NHTSA owner reports · September 18, 2026 snapshot.
Structure complaints
45 reportsClear category filter16,500 miles · Nov 14, 2007
Structure
I HAVE A 2005 CHEVY UPLANDER. BOTH REAR SLIDING DOORS LIKE TO REOPEN BY THEMSELVES. WE BOUGHT THE VAN USED IN FEBRUARY 2006. THE FIRST TIME IT STARTED HAPPENING WAS MARCH OF 2006. WE FINALLY TOOK THE VAN IN JUNE OF 2006 TO SEE WHAT WAS GOING ON. THE DEALERSHIP COULD NOT SEEM TO FIGURE IT OUT. WE HAD IT IN A FEW MORE TIMES AND TH…
Read full complaint
I HAVE A 2005 CHEVY UPLANDER. BOTH REAR SLIDING DOORS LIKE TO REOPEN BY THEMSELVES. WE BOUGHT THE VAN USED IN FEBRUARY 2006. THE FIRST TIME IT STARTED HAPPENING WAS MARCH OF 2006. WE FINALLY TOOK THE VAN IN JUNE OF 2006 TO SEE WHAT WAS GOING ON. THE DEALERSHIP COULD NOT SEEM TO FIGURE IT OUT. WE HAD IT IN A FEW MORE TIMES AND THEY FINALLY TOLD US THAT THE DRIVER SIDE SLIDING DOOR LATCH AND LOCK NEEDED TO BE REPLACED. THAT DID NOT FIX THE PROBLEM. WE TOOK IT IN A COUPLE OF MORE TIMES AND STILL THEY COULD NOT FIND ANYTHING. I CONTACTED GM AND WAS TOLD TO TAKE IT BACK TO THE DEALERSHIP AGAIN TO SEE IF THE SEALS WERE GETTING IN THE WAY. AGAIN, NOTHING. GM THEN TOLD ME TO TAKE IT TO ANOTHER DEALERSHIP FOR A SECOND OPINION. THAT DEALERSHIP COULD NOT FIGURE IT OUT. GM THEM TOLD ME THAT THEY COULDN'T DO ANYTHING FOR ME BECAUSE THE DEALERSHIPS COULD NOT DUPLICATE THE PROBLEM. NOW WHAT? *TR
NHTSA ODI #10208880
700 miles · Aug 20, 2007
Structure
OUR 2005 CHEVROLET UPLANDER HAS SERIOUS ON GOING PROBLEMS WITH THE POWER PASSENGER SLIDING DOOR OPENS WHILE THE VEHICLE IS BEING DRIVEN. THE FAILURE OCCURS WHILE DRIVING UNDER NORMAL CONDITIONS BETWEEN 5 AND 35 MPH. THE PASSENGER DOOR OFTEN OPENS BY ITSELF AND WHEN THE BUTTON IS PRESSED TO CLOSE IT, THE DOOR BEGINS TO CLOSE AND …
Read full complaint
OUR 2005 CHEVROLET UPLANDER HAS SERIOUS ON GOING PROBLEMS WITH THE POWER PASSENGER SLIDING DOOR OPENS WHILE THE VEHICLE IS BEING DRIVEN. THE FAILURE OCCURS WHILE DRIVING UNDER NORMAL CONDITIONS BETWEEN 5 AND 35 MPH. THE PASSENGER DOOR OFTEN OPENS BY ITSELF AND WHEN THE BUTTON IS PRESSED TO CLOSE IT, THE DOOR BEGINS TO CLOSE AND THEN REOPENS. THE VEHICLE HAS BEEN TO THE DEALER FOUR TIMES WHILE IT WAS STILL UNDER WARRANTY, BUT THE FAILURE CONTINUES TO OCCUR. GM KNOWS ABOUT THE PROBLEM BECAUSE THE LAST TIME OUR UPLANDER WAS IN WE WERE TOLD THAT THERE IS INTERNAL SERVICE BULLETINS ON RECORD: SERVICE BULLETIN:3278 NHTSA ITEM NUMBER:10011754 SERVICE BULLETIN:3532 NHTSA ITEM NUMBER:10016718 SERVICE BULLETIN:050864013 NHTSA ITEM NUMBER:10017349 SERVICE BULLETIN:3798 NHTSA ITEM NUMBER:10021078 SERVICE BULLETIN:070864007 NHTSA ITEM NUMBER:10021456 THE CURRENT MILEAGE IS 42,000 AND DOOR PROBLEMS STARTED AT 700 MILE WITH A COMPLETE REAR DRIVER SIDE POWER SLIDING DOOR FAILURE RESULTING IN THE DEALER COMPLETELY REBUILDING THE ASSEMBLE CABLES, DRIVE MOTOR AND SENSORS. *TR
NHTSA ODI #10200131
40,000 miles · Aug 19, 2007
Structure
BOTH, LEFT AND RIGHT, POWER SLIDING DOORS WILL NOT SHUT PROPERLY. YOU HAVE TO OPEN AND CLOSE THE DOORS SEVERAL TIME TO MAKE THEM SHUT PROPERLY. THE LEFT POWER SLIDING DOOR WILL SHUT THEN THE ALARM BELL WILL SOUND UNTIL YOU STOP THE VEHICLE THEN OPEN AND SHUT THE DOOR. THE RIGHT POWER SLIDING DOOR HAS CAME OPEN WHILE DRIVING, …
Read full complaint
BOTH, LEFT AND RIGHT, POWER SLIDING DOORS WILL NOT SHUT PROPERLY. YOU HAVE TO OPEN AND CLOSE THE DOORS SEVERAL TIME TO MAKE THEM SHUT PROPERLY. THE LEFT POWER SLIDING DOOR WILL SHUT THEN THE ALARM BELL WILL SOUND UNTIL YOU STOP THE VEHICLE THEN OPEN AND SHUT THE DOOR. THE RIGHT POWER SLIDING DOOR HAS CAME OPEN WHILE DRIVING, AT SLOW SPEEDS. THE RIGHT POWER SLIDING DOOR REAR LATCH WILL NOT LATCH PROPERLY 95% OF THE TIME. THE VAN HAS BEEN TO THE DEALERSHIP FOR SERVICE ON THE DOORS TWICE SO FAR AND WILL BE RETURNING AUG 20TH FOR MORE SERVICE ON THE DOORS. *TR
NHTSA ODI #10200039
18,000 miles · Aug 8, 2007
Structure
THE RIGHT POWER SLIDING DOOR HAS BEEN IN FOR SERVICE ON NUMEROUS OCCASIONS AT THE DEALERSHIP. IT CONTINUES TO MALFUNCTION IN OPENING AND CLOSING. CURRENTLY, THE DOOR HAS OPENED WHILE THE VAN IS IN OPERATION AND ON OTHER OCCASIONS, THE ALARM BELL HAS STARTED TO RING WHILE THE DOOR WAS CLOSED AND THE VEHICLE WAS IN OPERATION, NO…
Read full complaint
THE RIGHT POWER SLIDING DOOR HAS BEEN IN FOR SERVICE ON NUMEROUS OCCASIONS AT THE DEALERSHIP. IT CONTINUES TO MALFUNCTION IN OPENING AND CLOSING. CURRENTLY, THE DOOR HAS OPENED WHILE THE VAN IS IN OPERATION AND ON OTHER OCCASIONS, THE ALARM BELL HAS STARTED TO RING WHILE THE DOOR WAS CLOSED AND THE VEHICLE WAS IN OPERATION, NOT STOPPING UNTIL THE VEHICLE WAS TURNED OFF. *TR
NHTSA ODI #10198834
6,000 miles · Jul 30, 2007
Structure
TL*THE CONTACT OWNS A 2005 CHEVROLET UPLANDER. THE CONTACT STATED THAT THE AUTOMATIC PASSENGER SIDE SLIDING DOORS FAIL TO REMAIN CLOSED. WHILE DRIVING OVER A BUMP ON TWO OCCASIONS, THE DOOR OPENED ON ITS OWN. HE STATED THAT TWO MONTHS AFTER PURCHASING THE VEHICLE, THE DOOR WOULD ONLY REMAIN CLOSED WHEN HE WOULD QUICKLY SHUT A…
Read full complaint
TL*THE CONTACT OWNS A 2005 CHEVROLET UPLANDER. THE CONTACT STATED THAT THE AUTOMATIC PASSENGER SIDE SLIDING DOORS FAIL TO REMAIN CLOSED. WHILE DRIVING OVER A BUMP ON TWO OCCASIONS, THE DOOR OPENED ON ITS OWN. HE STATED THAT TWO MONTHS AFTER PURCHASING THE VEHICLE, THE DOOR WOULD ONLY REMAIN CLOSED WHEN HE WOULD QUICKLY SHUT AND LOCK IT WITH THE AUTOMATIC REMOTE. THE CONTACT RETURNED TO THE DEALER AND THEY REPAIRED THE FAILURE TEMPORARILY. HOWEVER, THE FAILURE HAS RECURRED. THE PURCHASE DATE AND SPEED WERE UNKNOWN. THE CURRENT MILEAGE WAS 65,450 AND FAILURE MILEAGE WAS 6,000. UPDATED 02-01-08 *BF UPDATED 02/01/08 *TR
NHTSA ODI #10197800
2,000 miles · Jul 16, 2007
Structure
TL*THE CONTACT OWNS A 2005 CHEVROLET UPLANDER. WHEN THE CONTACT CLOSED THE ELECTRONIC DOOR USING THE REMOTE, HE HEARD A BEEPING SOUND AND THE DOOR RE-OPENED. THE DEALER WAS UNABLE TO DIAGNOSE THE CAUSE OF FAILURE. THE DEALER SENT THE VEHICLE TO A BODY SHOP AND THEY ALIGNED THE DOOR. APPROXIMATELY THREE MONTHS LATER, THE FAIL…
Read full complaint
TL*THE CONTACT OWNS A 2005 CHEVROLET UPLANDER. WHEN THE CONTACT CLOSED THE ELECTRONIC DOOR USING THE REMOTE, HE HEARD A BEEPING SOUND AND THE DOOR RE-OPENED. THE DEALER WAS UNABLE TO DIAGNOSE THE CAUSE OF FAILURE. THE DEALER SENT THE VEHICLE TO A BODY SHOP AND THEY ALIGNED THE DOOR. APPROXIMATELY THREE MONTHS LATER, THE FAILURE RECURRED. THE DEALER ALIGNED THE DOOR, HOWEVER, THE PROBLEM RECURRED APPROXIMATELY TWO MONTHS LATER. THE CONTACT OPENED THE DOOR AND A BLACK CABLE POPPED FROM THE INSIDE OF THE DOOR TRACK, MAKING IT IMPOSSIBLE TO CLOSE THE DOOR. THE DEALER REPLACED THE PULLEY CABLE AND THE DOOR MOTOR. THE CURRENT MILEAGE IS 35,981 AND FAILURE MILEAGE WAS 2,000.
NHTSA ODI #10196449
12 miles · May 21, 2007
Electrical SystemStructureSuspension
TL*THE CONTACT OWNS A 2005 CHEVROLET UPLANDER. WHILE ATTEMPTING TO CLOSE THE PASSENGER SIDE DOOR, THE ALERT BELL BEGAN TO RING AND THE DOOR FAILED TO SHUT. THE CONTACT HAD TO PUSH THE BUTTON TO RELEASE THE DOOR. ONCE THE DOOR OPENED, IT WAS FINALLY ABLE TO BE CLOSED. THE VEHICLE'S HORN DOES NOT WORK. IN ADDITION, THE STARTE…
Read full complaint
TL*THE CONTACT OWNS A 2005 CHEVROLET UPLANDER. WHILE ATTEMPTING TO CLOSE THE PASSENGER SIDE DOOR, THE ALERT BELL BEGAN TO RING AND THE DOOR FAILED TO SHUT. THE CONTACT HAD TO PUSH THE BUTTON TO RELEASE THE DOOR. ONCE THE DOOR OPENED, IT WAS FINALLY ABLE TO BE CLOSED. THE VEHICLE'S HORN DOES NOT WORK. IN ADDITION, THE STARTER IS BAD. WHEN THE CONTACT TURNS THE IGNITION, THE VEHICLE FAILS TO START. SHE MUST DEPRESS THE ACCELERATOR PEDAL AFTER TURNING THE IGNITION IN ORDER FOR IT TO START. THE RIGHT WINDOW REMAINS OPEN WHEN ATTEMPTING TO CLOSE IT WITH THE OVERHEAD BUTTON. THE DEALER HAS REPAIRED THE VEHICLE, BUT THE FAILURE PERSISTS. WHEN MAKING A LEFT TURN, THE CONTACT HEARS A NOISE COMING FROM THE SUSPENSION. THE ENGINE SIZE WAS UNKNOWN. THE CURRENT MILEAGE IS 18,000 AND FAILURE MILEAGE WAS 12. THE CONSUMER STATED WATER NOW LEAKS INTO THE VEHICLE WHEN IT RAINS AND VEHICLE IS VERY WET BEHIND 3RD ROW. UPDATED 12/12/07 *TR
NHTSA ODI #10191384
21,000 miles · Apr 18, 2007
Structure
AUTOMATIC SLIDING SIDE DOORS FAIL TO STOP IF BLOCKED. DURING THE CLOSING OF SIDE AUTOMATIC SIDE DOORS, THEY HAVE FAILED TO STOP WHEN BLOCKED, ALL TIMES THIS HAS HAPPENED HAVE BEEN WHEN MYSELF OR WIFE WAS IN THE PROCESS OF PUTTING CHILD IN VEHICLE OR REMOVING. WE HAVE BEEN ABLE TO MOVE OUT OF THE WAY THUS AVOIDING ANY MAJOR INJ…
Read full complaint
AUTOMATIC SLIDING SIDE DOORS FAIL TO STOP IF BLOCKED. DURING THE CLOSING OF SIDE AUTOMATIC SIDE DOORS, THEY HAVE FAILED TO STOP WHEN BLOCKED, ALL TIMES THIS HAS HAPPENED HAVE BEEN WHEN MYSELF OR WIFE WAS IN THE PROCESS OF PUTTING CHILD IN VEHICLE OR REMOVING. WE HAVE BEEN ABLE TO MOVE OUT OF THE WAY THUS AVOIDING ANY MAJOR INJURIES (WIFE RECEIVED A BRUISE. *AK.
NHTSA ODI #10188279
42,650 miles · Dec 26, 2006
Structure
I HAVE HAD THE CHEVROLET UPLANDER IN FOR REPAIR ON A REAR PASSENGER DOOR THAT KEEPS MALFUNCTIONING. THEY HAVE REPAIRED IT ON SEVERAL OCCASIONS BUT IT IS KNOW OUT OF MANUFACTURING WARRANTY. THE DOOR HAS BEEN REPAIRED TO THE BEST OF GMAC ABILITY THEY CAN NOT FIGURE OUT THE PROBLEM BUT THE DOOR NOW WILL FALL SHUT WHEN ON A DOWNHI…
Read full complaint
I HAVE HAD THE CHEVROLET UPLANDER IN FOR REPAIR ON A REAR PASSENGER DOOR THAT KEEPS MALFUNCTIONING. THEY HAVE REPAIRED IT ON SEVERAL OCCASIONS BUT IT IS KNOW OUT OF MANUFACTURING WARRANTY. THE DOOR HAS BEEN REPAIRED TO THE BEST OF GMAC ABILITY THEY CAN NOT FIGURE OUT THE PROBLEM BUT THE DOOR NOW WILL FALL SHUT WHEN ON A DOWNHILL INCLINE REGARDLESS IF ANYONE IS IN THE DOOR. THEY ARE SUPPOSE TO BE CHILD SAFETY TO KEEP THE DOOR FROM CLOSING ON A CHILD BUT THE DOOR WILL NOT STAY OPEN WHEN PARKED A DOWNHILL GRADE. I AM REALLY SCARED THE DOOR COULD CLOSE ON MY CHILDREN BUT THEY TELL ME THAT THEY HAVE REPAIRED IT AND DON'T KNOW WHAT IS CAUSING THE DIFFICULTY IN THE DOOR. I WAS AT A CHRISTMAS PARTY WHEN THE DOOR MALFUNCTION AND FELL SHUT ON ME. I AM A FOSTER PARENT IN THE STATE OF KENTUCKY AND PURCHASED THIS VAN SO I COULD HAVE RELIABLE TRANSPORTATION FOR THESE CHILDREN AND NOW I'M NOT SURE WHEN I CHILD COULD GET CAUGHT IN THE DOOR. *NM
NHTSA ODI #10177017
13,000 miles · Oct 16, 2006
Structure
DT*: THE CONTACT STATED WHILE PARKED, THE PASSENGER SLIDING DOOR OPENED ON ITS' OWN. ON 10/14/06, THE SLIDING DOOR OPENED WHILE TRAVELING 25 MPH. NO INJURIES WERE SUSTAINED. THE SLIDING DOOR FUNCTIONS CORRECTLY SOMETIMES, BUT OPENS AUTOMATICALLY ON OCCASION. THIS HAD OCCURRED 32 TIMES. TWO DEALERS WERE CONTACTED, AND COULD …
Read full complaint
DT*: THE CONTACT STATED WHILE PARKED, THE PASSENGER SLIDING DOOR OPENED ON ITS' OWN. ON 10/14/06, THE SLIDING DOOR OPENED WHILE TRAVELING 25 MPH. NO INJURIES WERE SUSTAINED. THE SLIDING DOOR FUNCTIONS CORRECTLY SOMETIMES, BUT OPENS AUTOMATICALLY ON OCCASION. THIS HAD OCCURRED 32 TIMES. TWO DEALERS WERE CONTACTED, AND COULD NOT DUPLICATE THE PROBLEM. THE MANUFACTURER WAS CONTACTED, AND SUGGESTED THAT THE CONTACT SHOULD NOTIFY THE NHTSA.
NHTSA ODI #10170922
Official recalls
3Mar 19, 2010
THE BRAUN CORPORATION HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2005-2008 GENERAL MOTORS MOBILITY CONVERSION, HANDICAPPED ACCESSIBLE LOW FLOOR MINIVANS. DURING CONVERSION, THE DRIVER OR PASSENGER SIDE TRAILING ARM MODIFICATION MAY NOT HAVE BEEN ADEQUATELY WELDED.
Consequence & remedy
Consequence: A SQUEAKING OR CLUNKING NOISE MAY DEVELOP. THE TRAILING ARM BUSHINGS MAY PREMATURELY WEAR AND THE TRAILING ARM MAY FRACTURE OR SEPARATE, ALLOWING THE REAR AXLE TO BECOME PARTIALLY SEPARATED FROM THE CHASSIS INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND WILL HAVE A SUPPLY OF RETROFIT PARTS AVAILABLE TO REMEDY THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 4, 2010. OWNERS MAY CONTACT BRAUN AT 1-800-488-0359.
Jun 20, 2005
CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' TO MEET THE STANDARD, THE VEHICLE MUST NOT MOVE FOR FIVE MINUTES WHEN STOPPED ON A STEEP HILL WITH THE PARKING BRAKE APPLIED AND THE VEHICLE IN NEUTRAL (N). SOME OF THESE VEHICLES FAILED THIS TEST.
Consequence & remedy
Consequence: WHEN THE PARKING BRAKE IS RELEASED, THE DRIVER MAY NOTICE UNINTENDED BRAKING WHEN ACCELERATING, DECELERATING, OR COASTING, AND A NOISE COMING FROM THE REAR OF THE VEHICLE. UNINTENDED VEHICLE MOVEMENT COULD OCCUR INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT FOR PARKING BRAKE LEVER SLIPPAGE AT EACH REAR BRAKE CALIPER AND REPLACE THE CALIPER IF LEVER SLIPPAGE IS IDENTIFIED. THE RECALL BEGAN ON NOVEMBER 14, 2005. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR SATURN AT 1-800-972-8876.
Feb 18, 2005
ON CERTAIN MINIVANS, THE OUTBOARD RELEASE HANDLE ON THE IMPACT-SIDE SECOND-ROW BUCKET SEAT MAY BE ACTUATED AND THE REAR LATCHES MAY UNLATCH EARLY IN A SIDE IMPACT CRASH. THIS WAS DISCOVERED IN A SIDE IMPACT TEST RUN BY GM, UNDER CONDITIONS SIMILAR TO NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) SIDE IMPACT TEST.
Consequence & remedy
Consequence: IF THE REAR LATCHES OF THE SEAT RELEASE EARLY IN A SEVERE SIDE IMPACT, THE FRONT OUTBOARD LATCH MAY DISENGAGE AND INCREASE THE POTENTIAL FOR INJURY TO THE OCCUPANT OF THE SEAT.
Remedy: DEALERS WILL REMOVE THE SEAT LATCH RELEASE HANDLE AND INSTALL A BLACK PLASTIC CAP OVER THE EXPOSED METAL STUD TO ELIMINATE THE SIDE IMPACT SAFETY CONCERN FREE OF CHARGE. THE RECALL BEGAN ON APRIL 5, 2005. OWNERS MAY CONTACT SATURN AT 1-800-972-8876, CHEVROLET AT 1-800-630-2438, AND PONTIAC AT 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA07019 · Power Sliding Door
Opened Dec 11, 2007 · Closed Feb 23, 2009
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
PE07044 · Power Sliding Door Opening
Opened Aug 16, 2007 · Closed Dec 11, 2007
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
PE05063 · Electrical Harness Damage
Opened Nov 29, 2005 · Closed Mar 6, 2006
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Electrical System:wiring:front Underhood
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Electrical System:wiring:fuses And Circuit Breakers
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Illustration