WHILE DRIVING DOWN I-75 IN MICHIGAN DOING ~75MPH, I FEEL A SHARP TUG THEN A SWAY. WE TOOK THE VEHICLE HOME AND INSPECTED IT. THE WELDS ON THE BODY TO THE ATTACHING POINT OF THE REAR AXLE HAD BROKEN AND THE REAR END OF THE VEHICLE WAS TRACKING SIDEWAYS. THANK GOD NOTHING BAD HAPPENED, WE HAD ALL SIX OF OUR KIDS WITH US WHEN IT WE…
Read full complaint
WHILE DRIVING DOWN I-75 IN MICHIGAN DOING ~75MPH, I FEEL A SHARP TUG THEN A SWAY. WE TOOK THE VEHICLE HOME AND INSPECTED IT. THE WELDS ON THE BODY TO THE ATTACHING POINT OF THE REAR AXLE HAD BROKEN AND THE REAR END OF THE VEHICLE WAS TRACKING SIDEWAYS. THANK GOD NOTHING BAD HAPPENED, WE HAD ALL SIX OF OUR KIDS WITH US WHEN IT WENT OUT AT 75MPH.
NHTSA ODI #11184428
175,000 miles · Aug 6, 2018
Structure
THE BACK REAR HATCH WHEN I LIFTED DROPPED! I GOT MY HANDS UP FAST ENOUGH TO STOP IT AND WAS NOT INJURED THOUGH
NHTSA ODI #11118086
5 miles · May 11, 2018
Electronic Stability Control (esc)StructureWheelsInjury
THE CHASSIS HAS A SERIOUS RUST ISSUE AS I'VE NEVER SEEN BEFORE. THE RUST ISSUE IS ONE THAT YOU WOULD NOT EVEN SEE ON A 60 YEAR OLD CAR. IT CAUSED THE REAR WHEEL AND ALL OF ITS COMPONENTS TO BREAK FREE. I DO HAVE PICTURES (IT'S DARK OUT RIGHT AT THE MOMENT BUT I CAN BY MORNING) I HAVE BEEN TRYING TO FIND A SOLUTION FOR THIS FOR Q…
Read full complaint
THE CHASSIS HAS A SERIOUS RUST ISSUE AS I'VE NEVER SEEN BEFORE. THE RUST ISSUE IS ONE THAT YOU WOULD NOT EVEN SEE ON A 60 YEAR OLD CAR. IT CAUSED THE REAR WHEEL AND ALL OF ITS COMPONENTS TO BREAK FREE. I DO HAVE PICTURES (IT'S DARK OUT RIGHT AT THE MOMENT BUT I CAN BY MORNING) I HAVE BEEN TRYING TO FIND A SOLUTION FOR THIS FOR QUIET A WHILE NOW.
NHTSA ODI #11093431
198,000 miles · Mar 20, 2018
StructureSuspension
2005 CHEVY UPLANDER LT. UNDERCARRIAGE RUSTED ON BACK PASSENGER SIDE WITHIN 9 MONTHS AFTER PURCHASE, CAUSING SEPARATION OF THE REAR PASSENGER WHEEL FROM THE BODY OF VEHICLE. WHEN DRIVING, YOU CAN HEAR/FEEL CLUNKING/SQUEAKING NOISE WHICH SOUNDS LIKE THE TIRE IS GOING TO COME COMPLETELY OFF THE CAR. AREA AFFECTED CANNOT BE REPLACE…
Read full complaint
2005 CHEVY UPLANDER LT. UNDERCARRIAGE RUSTED ON BACK PASSENGER SIDE WITHIN 9 MONTHS AFTER PURCHASE, CAUSING SEPARATION OF THE REAR PASSENGER WHEEL FROM THE BODY OF VEHICLE. WHEN DRIVING, YOU CAN HEAR/FEEL CLUNKING/SQUEAKING NOISE WHICH SOUNDS LIKE THE TIRE IS GOING TO COME COMPLETELY OFF THE CAR. AREA AFFECTED CANNOT BE REPLACED NOR WELDED AS THIS CAN BE UNSAFE TO DRIVE. I HAVE IMAGES THAT CAN BE SENT VIA EMAIL.
NHTSA ODI #11080389
94,100 miles · Mar 24, 2015
Structure
AS I AM DRIVING THE ELECTRONIC SLIDING DOOR ON THE PASSENGER SIDE STARTS TO BUZZ LIKE IT DOES WHEN THE DOOR IS OPENING AND I CAN HEAR IT CLICKING AS IF IT IS GOING TO OPEN. THIS HAS HAPPENED SEVERAL TIMES. I AM AFRAID I WILL BE DRIVING DOWN THE HIGHWAY AND THE DOOR WILL OPEN. *TR
NHTSA ODI #10701291
Mileage unknown · Sep 3, 2014
Structure
TL* THE CONTACT OWNS A 2005 CHEVROLET UPLANDER. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 35 MPH, THE REAR DRIVER SIDE DOOR OPEN INDEPENDENTLY WHILE WITHOUT ANY WARNINGS. THE DOOR WOULD NOT CLOSE PROPERLY AND OPEN AND CLOSE INDEPENDENTLY. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECH…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET UPLANDER. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 35 MPH, THE REAR DRIVER SIDE DOOR OPEN INDEPENDENTLY WHILE WITHOUT ANY WARNINGS. THE DOOR WOULD NOT CLOSE PROPERLY AND OPEN AND CLOSE INDEPENDENTLY. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN WAS NOT ABLE TO DIAGNOSE THE PROBLEM. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS UNKNOWN. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10630404
45,000 miles · Jun 17, 2014
Electrical SystemStructure
THE SLIDING DOOR ON REAR PASSENGER SIDE OF VAN WOULD NOT CLOSE WITHOUT THE 'OPEN DOOR BELL' BEEPING CONSTANTLY (EVEN AFTER CLOSED). SOMETIMES AFTER RE-CLOSING, IT WOULD STOP BUT THIS EVENTUALLY BECAME A CONSTANT HAPPENING. WE LIVE IN PA. AND WERE IN FL. WHEN THIS FIRST HAPPENED, SO WE TOOK IT TO A DEALER TO HAVE IT FIXED. AP…
Read full complaint
THE SLIDING DOOR ON REAR PASSENGER SIDE OF VAN WOULD NOT CLOSE WITHOUT THE 'OPEN DOOR BELL' BEEPING CONSTANTLY (EVEN AFTER CLOSED). SOMETIMES AFTER RE-CLOSING, IT WOULD STOP BUT THIS EVENTUALLY BECAME A CONSTANT HAPPENING. WE LIVE IN PA. AND WERE IN FL. WHEN THIS FIRST HAPPENED, SO WE TOOK IT TO A DEALER TO HAVE IT FIXED. APPROX. A YEAR LATER, THE SAME THING HAPPENED. AGAIN, AFTER OPENING AND CLOSING THE DOOR A NUMBER OF TIMES THE BEEPING WOULD SOMETIMES STOP, BUT WHEN WE NEEDED TO USE THE DOOR, IT WOULD REPEAT. WE TOOK IT TO THE DEALER THE SECOND TIME TO HAVE IT REPAIRED. NOW, WE ARE EXPERIENCING THE SAME THING AGAIN AND THE BEEPING WILL NOT STOP! THIS IS WAY TOO EXPENSIVE FOR US TO HANDLE. WE ARE SENIORS AND CANNOT AFFORD TO PAY FOR THIS KIND OF DEFECT. PLEASE HELP US! *TR
NHTSA ODI #10598804
102,650 miles · Aug 11, 2013
Structure
SLIDING DOORS KEPT MESSING UP, DINGING EVEN AFTER BEING CLOSED, WON'T LATCH ALL THE WAY. *TR
NHTSA ODI #10534771
88,420 miles · Aug 11, 2013
Structure
THE TENSION RODS OR WHATEVER THEY ARE CALLED THAT KEEP THE HATCH UP, THEY BOTH WENT OUT AT THE SAME TIME AND THE HATCH CAME SLAMMING DOWN. WOULD HAVE SERIOUSLY INJURED OR KILLED SOMEONE HAD THEY BEEN UNDER IT. VEHICLE ONLY 2 YRS OLD! I'VE HAD 6 VANS IN MY LIFE AND NONE HAVE EVER HAD THIS HAPPEN, THIS VAN HAS BEEN A PIECE …
Read full complaint
THE TENSION RODS OR WHATEVER THEY ARE CALLED THAT KEEP THE HATCH UP, THEY BOTH WENT OUT AT THE SAME TIME AND THE HATCH CAME SLAMMING DOWN. WOULD HAVE SERIOUSLY INJURED OR KILLED SOMEONE HAD THEY BEEN UNDER IT. VEHICLE ONLY 2 YRS OLD! I'VE HAD 6 VANS IN MY LIFE AND NONE HAVE EVER HAD THIS HAPPEN, THIS VAN HAS BEEN A PIECE OF CRAP FROM DAY ONE! *TR
NHTSA ODI #10534768
52,700 miles · Aug 6, 2013
Structure
THE REAR SLIDING DOOR ON THE PASSENGER SIDE CAME OPEN WHILE DRIVING DOWN THE ROAD WITH MY TWO CHILDREN IN THE CAR. THIS HAS HAPPENED ON MULTIPLE OCCASIONS AND THE DEALERSHIP HAS BEEN UNABLE TO FIX THE PROBLEM. THE DOORS CONTINUE TO OPEN WITHOUT WARNING WHILE DRIVING. THE CAR WAS PURCHASED NEW ON 6/7/05. I STARTED HAVING PROB…
Read full complaint
THE REAR SLIDING DOOR ON THE PASSENGER SIDE CAME OPEN WHILE DRIVING DOWN THE ROAD WITH MY TWO CHILDREN IN THE CAR. THIS HAS HAPPENED ON MULTIPLE OCCASIONS AND THE DEALERSHIP HAS BEEN UNABLE TO FIX THE PROBLEM. THE DOORS CONTINUE TO OPEN WITHOUT WARNING WHILE DRIVING. THE CAR WAS PURCHASED NEW ON 6/7/05. I STARTED HAVING PROBLEMS WITH THE DOORS RIGHT AWAY AND TOOK IT IN FOR THE FIRST REPAIR ON 7/7/05 WITH 980 MILES. THE DOORS WERE ALSO REPAIRED 7/25/05 WITH 1338 MILES, 10/25/05 WITH 2,768 MILES, AND 11/4/05 WITH 2,865 MILES. THE DOORS CONTINUED TO NOT OPEN OR CLOSE AT TIMES AND/OR THE DOOR CHIMES WOULD DING AND NOT TURN OFF FROM 2005-2012. WE TRIED TO AVOID USING THE CAR WITH THE CHILDREN AND USE OUR OTHER CAR. IN SEPTEMBER OF 2012 THE PROBLEMS WITH THE DOORS PROGRESSED AND AT TIMES IT WOULD TAKE HOURS TO GET THE DOORS TO CLOSE OR THE CHIMES WOULD NOT GO OFF AT ALL. THIS IS WHEN THE DOORS STARTED COMING OPEN WHILE THE VAN WAS IN MOTION. THE DEALERSHIP WORKED ON THE VAN AGAIN 9/28/12 WITH 52,782 MILES. FROM SEPTEMBER 2013-JUNE 2013 THE DOORS CONTINUED TO NOT WANT TO OPEN OR CLOSE AT TIMES. WE STILL TRIED TO AVOID USING THE VEHICLE WITH THE CHILDREN. THE ISSUES STARTED AGAIN IN JUNE OF 2013 WITH THE DOORS OPENING WHILE IN MOTION. I TOOK THE VAN TO ANOTHER DEALERSHIP ON 7/2/13 WITH 60,873 MILES TO SERVICE THE DOORS AND FLICKERING HEADLAMPS. ON 8/2/13 I TOOK THE VAN TO THE DEALERSHIP BECAUSE THE DOORS ARE OPENING AGAIN WHILE IN MOTION AND I REFUSE TO PICK IT UP DUE TO DANGEROUS CONDITIONS. *TR
THE BRAUN CORPORATION HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2005-2008 GENERAL MOTORS MOBILITY CONVERSION, HANDICAPPED ACCESSIBLE LOW FLOOR MINIVANS. DURING CONVERSION, THE DRIVER OR PASSENGER SIDE TRAILING ARM MODIFICATION MAY NOT HAVE BEEN ADEQUATELY WELDED.
Consequence & remedy
Consequence: A SQUEAKING OR CLUNKING NOISE MAY DEVELOP. THE TRAILING ARM BUSHINGS MAY PREMATURELY WEAR AND THE TRAILING ARM MAY FRACTURE OR SEPARATE, ALLOWING THE REAR AXLE TO BECOME PARTIALLY SEPARATED FROM THE CHASSIS INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND WILL HAVE A SUPPLY OF RETROFIT PARTS AVAILABLE TO REMEDY THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 4, 2010. OWNERS MAY CONTACT BRAUN AT 1-800-488-0359.
CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' TO MEET THE STANDARD, THE VEHICLE MUST NOT MOVE FOR FIVE MINUTES WHEN STOPPED ON A STEEP HILL WITH THE PARKING BRAKE APPLIED AND THE VEHICLE IN NEUTRAL (N). SOME OF THESE VEHICLES FAILED THIS TEST.
Consequence & remedy
Consequence: WHEN THE PARKING BRAKE IS RELEASED, THE DRIVER MAY NOTICE UNINTENDED BRAKING WHEN ACCELERATING, DECELERATING, OR COASTING, AND A NOISE COMING FROM THE REAR OF THE VEHICLE. UNINTENDED VEHICLE MOVEMENT COULD OCCUR INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT FOR PARKING BRAKE LEVER SLIPPAGE AT EACH REAR BRAKE CALIPER AND REPLACE THE CALIPER IF LEVER SLIPPAGE IS IDENTIFIED. THE RECALL BEGAN ON NOVEMBER 14, 2005. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR SATURN AT 1-800-972-8876.
ON CERTAIN MINIVANS, THE OUTBOARD RELEASE HANDLE ON THE IMPACT-SIDE SECOND-ROW BUCKET SEAT MAY BE ACTUATED AND THE REAR LATCHES MAY UNLATCH EARLY IN A SIDE IMPACT CRASH. THIS WAS DISCOVERED IN A SIDE IMPACT TEST RUN BY GM, UNDER CONDITIONS SIMILAR TO NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) SIDE IMPACT TEST.
Consequence & remedy
Consequence: IF THE REAR LATCHES OF THE SEAT RELEASE EARLY IN A SEVERE SIDE IMPACT, THE FRONT OUTBOARD LATCH MAY DISENGAGE AND INCREASE THE POTENTIAL FOR INJURY TO THE OCCUPANT OF THE SEAT.
Remedy: DEALERS WILL REMOVE THE SEAT LATCH RELEASE HANDLE AND INSTALL A BLACK PLASTIC CAP OVER THE EXPOSED METAL STUD TO ELIMINATE THE SIDE IMPACT SAFETY CONCERN FREE OF CHARGE. THE RECALL BEGAN ON APRIL 5, 2005. OWNERS MAY CONTACT SATURN AT 1-800-972-8876, CHEVROLET AT 1-800-630-2438, AND PONTIAC AT 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA07019 · Power Sliding Door
Opened Dec 11, 2007 · Closed Feb 23, 2009
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
PE07044 · Power Sliding Door Opening
Opened Aug 16, 2007 · Closed Dec 11, 2007
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
PE05063 · Electrical Harness Damage
Opened Nov 29, 2005 · Closed Mar 6, 2006
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Electrical System:wiring:front Underhood
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Electrical System:wiring:fuses And Circuit Breakers
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
2005 Chevrolet Uplander Problems, Complaints & Recalls | Skip That Year
Illustration