IllustrationWHILE CONSUMER WAS INSIDE OF THE VEHICLE DRIVER 'S SIDE SEAT FRAME BROKE. NO INJURIES REPORTED. THE SEAT COLLAPSED FORWARD. CONSUMER WAS ABLE TO FIX THE SEAT. *AK...CONSUMER REPLACED THE FRAME. CONSUMER HAS ACTUAL SEAT FRAME AND PARTS ON HAND. ALSO, HAS AIR BAG PHOTOS. *AK
1994 Chevrolet Suburban
Owner reports · Recalls · Investigations
More warning signs than most Suburban years
Owner complaints for the 1994 Chevrolet Suburban are substantially higher than the model-year median of 118.
About this comparison →How this year compares
Owner complaints by model year
Compare all Suburban years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 32 of 858 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 568 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 167 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
146 crash reports8 fire reports33 injury reports
Seats complaints
18 reportsSEAT WELD BROKE ON DRIVERS SEAT. *AK
I SAT DOWN ON THE DRIVERS SEAT ON 2/5/04 AND IT FELT LIKE THE SEAT WAS LOOSE. I LOOKED UNDERNEATH THE SEAT AND DISCOVERED THE METAL BRACKET NEAR THE LEFT FRONT BOLT OF THE THE SEAT HAD BROKEN OFF AND THE SEAT WAS NO LONGER ATTACHED TO THE FRAME. THIS IS DISTURBING AS THIS VEHICLE HAS NEVER BEED IN AN ACCIDENT OR HAD ANY UNUSAL …
Read full complaint
I SAT DOWN ON THE DRIVERS SEAT ON 2/5/04 AND IT FELT LIKE THE SEAT WAS LOOSE. I LOOKED UNDERNEATH THE SEAT AND DISCOVERED THE METAL BRACKET NEAR THE LEFT FRONT BOLT OF THE THE SEAT HAD BROKEN OFF AND THE SEAT WAS NO LONGER ATTACHED TO THE FRAME. THIS IS DISTURBING AS THIS VEHICLE HAS NEVER BEED IN AN ACCIDENT OR HAD ANY UNUSAL USE AND HAS LESS THAN 83,000 MILES. I AM THE ORIGINAL OWNER.
1994 CHEVROLET SUBURBAN DRIVERS SEAT FAILED DUE TO CRACK IN FRAME STRUCTURE.*AK
DRIVER'S SEAT PLATE IS CRACKING WHICH MAY CAUSE THE SEAT TO COLLAPSE.*AKTHE METAL IS SO THIN THAT THE CONSUMER IS CONCERNED THAT IF IT BREAKS THERE MAY BE AN ACCIDENT. *NLM
WHILE DRIVING NUT WELDED ONTO FRAME OF THE SEAT BROKE AWAY FROM THE BOLT. IT MADE THE SEAT TILT BACK WHILE DRIVING. *AK
THE DRIVER'S SEAT FRAME, WHERE IT IS BOLTED TO THE SEAT TRACK, FRACTURED AND BROKE LOOSE AT THE LEFT FRONT BOLT. THE FRAME SHEARED OFF IN A JAGGED PIECE, LEAVING THE BOLT AND NUT ATTACHED TO THE TRACK AND ALLOWING THE SEAT TO SUDDENLY TILT BACKWARDS. *AK
DRIVER'S SEAT CUSHION BROKE FROM ITS ANCHOR, MAKING CONTROL OF VEHICLE DIFFICULT. *AK
WHEN DRIVING THE SEAT WILL ROCK FROM THE BACK TO THE FRONT AND ONLY WHEN SHORT DRIVERS ARE DRIVING. *AK THE WINDSHIELD WIPERS STOPPED WORKING TWICE BECAUSE WINDSHIELD WIPER MOTOR FAILED. *YH
THE BRACKET BETWEEN THE SEAT CUSHION AND SEAT BASE AT THE FRONT LEFT CORNER OF THE SEAT BROKE. THE VEHICLE COULD NOT BE DRIVEN IN THIS CONDITION.
Official recalls
303V159000 · Visibility:windshield Wiper/washer
Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
99V025000 · Exterior Lighting:brake Lights:switch
Feb 5, 1999
VEHICLE DESCRIPTION: PICKUP TRUCKS, CREW CABS, UTILITY TRUCKS AND SPORT UTILITY VEHICLES. THESE VEHICLES WERE BUILT WITH THE POLARITY OF THE WIRING FOR THE ZERO ADJUST BRAKE SWITCH REVERSED FROM WHAT WAS SPECIFIED ON THE SWITCH DRAWING. WITH THE REVERSED POLARITY, THE CONTACTS IN THE BRAKE SWITCH CAN WEAR OUT PREMATURELY. THE BRAKE SWITCH WILL PERFORM NORMALLY UNTIL THE BRAKE SWITCH CONTACTS WEAR OUT, RESULTING IN LOSS OF THE BRAKE LAMPS WITHOUT ANY WARNING TO THE DRIVER.
Consequence & remedy
Consequence: THIS WOULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND COULD LEAD TO A CRASH.
Remedy: DEALERS WILL REPLACE THE BRAKE SWITCH AND REVERSE THE WIRING.
98V150001 · Visibility:windshield Wiper/washer
Jul 1, 1998
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
DP00001 · Oem Hitch Receiver Platform Cracking
Opened Jan 31, 2000 · No close date supplied
Status: open (inferred from source dates) · Equipment
THE PETITION ALLEGES THAT CRACKS IN THE HITCH RECEIVER PLATFORM MAY LEAD TO SEPARATION OF THE TRAILER AND LOSS OF STEERING CONTROL
PE97027 · Drivers Seat Failure
Opened Jun 17, 1997 · Closed Oct 31, 1997
Status: closed (inferred from source dates) · Seats
THE COMPLAINANTS ALLEGE THE DRIVERS SEAT MOUNTING FAILS, ALLOWING THE SEAT TO MOVE OR TIP REARWARD INTO A RECLINED POSITION.
EA95026 · Poor Brake Performance
Opened Sep 20, 1995 · Closed Sep 20, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
POOR PERFORMANCE OF ABS BRAKES