKING NOISE WHICH SOUNDS LIKE THE TIRE IS GOING TO COME COMPLETELY OFF THE CAR. AREA AFFECTED CANNOT BE REPLACE…
Read full complaint
2005 CHEVY UPLANDER LT. UNDERCARRIAGE RUSTED ON BACK PASSENGER SIDE WITHIN 9 MONTHS AFTER PURCHASE, CAUSING SEPARATION OF THE REAR PASSENGER WHEEL FROM THE BODY OF VEHICLE. WHEN DRIVING, YOU CAN HEAR/FEEL CLUNKING/SQUEAKING NOISE WHICH SOUNDS LIKE THE TIRE IS GOING TO COME COMPLETELY OFF THE CAR. AREA AFFECTED CANNOT BE REPLACED NOR WELDED AS THIS CAN BE UNSAFE TO DRIVE. I HAVE IMAGES THAT CAN BE SENT VIA EMAIL.
NHTSA ODI #11080389
113,000 miles · Jun 22, 2017
Suspension
TAMARA RECALL AS I WAS DRIVING WITH MY WHOLE FAMILY IN OUR VAN, THE LEFT TRAILING ARE BROKE OFF. THEREFORE, MY AXLE STARTED TO FALL OFF. I COULD NOT STOP US. MY BREAKS DIDN'T WORK, SINCE IT SNAPPED MY BREAK LINE TOO. I WAS ONLY GOING 25MPH. ONCE WE CAME TO A STOP, WE GOT OUT, AND MY LEFT BACK TIRE WAS UNDER MY BUMPER.
NHTSA ODI #11000594
100,000 miles · Apr 7, 2016
Suspension
TL* THE CONTACT OWNS A 2005 CHEVROLET UPLANDER. WHILE DRIVING 45 MPH, THE CONTACT NOTICED AN ABNORMAL NOISE COMING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TRAILING ARM OR THE TRAILING ARM BUSHING NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFA…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET UPLANDER. WHILE DRIVING 45 MPH, THE CONTACT NOTICED AN ABNORMAL NOISE COMING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TRAILING ARM OR THE TRAILING ARM BUSHING NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 10V110000 (SUSPENSION). THE FAILURE MILEAGE WAS 100,000. UPDATED 05/26/16*LJ
NHTSA ODI #10854101
99,261 miles · Jan 20, 2012
SteeringSuspensionCrash
ON DECEMBER 15, 2011, A 2005 CHEVROLET UPLANDER WAS DRIVEN ON A SIDE STREET AT APPROXIMATELY 25 MPH. WITHOUT WARNING, THE WHEEL JERKED OUT OF THE DRIVER'S HAND AND THE VEHICLE STRUCK A PARKED VEHICLE AND CAME TO A STOP. NO ONE WAS INJURED. A FORENSIC ENGINEERING INVESTIGATION REVEALED THAT THE FAILURE OF THE RIGHT STEERING KN…
Read full complaint
ON DECEMBER 15, 2011, A 2005 CHEVROLET UPLANDER WAS DRIVEN ON A SIDE STREET AT APPROXIMATELY 25 MPH. WITHOUT WARNING, THE WHEEL JERKED OUT OF THE DRIVER'S HAND AND THE VEHICLE STRUCK A PARKED VEHICLE AND CAME TO A STOP. NO ONE WAS INJURED. A FORENSIC ENGINEERING INVESTIGATION REVEALED THAT THE FAILURE OF THE RIGHT STEERING KNUCKLE WAS THE SOLE CAUSE OF THIS INCIDENT. THE PART NUMBER ON THE FRONT OF THE BOTTOM PORTION OF THE STEERING KNUCKLE IS "INTERMEDIATE 0472 98 U/W R". THE CASTING NUMBER ON THE REAR OF THE BOTTOM PORTION OF THE STEERING KNUCKLE IS "0800 561 220". NHTSA CAMPAIGN ID NUMBER: 09E005000 REFERS TO FAILURE OF STEERING KNUCKLES MANUFACTURED BY DORMAN PRODUCTS, INC. THIS RECALL STATES THAT, "A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA." THE HUB AREA IS ALSO THE AREA WHERE THE INTERMEDIATE STEERING KNUCKLE FRACTURED IN THIS INCIDENT. *TR
NHTSA ODI #10444678
70,200 miles · Feb 15, 2010
Service Brakes, HydraulicSuspension
THE ABS LIGHT ON THE VEHICLE CAME ON WHILE DRIVING. THE LIGHT STARTED GOING ON AND OFF REGULARLY SO THE VEHICLE WAS BROUGHT IN TO THE DEALER FOR SERVICE. THE DEALER SAID THE FRONT WHEEL HUB BEARINGS NEEDED TO BE REPLACED BUT THESE WERE NOT COVERED UNDER WARRANTY. BOTH FRONT WHEEL HUB BEARINGS WERE REPLACED AT OUR OWN EXPENSE BUT…
Read full complaint
THE ABS LIGHT ON THE VEHICLE CAME ON WHILE DRIVING. THE LIGHT STARTED GOING ON AND OFF REGULARLY SO THE VEHICLE WAS BROUGHT IN TO THE DEALER FOR SERVICE. THE DEALER SAID THE FRONT WHEEL HUB BEARINGS NEEDED TO BE REPLACED BUT THESE WERE NOT COVERED UNDER WARRANTY. BOTH FRONT WHEEL HUB BEARINGS WERE REPLACED AT OUR OWN EXPENSE BUT THEN THE LIGHT STARTED GOING ON AND OFF AGAIN. THE VEHICLE WAS TAKEN BACK TO THE DEALER AND THIS TIME THEY SAID THE COMPUTER & WIRING SYSTEM WAS BAD AND NEEDED TO BE REPLACED. THE DEALER ALSO INDICATED THAT THIS HAD BEEN A RECURRING PROBLEM ON THIS MODEL BUT NOT ENOUGH CONSUMERS WERE AFFECTED TO GENERATE A RECALL SO WE WOULD HAVE TO PAY FOR THIS REPAIR OURSELVES AS WELL. THE DEALER HAS INSTRUCTED US THAT IT IS DANGEROUS TO OPERATE THE VEHICLE UNTIL THE REPAIRS ARE MADE. *TR
NHTSA ODI #10310477
49,043 miles · Oct 23, 2007
Electrical SystemLatches/locks/linkagesService Brakes, Hydraulic
TL*THE CONTACT OWNS A 2005 CHEVROLET UPLANDER. THE SLIDING DOOR ON THE REAR DRIVER SIDE WOULD NOT STAY LATCHED. THE CONTACT CALLED THE DEALER AND MANUFACTURER AND THEY STATED THAT SHE WAS RESPONSIBLE FOR HAVING THE DOOR REPAIRED. THE VEHICLE HAS BEEN IN THE SHOP SIX TIMES NOW FOR THE LATCH FAILURE AND THE DOOR OPENING ON ITS …
Read full complaint
TL*THE CONTACT OWNS A 2005 CHEVROLET UPLANDER. THE SLIDING DOOR ON THE REAR DRIVER SIDE WOULD NOT STAY LATCHED. THE CONTACT CALLED THE DEALER AND MANUFACTURER AND THEY STATED THAT SHE WAS RESPONSIBLE FOR HAVING THE DOOR REPAIRED. THE VEHICLE HAS BEEN IN THE SHOP SIX TIMES NOW FOR THE LATCH FAILURE AND THE DOOR OPENING ON ITS OWN. EACH TIME THE VEHICLE WAS RETRIEVED FROM THE DEALER, THEY STATED THAT IT WAS REPAIRED WHEN IT WAS NOT. WHEN THE BUTTON WAS PRESSED TO CLOSE THE DOOR, IT WOULD BEGIN TO SHUT AND AN ALARM WOULD SOUND; HOWEVER, IT WOULD NOT SHUT AND FLEW OPEN WHILE DRIVING. THE INSTRUMENT PANEL DOES NOT INDICATE THAT THE DOOR IS AJAR. THE REAR PASSENGER SIDE DOOR IS BEGINNING TO EXPERIENCE THE SAME FAILURE. NEITHER THE WEATHER NOR THE SPEED WERE FACTORS. THE CURRENT MILEAGE WAS 51,800 AND FAILURE MILEAGE WAS 49,043. THE DEALER STATED THE VEHICLE WOULD NOT START, CHECK BRAKE CONDITION, AND HUMMING NOISE LEFT FRONT HUB AREA. UPDATED 12/12/07 *TR
NHTSA ODI #10206612
11,000 miles · Aug 25, 2007
Electrical SystemFuel System, GasolineLatches/locks/linkagesInjury
THE CAR INTERMITTENTLY TRIES TO START THE CRANK KEEPS TURNING BUT DOES NOT START. AS WELL AS I WAS TRAVELING ON FREEWAY WITH A BIG RIG ON THE SIDE OF ME AND THE CAR STALLED AND STEERING LOCKED. THANK GOD I MANAGED TO GLIDE OVER TO THE EXIT LANE. I WAS TERRIFIED AS WAS MY PASSENGER. WHEN I LOOKED AT THE GAUGES I NOTICED I WAS OUT…
Read full complaint
THE CAR INTERMITTENTLY TRIES TO START THE CRANK KEEPS TURNING BUT DOES NOT START. AS WELL AS I WAS TRAVELING ON FREEWAY WITH A BIG RIG ON THE SIDE OF ME AND THE CAR STALLED AND STEERING LOCKED. THANK GOD I MANAGED TO GLIDE OVER TO THE EXIT LANE. I WAS TERRIFIED AS WAS MY PASSENGER. WHEN I LOOKED AT THE GAUGES I NOTICED I WAS OUT OF GAS, BUT I HAD JUST PUT IN $20 . CHEVY SENT OUT TOW TRUCK TO GIVE ME GAS, BUT CAR STILL WOULD NOT START. FINALLY HOURS LATER CAR WAS TAKEN TO CHEVY. WHEN UPLANDER WAS FINISHED THEY SAID IT WAS ELECTRICAL SHORT DUE TO WATER IN LINES. WEATHER WAS GREAT NO RAIN OR PUDDLES ANYWHERE. UPLANDER ALMOST STALLED ON ANOTHER NIGHT LIGHTS DIMMED AND TIRES STOPPED ,BUT THEN IT WORKED FINE. STRANGE VERY!!! DRIVER SIDE SLIDING DOOR OPENS OR SHUTS WHEN IT WANTS. MY DAUGHTER WAS IN HER CAR SEAT AND I PUSHED BUTTON TO CLOSE DOOR SHE PUT HER FOOT UP TOWARDS DOOR AND IT SHUT AND LOCKED. LUCKILY HER TENNIS SHOES WERE A LITTLE BIG SO ONLY MINOR BRUISING OCCURRED. HOWEVER MY DAUGHTER IS TERRIFIED OF CAR. ALSO I HAVE ALREADY PUT 6 NEW TIRES ON CAR BECAUSE THEY WERE BALD AT 13,000 MILES FIRST TIME. TIRES IN FRONT ARE BALD AGAIN. UPLANDER IS NOT STABLE TO DRIVE ON HIGHWAY. *TR
NHTSA ODI #10200759
12 miles · May 21, 2007
Electrical SystemStructureSuspension
TL*THE CONTACT OWNS A 2005 CHEVROLET UPLANDER. WHILE ATTEMPTING TO CLOSE THE PASSENGER SIDE DOOR, THE ALERT BELL BEGAN TO RING AND THE DOOR FAILED TO SHUT. THE CONTACT HAD TO PUSH THE BUTTON TO RELEASE THE DOOR. ONCE THE DOOR OPENED, IT WAS FINALLY ABLE TO BE CLOSED. THE VEHICLE'S HORN DOES NOT WORK. IN ADDITION, THE STARTE…
Read full complaint
TL*THE CONTACT OWNS A 2005 CHEVROLET UPLANDER. WHILE ATTEMPTING TO CLOSE THE PASSENGER SIDE DOOR, THE ALERT BELL BEGAN TO RING AND THE DOOR FAILED TO SHUT. THE CONTACT HAD TO PUSH THE BUTTON TO RELEASE THE DOOR. ONCE THE DOOR OPENED, IT WAS FINALLY ABLE TO BE CLOSED. THE VEHICLE'S HORN DOES NOT WORK. IN ADDITION, THE STARTER IS BAD. WHEN THE CONTACT TURNS THE IGNITION, THE VEHICLE FAILS TO START. SHE MUST DEPRESS THE ACCELERATOR PEDAL AFTER TURNING THE IGNITION IN ORDER FOR IT TO START. THE RIGHT WINDOW REMAINS OPEN WHEN ATTEMPTING TO CLOSE IT WITH THE OVERHEAD BUTTON. THE DEALER HAS REPAIRED THE VEHICLE, BUT THE FAILURE PERSISTS. WHEN MAKING A LEFT TURN, THE CONTACT HEARS A NOISE COMING FROM THE SUSPENSION. THE ENGINE SIZE WAS UNKNOWN. THE CURRENT MILEAGE IS 18,000 AND FAILURE MILEAGE WAS 12. THE CONSUMER STATED WATER NOW LEAKS INTO THE VEHICLE WHEN IT RAINS AND VEHICLE IS VERY WET BEHIND 3RD ROW. UPDATED 12/12/07 *TR
NHTSA ODI #10191384
11,500 miles · Apr 6, 2007
Suspension
TL*THE CONTACT OWNS A 2005 CHEVROLET UPLANDER. WHILE DRIVING THE VEHICLE AT VARIOUS SPEEDS RANGING FROM 45 AND HIGHER THERE WAS A LOUD RATTLING NOISE. THE DEALER STATED THAT THERE WAS A MANUFACTURER'S DEFECT ON THE FRONT SUSPENSION. THE DEALER LUBRICATED THE FRONT SUSPENSION , AND STATED THAT DUE TO A MANUFACTURER'S INVESTI…
Read full complaint
TL*THE CONTACT OWNS A 2005 CHEVROLET UPLANDER. WHILE DRIVING THE VEHICLE AT VARIOUS SPEEDS RANGING FROM 45 AND HIGHER THERE WAS A LOUD RATTLING NOISE. THE DEALER STATED THAT THERE WAS A MANUFACTURER'S DEFECT ON THE FRONT SUSPENSION. THE DEALER LUBRICATED THE FRONT SUSPENSION , AND STATED THAT DUE TO A MANUFACTURER'S INVESTIGATION THERE WAS NOTHING ELSE THEY COULD DO . THE CURRENT AND FAILURE MILEAGE WERE 11500. *AK
NHTSA ODI #10187217
Official recalls
3Mar 19, 2010
THE BRAUN CORPORATION HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2005-2008 GENERAL MOTORS MOBILITY CONVERSION, HANDICAPPED ACCESSIBLE LOW FLOOR MINIVANS. DURING CONVERSION, THE DRIVER OR PASSENGER SIDE TRAILING ARM MODIFICATION MAY NOT HAVE BEEN ADEQUATELY WELDED.
Consequence & remedy
Consequence: A SQUEAKING OR CLUNKING NOISE MAY DEVELOP. THE TRAILING ARM BUSHINGS MAY PREMATURELY WEAR AND THE TRAILING ARM MAY FRACTURE OR SEPARATE, ALLOWING THE REAR AXLE TO BECOME PARTIALLY SEPARATED FROM THE CHASSIS INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND WILL HAVE A SUPPLY OF RETROFIT PARTS AVAILABLE TO REMEDY THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 4, 2010. OWNERS MAY CONTACT BRAUN AT 1-800-488-0359.
Jun 20, 2005
CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' TO MEET THE STANDARD, THE VEHICLE MUST NOT MOVE FOR FIVE MINUTES WHEN STOPPED ON A STEEP HILL WITH THE PARKING BRAKE APPLIED AND THE VEHICLE IN NEUTRAL (N). SOME OF THESE VEHICLES FAILED THIS TEST.
Consequence & remedy
Consequence: WHEN THE PARKING BRAKE IS RELEASED, THE DRIVER MAY NOTICE UNINTENDED BRAKING WHEN ACCELERATING, DECELERATING, OR COASTING, AND A NOISE COMING FROM THE REAR OF THE VEHICLE. UNINTENDED VEHICLE MOVEMENT COULD OCCUR INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT FOR PARKING BRAKE LEVER SLIPPAGE AT EACH REAR BRAKE CALIPER AND REPLACE THE CALIPER IF LEVER SLIPPAGE IS IDENTIFIED. THE RECALL BEGAN ON NOVEMBER 14, 2005. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR SATURN AT 1-800-972-8876.
Feb 18, 2005
ON CERTAIN MINIVANS, THE OUTBOARD RELEASE HANDLE ON THE IMPACT-SIDE SECOND-ROW BUCKET SEAT MAY BE ACTUATED AND THE REAR LATCHES MAY UNLATCH EARLY IN A SIDE IMPACT CRASH. THIS WAS DISCOVERED IN A SIDE IMPACT TEST RUN BY GM, UNDER CONDITIONS SIMILAR TO NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) SIDE IMPACT TEST.
Consequence & remedy
Consequence: IF THE REAR LATCHES OF THE SEAT RELEASE EARLY IN A SEVERE SIDE IMPACT, THE FRONT OUTBOARD LATCH MAY DISENGAGE AND INCREASE THE POTENTIAL FOR INJURY TO THE OCCUPANT OF THE SEAT.
Remedy: DEALERS WILL REMOVE THE SEAT LATCH RELEASE HANDLE AND INSTALL A BLACK PLASTIC CAP OVER THE EXPOSED METAL STUD TO ELIMINATE THE SIDE IMPACT SAFETY CONCERN FREE OF CHARGE. THE RECALL BEGAN ON APRIL 5, 2005. OWNERS MAY CONTACT SATURN AT 1-800-972-8876, CHEVROLET AT 1-800-630-2438, AND PONTIAC AT 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA07019 · Power Sliding Door
Opened Dec 11, 2007 · Closed Feb 23, 2009
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
PE07044 · Power Sliding Door Opening
Opened Aug 16, 2007 · Closed Dec 11, 2007
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
PE05063 · Electrical Harness Damage
Opened Nov 29, 2005 · Closed Mar 6, 2006
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Electrical System:wiring:front Underhood
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Electrical System:wiring:fuses And Circuit Breakers
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Illustration