IllustrationSINCE NEW THE VEHICLE HAS EXHIBITED ERRATIC SHIFTING DURING ACCELERATION. OFTEN THE VEHICLE ACCELERATES BRIEFLY WHEN BRAKES APPLIED. TRANSMISSION FAILED WHILE ON VACATION AT 78,000 MILES.
1999 Chevrolet Suburban
Owner reports · Recalls · Investigations
More warning signs than most Suburban years
Owner complaints for the 1999 Chevrolet Suburban are substantially higher than the model-year median of 118.
About this comparison →How this year compares
Owner complaints by model year
Compare all Suburban years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
60–25K
2925–50K
5450–75K
4975–100K
56100–150K
22150K+
216 reports with mileage · 418 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 223 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Tires. Review the 92 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 58 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
51 crash reports12 fire reports30 injury reports
Power Train complaints
47 reportsREAR AXLE HAS BEEN REPLACED A COUPLE OF TIMES DUE TO THE AXLE LEAKING FLUIDS. CONTACTED DEALER, AND THE DEALER WAS NOT WILLING TO DO ANYTHING.*AK
WE PURCHASED THE VECHICLE USED FROM THE DEALER LISTED. VEHICLE HAS BEEN IN FOR BRAKE PROBLEMS WHEN WHEELS ARE WET THEY SHUTTER AND LOCK UP. THE BATTERY CRACKED AND LEAKED ALL OVER THE BATTERY TRAY AND BRAKE LINES AND OTHER FRAME COMPONETS. THE REAR DOOR DOME LIGHT SWITCH SHORTED OUT. THE FRONT END HAS BEEN ALIGNED SEVERAL TIMES …
Read full complaint
WE PURCHASED THE VECHICLE USED FROM THE DEALER LISTED. VEHICLE HAS BEEN IN FOR BRAKE PROBLEMS WHEN WHEELS ARE WET THEY SHUTTER AND LOCK UP. THE BATTERY CRACKED AND LEAKED ALL OVER THE BATTERY TRAY AND BRAKE LINES AND OTHER FRAME COMPONETS. THE REAR DOOR DOME LIGHT SWITCH SHORTED OUT. THE FRONT END HAS BEEN ALIGNED SEVERAL TIMES FOR THE WHEELS PULLING TO THE LEFT. THE A/C AIR BARLY COMES OUT OF THE FRONT DASH VENTS. THE REAR END IS POSITIVE TRACTION AND WHEN MAKING A TURN IT MAKES A POPIING NOISE.
THE PLANETARY GEARS FAILED IN THE TRANSMISSION WHILE DRIVING IN NORMAL CONDITIONS WITH NO LOAD. THE VEHICLE HAD BEEN REPORTED TO THE MANUFACTURES DEALER WHILE UNDER WARRANTY AS HAVING A VIOLENT HARD SHIFT AFTER KICKDOWN TO PASS ANOTHER VEHCILE. THE SOLUTION OFFERED BY THE DEALER WAS TO DISCONNECT THE BATTERY AND RESET THE COMPUT…
Read full complaint
THE PLANETARY GEARS FAILED IN THE TRANSMISSION WHILE DRIVING IN NORMAL CONDITIONS WITH NO LOAD. THE VEHICLE HAD BEEN REPORTED TO THE MANUFACTURES DEALER WHILE UNDER WARRANTY AS HAVING A VIOLENT HARD SHIFT AFTER KICKDOWN TO PASS ANOTHER VEHCILE. THE SOLUTION OFFERED BY THE DEALER WAS TO DISCONNECT THE BATTERY AND RESET THE COMPUTER. THIS REMOVED THE INITIAL PROBLEM FOR SOME TIME AND THEN THE SHIFTING OF THE TRANSMISSION FROM 1ST TO 2ND WAS VERY HARD AND JERKY. THE DEALER WOULD DO NOTHING ABOUT IT . TRICOUNTY TRANSMISSION SHOWED ME NUMEROUS PARTS FROM OTHER SUBURBANS AND TAHOES WHICH HAVE THE SAME ORIGINAL MANUFACTURER FAILURE. GM WILL NOT ACCEPT RESPONSIBILTY FOR THIS AS THEY NEVER DO. THEY HAVE A LATENT DEFECT IN THE HARDINESS OF THE GEAR INSIDE THE TRANSMISSION WHICH CAUSES TEETH FAILURE OF THE PLANETARY GEARS. THIS COULD CAUSE AN ACCIDENT IF I HAD BEEN DRIVING IN ATLANTA I-285 AND THE GEARS HAD FAILED IN TRAFFIC. THE TRANSMISSION SHOP SAID THIS SAME PROBLEMS APPLIES TO ALL 1998 THRU 2002 TRANSMISSIONS FOR THE CHEVY SUBURBANS AND TAHOES. CAN YOU PROVIDE ME WITH INFORMATION ON THIS MATTER. THANKS.*AK
REVERSE GEAR DROPPED OUT OF DRIVETRAIN. FUEL PUMP FAILED WHEN ATTEMPTING TO START PARKED VEHICLE. *AK
THE TRANSMISSION SHIFTED VERY HARD INTO 2ND GEAR. WHEN I CAME TO A STOP AND WENT TO GO THE VEHICLE WOULD NOT SHIFT INTO SECOND GEAR. IT WOULD PRCEED INTO THIRD GEAR AFTER THE ENGINE WOULD REV UP TO A HIGHER RPM. I CONTACTED SEVERAL TRANSMISSION SHOPS AND A DEALERSHIP. THEY ALL SAID THAT I LOST THE 2ND/4TH GEAR INTEMEDIATE SHAFT …
Read full complaint
THE TRANSMISSION SHIFTED VERY HARD INTO 2ND GEAR. WHEN I CAME TO A STOP AND WENT TO GO THE VEHICLE WOULD NOT SHIFT INTO SECOND GEAR. IT WOULD PRCEED INTO THIRD GEAR AFTER THE ENGINE WOULD REV UP TO A HIGHER RPM. I CONTACTED SEVERAL TRANSMISSION SHOPS AND A DEALERSHIP. THEY ALL SAID THAT I LOST THE 2ND/4TH GEAR INTEMEDIATE SHAFT WHICH ALSO INCLUDED THE REVERSE GEAR ALSO. THIS IS ON A 700R4 TRANSMISSON. THEY ALL SAID GM KNEW ABOUT THE PROBLEM BUT WOULD NOT DO A RECALL ON THAT MODEL YEAR BECAUSE OF THE EXTENIVE USE OF THAT TRANMISSION IN ALL OF THEIR VEHICLES . THEY SAID THAT ALMOST ALL OF THE TRANSMISSION HAD THE FAULTY INTERMEDIATE SHAFT. THIS COULD CAUSE A SERIOUS PROBLEM FOR SOME VEHICLE OWNERS IF THE TRANSMISSION FAILED AT AN INOPPORTUNE TIME, ESPECIALLY IN AN EMERGENCY THAT THEY HAD TO REVERSE QUICKLY. I HAD THE TRANSMISSION REPLACED AT A LOCAL SHOP AT A VERY HIGH EXPENSE. I THOUGHT I WOULD SUBMIT THIS DUE TO THE AMOUNT OF VEHICLES THAT USED THIS TRANSMISSIONIN THAT YEAR AND FOR THE SAFETY OF THE OWNERS.*AK
ON SATURDAY, JANUARY 26, WHILE DRIVING, THE REAR AXLE SEPARATED FROM THE SUBURBAN. THE WHEEL WAS DRUG 306 BEFORE COMING TO A STOP. THERE WAS NO WARNING THAT FAILURE WAS IMMANENT. I PURCHASED THE NEW SUBURBAN FROM LES MARKS 8/30/99. THE SUBURBAN WAS SERVICED ONLY AT LES MARKS. ON 1/30/01 THE SUBURBAN WAS REPAIRED AT LES MAR…
Read full complaint
ON SATURDAY, JANUARY 26, WHILE DRIVING, THE REAR AXLE SEPARATED FROM THE SUBURBAN. THE WHEEL WAS DRUG 306 BEFORE COMING TO A STOP. THERE WAS NO WARNING THAT FAILURE WAS IMMANENT. I PURCHASED THE NEW SUBURBAN FROM LES MARKS 8/30/99. THE SUBURBAN WAS SERVICED ONLY AT LES MARKS. ON 1/30/01 THE SUBURBAN WAS REPAIRED AT LES MARKS FOR A THUMPING NOISE IN THE REAR END. THE LES MARKS SERVICE DEPARTMENT REPLACED THE CASE, SIDE GEARS AND FLUSHED THE HOUSING.*AK
BRAKES SQUEAL, THE MASTER CYLINDER WAS REPLACED WHICH HELPED FOR A SHORT PERIOD OF TIME, AND THE PROBLEM HAS REOCCURED, THE BRAKES STOP SUDDENLY JUST ABOUT THROWING THE PASSENGERS THROUGH THE WINDSHIELD, DEALER INFORMED CONSUMER THAT MUD AND DIRT ARE CAUSING THE PROBLEM AND CAN NOT SEEM TO KEEP IT REPAIRED.*JB
FRIDAY JUNE 6, 2001 MY WIFE AND FIVE KIDS LEFT FROM HUNTSVILLE, AL TO GO TO PENSACOLA, FL FOR THE WEEKEND, THEY GOT ABOUT 250 MILES AND THE REAR END BLEW OUT ON OUR 1999 CHEVY SUBURBAN LT K1500. THE WAS A "KLUNK" AS SHE WAS TRAVELLING 70MPH ON I-65. THERE WAS A DEALERSHIP IN SIGHT, SO I HAD IT TOWED THERE, AND THE FOLLOWING MOND…
Read full complaint
FRIDAY JUNE 6, 2001 MY WIFE AND FIVE KIDS LEFT FROM HUNTSVILLE, AL TO GO TO PENSACOLA, FL FOR THE WEEKEND, THEY GOT ABOUT 250 MILES AND THE REAR END BLEW OUT ON OUR 1999 CHEVY SUBURBAN LT K1500. THE WAS A "KLUNK" AS SHE WAS TRAVELLING 70MPH ON I-65. THERE WAS A DEALERSHIP IN SIGHT, SO I HAD IT TOWED THERE, AND THE FOLLOWING MONDAY I CALLED TO GET AN ESTIMATE. I WAS TOLD THE REAR END HOUSING HAD A HOLE BLOWN THROUGH IT. THEY WANTED TO CHARGE ME $1,900 FOR A USED REAR END, AND $250 FOR LABOR. THE LABOR SOUNDED REASONABLE, BUT THE $1,900 WAS OUTRAGEOUS. I CONTACTED THE CHEVY DEALER IN PENSACOLA AND LOCATED A USED REAR END WITH A 12 MONTH PARTS AND LABOR WARRANTY FOR $1,200, SO I CALLED A FLAT BED WRECKER AND PAID $220 TO HAVE TOWED TO PENSACOLA FOR REPAIR. I CALLED CHEVY CUSTOMER SERVICE AND FILED A COMPLAINT AGAINST THE GREENVILLE DEALER AND ON THE VEHICLE ITSELF (FILE #C04557412). THE FIRST CR I SPOKE WITH TOOK THE INFORMATION, BUT WAS NOT VERY HELPFUL BEYOND THAT. MY OWN MECHANIC WHO REPAIRED THE VEHICLE EXAMINED THE REAR END AND SAID IT LOOKED LIKE THERE WAS NO SEAL OR LEAKAGE PROBLEM BUT THAT SOMETHING INSIDE JUST GAVE OUT AND WENT THROUGH THE HOUSING. WE HAD OWNED A 93, C2500 THAT HAD A PROBLEM WITH THE REAR END SEAL AFTER 140,000 MILES, AND THAT IS A LITTLE MORE UNDERSTANDABLE, BUT 72,000 MILES SEEMS LIKE A VERY PREMATURE DEATH FOR A REAR END TO INCUR AN INTERNAL FAILURE. I CALLED CHEVY CUSTOMER SERVICE BACK AND SPOKE WITH A JUDY FRANCO. I TOLD HER WHAT THE MECHANIC SAID ABOUT THE REAR END AND SHE SAID THEY WOULD LOOK INTO IT FURTHER. SHE REPORTED DOING SOME INVESTIGATING AND SAID THAT THERE WAS NOTHING CHEVY WOULD DO. SHE AND A SERVICE REP IN PENSACOLA SAID THEY DOUBTED THAT CHEVY WOULD DO ANYTHING FOR ME BECAUSE OF THE MILEAGE, AND BECAUSE I DID NOT HAVE IT REPAIRED AT THE DEALERSHIP. ALTHOUGH THE REP IN PENSACOLA TOLD ME THAT IF THE VEHICLE WAS UNDER 60,000 MILES THAT, IT WAS POSSIBLE THAT SOMETHING COULD HAVE BEEN DONE IN THE WAY OF COMPENSATION.*AK
NO SUMMARY LISTED FOR ABOV EVEHICLE. *AK
Official recalls
100V122000 · Seat Belts:front:webbing
Apr 27, 2000
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES. THESE VEHICLES DO NOT COMPLY WITH THE OCCUPANT PROTECTION REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE RIGHT FRONT PASSENGER RESTRAINT SYSTEMS MAY NOT MEET THE NECK EXTENSION REQUIREMENTS.
Remedy: DEALERS WILL INSTALL A TRAY INSERT ON THE TOP OF THE PASSENGER SIDE OF THE INSTRUMENT PANEL. THE TRAY INSERT CORRECTS THE NONCOMPLIANCE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA11001 · Brake Line Corrosion Failure
Opened Jan 5, 2011 · Closed Apr 8, 2015
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and 3500 series pick-up trucks; 2000-2006 Chevrolet Suburban, Chevrolet Tahoe and GMC Yukon sport utility vehicles; and 2002-2006 Cadillac Escalade and Chevrolet Avalanche sport-utility vehicles.General Motors produced a total of approximately 10,427,062 GMT800 vehicles for sales in the United States, including almost 5 million that were sold in salt states.Although there are over 60 different brake pipe routing configuration used in GMT800 vehicles, with the exception of the rear crossover pipes in MY 200x-2007 vehicles that changed from rear disc to drum brakes, all of the vehicles use brake pipes from the same supplier with a common double-wall, brazed steel pipe design with a combination of hot dip Zinc-Aluminum corrosion protection coating and Aluminum paint outer layer known in the industry as AlGal (ASTM-B750). ODI analysis of field data regarding GMT800 vehicles identified a total of 3,645 complaints of brake pipe corrosion failures, including 107 alleging crashes, and 40 injuries.Though only 20% of total GMT800 production, due to age and region the subject vehicles account for a disproportionate share of the failure experience; with 2,702 of the complaints (75%), 88 of the crashes (82%) and 20 of the injuries (50%) reported in those vehicles.Analysis of the complaints showed strong correlations to vehicle age and region.For vehicles with less than 8 years of service, the complaint rates were minimal for all regions.In the salt states the failure rates begin to climb as the vehicles advance in age, particularly in the Northeast corner of the United States.The complaint rates in the salt states go from less than 0.1 incident per thousand vehicles (IPTV) at 7 years in service to over 1.0 IPTV after the 12th year of service for the subject pickup trucks and utility vehicles.Most of the failures reported to ODI occurred in vehicles with more than 10 years in service.ODI?s investigation did not identify any specific defect conditions that were causing or contributing to the brake pipe failures.Nor did the analysis isolate the problem to any subject vehicle sub-populations when analyzed by vehicle type or production range.The investigation found that vehicles experiencing brake pipe corrosion failures were likely to have general patterns of excessive corrosion on the majority of the brake pipe assembly and appear to be occurring due to expected wear out for the brake pipe coating material used in the subject vehicles and the environmental conditions in severe corrosion states.A safety-related defect has not been identified at this time.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor t
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and 3500 series pick-up trucks; 2000-2006 Chevrolet Suburban, Chevrolet Tahoe and GMC Yukon sport utility vehicles; and 2002-2006 Cadillac Escalade and Chevrolet Avalanche sport-utility vehicles.General Motors produced a total of approximately 10,427,062 GMT800 vehicles for sales in the United States, including almost 5 million that were sold in salt states.Although there are over 60 different brake pipe routing configuration used in GMT800 vehicles, with the exception of the rear crossover pipes in MY 200x-2007 vehicles that changed from rear disc to drum brakes, all of the vehicles use brake pipes from the same supplier with a common double-wall, brazed steel pipe design with a combination of hot dip Zinc-Aluminum corrosion protection coating and Aluminum paint outer layer known in the industry as AlGal (ASTM-B750). ODI analysis of field data regarding GMT800 vehicles identified a total of 3,645 complaints of brake pipe corrosion failures, including 107 alleging crashes, and 40 injuries.Though only 20% of total GMT800 production, due to age and region the subject vehicles account for a disproportionate share of the failure experience; with 2,702 of the complaints (75%), 88 of the crashes (82%) and 20 of the injuries (50%) reported in those vehicles.Analysis of the complaints showed strong correlations to vehicle age and region.For vehicles with less than 8 years of service, the complaint rates were minimal for all regions.In the salt states the failure rates begin to climb as the vehicles advance in age, particularly in the Northeast corner of the United States.The complaint rates in the salt states go from less than 0.1 incident per thousand vehicles (IPTV) at 7 years in service to over 1.0 IPTV after the 12th year of service for the subject pickup trucks and utility vehicles.Most of the failures reported to ODI occurred in vehicles with more than 10 years in service.ODI?s investigation did not identify any specific defect conditions that were causing or contributing to the brake pipe failures.Nor did the analysis isolate the problem to any subject vehicle sub-populations when analyzed by vehicle type or production range.The investigation found that vehicles experiencing brake pipe corrosion failures were likely to have general patterns of excessive corrosion on the majority of the brake pipe assembly and appear to be occurring due to expected wear out for the brake pipe coating material used in the subject vehicles and the environmental conditions in severe corrosion states.A safety-related defect has not been identified at this time.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor t
Service Brakes, Hydraulic
On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and 3500 series pick-up trucks; 2000-2006 Chevrolet Suburban, Chevrolet Tahoe and GMC Yukon sport utility vehicles; and 2002-2006 Cadillac Escalade and Chevrolet Avalanche sport-utility vehicles.General Motors produced a total of approximately 10,427,062 GMT800 vehicles for sales in the United States, including almost 5 million that were sold in salt states.Although there are over 60 different brake pipe routing configuration used in GMT800 vehicles, with the exception of the rear crossover pipes in MY 200x-2007 vehicles that changed from rear disc to drum brakes, all of the vehicles use brake pipes from the same supplier with a common double-wall, brazed steel pipe design with a combination of hot dip Zinc-Aluminum corrosion protection coating and Aluminum paint outer layer known in the industry as AlGal (ASTM-B750). ODI analysis of field data regarding GMT800 vehicles identified a total of 3,645 complaints of brake pipe corrosion failures, including 107 alleging crashes, and 40 injuries.Though only 20% of total GMT800 production, due to age and region the subject vehicles account for a disproportionate share of the failure experience; with 2,702 of the complaints (75%), 88 of the crashes (82%) and 20 of the injuries (50%) reported in those vehicles.Analysis of the complaints showed strong correlations to vehicle age and region.For vehicles with less than 8 years of service, the complaint rates were minimal for all regions.In the salt states the failure rates begin to climb as the vehicles advance in age, particularly in the Northeast corner of the United States.The complaint rates in the salt states go from less than 0.1 incident per thousand vehicles (IPTV) at 7 years in service to over 1.0 IPTV after the 12th year of service for the subject pickup trucks and utility vehicles.Most of the failures reported to ODI occurred in vehicles with more than 10 years in service.ODI?s investigation did not identify any specific defect conditions that were causing or contributing to the brake pipe failures.Nor did the analysis isolate the problem to any subject vehicle sub-populations when analyzed by vehicle type or production range.The investigation found that vehicles experiencing brake pipe corrosion failures were likely to have general patterns of excessive corrosion on the majority of the brake pipe assembly and appear to be occurring due to expected wear out for the brake pipe coating material used in the subject vehicles and the environmental conditions in severe corrosion states.A safety-related defect has not been identified at this time.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor t
PE10010 · Brake Line Corrosion Failure
Opened Mar 30, 2010 · Closed Jan 5, 2011
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist:hydraulic:hoses, Lines/piping, And Fittings
The Office of Defects Investigation (ODI) received Defect Petition DP10-003 on March 2, 2010, requesting the investigation of model year (MY) 2003 Chevrolet Silverado 2500HD 4WD pickup trucks for corrosion failures of the vehicle brake lines.DP10-003 was granted and on March 30, 2010, Preliminary Evaluation PE10-010 was opened on more than six million model year 1999 through 2003 light trucks and sport utility vehicles manufactured and sold by General Motors Corporation (GM).On July 2, 2010, ODI received GM's response to an information request, which included GM's assessment of the frequency and safety consequences of the alleged defect. GM stated that:(1) the brake system of the subject vehicles is split front/rear and should a brake pipe suddenly fail for any reason, the affected vehicle would be capable of stopping with the pressure supplied by the remaining circuit; (2) the subject vehicles were designed to meet the hydraulic circuit partial failure requirements of Federal Motor Vehicle Safety Standards 105 and 135, Light Vehicle Brake Systems; and (3) should a brake fluid leak occur for any reason, the brake system malfunction indicator lamp (MIL) would illuminate and warn the driver before the brake fluid level was low enough to cause a loss of line pressure.ODI's and GM's analysis indicates that 85 percent of the complaints occurred on vehicles used primarily in States that use salt on the roads during Winter months (Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin).Overall the complaint rates per 100,000 vehicles for Salt Belt States is 43.0 and Non-Salt Belt is 3.0.In approximately 25 percent of the complaints the brake pipe failure occurred suddenly, with no warning (i.e., no MIL, Brake Fluid Loss Warning), and resulted in extended stopping distances.In 30 of these the increase in stopping distance that resulted was a factor in the crash and in 10 others the vehicle was intentionally steered off the road or into another lane of travel in order to avoid a crash.This investigation has been upgraded to an Engineering Analysis (EA11-001) for subject vehicles sold or currently registered in Salt Belt States to further assess the scope, frequency and safety risks associated with sudden failures of corroded brake pipes that can result in decreased brake effectiveness. ODI will continue to gather information on subject vehicles outside the Salt Belt as well.
Additional source detail variants (2)
Service Brakes, Hydraulic
The Office of Defects Investigation (ODI) received Defect Petition DP10-003 on March 2, 2010, requesting the investigation of model year (MY) 2003 Chevrolet Silverado 2500HD 4WD pickup trucks for corrosion failures of the vehicle brake lines.DP10-003 was granted and on March 30, 2010, Preliminary Evaluation PE10-010 was opened on more than six million model year 1999 through 2003 light trucks and sport utility vehicles manufactured and sold by General Motors Corporation (GM).On July 2, 2010, ODI received GM's response to an information request, which included GM's assessment of the frequency and safety consequences of the alleged defect. GM stated that:(1) the brake system of the subject vehicles is split front/rear and should a brake pipe suddenly fail for any reason, the affected vehicle would be capable of stopping with the pressure supplied by the remaining circuit; (2) the subject vehicles were designed to meet the hydraulic circuit partial failure requirements of Federal Motor Vehicle Safety Standards 105 and 135, Light Vehicle Brake Systems; and (3) should a brake fluid leak occur for any reason, the brake system malfunction indicator lamp (MIL) would illuminate and warn the driver before the brake fluid level was low enough to cause a loss of line pressure.ODI's and GM's analysis indicates that 85 percent of the complaints occurred on vehicles used primarily in States that use salt on the roads during Winter months (Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin).Overall the complaint rates per 100,000 vehicles for Salt Belt States is 43.0 and Non-Salt Belt is 3.0.In approximately 25 percent of the complaints the brake pipe failure occurred suddenly, with no warning (i.e., no MIL, Brake Fluid Loss Warning), and resulted in extended stopping distances.In 30 of these the increase in stopping distance that resulted was a factor in the crash and in 10 others the vehicle was intentionally steered off the road or into another lane of travel in order to avoid a crash.This investigation has been upgraded to an Engineering Analysis (EA11-001) for subject vehicles sold or currently registered in Salt Belt States to further assess the scope, frequency and safety risks associated with sudden failures of corroded brake pipes that can result in decreased brake effectiveness. ODI will continue to gather information on subject vehicles outside the Salt Belt as well.
Service Brakes, Hydraulic:power Assist:hydraulic:hoses, Lines/piping, And Fittings
The Office of Defects Investigation (ODI) received Defect Petition DP10-003 on March 2, 2010, requesting the investigation of model year (MY) 2003 Chevrolet Silverado 2500HD 4WD pickup trucks for corrosion failures of the vehicle brake lines.DP10-003 was granted and on March 30, 2010, Preliminary Evaluation PE10-010 was opened on more than six million model year 1999 through 2003 light trucks and sport utility vehicles manufactured and sold by General Motors Corporation (GM).On July 2, 2010, ODI received GM's response to an information request, which included GM's assessment of the frequency and safety consequences of the alleged defect. GM stated that:(1) the brake system of the subject vehicles is split front/rear and should a brake pipe suddenly fail for any reason, the affected vehicle would be capable of stopping with the pressure supplied by the remaining circuit; (2) the subject vehicles were designed to meet the hydraulic circuit partial failure requirements of Federal Motor Vehicle Safety Standards 105 and 135, Light Vehicle Brake Systems; and (3) should a brake fluid leak occur for any reason, the brake system malfunction indicator lamp (MIL) would illuminate and warn the driver before the brake fluid level was low enough to cause a loss of line pressure.ODI's and GM's analysis indicates that 85 percent of the complaints occurred on vehicles used primarily in States that use salt on the roads during Winter months (Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin).Overall the complaint rates per 100,000 vehicles for Salt Belt States is 43.0 and Non-Salt Belt is 3.0.In approximately 25 percent of the complaints the brake pipe failure occurred suddenly, with no warning (i.e., no MIL, Brake Fluid Loss Warning), and resulted in extended stopping distances.In 30 of these the increase in stopping distance that resulted was a factor in the crash and in 10 others the vehicle was intentionally steered off the road or into another lane of travel in order to avoid a crash.This investigation has been upgraded to an Engineering Analysis (EA11-001) for subject vehicles sold or currently registered in Salt Belt States to further assess the scope, frequency and safety risks associated with sudden failures of corroded brake pipes that can result in decreased brake effectiveness. ODI will continue to gather information on subject vehicles outside the Salt Belt as well.
PE05020 · Unwanted LOW-SPEED Abs Activation
Opened Apr 28, 2005 · Closed Sep 13, 2005
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
IN A LETTER DATED AUGUST 29, 2005, GM NOTIFIED ODI THAT IT WAS RECALLING CERTAIN MODEL YEAR 1999 THROUGH 2002 C/K PICKUP TRUCKS AND SPORT UTILITY VEHICLES TO CORRECT A PROBLEM WITH ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR CORROSION THAT MAY RESULT IN UNWANTED ABS ACTIVATION AND EXTENDED STOPPING DISTANCES DURING LOW-SPEED BRAKING (RECALL 05V-379).GM'S RECALL COVERS APPROXIMATELY 804,000 VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING 14 SALT-BELT STATES:CONNECTICUT, ILLINOIS, INDIANA, MASSACHUSETTS, MAINE, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WEST VIRGINIA.THE RECALL PROCEDURE WILL INVOLVE REMOVING THE SENSOR, CLEANING THE MOUNTING SURFACE, APPLYING A RUST INHIBITOR (ZINC-X) TO THE SURFACE, AND REINSTALLING THE SENSOR.IF NECESSARY, THE SENSOR WILL BE REPLACED. THE POPULATION AND FAILURE REPORT DATA GIVEN IN THIS RESUME ARE FOR THE FULL REGION THAT HAS BEEN CONSIDERED BY ODI AS THE SALT-BELT.THAT INCLUDES DELAWARE, IOWA, MARYLAND, MINNESOTA, MISSOURI, WISCONSIN AND THE DISTRICT OF COLUMBIA IN ADDITION TO THE 14 STATES INCLUDED IN 05V-379.THE STATES COVERED BY GM'S RECALL HAVE THE HIGHEST INCIDENT RATES FOR THE SUBJECT CONDITION, ACCOUNTING FOR 91% OF THE INCIDENTS, BUT ONLY 24% OF SUBJECT VEHICLE SALES IN THE UNITED STATES.ODI'S ANALYSIS DETERMINED THAT 840 OF THE COMPLAINTS, 244 OF THE CRASHES, AND 16 OF THE INJURIES IDENTIFIED IN THIS INVESTIGATION OCCURRED IN THOSE STATES.THE RESULTING INCIDENT AND CRASH RATES ARE 96.2 AND 28.0 PER 100,000 VEHICLES RESPECTIVELY (NOTE:RATES ARE BASED ON VEHICLE SALES, NOT REGISTERED VEHICLES). THE CORRESPONDING NUMBERS IN THE EXCLUDED PORTIONS OF THE SALT-BELT ARE 399,000 VEHICLES, 81 INCIDENTS (20.3 PER 100,000 VEHICLES), 3 CRASHES, AND NO INJURIES.THE STATISTICS IN THE REMAINING 30 STATES ARE 2,406,000 VEHICLES, 168 INCIDENTS (7.0 PER 100,000 VEHICLES), 31 CRASHES, AND ONE INJURY.GM AND ODI ARE CONTINUING TO MONITOR THE PROBLEM EXPERIENCE IN STATES THAT ARE NOT INCLUDED IN THE RECALL.GM WILL PROVIDE ODI WITH UPDATED COMPLAINT, FIELD REPORT, AND WARRANTY DATA IN NOVEMBER 2005.ODI AND GM WILL REVIEW THAT DATA AND ASSESS THE APPROPRIATENESS OF THE CURRENT SCOPE OF THE RECALL AT THAT TIME.
Additional source detail variants (2)
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
IN A LETTER DATED AUGUST 29, 2005, GM NOTIFIED ODI THAT IT WAS RECALLING CERTAIN MODEL YEAR 1999 THROUGH 2002 C/K PICKUP TRUCKS AND SPORT UTILITY VEHICLES TO CORRECT A PROBLEM WITH ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR CORROSION THAT MAY RESULT IN UNWANTED ABS ACTIVATION AND EXTENDED STOPPING DISTANCES DURING LOW-SPEED BRAKING (RECALL 05V-379).GM'S RECALL COVERS APPROXIMATELY 804,000 VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING 14 SALT-BELT STATES:CONNECTICUT, ILLINOIS, INDIANA, MASSACHUSETTS, MAINE, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WEST VIRGINIA.THE RECALL PROCEDURE WILL INVOLVE REMOVING THE SENSOR, CLEANING THE MOUNTING SURFACE, APPLYING A RUST INHIBITOR (ZINC-X) TO THE SURFACE, AND REINSTALLING THE SENSOR.IF NECESSARY, THE SENSOR WILL BE REPLACED. THE POPULATION AND FAILURE REPORT DATA GIVEN IN THIS RESUME ARE FOR THE FULL REGION THAT HAS BEEN CONSIDERED BY ODI AS THE SALT-BELT.THAT INCLUDES DELAWARE, IOWA, MARYLAND, MINNESOTA, MISSOURI, WISCONSIN AND THE DISTRICT OF COLUMBIA IN ADDITION TO THE 14 STATES INCLUDED IN 05V-379.THE STATES COVERED BY GM'S RECALL HAVE THE HIGHEST INCIDENT RATES FOR THE SUBJECT CONDITION, ACCOUNTING FOR 91% OF THE INCIDENTS, BUT ONLY 24% OF SUBJECT VEHICLE SALES IN THE UNITED STATES.ODI'S ANALYSIS DETERMINED THAT 840 OF THE COMPLAINTS, 244 OF THE CRASHES, AND 16 OF THE INJURIES IDENTIFIED IN THIS INVESTIGATION OCCURRED IN THOSE STATES.THE RESULTING INCIDENT AND CRASH RATES ARE 96.2 AND 28.0 PER 100,000 VEHICLES RESPECTIVELY (NOTE:RATES ARE BASED ON VEHICLE SALES, NOT REGISTERED VEHICLES). THE CORRESPONDING NUMBERS IN THE EXCLUDED PORTIONS OF THE SALT-BELT ARE 399,000 VEHICLES, 81 INCIDENTS (20.3 PER 100,000 VEHICLES), 3 CRASHES, AND NO INJURIES.THE STATISTICS IN THE REMAINING 30 STATES ARE 2,406,000 VEHICLES, 168 INCIDENTS (7.0 PER 100,000 VEHICLES), 31 CRASHES, AND ONE INJURY.GM AND ODI ARE CONTINUING TO MONITOR THE PROBLEM EXPERIENCE IN STATES THAT ARE NOT INCLUDED IN THE RECALL.GM WILL PROVIDE ODI WITH UPDATED COMPLAINT, FIELD REPORT, AND WARRANTY DATA IN NOVEMBER 2005.ODI AND GM WILL REVIEW THAT DATA AND ASSESS THE APPROPRIATENESS OF THE CURRENT SCOPE OF THE RECALL AT THAT TIME.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
IN A LETTER DATED AUGUST 29, 2005, GM NOTIFIED ODI THAT IT WAS RECALLING CERTAIN MODEL YEAR 1999 THROUGH 2002 C/K PICKUP TRUCKS AND SPORT UTILITY VEHICLES TO CORRECT A PROBLEM WITH ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR CORROSION THAT MAY RESULT IN UNWANTED ABS ACTIVATION AND EXTENDED STOPPING DISTANCES DURING LOW-SPEED BRAKING (RECALL 05V-379).GM'S RECALL COVERS APPROXIMATELY 804,000 VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING 14 SALT-BELT STATES:CONNECTICUT, ILLINOIS, INDIANA, MASSACHUSETTS, MAINE, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WEST VIRGINIA.THE RECALL PROCEDURE WILL INVOLVE REMOVING THE SENSOR, CLEANING THE MOUNTING SURFACE, APPLYING A RUST INHIBITOR (ZINC-X) TO THE SURFACE, AND REINSTALLING THE SENSOR.IF NECESSARY, THE SENSOR WILL BE REPLACED. THE POPULATION AND FAILURE REPORT DATA GIVEN IN THIS RESUME ARE FOR THE FULL REGION THAT HAS BEEN CONSIDERED BY ODI AS THE SALT-BELT.THAT INCLUDES DELAWARE, IOWA, MARYLAND, MINNESOTA, MISSOURI, WISCONSIN AND THE DISTRICT OF COLUMBIA IN ADDITION TO THE 14 STATES INCLUDED IN 05V-379.THE STATES COVERED BY GM'S RECALL HAVE THE HIGHEST INCIDENT RATES FOR THE SUBJECT CONDITION, ACCOUNTING FOR 91% OF THE INCIDENTS, BUT ONLY 24% OF SUBJECT VEHICLE SALES IN THE UNITED STATES.ODI'S ANALYSIS DETERMINED THAT 840 OF THE COMPLAINTS, 244 OF THE CRASHES, AND 16 OF THE INJURIES IDENTIFIED IN THIS INVESTIGATION OCCURRED IN THOSE STATES.THE RESULTING INCIDENT AND CRASH RATES ARE 96.2 AND 28.0 PER 100,000 VEHICLES RESPECTIVELY (NOTE:RATES ARE BASED ON VEHICLE SALES, NOT REGISTERED VEHICLES). THE CORRESPONDING NUMBERS IN THE EXCLUDED PORTIONS OF THE SALT-BELT ARE 399,000 VEHICLES, 81 INCIDENTS (20.3 PER 100,000 VEHICLES), 3 CRASHES, AND NO INJURIES.THE STATISTICS IN THE REMAINING 30 STATES ARE 2,406,000 VEHICLES, 168 INCIDENTS (7.0 PER 100,000 VEHICLES), 31 CRASHES, AND ONE INJURY.GM AND ODI ARE CONTINUING TO MONITOR THE PROBLEM EXPERIENCE IN STATES THAT ARE NOT INCLUDED IN THE RECALL.GM WILL PROVIDE ODI WITH UPDATED COMPLAINT, FIELD REPORT, AND WARRANTY DATA IN NOVEMBER 2005.ODI AND GM WILL REVIEW THAT DATA AND ASSESS THE APPROPRIATENESS OF THE CURRENT SCOPE OF THE RECALL AT THAT TIME.
PE03026 · Steel Wheel Rim Fracture
Opened Jun 12, 2003 · Closed Nov 3, 2003
Status: closed (inferred from source dates) · Wheels; Wheels:multi Piece; Wheels:rim
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Wheels
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Wheels:multi Piece
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Wheels:rim
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02015 · Throttle Sticking Closed
Opened Aug 1, 2002 · Closed Jan 12, 2004
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THIS INVESTIGATION INVOLVES THE GENERAL MOTORS CORPORATION (GM)THROTTLE BODY (TB) UTILIZED IN MODEL YEAR (MY) 1999-2002 SILVERADO, SIERRA, TAHOE, SUBURBAN, AVALANCHE AND YUKON (SUBJECT VEHICLE(S)) WITH 4.8L, 5.3L, AND 6.0L ENGINES. THE TB VALVE MAY INTERMITTENTLY STICK IN A CLOSED POSITION.IN SUCH A SITUATION, AN OPERATOR MAY APPLY ADDITIONAL ACCELERATOR PEDAL FORCE TO INCREASE ENGINE SPEED.THE APPLICATION OF ADDITIONAL ACCELERATOR PEDAL FORCE, TO OPEN A STUCK THROTTLE VALVE, MAY OPEN THE THROTTLE VALVE MORE THAN INTENDED AND, IN TURN, ACCELERATE THE ENGINE AND VEHICLE MORE THAN INTENDED AND REASONABLY EXPECTED BY THE DRIVER.ON AUGUST 1, 2002, THE OFFICE OF DEFECTS INVESTIGATION (ODI), OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA), OPENED THIS ENGINEERING ANALYSIS.THE INVESTIGATION REVEALED THAT TWO FACTORS MAY CAUSE THE DEFECT: 1) TB MANUFACTURING PROCESS PROBLEMS; AND 2) ACCUMULATION OF DEPOSITS (A PCV SYSTEM BY-PRODUCT) ON OR AROUND THE TB THROTTLE VALVE AND BORE.ODI CONCLUDES THAT THE TB PERFORMS IN A DEFECTIVE MANNER AFTER ANALYZING GM?S DATA SUBMISSIONS, AND TEST DATA COLLECTED BY THE VEHICLE RESEARCH AND TEST CENTER (VRTC).FIFTY-NINE CRASHES ARE ALLEGED TO HAVE OCCURRED AS A RESULT OF GM?S TB DEFECT.THE MAJORITY OF THE CRASHES INVOLVE A SINGLE VEHICLE, ENGAGING IN A CLOSE QUARTER VEHICLE MANEUVER (OR LOW SPEED), AND CAUSING ONLY MINOR PROPERTY DAMAGE.FOUR OUT OF THE FIFTY-NINE CRASHES INVOLVE INJURY, AND THOSE INJURIES WERE MINOR.ALTHOUGH GM?S TB IS DEFECTIVE, BASED ON THE EVIDENCE GATHERED, ODI HAS FOUND THAT THE ACCELERATOR PEDAL FORCE REQUIRED TO OPEN A STUCK THROTTLE VALVE IS NEGLIGIBLE, AND THE THROTTLE VALVE DOES NOT STICK IN THE OPEN POSITION.THEREFORE THIS ENGINEERING ANALYSIS (EA02-015) WILL BE CLOSED AT THIS TIME.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.FOR A DETAILED DISCUSSION OF THE TB COMPONENT AND TESTING, PLEASE SEE THE ATTACHED REPORT.
EA99011 · Erratic Power Steering Assist While Driv
Opened May 12, 1999 · Closed Feb 27, 2001
Status: closed (inferred from source dates) · Steering
THE OFFICE OF DEFECT INVESTIGATION (ODI) HAS INVESTIGATED ALLEGATIONS OF POWER STEERING ASSIST FLUCTUATIONS IN THE SUBJECT VEHICLES.FOR DETAILS AND A BASIS FOR THE INVESTIGATION CONCLUSIONS, PLEASE SEE THE CLOSING REPORT IN THE EA99-011 PUBLIC FILE.ODI HAS NOT IDENTIFIED A SAFETY-RELATED DEFECT TREND IN THE SUBJECT VEHICLE POPULATION.FUTHER EXPENDITURE OF AGENCY RESOURCES ON THIS SUBJECT DOES NOT APPEAR TO BE WARRANTED AT THIS TIME.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.THE ENGINEERING IS CLOSED.