NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
33 reportsClear category filterMileage unknown · Mar 16, 2001
Engine And Engine CoolingSeat BeltsService Brakes, Hydraulic
THE BRAKING SYSTEM FAILED AND THE CUSTOMER IS RESPONSIBLE FOR REPLACING THEIR FRONT BRAKE PADS APPROXIMATELY EVERY 16000 MILES, THE SITUATION WAS COMPOUNDED BY THE FACT THAT THE REAR BRAKES WERE NOT ENGAGED WHEN THE VEHICLE WAS DELIVERED FROM THE FACTORY, THE CONSUMER BELIEVES THESE PROBLEMS ARE CAUSED BY AN ENGINEERING AND/OR D…
Read full complaint
THE BRAKING SYSTEM FAILED AND THE CUSTOMER IS RESPONSIBLE FOR REPLACING THEIR FRONT BRAKE PADS APPROXIMATELY EVERY 16000 MILES, THE SITUATION WAS COMPOUNDED BY THE FACT THAT THE REAR BRAKES WERE NOT ENGAGED WHEN THE VEHICLE WAS DELIVERED FROM THE FACTORY, THE CONSUMER BELIEVES THESE PROBLEMS ARE CAUSED BY AN ENGINEERING AND/OR DESIGN FLAW. NLM
NHTSA ODI #560390
Mileage unknown · Mar 6, 2001
Engine And Engine CoolingPower Train
WHILE TOWING A TRAILER AT 55MPH, BLACK SMOKE CAME OUT FROM THE REAREND AND OIL BLEW OUT ALL OVER THE BACK OF MY CAR AND THE TRAILER. THIS WAS THE FIRST OF FOUR OCCURRENCES.
NHTSA ODI #742034
Mileage unknown · Feb 13, 2001
Engine And Engine Cooling
RADIATOR FAILED CAUSING DAMAGE TO THE TRANSMISSION COOLING BLOCK LOCATED IN THE RADIATOR, CONSUMER STATES THAT THE TRANSMISSION MAY NEED REPLACED AND THE DEALER WILL NOT COVER THIS. *SLC
NHTSA ODI #785271
Mileage unknown · Feb 9, 2001
Engine And Engine CoolingPower TrainSeats
WHEN BRAKES ARE APPLIED FRONT PULLS TO LEFT, AND SOMETIMES TO RIGHT. THIS ALSO HAPPENS WHEN A BUMP IN ROAD IS HIT. DEALER HAS WORKED ON THIS VEHICLE A NUMBER OF TIMES, BUT PROBLEM HAS NOT BEEN SOLVED. *AK CONSUMER ALSO COMPLAINS OF SOFT PEDAL, STEERING WHEEL ALSO PULSATES WHEN BRAKING, DEALER HAS SWITCHED ROTORS FROM SIDE…
Read full complaint
WHEN BRAKES ARE APPLIED FRONT PULLS TO LEFT, AND SOMETIMES TO RIGHT. THIS ALSO HAPPENS WHEN A BUMP IN ROAD IS HIT. DEALER HAS WORKED ON THIS VEHICLE A NUMBER OF TIMES, BUT PROBLEM HAS NOT BEEN SOLVED. *AK CONSUMER ALSO COMPLAINS OF SOFT PEDAL, STEERING WHEEL ALSO PULSATES WHEN BRAKING, DEALER HAS SWITCHED ROTORS FROM SIDE TO SIDE, REPLACED OUT OF ROUND ROTORS, REPLACED FRONT BRAKE PADS TWICE, AND RESURFACED ROTORS AND DRUMS, DEALER ROTATED TIRES AND VEHICLE STILL PULLED. STEERING WHEEL FOUND OFF CENTER. CENTER SEAT RECLINER HANDLE BROKE, DEALER REPLACED HANDLE. VEHICLE EXPERIENCED OIL LEAK. DRIVER DOOR POWER SWITCH LOOSE IN DOOR. REVERSE LOW PLANETARY GEAR WAS BROKEN CAUSING A GRINDING NOISE AT LOW GEAR, VALVE BODY AND GEAR WERE SCORED DUE TO METAL IN TRANSMISSION. AIR PUMP REPLACED DUE TO BEING VERY NOISY. *SLC
NHTSA ODI #880261
Mileage unknown · Jan 22, 2001
Engine And Engine CoolingService Brakes, Hydraulic
EXHAUST SYSTEM WHICH HAS BEEN REPLACED TWICE MAKES A GRINDING AND CRUNCHING SOUND. IT'S STILL UNDER WARRANTY.BRAKE SYSTEM HAS BEEN REPLACED TWICE. ALL TOGETHER VEHICLE HAS BEEN IN SHOP FOR BRAKES ABOUT SEVERAL TIMES. BRAKES FAILED WHILE TRAVELING AT 45MPH WITH NO WARNING. EMERGENCY BRAKES WERE USED TO STOP. CONSUMER HAD TO…
Read full complaint
EXHAUST SYSTEM WHICH HAS BEEN REPLACED TWICE MAKES A GRINDING AND CRUNCHING SOUND. IT'S STILL UNDER WARRANTY.BRAKE SYSTEM HAS BEEN REPLACED TWICE. ALL TOGETHER VEHICLE HAS BEEN IN SHOP FOR BRAKES ABOUT SEVERAL TIMES. BRAKES FAILED WHILE TRAVELING AT 45MPH WITH NO WARNING. EMERGENCY BRAKES WERE USED TO STOP. CONSUMER HAD TO PAY FOR SERVICE ONLY FIRST TIME. DEALER HAS BEEN NICE ABOUT IT, CONSUMER WANTS A NEW VEHCILE.*AK
NHTSA ODI #878652
Mileage unknown · Jan 8, 2001
Electrical SystemEngine And Engine CoolingPower Train
CONSUMER HAS SEVERAL PROBLEMS WITH VEHICLE: FRONT END PULLS TO THE RIGHT AND LEFT WHILE DRIVING, THERE ARE FRONT END ALIGNMENT PROBLEMS, IT HAS BEEN ALIGNED, HOWEVER STILL PULLS TO THE RIGHT AND LEFT. ENGINE IS BURNING ANTIFREEZE, WHEN CHECKED SHORTLY AFTER VEHICLE WAS SERVICED THE OIL WAS DOWN 2 QUARTS, VAPOR RECOVERY TANK WA…
Read full complaint
CONSUMER HAS SEVERAL PROBLEMS WITH VEHICLE: FRONT END PULLS TO THE RIGHT AND LEFT WHILE DRIVING, THERE ARE FRONT END ALIGNMENT PROBLEMS, IT HAS BEEN ALIGNED, HOWEVER STILL PULLS TO THE RIGHT AND LEFT. ENGINE IS BURNING ANTIFREEZE, WHEN CHECKED SHORTLY AFTER VEHICLE WAS SERVICED THE OIL WAS DOWN 2 QUARTS, VAPOR RECOVERY TANK WAS EMPTY, ANTIFREEZE/WATER LEVEL IN ANTIFREEZE IN RADIATOR WAS DOWN 1 QUART, HEAD GASKETS LEAKING ANTIFREEZE INTO THE COMBUSTION CHAMBER AND BURNING THE ANTIFREEZE, CHECK ENGINE LIGHT ILLUMINATED, COOLANT LEVEL IN RADIATOR DROPPED ONCE THE ENGINE WAS STARTED, THERE WAS A MINUTE AMOUNT OF EXHAUST GASES COMING OUT OF THE FILLER NECK OF THE RADIATOR AND THE WATER LEVEL SLOWLY DROPPED IN THE RADIATOR. VEHICLE PULLS DRASTICALLY TO THE LEFT WHILE BRAKING, DEALER HAS REPLACED BRAKE PADS AND REAR SHOES AND HAS REFACED ROTORS AND DRUMS, PULLING STILL EXISTS, DEALER ALSO REPLACED THE PROPORTIONING VALVE. TRANSMISSION MAKES A TICKING NOISE. A SPECIALIST LOOKED AT VEHICLE AND OBSERVED THAT WHEN THE ENGINE WAS STARTED, IT CHARGES AT 15.1 VOLTS DIRECT CURRENT WHICH IS OVERHCARGING THE BATTER, EVEN AFTER VEHICLE RAN FOR 15 MINUTES, THE VEHICLE WAS STILL CHARGING AT 14.71 VOLTS, THE BATTERY HAS FAILED 4 TIMES, IT HAS LEAKED AND CORRODED, CHECK GAUGES LIGHT CAME ON AND ALL GAUGES WENT CRAZY. VEHICLE IDLES HIGH, DEALER REPLACED IDLER AIR CONTROL VALVE. DRIVER SIDE MIRROR WILL NOT TURN SIDE TO SIDE, DEALER REPLACED FAULTY MIRROR SWITCH. *SLC
NHTSA ODI #877622
Mileage unknown · Nov 1, 2000
Engine And Engine CoolingPower Train
STRONG INTERMITTENT ODOR FROM ? PRIOR COMPLAINT ODI ID 865611 IS PROBABLY THE SAME ISSUE.*AK
NHTSA ODI #735564
Mileage unknown · Oct 19, 2000
Electrical SystemEngine And Engine CoolingFuel System, Other
RADIATOR WAS REPLACED. ALSO, BRAKE MASTER CYLINDER WAS REPLACED. TRANSMISSION WAS LEAKING, AND STEERING WHEEL ROTATION SENSOR (EVO) WAS REPLACED, FUEL TANK SENDER PUMP UNIT WAS REPLACED, AND THE ALTERNATOR WAS REPAIRED. *AK MIDDLE SEAT BELT BUCKLE WON'T LOCK. *YH
NHTSA ODI #873402
Mileage unknown · Mar 3, 2000
Engine And Engine Cooling
OUR DEALER CLAIMS OUR VEHICLE IS FLOODING-ARE THERE SIMILAR CASES? *AK
NHTSA ODI #719601
Mileage unknown · Sep 23, 1999
Engine And Engine CoolingUnknown Or OtherVehicle Speed Control
WHILE DRIVING VEHICLE IT SUDDENLY DIED OUT FOR NO REASON. LATER, VEHICLE COULD BE RESTARTED. THEN THE ENGINE CHECK LIGHT WOULD COME ON & STAY ON. ENGINE WOULD START TO SURGE. VEHICLE WOULD STALL OUT AGAIN. WOULD NOT STAY STARTED. AFTER GIVING VEHICLE GAS, THE RPMS WOULD REV HIGH. TAKING VEHICLE TO DEALER TO HAVE IT CHECKED OUT…
Read full complaint
WHILE DRIVING VEHICLE IT SUDDENLY DIED OUT FOR NO REASON. LATER, VEHICLE COULD BE RESTARTED. THEN THE ENGINE CHECK LIGHT WOULD COME ON & STAY ON. ENGINE WOULD START TO SURGE. VEHICLE WOULD STALL OUT AGAIN. WOULD NOT STAY STARTED. AFTER GIVING VEHICLE GAS, THE RPMS WOULD REV HIGH. TAKING VEHICLE TO DEALER TO HAVE IT CHECKED OUT. *AK
NHTSA ODI #848523
NHTSA investigations
6EA11001 · Brake Line Corrosion Failure
Opened Jan 5, 2011 · Closed Apr 8, 2015
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and 3500 series pick-up trucks; 2000-2006 Chevrolet Suburban, Chevrolet Tahoe and GMC Yukon sport utility vehicles; and 2002-2006 Cadillac Escalade and Chevrolet Avalanche sport-utility vehicles.General Motors produced a total of approximately 10,427,062 GMT800 vehicles for sales in the United States, including almost 5 million that were sold in salt states.Although there are over 60 different brake pipe routing configuration used in GMT800 vehicles, with the exception of the rear crossover pipes in MY 200x-2007 vehicles that changed from rear disc to drum brakes, all of the vehicles use brake pipes from the same supplier with a common double-wall, brazed steel pipe design with a combination of hot dip Zinc-Aluminum corrosion protection coating and Aluminum paint outer layer known in the industry as AlGal (ASTM-B750). ODI analysis of field data regarding GMT800 vehicles identified a total of 3,645 complaints of brake pipe corrosion failures, including 107 alleging crashes, and 40 injuries.Though only 20% of total GMT800 production, due to age and region the subject vehicles account for a disproportionate share of the failure experience; with 2,702 of the complaints (75%), 88 of the crashes (82%) and 20 of the injuries (50%) reported in those vehicles.Analysis of the complaints showed strong correlations to vehicle age and region.For vehicles with less than 8 years of service, the complaint rates were minimal for all regions.In the salt states the failure rates begin to climb as the vehicles advance in age, particularly in the Northeast corner of the United States.The complaint rates in the salt states go from less than 0.1 incident per thousand vehicles (IPTV) at 7 years in service to over 1.0 IPTV after the 12th year of service for the subject pickup trucks and utility vehicles.Most of the failures reported to ODI occurred in vehicles with more than 10 years in service.ODI?s investigation did not identify any specific defect conditions that were causing or contributing to the brake pipe failures.Nor did the analysis isolate the problem to any subject vehicle sub-populations when analyzed by vehicle type or production range.The investigation found that vehicles experiencing brake pipe corrosion failures were likely to have general patterns of excessive corrosion on the majority of the brake pipe assembly and appear to be occurring due to expected wear out for the brake pipe coating material used in the subject vehicles and the environmental conditions in severe corrosion states.A safety-related defect has not been identified at this time.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor t
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and 3500 series pick-up trucks; 2000-2006 Chevrolet Suburban, Chevrolet Tahoe and GMC Yukon sport utility vehicles; and 2002-2006 Cadillac Escalade and Chevrolet Avalanche sport-utility vehicles.General Motors produced a total of approximately 10,427,062 GMT800 vehicles for sales in the United States, including almost 5 million that were sold in salt states.Although there are over 60 different brake pipe routing configuration used in GMT800 vehicles, with the exception of the rear crossover pipes in MY 200x-2007 vehicles that changed from rear disc to drum brakes, all of the vehicles use brake pipes from the same supplier with a common double-wall, brazed steel pipe design with a combination of hot dip Zinc-Aluminum corrosion protection coating and Aluminum paint outer layer known in the industry as AlGal (ASTM-B750). ODI analysis of field data regarding GMT800 vehicles identified a total of 3,645 complaints of brake pipe corrosion failures, including 107 alleging crashes, and 40 injuries.Though only 20% of total GMT800 production, due to age and region the subject vehicles account for a disproportionate share of the failure experience; with 2,702 of the complaints (75%), 88 of the crashes (82%) and 20 of the injuries (50%) reported in those vehicles.Analysis of the complaints showed strong correlations to vehicle age and region.For vehicles with less than 8 years of service, the complaint rates were minimal for all regions.In the salt states the failure rates begin to climb as the vehicles advance in age, particularly in the Northeast corner of the United States.The complaint rates in the salt states go from less than 0.1 incident per thousand vehicles (IPTV) at 7 years in service to over 1.0 IPTV after the 12th year of service for the subject pickup trucks and utility vehicles.Most of the failures reported to ODI occurred in vehicles with more than 10 years in service.ODI?s investigation did not identify any specific defect conditions that were causing or contributing to the brake pipe failures.Nor did the analysis isolate the problem to any subject vehicle sub-populations when analyzed by vehicle type or production range.The investigation found that vehicles experiencing brake pipe corrosion failures were likely to have general patterns of excessive corrosion on the majority of the brake pipe assembly and appear to be occurring due to expected wear out for the brake pipe coating material used in the subject vehicles and the environmental conditions in severe corrosion states.A safety-related defect has not been identified at this time.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor t
Service Brakes, Hydraulic
On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and 3500 series pick-up trucks; 2000-2006 Chevrolet Suburban, Chevrolet Tahoe and GMC Yukon sport utility vehicles; and 2002-2006 Cadillac Escalade and Chevrolet Avalanche sport-utility vehicles.General Motors produced a total of approximately 10,427,062 GMT800 vehicles for sales in the United States, including almost 5 million that were sold in salt states.Although there are over 60 different brake pipe routing configuration used in GMT800 vehicles, with the exception of the rear crossover pipes in MY 200x-2007 vehicles that changed from rear disc to drum brakes, all of the vehicles use brake pipes from the same supplier with a common double-wall, brazed steel pipe design with a combination of hot dip Zinc-Aluminum corrosion protection coating and Aluminum paint outer layer known in the industry as AlGal (ASTM-B750). ODI analysis of field data regarding GMT800 vehicles identified a total of 3,645 complaints of brake pipe corrosion failures, including 107 alleging crashes, and 40 injuries.Though only 20% of total GMT800 production, due to age and region the subject vehicles account for a disproportionate share of the failure experience; with 2,702 of the complaints (75%), 88 of the crashes (82%) and 20 of the injuries (50%) reported in those vehicles.Analysis of the complaints showed strong correlations to vehicle age and region.For vehicles with less than 8 years of service, the complaint rates were minimal for all regions.In the salt states the failure rates begin to climb as the vehicles advance in age, particularly in the Northeast corner of the United States.The complaint rates in the salt states go from less than 0.1 incident per thousand vehicles (IPTV) at 7 years in service to over 1.0 IPTV after the 12th year of service for the subject pickup trucks and utility vehicles.Most of the failures reported to ODI occurred in vehicles with more than 10 years in service.ODI?s investigation did not identify any specific defect conditions that were causing or contributing to the brake pipe failures.Nor did the analysis isolate the problem to any subject vehicle sub-populations when analyzed by vehicle type or production range.The investigation found that vehicles experiencing brake pipe corrosion failures were likely to have general patterns of excessive corrosion on the majority of the brake pipe assembly and appear to be occurring due to expected wear out for the brake pipe coating material used in the subject vehicles and the environmental conditions in severe corrosion states.A safety-related defect has not been identified at this time.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor t
PE10010 · Brake Line Corrosion Failure
Opened Mar 30, 2010 · Closed Jan 5, 2011
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist:hydraulic:hoses, Lines/piping, And Fittings
The Office of Defects Investigation (ODI) received Defect Petition DP10-003 on March 2, 2010, requesting the investigation of model year (MY) 2003 Chevrolet Silverado 2500HD 4WD pickup trucks for corrosion failures of the vehicle brake lines.DP10-003 was granted and on March 30, 2010, Preliminary Evaluation PE10-010 was opened on more than six million model year 1999 through 2003 light trucks and sport utility vehicles manufactured and sold by General Motors Corporation (GM).On July 2, 2010, ODI received GM's response to an information request, which included GM's assessment of the frequency and safety consequences of the alleged defect. GM stated that:(1) the brake system of the subject vehicles is split front/rear and should a brake pipe suddenly fail for any reason, the affected vehicle would be capable of stopping with the pressure supplied by the remaining circuit; (2) the subject vehicles were designed to meet the hydraulic circuit partial failure requirements of Federal Motor Vehicle Safety Standards 105 and 135, Light Vehicle Brake Systems; and (3) should a brake fluid leak occur for any reason, the brake system malfunction indicator lamp (MIL) would illuminate and warn the driver before the brake fluid level was low enough to cause a loss of line pressure.ODI's and GM's analysis indicates that 85 percent of the complaints occurred on vehicles used primarily in States that use salt on the roads during Winter months (Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin).Overall the complaint rates per 100,000 vehicles for Salt Belt States is 43.0 and Non-Salt Belt is 3.0.In approximately 25 percent of the complaints the brake pipe failure occurred suddenly, with no warning (i.e., no MIL, Brake Fluid Loss Warning), and resulted in extended stopping distances.In 30 of these the increase in stopping distance that resulted was a factor in the crash and in 10 others the vehicle was intentionally steered off the road or into another lane of travel in order to avoid a crash.This investigation has been upgraded to an Engineering Analysis (EA11-001) for subject vehicles sold or currently registered in Salt Belt States to further assess the scope, frequency and safety risks associated with sudden failures of corroded brake pipes that can result in decreased brake effectiveness. ODI will continue to gather information on subject vehicles outside the Salt Belt as well.
Additional source detail variants (2)
Service Brakes, Hydraulic
The Office of Defects Investigation (ODI) received Defect Petition DP10-003 on March 2, 2010, requesting the investigation of model year (MY) 2003 Chevrolet Silverado 2500HD 4WD pickup trucks for corrosion failures of the vehicle brake lines.DP10-003 was granted and on March 30, 2010, Preliminary Evaluation PE10-010 was opened on more than six million model year 1999 through 2003 light trucks and sport utility vehicles manufactured and sold by General Motors Corporation (GM).On July 2, 2010, ODI received GM's response to an information request, which included GM's assessment of the frequency and safety consequences of the alleged defect. GM stated that:(1) the brake system of the subject vehicles is split front/rear and should a brake pipe suddenly fail for any reason, the affected vehicle would be capable of stopping with the pressure supplied by the remaining circuit; (2) the subject vehicles were designed to meet the hydraulic circuit partial failure requirements of Federal Motor Vehicle Safety Standards 105 and 135, Light Vehicle Brake Systems; and (3) should a brake fluid leak occur for any reason, the brake system malfunction indicator lamp (MIL) would illuminate and warn the driver before the brake fluid level was low enough to cause a loss of line pressure.ODI's and GM's analysis indicates that 85 percent of the complaints occurred on vehicles used primarily in States that use salt on the roads during Winter months (Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin).Overall the complaint rates per 100,000 vehicles for Salt Belt States is 43.0 and Non-Salt Belt is 3.0.In approximately 25 percent of the complaints the brake pipe failure occurred suddenly, with no warning (i.e., no MIL, Brake Fluid Loss Warning), and resulted in extended stopping distances.In 30 of these the increase in stopping distance that resulted was a factor in the crash and in 10 others the vehicle was intentionally steered off the road or into another lane of travel in order to avoid a crash.This investigation has been upgraded to an Engineering Analysis (EA11-001) for subject vehicles sold or currently registered in Salt Belt States to further assess the scope, frequency and safety risks associated with sudden failures of corroded brake pipes that can result in decreased brake effectiveness. ODI will continue to gather information on subject vehicles outside the Salt Belt as well.
Service Brakes, Hydraulic:power Assist:hydraulic:hoses, Lines/piping, And Fittings
The Office of Defects Investigation (ODI) received Defect Petition DP10-003 on March 2, 2010, requesting the investigation of model year (MY) 2003 Chevrolet Silverado 2500HD 4WD pickup trucks for corrosion failures of the vehicle brake lines.DP10-003 was granted and on March 30, 2010, Preliminary Evaluation PE10-010 was opened on more than six million model year 1999 through 2003 light trucks and sport utility vehicles manufactured and sold by General Motors Corporation (GM).On July 2, 2010, ODI received GM's response to an information request, which included GM's assessment of the frequency and safety consequences of the alleged defect. GM stated that:(1) the brake system of the subject vehicles is split front/rear and should a brake pipe suddenly fail for any reason, the affected vehicle would be capable of stopping with the pressure supplied by the remaining circuit; (2) the subject vehicles were designed to meet the hydraulic circuit partial failure requirements of Federal Motor Vehicle Safety Standards 105 and 135, Light Vehicle Brake Systems; and (3) should a brake fluid leak occur for any reason, the brake system malfunction indicator lamp (MIL) would illuminate and warn the driver before the brake fluid level was low enough to cause a loss of line pressure.ODI's and GM's analysis indicates that 85 percent of the complaints occurred on vehicles used primarily in States that use salt on the roads during Winter months (Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin).Overall the complaint rates per 100,000 vehicles for Salt Belt States is 43.0 and Non-Salt Belt is 3.0.In approximately 25 percent of the complaints the brake pipe failure occurred suddenly, with no warning (i.e., no MIL, Brake Fluid Loss Warning), and resulted in extended stopping distances.In 30 of these the increase in stopping distance that resulted was a factor in the crash and in 10 others the vehicle was intentionally steered off the road or into another lane of travel in order to avoid a crash.This investigation has been upgraded to an Engineering Analysis (EA11-001) for subject vehicles sold or currently registered in Salt Belt States to further assess the scope, frequency and safety risks associated with sudden failures of corroded brake pipes that can result in decreased brake effectiveness. ODI will continue to gather information on subject vehicles outside the Salt Belt as well.
PE05020 · Unwanted LOW-SPEED Abs Activation
Opened Apr 28, 2005 · Closed Sep 13, 2005
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
IN A LETTER DATED AUGUST 29, 2005, GM NOTIFIED ODI THAT IT WAS RECALLING CERTAIN MODEL YEAR 1999 THROUGH 2002 C/K PICKUP TRUCKS AND SPORT UTILITY VEHICLES TO CORRECT A PROBLEM WITH ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR CORROSION THAT MAY RESULT IN UNWANTED ABS ACTIVATION AND EXTENDED STOPPING DISTANCES DURING LOW-SPEED BRAKING (RECALL 05V-379).GM'S RECALL COVERS APPROXIMATELY 804,000 VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING 14 SALT-BELT STATES:CONNECTICUT, ILLINOIS, INDIANA, MASSACHUSETTS, MAINE, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WEST VIRGINIA.THE RECALL PROCEDURE WILL INVOLVE REMOVING THE SENSOR, CLEANING THE MOUNTING SURFACE, APPLYING A RUST INHIBITOR (ZINC-X) TO THE SURFACE, AND REINSTALLING THE SENSOR.IF NECESSARY, THE SENSOR WILL BE REPLACED. THE POPULATION AND FAILURE REPORT DATA GIVEN IN THIS RESUME ARE FOR THE FULL REGION THAT HAS BEEN CONSIDERED BY ODI AS THE SALT-BELT.THAT INCLUDES DELAWARE, IOWA, MARYLAND, MINNESOTA, MISSOURI, WISCONSIN AND THE DISTRICT OF COLUMBIA IN ADDITION TO THE 14 STATES INCLUDED IN 05V-379.THE STATES COVERED BY GM'S RECALL HAVE THE HIGHEST INCIDENT RATES FOR THE SUBJECT CONDITION, ACCOUNTING FOR 91% OF THE INCIDENTS, BUT ONLY 24% OF SUBJECT VEHICLE SALES IN THE UNITED STATES.ODI'S ANALYSIS DETERMINED THAT 840 OF THE COMPLAINTS, 244 OF THE CRASHES, AND 16 OF THE INJURIES IDENTIFIED IN THIS INVESTIGATION OCCURRED IN THOSE STATES.THE RESULTING INCIDENT AND CRASH RATES ARE 96.2 AND 28.0 PER 100,000 VEHICLES RESPECTIVELY (NOTE:RATES ARE BASED ON VEHICLE SALES, NOT REGISTERED VEHICLES). THE CORRESPONDING NUMBERS IN THE EXCLUDED PORTIONS OF THE SALT-BELT ARE 399,000 VEHICLES, 81 INCIDENTS (20.3 PER 100,000 VEHICLES), 3 CRASHES, AND NO INJURIES.THE STATISTICS IN THE REMAINING 30 STATES ARE 2,406,000 VEHICLES, 168 INCIDENTS (7.0 PER 100,000 VEHICLES), 31 CRASHES, AND ONE INJURY.GM AND ODI ARE CONTINUING TO MONITOR THE PROBLEM EXPERIENCE IN STATES THAT ARE NOT INCLUDED IN THE RECALL.GM WILL PROVIDE ODI WITH UPDATED COMPLAINT, FIELD REPORT, AND WARRANTY DATA IN NOVEMBER 2005.ODI AND GM WILL REVIEW THAT DATA AND ASSESS THE APPROPRIATENESS OF THE CURRENT SCOPE OF THE RECALL AT THAT TIME.
Additional source detail variants (2)
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
IN A LETTER DATED AUGUST 29, 2005, GM NOTIFIED ODI THAT IT WAS RECALLING CERTAIN MODEL YEAR 1999 THROUGH 2002 C/K PICKUP TRUCKS AND SPORT UTILITY VEHICLES TO CORRECT A PROBLEM WITH ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR CORROSION THAT MAY RESULT IN UNWANTED ABS ACTIVATION AND EXTENDED STOPPING DISTANCES DURING LOW-SPEED BRAKING (RECALL 05V-379).GM'S RECALL COVERS APPROXIMATELY 804,000 VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING 14 SALT-BELT STATES:CONNECTICUT, ILLINOIS, INDIANA, MASSACHUSETTS, MAINE, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WEST VIRGINIA.THE RECALL PROCEDURE WILL INVOLVE REMOVING THE SENSOR, CLEANING THE MOUNTING SURFACE, APPLYING A RUST INHIBITOR (ZINC-X) TO THE SURFACE, AND REINSTALLING THE SENSOR.IF NECESSARY, THE SENSOR WILL BE REPLACED. THE POPULATION AND FAILURE REPORT DATA GIVEN IN THIS RESUME ARE FOR THE FULL REGION THAT HAS BEEN CONSIDERED BY ODI AS THE SALT-BELT.THAT INCLUDES DELAWARE, IOWA, MARYLAND, MINNESOTA, MISSOURI, WISCONSIN AND THE DISTRICT OF COLUMBIA IN ADDITION TO THE 14 STATES INCLUDED IN 05V-379.THE STATES COVERED BY GM'S RECALL HAVE THE HIGHEST INCIDENT RATES FOR THE SUBJECT CONDITION, ACCOUNTING FOR 91% OF THE INCIDENTS, BUT ONLY 24% OF SUBJECT VEHICLE SALES IN THE UNITED STATES.ODI'S ANALYSIS DETERMINED THAT 840 OF THE COMPLAINTS, 244 OF THE CRASHES, AND 16 OF THE INJURIES IDENTIFIED IN THIS INVESTIGATION OCCURRED IN THOSE STATES.THE RESULTING INCIDENT AND CRASH RATES ARE 96.2 AND 28.0 PER 100,000 VEHICLES RESPECTIVELY (NOTE:RATES ARE BASED ON VEHICLE SALES, NOT REGISTERED VEHICLES). THE CORRESPONDING NUMBERS IN THE EXCLUDED PORTIONS OF THE SALT-BELT ARE 399,000 VEHICLES, 81 INCIDENTS (20.3 PER 100,000 VEHICLES), 3 CRASHES, AND NO INJURIES.THE STATISTICS IN THE REMAINING 30 STATES ARE 2,406,000 VEHICLES, 168 INCIDENTS (7.0 PER 100,000 VEHICLES), 31 CRASHES, AND ONE INJURY.GM AND ODI ARE CONTINUING TO MONITOR THE PROBLEM EXPERIENCE IN STATES THAT ARE NOT INCLUDED IN THE RECALL.GM WILL PROVIDE ODI WITH UPDATED COMPLAINT, FIELD REPORT, AND WARRANTY DATA IN NOVEMBER 2005.ODI AND GM WILL REVIEW THAT DATA AND ASSESS THE APPROPRIATENESS OF THE CURRENT SCOPE OF THE RECALL AT THAT TIME.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
IN A LETTER DATED AUGUST 29, 2005, GM NOTIFIED ODI THAT IT WAS RECALLING CERTAIN MODEL YEAR 1999 THROUGH 2002 C/K PICKUP TRUCKS AND SPORT UTILITY VEHICLES TO CORRECT A PROBLEM WITH ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR CORROSION THAT MAY RESULT IN UNWANTED ABS ACTIVATION AND EXTENDED STOPPING DISTANCES DURING LOW-SPEED BRAKING (RECALL 05V-379).GM'S RECALL COVERS APPROXIMATELY 804,000 VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING 14 SALT-BELT STATES:CONNECTICUT, ILLINOIS, INDIANA, MASSACHUSETTS, MAINE, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WEST VIRGINIA.THE RECALL PROCEDURE WILL INVOLVE REMOVING THE SENSOR, CLEANING THE MOUNTING SURFACE, APPLYING A RUST INHIBITOR (ZINC-X) TO THE SURFACE, AND REINSTALLING THE SENSOR.IF NECESSARY, THE SENSOR WILL BE REPLACED. THE POPULATION AND FAILURE REPORT DATA GIVEN IN THIS RESUME ARE FOR THE FULL REGION THAT HAS BEEN CONSIDERED BY ODI AS THE SALT-BELT.THAT INCLUDES DELAWARE, IOWA, MARYLAND, MINNESOTA, MISSOURI, WISCONSIN AND THE DISTRICT OF COLUMBIA IN ADDITION TO THE 14 STATES INCLUDED IN 05V-379.THE STATES COVERED BY GM'S RECALL HAVE THE HIGHEST INCIDENT RATES FOR THE SUBJECT CONDITION, ACCOUNTING FOR 91% OF THE INCIDENTS, BUT ONLY 24% OF SUBJECT VEHICLE SALES IN THE UNITED STATES.ODI'S ANALYSIS DETERMINED THAT 840 OF THE COMPLAINTS, 244 OF THE CRASHES, AND 16 OF THE INJURIES IDENTIFIED IN THIS INVESTIGATION OCCURRED IN THOSE STATES.THE RESULTING INCIDENT AND CRASH RATES ARE 96.2 AND 28.0 PER 100,000 VEHICLES RESPECTIVELY (NOTE:RATES ARE BASED ON VEHICLE SALES, NOT REGISTERED VEHICLES). THE CORRESPONDING NUMBERS IN THE EXCLUDED PORTIONS OF THE SALT-BELT ARE 399,000 VEHICLES, 81 INCIDENTS (20.3 PER 100,000 VEHICLES), 3 CRASHES, AND NO INJURIES.THE STATISTICS IN THE REMAINING 30 STATES ARE 2,406,000 VEHICLES, 168 INCIDENTS (7.0 PER 100,000 VEHICLES), 31 CRASHES, AND ONE INJURY.GM AND ODI ARE CONTINUING TO MONITOR THE PROBLEM EXPERIENCE IN STATES THAT ARE NOT INCLUDED IN THE RECALL.GM WILL PROVIDE ODI WITH UPDATED COMPLAINT, FIELD REPORT, AND WARRANTY DATA IN NOVEMBER 2005.ODI AND GM WILL REVIEW THAT DATA AND ASSESS THE APPROPRIATENESS OF THE CURRENT SCOPE OF THE RECALL AT THAT TIME.
PE03026 · Steel Wheel Rim Fracture
Opened Jun 12, 2003 · Closed Nov 3, 2003
Status: closed (inferred from source dates) · Wheels; Wheels:multi Piece; Wheels:rim
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Wheels
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Wheels:multi Piece
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Wheels:rim
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02015 · Throttle Sticking Closed
Opened Aug 1, 2002 · Closed Jan 12, 2004
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THIS INVESTIGATION INVOLVES THE GENERAL MOTORS CORPORATION (GM)THROTTLE BODY (TB) UTILIZED IN MODEL YEAR (MY) 1999-2002 SILVERADO, SIERRA, TAHOE, SUBURBAN, AVALANCHE AND YUKON (SUBJECT VEHICLE(S)) WITH 4.8L, 5.3L, AND 6.0L ENGINES. THE TB VALVE MAY INTERMITTENTLY STICK IN A CLOSED POSITION.IN SUCH A SITUATION, AN OPERATOR MAY APPLY ADDITIONAL ACCELERATOR PEDAL FORCE TO INCREASE ENGINE SPEED.THE APPLICATION OF ADDITIONAL ACCELERATOR PEDAL FORCE, TO OPEN A STUCK THROTTLE VALVE, MAY OPEN THE THROTTLE VALVE MORE THAN INTENDED AND, IN TURN, ACCELERATE THE ENGINE AND VEHICLE MORE THAN INTENDED AND REASONABLY EXPECTED BY THE DRIVER.ON AUGUST 1, 2002, THE OFFICE OF DEFECTS INVESTIGATION (ODI), OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA), OPENED THIS ENGINEERING ANALYSIS.THE INVESTIGATION REVEALED THAT TWO FACTORS MAY CAUSE THE DEFECT: 1) TB MANUFACTURING PROCESS PROBLEMS; AND 2) ACCUMULATION OF DEPOSITS (A PCV SYSTEM BY-PRODUCT) ON OR AROUND THE TB THROTTLE VALVE AND BORE.ODI CONCLUDES THAT THE TB PERFORMS IN A DEFECTIVE MANNER AFTER ANALYZING GM?S DATA SUBMISSIONS, AND TEST DATA COLLECTED BY THE VEHICLE RESEARCH AND TEST CENTER (VRTC).FIFTY-NINE CRASHES ARE ALLEGED TO HAVE OCCURRED AS A RESULT OF GM?S TB DEFECT.THE MAJORITY OF THE CRASHES INVOLVE A SINGLE VEHICLE, ENGAGING IN A CLOSE QUARTER VEHICLE MANEUVER (OR LOW SPEED), AND CAUSING ONLY MINOR PROPERTY DAMAGE.FOUR OUT OF THE FIFTY-NINE CRASHES INVOLVE INJURY, AND THOSE INJURIES WERE MINOR.ALTHOUGH GM?S TB IS DEFECTIVE, BASED ON THE EVIDENCE GATHERED, ODI HAS FOUND THAT THE ACCELERATOR PEDAL FORCE REQUIRED TO OPEN A STUCK THROTTLE VALVE IS NEGLIGIBLE, AND THE THROTTLE VALVE DOES NOT STICK IN THE OPEN POSITION.THEREFORE THIS ENGINEERING ANALYSIS (EA02-015) WILL BE CLOSED AT THIS TIME.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.FOR A DETAILED DISCUSSION OF THE TB COMPONENT AND TESTING, PLEASE SEE THE ATTACHED REPORT.
EA99011 · Erratic Power Steering Assist While Driv
Opened May 12, 1999 · Closed Feb 27, 2001
Status: closed (inferred from source dates) · Steering
THE OFFICE OF DEFECT INVESTIGATION (ODI) HAS INVESTIGATED ALLEGATIONS OF POWER STEERING ASSIST FLUCTUATIONS IN THE SUBJECT VEHICLES.FOR DETAILS AND A BASIS FOR THE INVESTIGATION CONCLUSIONS, PLEASE SEE THE CLOSING REPORT IN THE EA99-011 PUBLIC FILE.ODI HAS NOT IDENTIFIED A SAFETY-RELATED DEFECT TREND IN THE SUBJECT VEHICLE POPULATION.FUTHER EXPENDITURE OF AGENCY RESOURCES ON THIS SUBJECT DOES NOT APPEAR TO BE WARRANTED AT THIS TIME.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.THE ENGINEERING IS CLOSED.
Illustration