IllustrationTHE DASHBOARD ON MY VEHICLE IS CRACKING. THIS IS A POTENTIAL SAFETY HAZARD BECAUSE IF THE AIRBAGS DEPLOY THE DASH MAY BREAK COMPLETELY AND SHARDS OF PLASTIC MAY HURT MY FAMILY.
2007 Chevrolet Suburban
Owner reports · Recalls · Investigations
More warning signs than most Suburban years
Owner complaints for the 2007 Chevrolet Suburban are substantially higher than the model-year median of 118.
About this comparison →How this year compares
Owner complaints by model year
Compare all Suburban years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
80–25K
1925–50K
2950–75K
2775–100K
26100–150K
32150K+
141 reports with mileage · 151 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 146 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 42 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports6 fire reports21 injury reports
Unknown Or Other complaints
38 reportsTHE DASHBOARD IS CRACKED ON BOTH THE PASSENGER AND DRIVER SIDE. THE CRACK ON THE PASSENGER SIDE IS CONCERNING BECAUSE IF THE AIRBAG DEPLOYS THE DASHBOARD US GOING WITH IT AND WHO EVER IS ON THAT SIDE WILL BE HIT WITH THE PIECES.
MY 07 CHEVY SUBURBAN HAS MULTIPLE CRACKS ON THE DASHBOARD. THE CRACKS ARE NEAR THE AIR BAG AND CLOSE TO THE DRIVER'S SIDE OF THE VEHICLE. THE DASHBOARD RATTLES AND I AM CONCERNED THAT AN AIR BAG DEPLOYMENT WILL CONSIST OF SHRAPNEL FROM THE DASHBOARD AS WELL. ALSO, FURTHER CRACKING OF THE DASHBOARD COULD POSSIBLY CAUSE THE DAS…
Read full complaint
MY 07 CHEVY SUBURBAN HAS MULTIPLE CRACKS ON THE DASHBOARD. THE CRACKS ARE NEAR THE AIR BAG AND CLOSE TO THE DRIVER'S SIDE OF THE VEHICLE. THE DASHBOARD RATTLES AND I AM CONCERNED THAT AN AIR BAG DEPLOYMENT WILL CONSIST OF SHRAPNEL FROM THE DASHBOARD AS WELL. ALSO, FURTHER CRACKING OF THE DASHBOARD COULD POSSIBLY CAUSE THE DASHBOARD TO CAVE IN ALL TOGETHER WHILE DRIVING. THESE CRACKS HAVE BEEN REPORTED BY NUMEROUS GM CUSTOMERS, SO THIS IS OBVIOUSLY A SAFETY CONCERN THAT IS IN NEED OF AN INVESTIGATION AND RECALL ACTION FROM GM. THANKS
THE FIRST ISSUE WAS THE DASHBOARD CRAKING IN NUMEROUS SPOTS AND CHEVY DID FINALY REPLACE THE ENTIRE DASH. THE NEXT ISSUE WAS THE PAINT ON THE "WHITE EXTERIOR" BEGAIN CHIPPING OFF IN LARGE 4-7 INCH PARTS ALL OVER THE SUV. THE DEALER FORCED ME TO PAY HALF OR THE PARTIAL REPAINT .1000. :( TAKATA RECALL IS THE LATEST. I WONDER HOW …
Read full complaint
THE FIRST ISSUE WAS THE DASHBOARD CRAKING IN NUMEROUS SPOTS AND CHEVY DID FINALY REPLACE THE ENTIRE DASH. THE NEXT ISSUE WAS THE PAINT ON THE "WHITE EXTERIOR" BEGAIN CHIPPING OFF IN LARGE 4-7 INCH PARTS ALL OVER THE SUV. THE DEALER FORCED ME TO PAY HALF OR THE PARTIAL REPAINT .1000. :( TAKATA RECALL IS THE LATEST. I WONDER HOW AMERICA CAN BE GREAT AGAIN WITH THIS LEVEL OF QUALITY. SO SAD.
I HAVE SEVERAL CRACKS THROUGHOUT MY DASH AND AM CONCERNED THAT I WILL HAVE ADDITIONAL DANGEROUS SHARP PLASTIC FRAGMENTS IN ADDITION TO METAL FRAGMENTS FROM THE OPEN AIR BAG RECALL. THIS HAS BEEN A KNOWN PROBLEM GM HAS FAILED TO ADDRESS. IN ADDITION, I ALSO HAVE A PROBLEM WITH ENGINE TEMPS HEATING UP TO WHERE THE AC GOES INTO FAI…
Read full complaint
I HAVE SEVERAL CRACKS THROUGHOUT MY DASH AND AM CONCERNED THAT I WILL HAVE ADDITIONAL DANGEROUS SHARP PLASTIC FRAGMENTS IN ADDITION TO METAL FRAGMENTS FROM THE OPEN AIR BAG RECALL. THIS HAS BEEN A KNOWN PROBLEM GM HAS FAILED TO ADDRESS. IN ADDITION, I ALSO HAVE A PROBLEM WITH ENGINE TEMPS HEATING UP TO WHERE THE AC GOES INTO FAIL SAFE THAT GM SAYS THEY CANNOT FIX EVEN AT MY EXPENSE. AFTER ABOUT 10-15 MINUTES RUNNING IN IDLE TO LAUNCH MY BOAT I CAME BACK TO FIND MY CHILDREN DIAPHORETIC IN THEIR CAR SEATS AND HAD TO USE MY SKILLS AS A PARAMEDIC TO COOL THEM DOWN DUE TO THE EXTREME TEMPERATURE IN THE VEHICLE. I CANNOT EVEN SIT IN DRIVE FOR A FEW MINUTES PICKING UP THE CHILDREN WITHOUT THIS HAPPENING. I PUT A TEMPORARY FIX ON WITH AN AFTERMARKET ELECTRIC FAN AFTER REPLACING THE FAN CLUTCH AND WHOLE COOLING SYSTEM IN THE VEHICLE, PLUS 3 AC COMPRESSORS NOW TO BUY ME A FEW MORE MINUTES. GM DOES NOT CARE ABOUT THE SAFETY OF THEIR CUSTOMERS. I NOW ONLY USE THE VEHICLE IN THE WINTER WHEN THE CHILDREN ARE WITH ME FOR THEIR SAFETY.
DASH CRACKED WHILE STILL UNDER WARRANTY, I HAD IT REPLACED ONCE AND IT CRACKED AGAIN. IT HAS JUST GOTTEN WORSE OVER THE YEARS. IT NOW HAS MULTIPLE CRACKS ALL OVER THE DASH AND RATTLES WHEN YOU DRIVE DOWN THE STREET. NOT ONLY DOES IT POSE A SAFETY CONCERN BUT S ONE OF THE MOST ANNOYING THINGS EVER.
THE DASHBOARD AROUND THE AIRBAG HAS CRACKED IN MULTIPLE PLACES. THIS IS ALARMING AS THE INTEGRITY OF THE DASH/ AIR BAG IS NOW AT RISK. SHOULD THESES AIRBAGS DEPLOY I AM AFRAID THE PLASTIC WILL HIT MYSELF OR WORSE MY WIFE AND FAMILY.
THE DASHBOARD ON OUR 2007 CHEVROLET SUBURBAN HAS CRACKED FOR THE 2ND TIME. THE FIRST TIME THE DEALERSHIP EAGERLY REPLACED THAT DASHBOARD AFTER ABOUT 2 YRS. NOW 165,000 MILES LATER THE DASHBOARD IS CRACKED AGAIN (CRACKED ABOUT 2 YRS AGO) IN MULTIPLE PLACES AND NO ONE WANTS TO TAKE RESPONSIBLITY FOR THIS POTENTIALLY SERIOUS SAFE…
Read full complaint
THE DASHBOARD ON OUR 2007 CHEVROLET SUBURBAN HAS CRACKED FOR THE 2ND TIME. THE FIRST TIME THE DEALERSHIP EAGERLY REPLACED THAT DASHBOARD AFTER ABOUT 2 YRS. NOW 165,000 MILES LATER THE DASHBOARD IS CRACKED AGAIN (CRACKED ABOUT 2 YRS AGO) IN MULTIPLE PLACES AND NO ONE WANTS TO TAKE RESPONSIBLITY FOR THIS POTENTIALLY SERIOUS SAFETY CONCERN. I THINK IT IS SAD THAT WE COULD END UP LIKE THE AIRBAG RECALL WHERE IT IS TOO LATE BEFORE SOMETHING WILL BE DONE. WE HAVE KEPT THIS SUBURBAN BECAUSE IT RUNS GOOD AND IT HAS PROVIDED A SAFE MEANS OF TRANSPORTAION FOR OUR 3 TEENAGE BOY DRIVERS UP TO THIS POINT. IT HAS NOT BEEN INVOLVED IN ANY ACCIDENTS AT THIS TIME BUT WE DON'T WANT TO FIND OUT WHAT PARTS GO FLYING IF THERE IS AN ACCIDENT. CHEVROLET NEEDS TO OWN UP TO THIS PROBLEM AND AGREE TO FIX IT NO MATTER WHAT THE MILEAGE-IT WAS ALEADY REPLACED ONCE SO OBVIOUSLY IT'S NOT OWNER NEGLECT!
I PURCHASED MY CHEVY SUBURBAN AND NOTICE A SMALL CRACK ON MY DASHBOARD. AFTER ONLY A FEW MONTHS AFTER PURCHASED I NOTICE THE SAME CRACK ON MY DASHBOARD EXTENDING TOWARD THE AIRBAG AND DOWN TO THE INSTRUMENT PANEL . I AM CONCERN DUE TO IT MAY AFFECT THE AIRBAGS PERFORMANCE. IF SOMEONE CAN PLEASE LOOK INTO THIS MATTER. I WOULD AP…
Read full complaint
I PURCHASED MY CHEVY SUBURBAN AND NOTICE A SMALL CRACK ON MY DASHBOARD. AFTER ONLY A FEW MONTHS AFTER PURCHASED I NOTICE THE SAME CRACK ON MY DASHBOARD EXTENDING TOWARD THE AIRBAG AND DOWN TO THE INSTRUMENT PANEL . I AM CONCERN DUE TO IT MAY AFFECT THE AIRBAGS PERFORMANCE. IF SOMEONE CAN PLEASE LOOK INTO THIS MATTER. I WOULD APPRECIATE IT. BEST, CARINA
CRACKED DASH ABOVE THE INSTRUMENT PANEL AND AT THE TOP OF THE PASSENGER AIRBAG COMPARTMENT. FRONT IMPACT COLLISION COULD CAUSE PIECES OF DASH TO PUNCTURE AIRBAG OR INJURE PASSENGERS.
Official recalls
421V050000 · Air Bags:frontal:passenger Side:inflator Module
Feb 5, 2021
General Motors, LLC (GM) is recalling certain 2007-2011 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL, and 2009-2011 Chevrolet Silverado 2500, Silverado 3500, GMC Sierra 2500 and Sierra 3500 vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, GM is recalling certain 2007-2008 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 22, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on March 1, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328760.
21V052000 · Air Bags:frontal:passenger Side:inflator Module
Feb 5, 2021
General Motors, LLC (GM) is recalling certain 2009 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500, Sierra 3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Additionally, GM is recalling certain 2007-2008 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 23, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on September 20, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020, Cadillac customer service at 1-800-458-8006, and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328780.
10V240000 · Electrical System
Jun 4, 2010
GM IS RECALLING CERTAIN MODEL YEAR 2006-2009 BUICK, LUCERNE; CADILLAC DTS; HUMMER H2; MODEL YEAR 2008-2009 BUICK ENCLAVE; CADILLAC CTS; MODEL YEAR 2007-2009 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL; SATURN OUTLOOK; AND MODEL YEAR 2009 CHEVROLET TRAVERSE VEHICLES EQUIPPED WITH A HEATED WASHER FLUID SYSTEM (HWFS). A RECALL WAS IMPLEMENTED IN 2008 TO ADD A FUSE TO THE CONTROL CIRCUIT HARNESS TO ADDRESS THE POTENTIAL CONSEQUENCES OF A PRINTED CIRCUIT BOARD (PCB) ELECTRICAL SHORT. HOWEVER, THERE HAVE BEEN NEW REPORTS OF THERMAL INCIDENTS ON HWFS MODULES AFTER THIS IMPROVEMENT WAS INSTALLED. THESE INCIDENTS RESULTED FROM A NEW FAILURE MODE ATTRIBUTED TO THE DEVICE'S THERMAL PROTECTION FEATURE. THE SIGNIFICANCE VARIES FROM MINOR DISTORTION TO CONSIDERABLE MELTING OF THE PLASTIC AROUND THE HWFS FLUID CHAMBER.
Consequence & remedy
Consequence: IT IS POSSIBLE FOR THE HEATED WASHER MODULE TO IGNITE AND A FIRE MAY OCCUR.
Remedy: DEALERS WILL PERMANENTLY DISABLE AND REMOVE THE HEATED WASHER FLUID MODULE. AN UPDATED PAGE FOR THE OWNER MANUAL WILL BE PROVIDED AND INSERTED IN THE OWNER MANUAL TO DOCUMENT THAT THE FEATURE HAS BEEN PERMANENTLY DISABLED AND REMOVED FROM THE VEHICLE. THE SAFETY RECALL BEGAN ON JUNE 11, 2010. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876, GMC AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
08V441000 · Electrical System
Aug 28, 2008
GM IS RECALLING 857,735 MY 2006-2008 BUICK LUCERNE; CADILLAC DTS; HUMMER H2; MY 2007-2008 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL, SATURN OUTLOOK; AND MY 2008 BUICK ENCLAVE VEHICLES EQUIPPED WITH A HEATED WIPER WASHER FLUID SYSTEM. A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WASHER FLUID HEATER MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE.
Consequence & remedy
Consequence: THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR, OR CAUSE SMOKE INCREASING THE RISK OF A FIRE.
Remedy: DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 12, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CADILLAC AT 1-800-982-2339 OR HTTP://WWW.CADILLAC.COM; CHEVROLET AT 1-800-630-2438; SATURN AT 1-800-972-8876 OR HTTP://WWW.SATURN.COM, GMC AT 1-866-996-9436; OR HUMMER AT 1-800-732-5493; OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.