IllustrationPOWER STEERING HYDROBOOST UNIT SURGES, MAKES STEERING WHEEL JERK IN A DIFFERENT DIRECTION.*AK
1997 Chevrolet Suburban
Owner reports · Recalls · Investigations
More warning signs than most Suburban years
Owner complaints for the 1997 Chevrolet Suburban are substantially higher than the model-year median of 118.
About this comparison →How this year compares
Owner complaints by model year
Compare all Suburban years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 76 of 414 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 105 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 92 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 47 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
22 crash reports13 fire reports13 injury reports
Steering complaints
105 reportsWHILE TRAVELING AT ANY SPEED VEHICLE TRAVELED OUT OF CONTROL DUE TO STEERING SENSOR. PLEASE PROVIDE FURTHER INFORMATION.*AK
VEHICLE EXPERIENCED MORE ASSIST TO STEERING AT 30 MPH WHICH CAUSED LOSS OF CONTROL. *AK THE DEALER REPLACED THE ELECTRONIC SOLENOID RELAY AS POSSIBLE CAUSE OF POWER ASSIST TO STEERING ASSEMBLY. *YH
VEHICLE WOULD OVERSTEER WHILE MAKING A TURN . DEALER STATED EVO SENSOR NEEDED TO BE REPLACED.*AK
1. BATTERY LEAKED ACID WHILE IDLE AND ULTIMATELY FAILED. LEAK CORRODED POSITIVE POWER CABLE AND UNDERCOATING. 2. ERRATIC STEERING WHILE DRIVING - STEERING POSITION SENSOR REPLACED FIRST TIME. 3. STARTER FAILED 3 TIMES - COMPLETE LOCK-UP 4. U-JOINT FAILED TWICE - SEALED/NON-GREASABLE POOR ACCESS TO ADD GREASE FITTING
POWER STEERING IS UNRELIABLE, SURGE/INCREASE IN STEERING POWER IS VERY UNPREDICTABLE. THIS VEHICLE HAS BEEN TO DEALER 5 TIMES FOR THIS PROBLEM. FIRST TIME THE DEALER SAID ALIGNMENT WAS PROBLEM, NOT SO. SECOND TIME THE DEALER REPLACED THE POWER STEERING GEAR BOX, THIS FIXED PROBLEM FOR 4 MONTHS. THIRD TIME THE DEALER REPLACED…
Read full complaint
POWER STEERING IS UNRELIABLE, SURGE/INCREASE IN STEERING POWER IS VERY UNPREDICTABLE. THIS VEHICLE HAS BEEN TO DEALER 5 TIMES FOR THIS PROBLEM. FIRST TIME THE DEALER SAID ALIGNMENT WAS PROBLEM, NOT SO. SECOND TIME THE DEALER REPLACED THE POWER STEERING GEAR BOX, THIS FIXED PROBLEM FOR 4 MONTHS. THIRD TIME THE DEALER REPLACED POWER STEERING GEAR BOX, POWER STEERING PUMP AND FLUSHED LINES, THIS FIXED PROBLEM FOR 5 MONTHS. FOURTH TIME THE DEALER REPLACED THE EVO SENSOR ON STEERING COLUMN, THIS FIX LASTED 15 MONTHS. FIFTH TIME THE DEALER STATED THAT THE EVO SENSOR MUST BE BAD AND WILL NOT REPLACE UNDER EXTENDED WARRENTY. AFTER MUCH INVESTIGATION, I FIND THAT THIS IS AN ONGOING PROBLEM SPECIFIC TO THE 1997 SUBURBAN WITH THE ELECTRONIC CONTROL ON THE POWER STEERING SYSTEM. THERE HAVE BEEN IN EXCESS OF 75 REPORTS OF THIS OR SIMILAR STEERING RELATED PROBLEMS. NHTSA SHOULD INVESTIGATE THIS PRIOR TO THERE BEING ANY FATALITIES.*AK
WE HAD CAR LOOKED AT, SMALL LEAK IN POWER STEERING FIXED,DIDN'T HELP..FOUND NO MAJOR WEAR ON ANY STEERING PARTS.... INTERESTING, SISTER HAS SAME CAR, WITH SAME PROBLEM, HERS DOES THIS 'CATCH' FEELING, TURNING LEFT OR RIGHT! I ALSO FEEL THE 'CATCH' IF DRIVING OVER AN UNEVEN SPOT ON ROAD GOING STRAIGHT. *AK
WHILE TRAVELING AND WHEN GOING AROUND A BEND VEHICLE LOST STEERING. DEALER STATED EVO SENSOR NEEDED TO BE REPLACED. PLEASE PROVIDE FURTHER INFORMATION. *AK
LOSS OF STEERING POWER AND EXCESSIVE PLAY IN THE STEERING FOR UP TO 4-5 SECONDS AT HIGHWAY SPEEDS. *AK
INTRMITTENTLY WHEN TURNING WHEEL SLIGHTLY VEHICLE OVERSTEERS. DEALER IS INSPECTING VEHICLE.*AK
Official recalls
203V159000 · Visibility:windshield Wiper/washer
Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
03V093000 · Visibility:rearview Mirrors/devices:exterior
Mar 7, 2003
CERTAIN SPORT UTILITY VEHICLES, MINI VANS, AND PICKUP TRUCKS MAY DEVELOP A SHORT CIRCUIT IN THE ELECTRIC OUTSIDE REARVIEW MIRROR SWITCH.
Consequence & remedy
Consequence: IF THIS WERE TO HAPPEN, IT COULD RESULT IN AN INOPERATIVE SWITCH, HEAT DAMAGE TO THE DRIVER'S DOOR, AND/OR IGNITION OF COMPONENTS IN THE DRIVER'S DOOR AND A SUBSEQUENT VEHICLE FIRE WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSTALL A FUSED JUMPER HARNESS TO THE ELECTRIC OUTSIDE REARVIEW MIRROR SWITCH. OWNER NOTIFICATION BEGAN ON APRIL 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
EA00013 · Battery Leaks Acid
Opened May 2, 2000 · Closed Jun 28, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
DP00001 · Oem Hitch Receiver Platform Cracking
Opened Jan 31, 2000 · No close date supplied
Status: open (inferred from source dates) · Equipment
THE PETITION ALLEGES THAT CRACKS IN THE HITCH RECEIVER PLATFORM MAY LEAD TO SEPARATION OF THE TRAILER AND LOSS OF STEERING CONTROL
EA99011 · Erratic Power Steering Assist While Driv
Opened May 12, 1999 · Closed Feb 27, 2001
Status: closed (inferred from source dates) · Steering
THE OFFICE OF DEFECT INVESTIGATION (ODI) HAS INVESTIGATED ALLEGATIONS OF POWER STEERING ASSIST FLUCTUATIONS IN THE SUBJECT VEHICLES.FOR DETAILS AND A BASIS FOR THE INVESTIGATION CONCLUSIONS, PLEASE SEE THE CLOSING REPORT IN THE EA99-011 PUBLIC FILE.ODI HAS NOT IDENTIFIED A SAFETY-RELATED DEFECT TREND IN THE SUBJECT VEHICLE POPULATION.FUTHER EXPENDITURE OF AGENCY RESOURCES ON THIS SUBJECT DOES NOT APPEAR TO BE WARRANTED AT THIS TIME.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.THE ENGINEERING IS CLOSED.
EA95026 · Poor Brake Performance
Opened Sep 20, 1995 · Closed Sep 20, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
POOR PERFORMANCE OF ABS BRAKES