IllustrationWHILE TRAVELING VEHICLE STALLED . DEALER CHECKED AND NOTICED FUEL PUMP NEEDED TO BE REPLACED. PROVIDE FURTHER INFORMATION.*AK
1997 Chevrolet Suburban
Owner reports · Recalls · Investigations
More warning signs than most Suburban years
Owner complaints for the 1997 Chevrolet Suburban are substantially higher than the model-year median of 118.
About this comparison →How this year compares
Owner complaints by model year
Compare all Suburban years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 76 of 414 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 105 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 92 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 47 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
22 crash reports13 fire reports13 injury reports
Fuel System, Gasoline complaints
39 reportsPOTENTIAL FOR FUEL TANK TO EXPLODE. FUEL PUMP CONNECTED OVERHEATED, AND THE GREY WIRE MELTED. THIS WAS CAUSED BY CONNECTOR TO FUEL PUMP WHICH WAS TOO SMALL. DEALERSHIP WAS AWARE OF THE POTENTIAL PROBLEM.*AK
FUEL PUMP CLOGGED UP AND BURNED TWICE. DEALER HAS INSPECTED VEHICLE. *AK
ENGINE WOULDN'T START. TOWED TO DEALER. STARTED AND DEALER COULDN'T FIND PROBLEM. STATED IT WAS PROBABLY FUEL PUMP SINCE HAD SEEN THIS BEFORE. FINALLY FAILED AFTER SURGING AND DYING DURING DRIVE. FOUND "BURNED" (SAID DARKENED INSULATION) WIRING HARNESS WHICH DAMAGED OTHER COMPONENTS FROM FUEL PUMP TO ENGINE
FUEL PUMP AND SENDING UNIT MELTED AND SHORTED OUT CAUSING CAR TO STALL ON THE ROAD.TORQUE CONVERTOR REPLACED/ TRANS RECONDITIONED, POWER STEERING BOX LEAKING/ REPLACED. BOTH CATALYTIC CONVERTERS REPLACED,AC COMPRESSOR REPLACED. NUMEROUS COOLANT LEAKS FIXED. WINDSHIELD REPLACED DUE TO DEFECT. BATTERY REPLACED DUE TO ACID LEAK. W…
Read full complaint
FUEL PUMP AND SENDING UNIT MELTED AND SHORTED OUT CAUSING CAR TO STALL ON THE ROAD.TORQUE CONVERTOR REPLACED/ TRANS RECONDITIONED, POWER STEERING BOX LEAKING/ REPLACED. BOTH CATALYTIC CONVERTERS REPLACED,AC COMPRESSOR REPLACED. NUMEROUS COOLANT LEAKS FIXED. WINDSHIELD REPLACED DUE TO DEFECT. BATTERY REPLACED DUE TO ACID LEAK. WHATS NEXT? *AK
FUEL PUMP SENDING UNIT COMPLETELY BURNED CAUSING THE ENGINE TO SHUT DOWN WHILE DRIVING. (ATTORNEY FOR CONSUMER) NLM
ENGINE CHECK LIGHT CAME ON 1ST THEN A VARIOUS OTHER PROBLES BEGAN OCCURING AS WE TRIED TO GET OUR VEHICLE HOME. WHEN WE GOT IT TO THE DEALER'S REPAIR SHOP WE WERE TOLD THAT THE #2 FUEL INJECTOR HAD STARTED LEAKING AND FILLED THE WHOLE ELECTRICAL SYSTEM WITH GAS. THIS HAPPENED AGAIN 4 MONTHES LATER WHEN THE #5 INJECTOR STARTED L…
Read full complaint
ENGINE CHECK LIGHT CAME ON 1ST THEN A VARIOUS OTHER PROBLES BEGAN OCCURING AS WE TRIED TO GET OUR VEHICLE HOME. WHEN WE GOT IT TO THE DEALER'S REPAIR SHOP WE WERE TOLD THAT THE #2 FUEL INJECTOR HAD STARTED LEAKING AND FILLED THE WHOLE ELECTRICAL SYSTEM WITH GAS. THIS HAPPENED AGAIN 4 MONTHES LATER WHEN THE #5 INJECTOR STARTED LEAKING. BOTH TIMES THE DEALER TOLD US THAT WE WERE LUCKY THAT THE VEHICLE DIDN'T START ON FIRE. *AK
TRANSMISSION: TORQUE CONVERTER BLEW UP.....FUEL PUMP FAILED AND HAD TO BE REPLACED, WIRING OVERHEATED AND INSULATION MELTED OFF INSIDE FUEL TANK .....STEERING: ERRATIC WHILE MAKING RIGHT TURN
ADD TO PRIOR TRANSMISSIONS, (ADDING PHONE AND FAX #S
ALTHOUGH THEIR WERE NO FATALITIES OR INJURIES INVOLVED IN REFERENCE TO THE MASTER CYLINDER/ FUEL PUMP, THE LOST OF POWER BRAKES CAUSED ME TO ALMOST VEER INTO A BRICK BUILDING. I HOPE THE INFO PROVIDED WILL DRAW ATTENTION TO THE PROBLEMS I'VE HAD SINCE PURCHASING THIS VEHICLE.
Official recalls
203V159000 · Visibility:windshield Wiper/washer
Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
03V093000 · Visibility:rearview Mirrors/devices:exterior
Mar 7, 2003
CERTAIN SPORT UTILITY VEHICLES, MINI VANS, AND PICKUP TRUCKS MAY DEVELOP A SHORT CIRCUIT IN THE ELECTRIC OUTSIDE REARVIEW MIRROR SWITCH.
Consequence & remedy
Consequence: IF THIS WERE TO HAPPEN, IT COULD RESULT IN AN INOPERATIVE SWITCH, HEAT DAMAGE TO THE DRIVER'S DOOR, AND/OR IGNITION OF COMPONENTS IN THE DRIVER'S DOOR AND A SUBSEQUENT VEHICLE FIRE WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSTALL A FUSED JUMPER HARNESS TO THE ELECTRIC OUTSIDE REARVIEW MIRROR SWITCH. OWNER NOTIFICATION BEGAN ON APRIL 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
EA00013 · Battery Leaks Acid
Opened May 2, 2000 · Closed Jun 28, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
DP00001 · Oem Hitch Receiver Platform Cracking
Opened Jan 31, 2000 · No close date supplied
Status: open (inferred from source dates) · Equipment
THE PETITION ALLEGES THAT CRACKS IN THE HITCH RECEIVER PLATFORM MAY LEAD TO SEPARATION OF THE TRAILER AND LOSS OF STEERING CONTROL
EA99011 · Erratic Power Steering Assist While Driv
Opened May 12, 1999 · Closed Feb 27, 2001
Status: closed (inferred from source dates) · Steering
THE OFFICE OF DEFECT INVESTIGATION (ODI) HAS INVESTIGATED ALLEGATIONS OF POWER STEERING ASSIST FLUCTUATIONS IN THE SUBJECT VEHICLES.FOR DETAILS AND A BASIS FOR THE INVESTIGATION CONCLUSIONS, PLEASE SEE THE CLOSING REPORT IN THE EA99-011 PUBLIC FILE.ODI HAS NOT IDENTIFIED A SAFETY-RELATED DEFECT TREND IN THE SUBJECT VEHICLE POPULATION.FUTHER EXPENDITURE OF AGENCY RESOURCES ON THIS SUBJECT DOES NOT APPEAR TO BE WARRANTED AT THIS TIME.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.THE ENGINEERING IS CLOSED.
EA95026 · Poor Brake Performance
Opened Sep 20, 1995 · Closed Sep 20, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
POOR PERFORMANCE OF ABS BRAKES