1998 Chevrolet Suburban

I PURCHASED ON 11/1997 A NEW 1998 CHEVROLET SUBURBAN 3/4 TON 2500 SERIES. THE SUBURBAN HAS 38,528 ORIGINAL MILES AND HAS BEEN GARAGE KEPT SINCE NEW. THE VEHICLE HAS BEEN USED PRIMARILY AS A SECONDARY VEHICLE FOR RECREATIONAL PURPOSES. THE SUBURBAN HAS BEEN DRIVEN IN SNOW CONDITIONS ONLY 12-14 TIMES. I AM EXPERIENCING EXCESSIVE BRAKE AND FUEL LINE CORROSION ON THE STEEL BRAKE/FUEL LINES, FLEXIBLE BRAKE HOSES AND CONNECTIONS. I AM VERY CONCERNED OVER THE BRAKE/FUEL LINE CORROSION ISSUEA AND HAVE SINCE LEARNED THAT AN INVESTIGATION HAS BEEN INITIATED BY THE NHTSA ON 1/5/11, NHTSA INVESTIGATION FILE NO. EA11001. *TR

DT*: THE CONTACT STATED WHILE DRIVING 5 MPH ON NORMAL ROAD CONDITIONS AND APPLYING THE BRAKES UNDER NORMAL BRAKING CONDITIONS, THE BRAKES INCREASED IN STOPPING DISTANCE. THE VEHICLE WAS TAKEN TO A DEALER, WHO DETERMINED THAT THE LEFT FRONT BRAKE SENSOR NEEDED TO BE REPLACED. AFTER THE VEHICLE WAS REPAIRED, THE CONTACT NOTICED A NHTSA RECALL # 05V379000 REGARDING SERVICE BRAKES HYDRAULIC:ANTILOCK. THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN.

CATASTROHIC LOSS OF ENTIRE BREAKING SYSTEM DUE TO BURSTING OF BRAKE LINES WITHOUT PRIOR NOTICE; DEALER REQUIRED COMPLETE REPLACEMENT OF ENTIRE BRAKE SYSTEM OWING TO SERVELY RUSTED PARTS THROUGHOUT; MECHANICAL EMERGENCY BRAKE SYSTEM REQUIRED SEVERAL HUNDRED YARDS TO STOP VEHICLE; VEHICLE HAD BEEN REGULARLY SERVICED SINCE NEW WITH MOST RECENT SERVICE JUST 2 MONTHS BEFORE BRAKE SYSTEM FAILURE; HAD VEHICLE BEEN TRAVELING AT HIGHWAY SPEED POSSIBLE FATAL CONSEQUENCES; POSSIBLE ISSUE OF DESIGN/COMPONENT DEFECT

DT: THE CONSUMER COMPLAINED ABOUT ABS BRAKES KICKING IN AT LOW SPEEDS. THE SERVICE BRAKES AND ABS WILL NOT HOLD WHEN THE ABS KICKS IN. THE PROBLEM HAS BEEN ON GOING SINCE NOVEMBER OF 2004. THE DEALERSHIP CLEANED AND GREASED THE BRAKES. THEY MACHINED THE ROTORS AND REPLACED THE LEFT UPPER ARM BUSHING. AND THEY CHECKED THE ABS SENSORS. THE PROBLEM RECURRED. WHEN SHE CONTACTED THEM THEY SAID THEY COULD NOT FIND THE CAUSE OF THE PROBLEM. IT STARTED GETTING WORSE IN JULY OF 2005. SHE TOOK VEHICLE TO THE DEALERSHIP AGAIN. THEY REPLACED THE SENSOR BUSHINGS AND AN IDLE ARM. THE PROBLEM IS STILL OCCURRING. SHE TOOK IT BACK TO THEM. THEY REPLACED TWO REAR DRUMS, THE SWAY BAR BUSHINGS, THE U JOINTS, AND T TIGHTENED THE TRANSFER CASE. HOWEVER, THE PROBLEM RECURRED. A RECALL FOR THE 2000 MODELS WAS ISSUED. WHEN SHE CONTACTED THE MANUFACTURER, THEY SAID THAT THIS MODEL YEAR VEHICLE WAS NOT INCLUDED IN THE RECALL. THE CONTACT HAD TO HAVE THE SERVICE BRAKES REPLACED BEFORE. THE DEALERSHIP REPLACED THE ROTORS AND THE PADS. THE CONTACT FELT THAT IT WAS A RESULT OF NORMAL WEAR AND TEAR. . *AK

ABS BRAKE SYSTEM ON THE FRONT DRIVER'S SIDE WHEEL BEGAN HAVING FAILURES AT VERY LOW SPEEDS(UNDER 10 MPH) WHEN THE VEHICLE(1998 CHEVROLET TAHOE) WAS COMING TO A FULL STOP AT THE END OF THE DRIVE OR WHEN PULLING TO A STOP. THIS WAS OCCURRING OVER & OVER MORE MORE THAN A MONTH. I CONTACTED WHITE-ALLEN CHEVOLET IN DAYTON OHIO AND THE SERVICE MANAGER CONTACTED THE GM ZONE MANAGER AND GM WOULD NOT WARRANTY THIS REPAIR SAYING THAT MY VEHICLE DID NOT FALL UNDER THE RECALL YEARS FOR THIS PROBLEM EVEN THOUGH THE PROBLEM WAS EXACTLY THE SAME AS THE RECALL ISSUED FOR THE SAME VEHICLE 1999-2002 ( MINE IS 1998). I FINALLY HAD TO HAVE IT DONE STRICTLY BECAUSE OF MY CHILDREN'S SAFETY THE DAY I MADE THE APPOINTMENT MY DAUGHTER AND I ALMOST GLIDED INTO TRAFFIC COMING TO A STOP WHILE TAKING HER TO SCHOOL. THE ZONE MANAGER RESPONSE TO OUR CLAIM WAS THAT MY VEHICLE WAS NOT PART OF THE RECALL AND THEY WILL NOT HAVE THE REPAIRS DONE AS PART OF THE RECALL EVEN THOUGH THE FAILURE IS THE SAME DEFECT ACCORDING TO THE SERVICE MANAGER. SERVICE WAS SUPPLIED ON 9/26/2005 AT WHITE-ALLEN SERVICE ORDER READS "CHECKED ABS SYSTEM RIGHT FRONT SENSOR FAILURE DUE TO LOW VOLTAGE OUTPUT ACTION TAKEN : REPLACED LEFT FRONT HUB AND BEARING PARTS: OWNER HAS THE OLD REPLACED PARTS. *JB

BRAKE PEDAL GOES DOWN OR GETS SPONGEY AT SLOW STOPPING SPEEDS UNDER 5 MPH. IT FEELS LIKE AN ABS EVENT IS OCCURING! NO ABS LIGHT COMES ON. INCIDENT OCCURS AT NEARLY EVERY STOP. STOPPING DISTANCE IS LONGER. IT FEELS LIKE THE VEHICLE IS NOT GOING TO STOP. IT IS NOT A SAFE SECURE FEELING WHEN COMING TO A STOP. I HAVE HEAR (ON THE RADIO) THAT THIS IS PROBABLEY THE SAME KIND OF PROBLEM OCCURING AS OCCURING ON 1999 TO 1005 VEHICLES. I BELIEVE MY VEHILCE SHOULD BE INCLUDED IN THE REPAIR.