IllustrationPOWER SLIDING PASSENGER DOOR DOES NOT FUNCTION PROPERLY. ERRATIC OPENING AND CLOSING CAUSING VAN TO SAY DOOR IS OPEN WHEN IT IS NOT. DOOR HAS OPENED ON IT'S OWN WHEN THE VEHICLE WAS IN MOTION; BACKING OUT OF THE DRIVEWAY. VAN CURRENTLY NOT IN USE BECAUSE DOOR CONTINUOUSLY INOPERABLE. *JB
2005 Chevrolet Uplander
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 Chevrolet Uplander do not stand out strongly from the model-year median of 119.
About this comparison →How this year compares
Owner complaints by model year
Compare all Uplander years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
670–25K
2225–50K
2950–75K
1475–100K
17100–150K
11150K+
160 reports with mileage · 36 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 57 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Latches/locks/linkages. Review the 45 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 45 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports1 fire reports16 injury reports
Latches/locks/linkages complaints
45 reports2005 CHEVROLET UPLANDER. ORDERED DIRECTLY FROM GM NEW. AUTOMATIC SLIDING DOORS INADVERTENTLY SLIDE OPEN, REPEATEDLY CLOSE AND RE-OPEN, OFTENTIMES WILL NOT CLOSE AT ALL, AUTOMATIC SYSTEM FAILS, MOST IMPORTANTLY, WE WERE TOLD WHEN WE BOUGHT THE VEHICLE THAT IT WAS MADE WITH A DEVICE THAT WOULD PREVENT IT FROM OPENING WHILE DRIVI…
Read full complaint
2005 CHEVROLET UPLANDER. ORDERED DIRECTLY FROM GM NEW. AUTOMATIC SLIDING DOORS INADVERTENTLY SLIDE OPEN, REPEATEDLY CLOSE AND RE-OPEN, OFTENTIMES WILL NOT CLOSE AT ALL, AUTOMATIC SYSTEM FAILS, MOST IMPORTANTLY, WE WERE TOLD WHEN WE BOUGHT THE VEHICLE THAT IT WAS MADE WITH A DEVICE THAT WOULD PREVENT IT FROM OPENING WHILE DRIVING. THIS IS FALSE - THIS DOOR OPENS WHILE THE CAR IS IN MOTION!!!! I HAVE REPEATEDLY HAD THE VEHICLE IN FOR SERVICE REGARDING THIS PROBLEM AND THEY CONTINUE TO TELL ME THAT THEY CANNOT SEE WHERE THE FAILURE IS OCCURRING, THEY SAY, "WELL, WE'VE CLEANED THE SENSORS, LUBED THE TRACK AND IT SHOULD BE FINE NOW". HOWEVER IT WILL CONTINUE TO MALFUNCTION THE MINUTE I LEAVE THE SERVICE AREA. *TR
TL*THE CONTACT OWNS A 2005 CHEVROLET UPLANDER. THE CONTACT STATED THAT THE VEHICLE'S DOORS OPEN AND CLOSE BY THEMSELVES. THE FAILURE HAS OCCURRED APPROXIMATELY THREE TO FOUR TIMES SINCE THE VEHICLE WAS PURCHASED. THE DEALER ADVISED HER TO TAKE AN EMORY BOARD AND FILE THE CONTACTS DOWN. ON OCCASION, THE OPEN DOOR INDICATOR WI…
Read full complaint
TL*THE CONTACT OWNS A 2005 CHEVROLET UPLANDER. THE CONTACT STATED THAT THE VEHICLE'S DOORS OPEN AND CLOSE BY THEMSELVES. THE FAILURE HAS OCCURRED APPROXIMATELY THREE TO FOUR TIMES SINCE THE VEHICLE WAS PURCHASED. THE DEALER ADVISED HER TO TAKE AN EMORY BOARD AND FILE THE CONTACTS DOWN. ON OCCASION, THE OPEN DOOR INDICATOR WILL CHIME WHEN SHE SHUTS THE DOORS. THE CONTACT MUST RE-OPEN AND CLOSE THE DOORS NUMEROUS TIMES IN ORDER FOR THE INDICATOR TO DEACTIVATE. THE VIN AND ENGINE SIZE WERE UNKNOWN. THE CURRENT MILEAGE IS 36,000 AND FAILURE MILEAGE WAS 15.
AUTOMATIC DOOR ON 2005 CHEVROLET UPLANDER MALFUNCTIONEDE. THE DOOR POPPE D BACK OPEN WHEN CLOSED. I HAVE TAKEN IT IN FOR REPAIRS 3 TIMES. FILED WITH WITH FL LEMON LAW IN JUNE 06. THE COMPANY REPORTED TO BY ATTORNEY THAT ITWAS NOT A SAFETY ISSUE. *AK
TL*THE CONTACT OWNS A 2005 CHEVROLET UPLANDER. THE CONTACT STATED THAT THE AUTOMATIC PASSENGER SIDE REAR DOOR OPENS ON ITS OWN AFTER IT HAS BEEN CLOSED. SHE TOOK THE VEHICLE TO THE DEALER, BUT THEY WERE UNABLE TO DUPLICATE THE FAILURE. THE CURRENT MILEAGE IS 16,000 AND FAILURE MILEAGE WAS 12,000. THE DEALER DID WITNESS THE P…
Read full complaint
TL*THE CONTACT OWNS A 2005 CHEVROLET UPLANDER. THE CONTACT STATED THAT THE AUTOMATIC PASSENGER SIDE REAR DOOR OPENS ON ITS OWN AFTER IT HAS BEEN CLOSED. SHE TOOK THE VEHICLE TO THE DEALER, BUT THEY WERE UNABLE TO DUPLICATE THE FAILURE. THE CURRENT MILEAGE IS 16,000 AND FAILURE MILEAGE WAS 12,000. THE DEALER DID WITNESS THE PROBLEM. UPDATED 09/26/07
IN PURCHASING THE UPLANDER THE SALESMAN DEMONSTRATED THE SAFETY FEATURE OF THE BLOCKING OF SLIDING SIDE DOORS BY STICKING HIS ARM IN THE PATH OF THE DOOR (WELL BEFORE IT SHUT) AND THE DOOR STOPPING AND RETRACTING. IN DEMONSTRATING THIS FEATURE TO MY GRANDCHILDREN I PLACED MY HAND IN THE WAY OF THE DRIVER SIDE SLIDING REAR DOOR …
Read full complaint
IN PURCHASING THE UPLANDER THE SALESMAN DEMONSTRATED THE SAFETY FEATURE OF THE BLOCKING OF SLIDING SIDE DOORS BY STICKING HIS ARM IN THE PATH OF THE DOOR (WELL BEFORE IT SHUT) AND THE DOOR STOPPING AND RETRACTING. IN DEMONSTRATING THIS FEATURE TO MY GRANDCHILDREN I PLACED MY HAND IN THE WAY OF THE DRIVER SIDE SLIDING REAR DOOR AND ALLOWED IT TO CLOSE ON MY HAND, THE DOOR DID NOT RETRACT AND TRAPPED ME THERE WITH MY HAND IN THE DOOR. IT WAS PAINFUL TO SAY THE LEAST AND MY GRANDCHILDREN WERE THE ONLY ONES THAT COULD PUSH THE BUTTON TO OPEN THE DOOR. I REPORTED THE MISHAP TO THE SALESMAN AT THE CHEVY DEALERS BUT NOTHING WAS EVER DONE. THE PROBLEM AS I SEE IT IS THAT ANY SMALL CHILD TRYING TO KEEP THE DOOR FROM CLOSING WOULD REACH FOR THE DOOR AND IN DOING SO WOULD PLACE HIS HAND IN THE DOOR IN THE SAME POSITION I WAS IN WHEN I DEMONSTRATED THIS "SAFETY FEATURE" TO MY GRAND CHILDREN. THIS FEATURE APPARENTLY WORKS ONLY WHEN THE DOOR IS SLIDING FORWARD AND NOT WHEN IT IS CLOSING. *JB
TL* - THE CONTACT CALLED REGARDING THE 2005 CHEVROLET UPLANDER. THE CONTACT STATED THAT THE POWER SLIDING DOOR OPENED AND CLOSED UNEXPECTEDLY. THE CONTACT TOOK THE VEHICLE IN TO THE DEALER FIVE TIMES. THE DEALE ADVISED THE CONTACT THAT EITHER THEY COULD NOT DUPLICATE THE FAILURE OR THAT THEY HAD REPAIRED IT. ON ONE OCCA…
Read full complaint
TL* - THE CONTACT CALLED REGARDING THE 2005 CHEVROLET UPLANDER. THE CONTACT STATED THAT THE POWER SLIDING DOOR OPENED AND CLOSED UNEXPECTEDLY. THE CONTACT TOOK THE VEHICLE IN TO THE DEALER FIVE TIMES. THE DEALE ADVISED THE CONTACT THAT EITHER THEY COULD NOT DUPLICATE THE FAILURE OR THAT THEY HAD REPAIRED IT. ON ONE OCCASION, THE DEALER REINSTALLED A LOOSE LOCK ROD. ON ANOTHER OCCASION, THE DEALER REPROGRAMMED THE SLIDING DOOR MODULE. THE FAILURE MILEAGE WAS 24,000. WHEN THE DOOR MALFUNCTIONED THE WARNING INDICATOR WAS A BELL ALERTING HER THE DOOR OPENED, THERE WERE NO OTHER WARNING INDICATORS. THE FRONT TWO TIRES WERE REPLACED AT 14,000 MILES DUE TO EXCESSIVE WEAR. THE BACK TWO TIRES WERE REPLACED AT 24,000 DUE TO EXCESSIVE WEAR. THE CONTACT STATED AT 37,000 MILES, THE VEHICLE NEEDED FOUR NEW TIRES DUE TO WEAR. THE DEALER SAID THE CAUSE WAS DUE TO THE TIRES NOT HAVING BEEN ALIGNED WHEN THE TIRES WERE REPLACED. THE CONTACT STATED THAT THE BRAKES HAVE HAD TO BE RESURFACED TWICE. SHE HEARD A KNOCKING NOISE IN THE FRONT END OF THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO DEALER FOUR TIMES. THE DEALER REPLACED TWO STEERING GEARS IN THE STEERING COLUMN. THE DEALER REPLACED STRUTS AND THE STABILIZER BAR, HOWEVER THE KNOCKING NOISE CONTINUED. THE CONTACT HAD THE REPAIR. INVOICES. THE CURRENT MILEAGE WAS 37000.*AK
TL* - THE CONTACT OWNS A 2005 CHEVROLET UPLANDER. THE TRANSMISSION FAILED AT 11,000 MILES. THE MECHANIC REPAIRED IT INSTEAD OF REPLACING, IT AND IT CONTINUED TO LEAK. THE DEALER REPLACED THE TRANSMISSION, AND THE NEW ONE FROM THE MANUFACTURER WAS ALSO LEAKING. THE VEHICLE WAS IN THE REPAIR SHOP FOR 16 DAYS, AND THE NEW TRANSMISS…
Read full complaint
TL* - THE CONTACT OWNS A 2005 CHEVROLET UPLANDER. THE TRANSMISSION FAILED AT 11,000 MILES. THE MECHANIC REPAIRED IT INSTEAD OF REPLACING, IT AND IT CONTINUED TO LEAK. THE DEALER REPLACED THE TRANSMISSION, AND THE NEW ONE FROM THE MANUFACTURER WAS ALSO LEAKING. THE VEHICLE WAS IN THE REPAIR SHOP FOR 16 DAYS, AND THE NEW TRANSMISSION HAD TO BE RESEALED. WHEN STARTING THE VEHICLE THE IGNITION WAS STICKING IN THE START MODE FOR 2 MINUTES AFTER RELEASING THE KEY. THE PASSENGER AUTOMATIC SLIDING DOOR DID NOT LATCH SHUT, NO WARNING INDICATOR LIGHT APPEARED NOR DID IT REGISTER WITH ONSTAR AS THE DOOR WAS BEING UN LATCHED. WHEN ATTEMPTING TO OPEN THE DOOR IT WILL NOT OPEN BECAUSE THE LATCH DID NOT ENGAGE. THE DEALER WAS UNABLE TO DIAGNOSE THE FAILURE. THE CONTACT WAS CONCERNED ABOUT THE SAFETY RISK INVOLVED. THE CONTACT FILED A COMPLAINT WITH THE BBB, AND SPOKEN TO GM ABOUT ALL OF THE FAILURES. THE GEAR SHIFTWS VERY DIFFICULT TO MOVE FROM PARK TO REVERSE. ALL OF THE ABOVE LISTED FAILURES OCCURRED FREQUENTLY. THE MOST RECENT WAS THE DOOR AND THE STARTER. THE STARTER FAILURE OCCURRED 15 TO 20 TIMES. THE GEAR SHIFT FAILED EVERY TIME THE VEHICLE WAS DRIVEN. THE DOOR FAILED 20 TIMES. THE CURRENT AND FAILURE MILEAGE WAS 13,000. *AK THE ENGINE WOULD CRANK, BUT IT WOULDN'T START, THE DRIVERS HEATED SEAT WAS INOPERATIVE, THERE WAS AN OIL LEAK FROM THE CRANKSHAFT SEAL, THE POWER SLIDING DOOR WAS INOPERATIVE. UPDATED 03/30/07. *JB
WE PURCHASED A 2005 CHEVY UPLANDER WHEN IT WAS 1 YR OLD WITH 10,000 MILES ON IT DIRECTLY FROM A CHEVY DEALER. ONE MONTH LATER, THE REAR PASSENGER SLIDING DOOR STARTED AUTOMATICALLY REOPENING IT AFTER BOTH THE SHUT BUTTONS BY THE DRIVER SEAT AND THE BUTTON ON THE DOOR ITSELF WERE PUSHED TO CLOSE. THIS VAN HAS NOW BEEN BACK TO THE…
Read full complaint
WE PURCHASED A 2005 CHEVY UPLANDER WHEN IT WAS 1 YR OLD WITH 10,000 MILES ON IT DIRECTLY FROM A CHEVY DEALER. ONE MONTH LATER, THE REAR PASSENGER SLIDING DOOR STARTED AUTOMATICALLY REOPENING IT AFTER BOTH THE SHUT BUTTONS BY THE DRIVER SEAT AND THE BUTTON ON THE DOOR ITSELF WERE PUSHED TO CLOSE. THIS VAN HAS NOW BEEN BACK TO THE CHEVY DEALER 6 TIMES FOR THIS PROBLEM WITHIN THE 7 MONTHS WE OWN IT. THE DEALER HAS MADE IT PRETTY CLEAR TO US THAT THEY CAN NOT FIND OR FIX THE PROBLEM. THEY HAVE NOW TAKEN THE STAND OF, "LET'S SEE IF IT WORKS THIS TIME". I HAVE A TODDLER AND I AM SCARED TO DRIVE THIS CAR. THE DOOR OPENS BY ITSELF. ALSO - THERE IS NOT A SAFETY MECHANISM ON THE DOOR TO REOPEN IF SOMETHING, LIKE MY DAUGHTER'S ARM OR LEG GET IN THE WAY. I HAVE PARKED THE CAR, AND GONE INTO A STORE AND WATCHED THE DOOR CLOSE, TO ONLY CONE OUT AND FIND THE DOOR WIDE OPEN. MY INITAL FEAR IS THAT THE CAR WAS BROKEN INTO. I WILL NOT DRIVE THIS VAN ANY LONGER SINCE IT IS AN ACCIDENT WAITING TO HAPPEN. *NM
VEHICLE REAR SLIDING DOOR WILL NOT OPEN OR CLOSE. *JB
Official recalls
310V110000 · Suspension:rear
Mar 19, 2010
THE BRAUN CORPORATION HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2005-2008 GENERAL MOTORS MOBILITY CONVERSION, HANDICAPPED ACCESSIBLE LOW FLOOR MINIVANS. DURING CONVERSION, THE DRIVER OR PASSENGER SIDE TRAILING ARM MODIFICATION MAY NOT HAVE BEEN ADEQUATELY WELDED.
Consequence & remedy
Consequence: A SQUEAKING OR CLUNKING NOISE MAY DEVELOP. THE TRAILING ARM BUSHINGS MAY PREMATURELY WEAR AND THE TRAILING ARM MAY FRACTURE OR SEPARATE, ALLOWING THE REAR AXLE TO BECOME PARTIALLY SEPARATED FROM THE CHASSIS INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND WILL HAVE A SUPPLY OF RETROFIT PARTS AVAILABLE TO REMEDY THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 4, 2010. OWNERS MAY CONTACT BRAUN AT 1-800-488-0359.
05V287000 · Parking Brake
Jun 20, 2005
CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' TO MEET THE STANDARD, THE VEHICLE MUST NOT MOVE FOR FIVE MINUTES WHEN STOPPED ON A STEEP HILL WITH THE PARKING BRAKE APPLIED AND THE VEHICLE IN NEUTRAL (N). SOME OF THESE VEHICLES FAILED THIS TEST.
Consequence & remedy
Consequence: WHEN THE PARKING BRAKE IS RELEASED, THE DRIVER MAY NOTICE UNINTENDED BRAKING WHEN ACCELERATING, DECELERATING, OR COASTING, AND A NOISE COMING FROM THE REAR OF THE VEHICLE. UNINTENDED VEHICLE MOVEMENT COULD OCCUR INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT FOR PARKING BRAKE LEVER SLIPPAGE AT EACH REAR BRAKE CALIPER AND REPLACE THE CALIPER IF LEVER SLIPPAGE IS IDENTIFIED. THE RECALL BEGAN ON NOVEMBER 14, 2005. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR SATURN AT 1-800-972-8876.
05V061000 · Seats:mid/rear Assembly
Feb 18, 2005
ON CERTAIN MINIVANS, THE OUTBOARD RELEASE HANDLE ON THE IMPACT-SIDE SECOND-ROW BUCKET SEAT MAY BE ACTUATED AND THE REAR LATCHES MAY UNLATCH EARLY IN A SIDE IMPACT CRASH. THIS WAS DISCOVERED IN A SIDE IMPACT TEST RUN BY GM, UNDER CONDITIONS SIMILAR TO NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) SIDE IMPACT TEST.
Consequence & remedy
Consequence: IF THE REAR LATCHES OF THE SEAT RELEASE EARLY IN A SEVERE SIDE IMPACT, THE FRONT OUTBOARD LATCH MAY DISENGAGE AND INCREASE THE POTENTIAL FOR INJURY TO THE OCCUPANT OF THE SEAT.
Remedy: DEALERS WILL REMOVE THE SEAT LATCH RELEASE HANDLE AND INSTALL A BLACK PLASTIC CAP OVER THE EXPOSED METAL STUD TO ELIMINATE THE SIDE IMPACT SAFETY CONCERN FREE OF CHARGE. THE RECALL BEGAN ON APRIL 5, 2005. OWNERS MAY CONTACT SATURN AT 1-800-972-8876, CHEVROLET AT 1-800-630-2438, AND PONTIAC AT 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA07019 · Power Sliding Door
Opened Dec 11, 2007 · Closed Feb 23, 2009
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
PE07044 · Power Sliding Door Opening
Opened Aug 16, 2007 · Closed Dec 11, 2007
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
PE05063 · Electrical Harness Damage
Opened Nov 29, 2005 · Closed Mar 6, 2006
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Electrical System:wiring:front Underhood
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Electrical System:wiring:fuses And Circuit Breakers
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.