SkipThatYearREAL DATA. SMARTER CAR DECISIONS.
← New search

2007 Chevrolet Suburban 1500

Owner reports · Recalls · Investigations

More warning signs than most Suburban 1500 years

Owner complaints for the 2007 Chevrolet Suburban 1500 are substantially higher than the model-year median of 53.

About this comparison →
190Owner complaints

Model-year median: 53

0Recall campaigns

View recall details →

2Investigations

View investigation details →

How this year compares

Owner complaints by model year

Other model years Selected year
182
200494
200531
2006190
2007101
200855
200953
2010
Compare all Suburban 1500 years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

Air Bags
63Structure
29Electrical System
26Unknown Or Other
22Power Train
17
All reported categories
Engine And Engine Cooling
13Engine
12Electronic Stability Control (esc)
9Latches/locks/linkages
9Fuel System, Gasoline
6Seat Belts
5Seats
4Tires
4Equipment
3Exterior Lighting
3Electronic Stability Control
2Steering
2Suspension
2Visibility
2Wheels
2Equipment Adaptive/mobility
1Fuel/propulsion System
1Service Brakes, Hydraulic
1Vehicle Speed Control
1Visibility/wiper
1

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

132 reports with mileage · 58 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Air Bags. Review the 63 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Structure. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

2 crash reports6 fire reports19 injury reports

Tires complaints

4 reports
Clear category filter
15,200 miles · May 17, 2011
Electrical SystemTires

TIRE PRESSURE MONITORING SYSTEM WAS PROBLEMATIC FOR YEARS. THE DISPLAY WOULD LIGHT AND MESSAGE CENTER WOULD INDICATE ALL TIRES WERE LOW WHEN NONE WERE BY CHECK OF ACCURATE GAUGE. THIS PROBLEM HAS FINALLY BEEN ADDRESSED AT LEAST TEMPORARILY. CHECK ENGINE LIGHTS STAY ON. VEHICLE HAS BEEN TO SHOP AND DEALER ON MULTIPLE OCCASION…

Read full complaint

TIRE PRESSURE MONITORING SYSTEM WAS PROBLEMATIC FOR YEARS. THE DISPLAY WOULD LIGHT AND MESSAGE CENTER WOULD INDICATE ALL TIRES WERE LOW WHEN NONE WERE BY CHECK OF ACCURATE GAUGE. THIS PROBLEM HAS FINALLY BEEN ADDRESSED AT LEAST TEMPORARILY. CHECK ENGINE LIGHTS STAY ON. VEHICLE HAS BEEN TO SHOP AND DEALER ON MULTIPLE OCCASIONS. TESTS HAVE BEEN RUN AND THE CODES RESET, TO NO AVAIL. THE CHECK ENGINE LIGHT IS ON AND VEHICLE PERFORMANCE SEEMS NORMAL, HOWEVER, THE WARNING LIGHT REMAINS USELESS FOR ANY "REAL" PROBLEM. PLEASE CONSIDER THE LOW MILEAGE (CURRENTLY 18,224) WHEN CONSIDERING PROBLEMS. *TR

NHTSA ODI #10401217

10,458 miles · Feb 5, 2010
Electrical SystemEquipmentTires

NO CRASHES OR INJURIES. ON THE INDICATED DATE I HAD THE ENGINE TURNED OFF WITH THE KEYS IN THE IGNITION, LISTENING TO THE RADIO. AFTER A SHORT TIME APPROXIMATELY 10 MINUTES, I DISCOVERED THAT THE CAR BATTERY WAS COMPLETELY DRAINED. I HAVE BEEN CAREFUL NOT LET THESE INCIDENTS OCCUR AGAIN BUT IT HAS REPEATED AT LEAST 6 TIMES. THE …

Read full complaint

NO CRASHES OR INJURIES. ON THE INDICATED DATE I HAD THE ENGINE TURNED OFF WITH THE KEYS IN THE IGNITION, LISTENING TO THE RADIO. AFTER A SHORT TIME APPROXIMATELY 10 MINUTES, I DISCOVERED THAT THE CAR BATTERY WAS COMPLETELY DRAINED. I HAVE BEEN CAREFUL NOT LET THESE INCIDENTS OCCUR AGAIN BUT IT HAS REPEATED AT LEAST 6 TIMES. THE MOST RECENT TIME WAS WHEN I HAD A FLAT TIRE REPLACED AND THE TIRE SERVICE TECH ATTEMPTED TO REPROGRAM THE TIRE PRESSURE MONITOR SYSTEM AT WHICH TIME, THE BATTERY WAS DRAINED IMMEDIATELY. THE REPROGRAMMING WAS IMPOSSIBLE BECAUSE THE BATTERY WOULD NOT PROVIDE ELECTRICITY TO COMPLETE THE TPMS. I FOLLOWED THE OWNER'S MANUAL'S INSTRUCTIONS' AND HAD THE SAME RESULTS, A DEAD BATTERY AND UNSUCCESSFUL ATTEMPT. I NOW HAVE A USELESS TPMS AND THE DANGER OF GETTING STRANDED WITH A DEAD BATTERY. THE DEALERSHIP OFFERS TO ATTEMPT TO FIX THE PROBLEM STARTING AT $99.00 +. A NEW VEHICLE SHOULD BE FREE OF THESE TYPES OF DEFECTS. I SHOULD NOT BE PAYING FOR THE REPAIR. *TR

NHTSA ODI #10306602

20,860 miles · Jun 18, 2008
Tires

WE WENT ON VACATION AND GOT A HOLE IN THE TREAD OF THE FRONT PASSENGER SIDE TIRE ON JUNE 3, 2008. WE GOT IT REPLACED, AND BLEW OUT THE FRONT DRIVER'S SIDE TIRE ON JUNE 5, 2008. WE GOT TWO NEW TIRES AND PUT THEM ON THE REAR AND MOVED THE OLD TIRES TO THE FRONT. ON JUNE 18, 2008 WE GOT ANOTHER HOLE IN THE DRIVER'S SIDE TIRE. WE…

Read full complaint

WE WENT ON VACATION AND GOT A HOLE IN THE TREAD OF THE FRONT PASSENGER SIDE TIRE ON JUNE 3, 2008. WE GOT IT REPLACED, AND BLEW OUT THE FRONT DRIVER'S SIDE TIRE ON JUNE 5, 2008. WE GOT TWO NEW TIRES AND PUT THEM ON THE REAR AND MOVED THE OLD TIRES TO THE FRONT. ON JUNE 18, 2008 WE GOT ANOTHER HOLE IN THE DRIVER'S SIDE TIRE. WE GOT RID OF THE FIRST TWO TIRES, BUT STILL HAVE THE TWO WE MOVED TO THE FRONT. *TR

NHTSA ODI #10231454

13,500 miles · Sep 2, 2007
Tires

THE TREADWALLS ON THE OUTSIDE OF THE TIRE AT THE TOP SLITS AND LOSS AIR. THIS IS UNREPAIRABLE. THIS IS THE 2ND OF 4 TIRES WITH THE SAME ISSUE. THE 1ST WE WERE STANDING OUTSIDE AND THE TRUCK WAS PARKED AND WE HEARD A POP AND THEN HEARD AIR COMING FROM THE TIRE. THIS TIME WE WERE TRAVELING AND THE INSTRUMENT PANEL SENSED THE LOSS …

Read full complaint

THE TREADWALLS ON THE OUTSIDE OF THE TIRE AT THE TOP SLITS AND LOSS AIR. THIS IS UNREPAIRABLE. THIS IS THE 2ND OF 4 TIRES WITH THE SAME ISSUE. THE 1ST WE WERE STANDING OUTSIDE AND THE TRUCK WAS PARKED AND WE HEARD A POP AND THEN HEARD AIR COMING FROM THE TIRE. THIS TIME WE WERE TRAVELING AND THE INSTRUMENT PANEL SENSED THE LOSS OF AIR AND ALERTED ME AND WE PULLED OFF THE INTERSTATE JUST IN TIME TO AVOID AN UNFORESEEN ACCIDENT. I HAD 8 PEOPLE INCLUDING MYSELF IN THE VEHICLE AT THIS TIME. *TR

NHTSA ODI #10201717

Official recalls

0

No recalls in this snapshot.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

EA08010 · NON-CRASH Engine Compartment Fires

Opened Jun 12, 2008 · Closed Sep 8, 2008

Status: closed (inferred from source dates) · Electrical System; Electrical SYSTEM:12V/24V/48V Battery; Electrical System:wiring; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers; Engine And Engine Cooling; Engine And Engine Cooling:engine; Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:switch/wiring

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

Additional source detail variants (9)

Electrical SYSTEM:12V/24V/48V Battery

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

Electrical System

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

Electrical System:wiring:front Underhood

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

Electrical System:wiring:fuses And Circuit Breakers

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

Electrical System:wiring

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

Engine And Engine Cooling:engine

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

Engine And Engine Cooling

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

Visibility:windshield Wiper/washer

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

Visibility:windshield Wiper/washer:switch/wiring

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

PE08010 · NON-CRASH Engine Compartment Fires

Opened Feb 4, 2008 · Closed Jun 12, 2008

Status: closed (inferred from source dates) · Electrical System; Electrical SYSTEM:12V/24V/48V Battery; Electrical SYSTEM:12V/24V/48V Battery:cables; Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine

IN RESPONSE TO AN INFORMATION REQUEST LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION(ODI) DURING PRELIMINARY EVALUATION PE08-010, GM PROVIDED ODI WITH 41 ALLEGATIONS OF NON-CRASH ENGINE COMPARTMENT FIRES INCLUDING 16 ALLEGATIONS OF FIRES ORIGINATING WITH THE IGNITION IN THE OFF POSITION.ONE OF THE FIRES WAS DETERMINED TO BE CAUSED BY AN ARSON EVENT.ODI HAS ALSO RECEIVED 5 REPORTS, 4 OF WHICH ARE OF DUPLICATIVE OF REPORTS PROVIDED BY GM, ALLEGING NON-CRASH ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.IN TOTAL, ODI IS AWARE OF 41 NON-CRASHENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES THAT ARE UNRELATED TO ARSON.EIGHT OF THE 41 FIRE ALLEGATIONS ALSO ALLEGE PROPERTY DAMAGE AS A RESULT OF THE FIRES.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-010) TO FURTHER ASSESS THE SCOPE, FREQUENCY, ORIGIN AND CAUSE OF THE ALLEGED NON-CRASH RELATED ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.

Additional source detail variants (7)

Electrical SYSTEM:12V/24V/48V Battery:cables

IN RESPONSE TO AN INFORMATION REQUEST LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION(ODI) DURING PRELIMINARY EVALUATION PE08-010, GM PROVIDED ODI WITH 41 ALLEGATIONS OF NON-CRASH ENGINE COMPARTMENT FIRES INCLUDING 16 ALLEGATIONS OF FIRES ORIGINATING WITH THE IGNITION IN THE OFF POSITION.ONE OF THE FIRES WAS DETERMINED TO BE CAUSED BY AN ARSON EVENT.ODI HAS ALSO RECEIVED 5 REPORTS, 4 OF WHICH ARE OF DUPLICATIVE OF REPORTS PROVIDED BY GM, ALLEGING NON-CRASH ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.IN TOTAL, ODI IS AWARE OF 41 NON-CRASHENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES THAT ARE UNRELATED TO ARSON.EIGHT OF THE 41 FIRE ALLEGATIONS ALSO ALLEGE PROPERTY DAMAGE AS A RESULT OF THE FIRES.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-010) TO FURTHER ASSESS THE SCOPE, FREQUENCY, ORIGIN AND CAUSE OF THE ALLEGED NON-CRASH RELATED ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.

Electrical SYSTEM:12V/24V/48V Battery

IN RESPONSE TO AN INFORMATION REQUEST LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION(ODI) DURING PRELIMINARY EVALUATION PE08-010, GM PROVIDED ODI WITH 41 ALLEGATIONS OF NON-CRASH ENGINE COMPARTMENT FIRES INCLUDING 16 ALLEGATIONS OF FIRES ORIGINATING WITH THE IGNITION IN THE OFF POSITION.ONE OF THE FIRES WAS DETERMINED TO BE CAUSED BY AN ARSON EVENT.ODI HAS ALSO RECEIVED 5 REPORTS, 4 OF WHICH ARE OF DUPLICATIVE OF REPORTS PROVIDED BY GM, ALLEGING NON-CRASH ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.IN TOTAL, ODI IS AWARE OF 41 NON-CRASHENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES THAT ARE UNRELATED TO ARSON.EIGHT OF THE 41 FIRE ALLEGATIONS ALSO ALLEGE PROPERTY DAMAGE AS A RESULT OF THE FIRES.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-010) TO FURTHER ASSESS THE SCOPE, FREQUENCY, ORIGIN AND CAUSE OF THE ALLEGED NON-CRASH RELATED ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.

Electrical System

IN RESPONSE TO AN INFORMATION REQUEST LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION(ODI) DURING PRELIMINARY EVALUATION PE08-010, GM PROVIDED ODI WITH 41 ALLEGATIONS OF NON-CRASH ENGINE COMPARTMENT FIRES INCLUDING 16 ALLEGATIONS OF FIRES ORIGINATING WITH THE IGNITION IN THE OFF POSITION.ONE OF THE FIRES WAS DETERMINED TO BE CAUSED BY AN ARSON EVENT.ODI HAS ALSO RECEIVED 5 REPORTS, 4 OF WHICH ARE OF DUPLICATIVE OF REPORTS PROVIDED BY GM, ALLEGING NON-CRASH ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.IN TOTAL, ODI IS AWARE OF 41 NON-CRASHENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES THAT ARE UNRELATED TO ARSON.EIGHT OF THE 41 FIRE ALLEGATIONS ALSO ALLEGE PROPERTY DAMAGE AS A RESULT OF THE FIRES.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-010) TO FURTHER ASSESS THE SCOPE, FREQUENCY, ORIGIN AND CAUSE OF THE ALLEGED NON-CRASH RELATED ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.

Electrical System:wiring:front Underhood

IN RESPONSE TO AN INFORMATION REQUEST LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION(ODI) DURING PRELIMINARY EVALUATION PE08-010, GM PROVIDED ODI WITH 41 ALLEGATIONS OF NON-CRASH ENGINE COMPARTMENT FIRES INCLUDING 16 ALLEGATIONS OF FIRES ORIGINATING WITH THE IGNITION IN THE OFF POSITION.ONE OF THE FIRES WAS DETERMINED TO BE CAUSED BY AN ARSON EVENT.ODI HAS ALSO RECEIVED 5 REPORTS, 4 OF WHICH ARE OF DUPLICATIVE OF REPORTS PROVIDED BY GM, ALLEGING NON-CRASH ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.IN TOTAL, ODI IS AWARE OF 41 NON-CRASHENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES THAT ARE UNRELATED TO ARSON.EIGHT OF THE 41 FIRE ALLEGATIONS ALSO ALLEGE PROPERTY DAMAGE AS A RESULT OF THE FIRES.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-010) TO FURTHER ASSESS THE SCOPE, FREQUENCY, ORIGIN AND CAUSE OF THE ALLEGED NON-CRASH RELATED ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.

Electrical System:wiring

IN RESPONSE TO AN INFORMATION REQUEST LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION(ODI) DURING PRELIMINARY EVALUATION PE08-010, GM PROVIDED ODI WITH 41 ALLEGATIONS OF NON-CRASH ENGINE COMPARTMENT FIRES INCLUDING 16 ALLEGATIONS OF FIRES ORIGINATING WITH THE IGNITION IN THE OFF POSITION.ONE OF THE FIRES WAS DETERMINED TO BE CAUSED BY AN ARSON EVENT.ODI HAS ALSO RECEIVED 5 REPORTS, 4 OF WHICH ARE OF DUPLICATIVE OF REPORTS PROVIDED BY GM, ALLEGING NON-CRASH ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.IN TOTAL, ODI IS AWARE OF 41 NON-CRASHENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES THAT ARE UNRELATED TO ARSON.EIGHT OF THE 41 FIRE ALLEGATIONS ALSO ALLEGE PROPERTY DAMAGE AS A RESULT OF THE FIRES.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-010) TO FURTHER ASSESS THE SCOPE, FREQUENCY, ORIGIN AND CAUSE OF THE ALLEGED NON-CRASH RELATED ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.

Engine And Engine Cooling:engine

IN RESPONSE TO AN INFORMATION REQUEST LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION(ODI) DURING PRELIMINARY EVALUATION PE08-010, GM PROVIDED ODI WITH 41 ALLEGATIONS OF NON-CRASH ENGINE COMPARTMENT FIRES INCLUDING 16 ALLEGATIONS OF FIRES ORIGINATING WITH THE IGNITION IN THE OFF POSITION.ONE OF THE FIRES WAS DETERMINED TO BE CAUSED BY AN ARSON EVENT.ODI HAS ALSO RECEIVED 5 REPORTS, 4 OF WHICH ARE OF DUPLICATIVE OF REPORTS PROVIDED BY GM, ALLEGING NON-CRASH ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.IN TOTAL, ODI IS AWARE OF 41 NON-CRASHENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES THAT ARE UNRELATED TO ARSON.EIGHT OF THE 41 FIRE ALLEGATIONS ALSO ALLEGE PROPERTY DAMAGE AS A RESULT OF THE FIRES.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-010) TO FURTHER ASSESS THE SCOPE, FREQUENCY, ORIGIN AND CAUSE OF THE ALLEGED NON-CRASH RELATED ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.

Engine And Engine Cooling

IN RESPONSE TO AN INFORMATION REQUEST LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION(ODI) DURING PRELIMINARY EVALUATION PE08-010, GM PROVIDED ODI WITH 41 ALLEGATIONS OF NON-CRASH ENGINE COMPARTMENT FIRES INCLUDING 16 ALLEGATIONS OF FIRES ORIGINATING WITH THE IGNITION IN THE OFF POSITION.ONE OF THE FIRES WAS DETERMINED TO BE CAUSED BY AN ARSON EVENT.ODI HAS ALSO RECEIVED 5 REPORTS, 4 OF WHICH ARE OF DUPLICATIVE OF REPORTS PROVIDED BY GM, ALLEGING NON-CRASH ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.IN TOTAL, ODI IS AWARE OF 41 NON-CRASHENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES THAT ARE UNRELATED TO ARSON.EIGHT OF THE 41 FIRE ALLEGATIONS ALSO ALLEGE PROPERTY DAMAGE AS A RESULT OF THE FIRES.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-010) TO FURTHER ASSESS THE SCOPE, FREQUENCY, ORIGIN AND CAUSE OF THE ALLEGED NON-CRASH RELATED ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.