Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
110–25K
725–50K
2250–75K
2275–100K
22100–150K
11150K+
95 reports with mileage · 34 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports1 fire reports3 injury reports
What owners actually said
129 reports
Mileage unknown · Mar 24, 2023
Service Brakes
The vehicle was idle for about 4 months. I took it to a carwash to clean the dust off. Upon returning (abt a 2 mile trip) the brakes failed and steam was coming out from under the hood. I opened the hood and brake fluid was sprayed all over the driver's side of the engine and wheel well. A brake line had rusted through and burst…
Read full complaint
The vehicle was idle for about 4 months. I took it to a carwash to clean the dust off. Upon returning (abt a 2 mile trip) the brakes failed and steam was coming out from under the hood. I opened the hood and brake fluid was sprayed all over the driver's side of the engine and wheel well. A brake line had rusted through and burst. Fortunately, I made it home carefully because I had noticed the brakes were soft.
NHTSA ODI #11513528
Mileage unknown · Mar 19, 2023
SteeringSuspension
This vehicle has less than 84,000 miles on it, and the chassis or frame is rotted. The rear anti sway bar already rotted off it, and the front bar is hanging down on the passenger side. I have photos of this, but don't know how to download them. The body has a little rot here, and there, but that is repairable. I spent a lot o…
Read full complaint
This vehicle has less than 84,000 miles on it, and the chassis or frame is rotted. The rear anti sway bar already rotted off it, and the front bar is hanging down on the passenger side. I have photos of this, but don't know how to download them. The body has a little rot here, and there, but that is repairable. I spent a lot of money in purchasing this vehicle, and I expected it to last a very long time. The interior is almost like new. I am thinking about putting a tort claim about this to GM. Please help me all you can. I forgot to write that I also spent extra money for it to be undercoated, and it is supposed to be a lifetime warranty. I called that company, and they said it was only for 10 years. When I buy a new vehicle, I expect it to last.
NHTSA ODI #11512604
Mileage unknown · Jan 22, 2023
Air Bags
Air bag sensors went out making air bag inoperable.
NHTSA ODI #11503051
Mileage unknown · Oct 25, 2022
Electrical System
This defect pertains to gear indicator on the instrument panel. During the daylight hours the light indicating the gear the car is in (park, neutral, drive, etc.) is impossible to read. At night you can just barely read the gear indicators. The dimness of the lights behind this gear indicator gauge is a safety hazard because …
Read full complaint
This defect pertains to gear indicator on the instrument panel. During the daylight hours the light indicating the gear the car is in (park, neutral, drive, etc.) is impossible to read. At night you can just barely read the gear indicators. The dimness of the lights behind this gear indicator gauge is a safety hazard because you cannot tell what gear you are in during the day. It is an expensive repair because the instrument panel needs to be removed to fix the problem.
NHTSA ODI #11490846
Mileage unknown · Oct 25, 2022
Vehicle Speed Control
Speedometer stops working intermittently. This is a safety hazard as the operator cannot tell the speed that the vehicle is operating. It seems to occur randomly.
NHTSA ODI #11490845
84,000 miles · Sep 7, 2022
Structure
The contact owns a 2005 Chevrolet Suburban. The contact stated upon taking the vehicle to an independent mechanic for tire replacement, he was informed that the entire chassis was severely corroded. The dealer was notified of the failure and referred the contact to the manufacturer for assistance. The manufacturer was notified o…
Read full complaint
The contact owns a 2005 Chevrolet Suburban. The contact stated upon taking the vehicle to an independent mechanic for tire replacement, he was informed that the entire chassis was severely corroded. The dealer was notified of the failure and referred the contact to the manufacturer for assistance. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline. The vehicle was not diagnosed or repaired. The failure mileage was approximately 84,000.
NHTSA ODI #11483289
Mileage unknown · Jun 15, 2022
Electrical SystemExterior LightingSeats
Started with driver side heated seat randomly turning on and off. Going from high, medium, low. No way to turn it off just comes back on. Can hear clicking coming from under dash. Lift gate wiring that goes into body, ground wire burnt. (Replaced) but ground wire has power. (Wiring issue) so rear wiper doesn’t work. “Reading” La…
Read full complaint
Started with driver side heated seat randomly turning on and off. Going from high, medium, low. No way to turn it off just comes back on. Can hear clicking coming from under dash. Lift gate wiring that goes into body, ground wire burnt. (Replaced) but ground wire has power. (Wiring issue) so rear wiper doesn’t work. “Reading” Lamps only work when door is open. After replacing life gate connector, says lift gate open. Started the repair, which leads to more wiring issues! Needs a recall! Unsafe
NHTSA ODI #11469495
Mileage unknown · Jun 30, 2021
Vehicle Speed Control
The speedometer issue started 1 year ago, the speedometer shows needle stuck on 0 or all the way down to right side. Now issues with the gas gauge and oil gauge are happening also Mechanic has checked on this and stated that replacement needed.
NHTSA ODI #11422993
Mileage unknown · Jun 29, 2021
Electrical System
Heated seats randomly turn on and off and goes thorugh the diffeent levels of heat and then off and then back on repeat for hours while driving and is very distracting as have to turn off every 10 sec and have almost crashed multiple times taking me eyes off the road but have to turn off as heat is too much in summer months, thi…
Read full complaint
Heated seats randomly turn on and off and goes thorugh the diffeent levels of heat and then off and then back on repeat for hours while driving and is very distracting as have to turn off every 10 sec and have almost crashed multiple times taking me eyes off the road but have to turn off as heat is too much in summer months, this is a known issue in almost ever suburban 01 to 05, how is this not a recall yet, there is massive amount of documentation of this issue online.
NHTSA ODI #11422855
Mileage unknown · May 17, 2021
Power Train
Gear status indicator does not display selected gear.
ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Consequence & remedy
Consequence: IF THE DAMPER COMES LOOSE, A FUEL LEAK MAY RESULT. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC TRUCKS AT 1-866-996-9463.
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence & remedy
Consequence: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
ON CERTAIN SPORT UTILITY VEHICLES, THE BRAKE PEDAL PUSHROD RETAINER MAY BE MISSING. IF THE RETAINER IS MISSING, THE BRAKE BOOSTER PUSHROD COULD DISENGAGE FROM THE BRAKE PEDAL.
Consequence & remedy
Consequence: THIS COULD RESULT IN A LOSS OF BRAKES WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT THE VEHICLES FOR THE BRAKE PEDAL PUSHROD RETAINER AND INSTALL ONE IF IT IS MISSING FREE OF CHARGE. THE MANUFACTURER BEGAN CONTACTING OWNERS BY TELEPHONE ON MARCH 10, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK AND TRANSMISSION BRAKING EFFECT." UNDER CERTAIN VEHICLE STARTING CONDITIONS, THE SHIFT LEVER POSITION INDICATOR LOCATED IN THE INSTRUMENT PANEL CLUSTER MAY NOT ILLUMINATE. IF THE SHIFT LEVER POSITION INDICATOR DOES NOT ILLUMINATE, THE DRIVER MAY NOT KNOW WHICH GEAR THE VEHICLE IS IN.
Consequence & remedy
Consequence: THE VEHICLE MAY MOVE IN AN UNINTENDED DIRECTION RESULTING IN POSSIBLE INJURY TO OTHERS OUTSIDE OF THE VEHICLE.
Remedy: DEALERS WILL REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 14, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, AND GMC AT 1-866-996-9463.
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH 5.3L (RPO L59) V8 ENGINES, THE ENGINE FUEL RAIL CROSSOVER TUBE RETAINER SCREWS WERE NOT MANUFACTURED TO SPECIFICATIONS AND MAY BREAK.
Consequence & remedy
Consequence: IF THE TUBE RETAINER SCREW BREAKS, FUEL COULD LEAK FROM THE FUEL RAIL CROSSOVER JOINT, THE ENGINE MAY STALL AND, IF AN IGNITION SOURCE WERE PRESENT, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE FUEL RAIL CROSSOVER TUBE AND, IF NECESSARY, REPLACE THE RETAINER SCREWS. OWNERS WERE NOTIFIED BY TELEPHONE ON JULY 30, 2004, WITH A FOLLOWUP OWNER LETTER BEGAN AUGUST 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463. NOTE: THE GM BULLETIN LISTS THE TAHOE AND YUKON MODELS BECAUSE CANADIAN VEHICLES ARE INCLUDED IN THE BULLETIN. NO U.S. TAHOE OR YUKON VEHICLES ARE INCLUDED IN THE U.S. CAMPAIGN.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2005 Chevrolet Suburban Problems, Complaints & Recalls | Skip That Year
Illustration