IllustrationWHEN DRIVING MY MINIVAN THE DOOR ON THE SIDE WILL FLY OPEN, ALSO THE GAUGES WILL STOP WORKING SO YOU CANNOT TELL HOW FAST YOU ARE GOING, I HAVE HAD MY CAR IN AT LEAST 5 TIMES THE LAST YEAR. *TR
2005 Chevrolet Uplander
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 Chevrolet Uplander do not stand out strongly from the model-year median of 119.
About this comparison →How this year compares
Owner complaints by model year
Compare all Uplander years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
670–25K
2225–50K
2950–75K
1475–100K
17100–150K
11150K+
160 reports with mileage · 36 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 57 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Latches/locks/linkages. Review the 45 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 45 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports1 fire reports16 injury reports
Electrical System complaints
57 reportsTHIS COMPLAINT COVERS MANY COMPONENTS OF THE CHEVY UPLANDER THAT HAS SPANNED OVER THE THREE YEARS THAT WE HAVE OWNED THE VAN. ALL PROBLEMS ARE "UNABLE TO BE DIAGNOSED" BY DEALERSHIPS AND CHEVY REFUSES TO HELP US. I HAVE BEEN IN CONTACT WITH CHEVY FROM ABOUT THE SECOND TIME THAT THE VAN WENT TO THE SHOP FOR ELECTRICAL PROBLEMS.…
Read full complaint
THIS COMPLAINT COVERS MANY COMPONENTS OF THE CHEVY UPLANDER THAT HAS SPANNED OVER THE THREE YEARS THAT WE HAVE OWNED THE VAN. ALL PROBLEMS ARE "UNABLE TO BE DIAGNOSED" BY DEALERSHIPS AND CHEVY REFUSES TO HELP US. I HAVE BEEN IN CONTACT WITH CHEVY FROM ABOUT THE SECOND TIME THAT THE VAN WENT TO THE SHOP FOR ELECTRICAL PROBLEMS. WE HAVE HAD ELECTRICAL PROBLEMS THAT VARY FROM THE LIGHTS FLICKERING TO THE FANS OUTPUT CHANGING TO THE RADIO NOT ALLOWING YOU TO PROGRAM IN A STATION ON ONE PRESET BUTTON, WE ARE ALSO CURRENTLY HAVING AN ABS ISSUE AND HAVE HAD A NON GM MECHANIC LOOK AT THE VAN AND SAID IT IS OK. THE PASSENGER SIDE AUTO SLIDING DOOR DOES NOT ALWAYS AUTOMATICALLY OPEN AND SOMETIMES DOES NOT CLOSE EITHER, WHEN YOU MANUALLY SHUT IT WILL OPEN BY ITSELF SEVERAL TIMES BEFORE IT STAYS SHUT. WE ARE CURRENTLY AND HAVE FOR SOME TIME HAD A PROBLEM WITH STARTING THE VAN THIS IS ALSO SOMETHING THAT "CAN'T BE DIAGNOSED" IT HAS BEEN LOOKED AT MANY TIMES. THE PROBLEMS HAPPENS ABOUT 15-20 TIMES A WEEK. WE DID PURCHASE THE EXTENDED WARRANTY ON THE VAN AND IT IS NOW ABOUT UP AND I AM AT A LOSS AS TO WHAT TO DO BECAUSE NOBODY WANTS TO HELP EVEN THOUGH IT IS CLEAR I AM NOT THE ONLY ONE . PLEASE LET ME KNOW IF THERE IS ANY OTHER WAY TO FIGHT THIS. THE DRIVERS SLIDING DOOR DOESN'T ALWAYS UNLOCK EITHER UNLESS DONE BY HAND. *TR
I PURCHASED A 2005 UPLANDER FROM A GM DEALER IN JULY 2005. I NOW HAVE 32,167. I TOOK MY VEHICLE IN FOR ITS NORMAL OIL CHANGE AT 22,000 WHEN THE SERVICE DEPARTMENT SAID I NEEDED FRONT AND BRAKES AND ROTORS. WE REPLACED THE BRAKES AND ROTORS AND MY ROTORS NEED TO REPLACED AGAIN. I ALSO NOTICED A NOISE COMING FROM THE LEFT FRONT TI…
Read full complaint
I PURCHASED A 2005 UPLANDER FROM A GM DEALER IN JULY 2005. I NOW HAVE 32,167. I TOOK MY VEHICLE IN FOR ITS NORMAL OIL CHANGE AT 22,000 WHEN THE SERVICE DEPARTMENT SAID I NEEDED FRONT AND BRAKES AND ROTORS. WE REPLACED THE BRAKES AND ROTORS AND MY ROTORS NEED TO REPLACED AGAIN. I ALSO NOTICED A NOISE COMING FROM THE LEFT FRONT TIRE I WAS TOLD THAT THEY DID NOT HEAR THE NOISE AND EVERYTHING WAS FINE. I HAVE TAKEN THE VAN IN FOR DIMMING ON THE LIGHTS AND THE VEHICLE FEELING LIKE IT IS GOING TO STALL TOO MANY TIMES TO COUNT AND EVERY TIME THEY TELL ME IT IS JUST THE WAY GM VEHICLES RUN. I ALSO HAVE A PROBLEM WITH THE STARTER I WILL CRANK IT AND NOTHING THIS HAPPENS AT LEASE ONCE A DAY AND I HAVE TO RETRY AT LEAST TWO TIMES BEFORE THE VAN WILL START.THE STEERING HAS BEEN A BIG ISSUE WE HAVE BEEN HAVING PROBLEMS WITH THE TIGHTNESS AND WHEN I AM DRIVING I CAN FEEL THE BACK END SWAYING. THE VEHICLE IS UNSAFE TO BE DRIVING AND WITH TWO SMALL CHILDREN IT IS EXTREMELY SCARY. AFTER READING ALL THE COMPLAINTS HOW IS THIS VEHICLE STILL ON THE ROAD. THE ISSUES PEOPLE ARE HAVING ARE EXTREMELY DANGEROUS. THE DEALERSHIP I GO TO HAS NEVER TRIED TO FIX OR REPLACE ANY OF THE ISSUES WITH MY VAN. THEY ALSO TELL ME ITS NORMAL AND THEY CANNOT FIND ANYTHING WRONG. I AM LOOKING TO REPLACE THE TIRES THEY ARE BALD WHICH IS CAUSING THE VAN TO HYDROPLANE EVERYTIME IT RAINS. THE STICKER ON THE INSIDE PANEL IS DIFFERENT FROM THE TIRES. THE TIRE GOODYEAR INTERGRITY P225/60R17 STATES 44 PSI WITH A MAX LOAD OF 1653 LBS. THE INSIDE STICKER STATES 35 PSI AND MAX LOAD OF 1330 LBS. THE TIRE SIZE IS EXTREMELY HARD TO FIND. I HAVE ALSO NOTICED WHEN WE CLOSE THE SLIDING DOORS THEY DO NOT SHUT, THE LATCH DOESNT CATCH THE DOOR UNTIL YOU SLAM EXTREMELY HARD. THEN MY DAUGHTER WILL TRY TO GET OUT OF THE VEHICLE AND THE CHILD LOCK WILL BE ON WHEN WE DIDN'T SLIDE IT ON. CAN SOMEONE PLEASE DO SOMETHING TO STOP THIS
I HAVE HAD TO JUMP START MY 2005 CHEVROLET UPLANDER SEVERAL TIMES. THE CAR HAS BEEN TAKEN TO THE DEALERSHIP THREE TIMES (TODAY 2-21-2008 BEING THE THIRD). THE BATTERY WAS REPLACED ONCE, THE RADIO WAS REPLACED THE SECOND TIME. I HAVE NOT RECEIVED A DIAGNOSES TO THE PROBLEM TODAY, BUT THE VEHICLE WOULD NOT START EVEN WITH A JUM…
Read full complaint
I HAVE HAD TO JUMP START MY 2005 CHEVROLET UPLANDER SEVERAL TIMES. THE CAR HAS BEEN TAKEN TO THE DEALERSHIP THREE TIMES (TODAY 2-21-2008 BEING THE THIRD). THE BATTERY WAS REPLACED ONCE, THE RADIO WAS REPLACED THE SECOND TIME. I HAVE NOT RECEIVED A DIAGNOSES TO THE PROBLEM TODAY, BUT THE VEHICLE WOULD NOT START EVEN WITH A JUMP FROM A TOW TRUCK. THE ONLY ITEM INSTALLED AFTER MARKET ON THIS VEHICLE WAS A SIT AND LIFT SEAT, INSTALLED BY THE DEALERSHIP AT A COST OF $5000. THE SEAT HAS PERFORMED WITHOUT FAILURE, OTHER THAN A FEW TIMES IT WOULD NOT OPERATE UNLESS THE SIDE SLIDING DOOR ON THE OPPOSITE SIDE OF THE VEHICLE WAS OPENED OR CLOSED, DEPENDING ON IT STATUS AT THE TIME OF THE FAILURE. *TR
ACCESS TO HORN PRESS BUTTON DIFFICULT TO ENGAGE WITHOUT VISUAL GUIDANCE THEREBY DISTRACTING DRIVER FROM PRIORITY NAVIGATION CONTROL, BECAUSE OF EXACT ACCESS POINT DIFFICULT TO LOCATE CAUSING DELAY OF NECESSARY EMPLOYMENT FOR AN IMMEDIATE EMERGENCY REQUIREMENT IS A SAFETY CONCERN. *TR
WHEN I LET OFF THE ACCELERATOR THE LIGHTS FLICKER AND THE BLOWER SLOWS DOWN. ALSO, SOMETIMES WHEN I TRY TO START IT, THE ENGINE WON'T START. *TR
TL*THE CONTACT OWNS A 2005 CHEVROLET UPLANDER. THE SLIDING DOOR ON THE REAR DRIVER SIDE WOULD NOT STAY LATCHED. THE CONTACT CALLED THE DEALER AND MANUFACTURER AND THEY STATED THAT SHE WAS RESPONSIBLE FOR HAVING THE DOOR REPAIRED. THE VEHICLE HAS BEEN IN THE SHOP SIX TIMES NOW FOR THE LATCH FAILURE AND THE DOOR OPENING ON ITS …
Read full complaint
TL*THE CONTACT OWNS A 2005 CHEVROLET UPLANDER. THE SLIDING DOOR ON THE REAR DRIVER SIDE WOULD NOT STAY LATCHED. THE CONTACT CALLED THE DEALER AND MANUFACTURER AND THEY STATED THAT SHE WAS RESPONSIBLE FOR HAVING THE DOOR REPAIRED. THE VEHICLE HAS BEEN IN THE SHOP SIX TIMES NOW FOR THE LATCH FAILURE AND THE DOOR OPENING ON ITS OWN. EACH TIME THE VEHICLE WAS RETRIEVED FROM THE DEALER, THEY STATED THAT IT WAS REPAIRED WHEN IT WAS NOT. WHEN THE BUTTON WAS PRESSED TO CLOSE THE DOOR, IT WOULD BEGIN TO SHUT AND AN ALARM WOULD SOUND; HOWEVER, IT WOULD NOT SHUT AND FLEW OPEN WHILE DRIVING. THE INSTRUMENT PANEL DOES NOT INDICATE THAT THE DOOR IS AJAR. THE REAR PASSENGER SIDE DOOR IS BEGINNING TO EXPERIENCE THE SAME FAILURE. NEITHER THE WEATHER NOR THE SPEED WERE FACTORS. THE CURRENT MILEAGE WAS 51,800 AND FAILURE MILEAGE WAS 49,043. THE DEALER STATED THE VEHICLE WOULD NOT START, CHECK BRAKE CONDITION, AND HUMMING NOISE LEFT FRONT HUB AREA. UPDATED 12/12/07 *TR
THE CAR INTERMITTENTLY TRIES TO START THE CRANK KEEPS TURNING BUT DOES NOT START. AS WELL AS I WAS TRAVELING ON FREEWAY WITH A BIG RIG ON THE SIDE OF ME AND THE CAR STALLED AND STEERING LOCKED. THANK GOD I MANAGED TO GLIDE OVER TO THE EXIT LANE. I WAS TERRIFIED AS WAS MY PASSENGER. WHEN I LOOKED AT THE GAUGES I NOTICED I WAS OUT…
Read full complaint
THE CAR INTERMITTENTLY TRIES TO START THE CRANK KEEPS TURNING BUT DOES NOT START. AS WELL AS I WAS TRAVELING ON FREEWAY WITH A BIG RIG ON THE SIDE OF ME AND THE CAR STALLED AND STEERING LOCKED. THANK GOD I MANAGED TO GLIDE OVER TO THE EXIT LANE. I WAS TERRIFIED AS WAS MY PASSENGER. WHEN I LOOKED AT THE GAUGES I NOTICED I WAS OUT OF GAS, BUT I HAD JUST PUT IN $20 . CHEVY SENT OUT TOW TRUCK TO GIVE ME GAS, BUT CAR STILL WOULD NOT START. FINALLY HOURS LATER CAR WAS TAKEN TO CHEVY. WHEN UPLANDER WAS FINISHED THEY SAID IT WAS ELECTRICAL SHORT DUE TO WATER IN LINES. WEATHER WAS GREAT NO RAIN OR PUDDLES ANYWHERE. UPLANDER ALMOST STALLED ON ANOTHER NIGHT LIGHTS DIMMED AND TIRES STOPPED ,BUT THEN IT WORKED FINE. STRANGE VERY!!! DRIVER SIDE SLIDING DOOR OPENS OR SHUTS WHEN IT WANTS. MY DAUGHTER WAS IN HER CAR SEAT AND I PUSHED BUTTON TO CLOSE DOOR SHE PUT HER FOOT UP TOWARDS DOOR AND IT SHUT AND LOCKED. LUCKILY HER TENNIS SHOES WERE A LITTLE BIG SO ONLY MINOR BRUISING OCCURRED. HOWEVER MY DAUGHTER IS TERRIFIED OF CAR. ALSO I HAVE ALREADY PUT 6 NEW TIRES ON CAR BECAUSE THEY WERE BALD AT 13,000 MILES FIRST TIME. TIRES IN FRONT ARE BALD AGAIN. UPLANDER IS NOT STABLE TO DRIVE ON HIGHWAY. *TR
TL*THE CONTACT OWNS A 2005 CHEVROLET UPLANDER. THE CONTACT STATED THAT A VEHICLE MERGED INTO TRAFFIC FROM A SIDE ROAD AND CRASHED INTO HIS VEHICLE'S PASSENGER SIDE DOOR. THE CONTACT WAS DRIVING 35 MPH AT THE TIME OF THE CRASH. THE AIR BAGS FAILED TO DEPLOY AND THE MIDDLE ROW SEATS RECLINED BACKWARDS. THE DRIVER AND SIX PASSE…
Read full complaint
TL*THE CONTACT OWNS A 2005 CHEVROLET UPLANDER. THE CONTACT STATED THAT A VEHICLE MERGED INTO TRAFFIC FROM A SIDE ROAD AND CRASHED INTO HIS VEHICLE'S PASSENGER SIDE DOOR. THE CONTACT WAS DRIVING 35 MPH AT THE TIME OF THE CRASH. THE AIR BAGS FAILED TO DEPLOY AND THE MIDDLE ROW SEATS RECLINED BACKWARDS. THE DRIVER AND SIX PASSENGERS WERE INJURED. THE VEHICLE WAS DESTROYED. THE VEHICLE WAS PREVIOUSLY TAKEN TO THE DEALER SEVERAL TIMES FOR THE ELECTRICAL SYSTEM, THE DASHBOARD, AND OTHER EQUIPMENT. THE DEALER STATED THAT THE ELECTRICAL FAILURE WAS CORRECTED. HINESVILLE POLICE REPORT NUMBER 07064548 WAS FILED. THE POWERTRAIN AND DEALER INFORMATION WERE UNAVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE 30,079. THE CONSUMER PROVIDED GEORGIA ACCIDENT REPORT, COURT DOCUMENTATION, MEDICAL DOCUMENTATION, NEWSPAPER ARTICLE PERTAINING TO THE ACCIDENT, PICTURES OF THE ACCIDENT AND INJURIES. THE DEALER STATED REPROGRAM INSTRUMENT PANEL. UPDATED 09/11/07 *TR
WE HAVE HAD SEVERAL ISSUES WITH THE DOORS NOT CLOSING AND HAVE TAKEN THE VEHICLE IN SEVERAL TIMES. THE SERVICE DEPT. COULDN'T DUPLICATE THE PROBLEM. APPARENTLY GM KNOWS ABOUT THE PROBLEM BECAUSE THE LAST TIME WE WERE IN THERE THEY TOLD US THERE WAS AN INTERNAL SERVICE BULLETIN ABOUT RE-ROUTING WIRES AND POSSIBLE MODULE REPLACEME…
Read full complaint
WE HAVE HAD SEVERAL ISSUES WITH THE DOORS NOT CLOSING AND HAVE TAKEN THE VEHICLE IN SEVERAL TIMES. THE SERVICE DEPT. COULDN'T DUPLICATE THE PROBLEM. APPARENTLY GM KNOWS ABOUT THE PROBLEM BECAUSE THE LAST TIME WE WERE IN THERE THEY TOLD US THERE WAS AN INTERNAL SERVICE BULLETIN ABOUT RE-ROUTING WIRES AND POSSIBLE MODULE REPLACEMENT, ALL OF WHICH WAS DONE TO OUR VEHICLE. IT IS GOING BACK IN AGAIN 7-27-07 FOR THE SAME PROBLEM. OUR UPLANDER ALSO HAS A PROBLEM OF THE DOOR LOCKS RAPIDLY LOCKING AND UNLOCKING AT VARIOUS TIMES WHILE DRIVING, AND ALL OF THE LIGHTS WILL FLICKER AND DIM. ONE INSTANCE WHILE DRIVING AT NIGHT ALL LIGHTS WENT OUT BRIEFLY AND CAME BACK ON, EXTREMELY DANGEROUS! SOMETHING HAS TO BE DONE. WE LIVE IN MICHIGAN, YOU'D THINK THERE WOULDN'T BE A PROBLEM IN THE MOTOR CITY. *JB
Official recalls
310V110000 · Suspension:rear
Mar 19, 2010
THE BRAUN CORPORATION HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2005-2008 GENERAL MOTORS MOBILITY CONVERSION, HANDICAPPED ACCESSIBLE LOW FLOOR MINIVANS. DURING CONVERSION, THE DRIVER OR PASSENGER SIDE TRAILING ARM MODIFICATION MAY NOT HAVE BEEN ADEQUATELY WELDED.
Consequence & remedy
Consequence: A SQUEAKING OR CLUNKING NOISE MAY DEVELOP. THE TRAILING ARM BUSHINGS MAY PREMATURELY WEAR AND THE TRAILING ARM MAY FRACTURE OR SEPARATE, ALLOWING THE REAR AXLE TO BECOME PARTIALLY SEPARATED FROM THE CHASSIS INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND WILL HAVE A SUPPLY OF RETROFIT PARTS AVAILABLE TO REMEDY THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 4, 2010. OWNERS MAY CONTACT BRAUN AT 1-800-488-0359.
05V287000 · Parking Brake
Jun 20, 2005
CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' TO MEET THE STANDARD, THE VEHICLE MUST NOT MOVE FOR FIVE MINUTES WHEN STOPPED ON A STEEP HILL WITH THE PARKING BRAKE APPLIED AND THE VEHICLE IN NEUTRAL (N). SOME OF THESE VEHICLES FAILED THIS TEST.
Consequence & remedy
Consequence: WHEN THE PARKING BRAKE IS RELEASED, THE DRIVER MAY NOTICE UNINTENDED BRAKING WHEN ACCELERATING, DECELERATING, OR COASTING, AND A NOISE COMING FROM THE REAR OF THE VEHICLE. UNINTENDED VEHICLE MOVEMENT COULD OCCUR INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT FOR PARKING BRAKE LEVER SLIPPAGE AT EACH REAR BRAKE CALIPER AND REPLACE THE CALIPER IF LEVER SLIPPAGE IS IDENTIFIED. THE RECALL BEGAN ON NOVEMBER 14, 2005. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR SATURN AT 1-800-972-8876.
05V061000 · Seats:mid/rear Assembly
Feb 18, 2005
ON CERTAIN MINIVANS, THE OUTBOARD RELEASE HANDLE ON THE IMPACT-SIDE SECOND-ROW BUCKET SEAT MAY BE ACTUATED AND THE REAR LATCHES MAY UNLATCH EARLY IN A SIDE IMPACT CRASH. THIS WAS DISCOVERED IN A SIDE IMPACT TEST RUN BY GM, UNDER CONDITIONS SIMILAR TO NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) SIDE IMPACT TEST.
Consequence & remedy
Consequence: IF THE REAR LATCHES OF THE SEAT RELEASE EARLY IN A SEVERE SIDE IMPACT, THE FRONT OUTBOARD LATCH MAY DISENGAGE AND INCREASE THE POTENTIAL FOR INJURY TO THE OCCUPANT OF THE SEAT.
Remedy: DEALERS WILL REMOVE THE SEAT LATCH RELEASE HANDLE AND INSTALL A BLACK PLASTIC CAP OVER THE EXPOSED METAL STUD TO ELIMINATE THE SIDE IMPACT SAFETY CONCERN FREE OF CHARGE. THE RECALL BEGAN ON APRIL 5, 2005. OWNERS MAY CONTACT SATURN AT 1-800-972-8876, CHEVROLET AT 1-800-630-2438, AND PONTIAC AT 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA07019 · Power Sliding Door
Opened Dec 11, 2007 · Closed Feb 23, 2009
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
PE07044 · Power Sliding Door Opening
Opened Aug 16, 2007 · Closed Dec 11, 2007
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
PE05063 · Electrical Harness Damage
Opened Nov 29, 2005 · Closed Mar 6, 2006
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Electrical System:wiring:front Underhood
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Electrical System:wiring:fuses And Circuit Breakers
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.