SkipThatYearREAL DATA. SMARTER CAR DECISIONS.
← New search

2007 Chevrolet Suburban 1500

Owner reports · Recalls · Investigations

More warning signs than most Suburban 1500 years

Owner complaints for the 2007 Chevrolet Suburban 1500 are substantially higher than the model-year median of 53.

About this comparison →
190Owner complaints

Model-year median: 53

0Recall campaigns

View recall details →

2Investigations

View investigation details →

How this year compares

Owner complaints by model year

Other model years Selected year
182
200494
200531
2006190
2007101
200855
200953
2010
Compare all Suburban 1500 years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

Air Bags
63Structure
29Electrical System
26Unknown Or Other
22Power Train
17
All reported categories
Engine And Engine Cooling
13Engine
12Electronic Stability Control (esc)
9Latches/locks/linkages
9Fuel System, Gasoline
6Seat Belts
5Seats
4Tires
4Equipment
3Exterior Lighting
3Electronic Stability Control
2Steering
2Suspension
2Visibility
2Wheels
2Equipment Adaptive/mobility
1Fuel/propulsion System
1Service Brakes, Hydraulic
1Vehicle Speed Control
1Visibility/wiper
1

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

132 reports with mileage · 58 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Air Bags. Review the 63 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Structure. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

2 crash reports6 fire reports19 injury reports

Air Bags complaints

63 reports
Clear category filter
24,000 miles · Aug 19, 2008
Air BagsInjury

TL*THE CONTACT OWNS A 2007 CHEVROLET SUBURBAN 1500. THE CONTACT STATED THAT THE STABILITRACK WARNING LIGHT CONTINUED TO ILLUMINATE ON THE INSTRUMENT PANEL. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. WHILE DRIVING 40 MPH, ALL SIX SIDE CURTAIN AIR BAGS DEPLOYED WITHOUT IMPACT OR ROLLOVER. SHE WAS UNABLE TO SEE OUT ANY…

Read full complaint

TL*THE CONTACT OWNS A 2007 CHEVROLET SUBURBAN 1500. THE CONTACT STATED THAT THE STABILITRACK WARNING LIGHT CONTINUED TO ILLUMINATE ON THE INSTRUMENT PANEL. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. WHILE DRIVING 40 MPH, ALL SIX SIDE CURTAIN AIR BAGS DEPLOYED WITHOUT IMPACT OR ROLLOVER. SHE WAS UNABLE TO SEE OUT ANY OF THE WINDOWS AND THE PASSENGER COMPARTMENT BECAME FILLED WITH SMOKE FROM THE AIR BAG DEBRIS. THE CONTACT WAS INJURED. THE DEALER FOUND NO FAILURES WITH THE VEHICLE. THE INSURANCE COMPANY SENT A CRASH TEAM TO INVESTIGATE THE FAILURE AND THEY STATED THAT ALTHOUGH THERE WAS NO RECALL, THE AIR BAG SENSORS WERE TOO SENSITIVE AND WOULD ACTIVATE WITHOUT WARNING. THEY ALSO STATED THAT THEY OBSERVED SEVERAL SIMILAR INSTANCES WITH THE SAME MODEL VEHICLE. THE FAILURE AND CURRENT MILEAGES WERE 24,000.

NHTSA ODI #10238857

1,000 miles · Mar 9, 2007
Air Bags

THE SENSOR FOR THE PASSENGER SIDE AIRBAG ON OUR 2007 CHEVROLET SUBURBAN DOES NOT FUNCTION PROPERLY WITH A SMALL ADULT WEIGHING BETWEEN 105 AND 115 POUNDS SITTING IN THE SEAT. THE AIRBAG CONTINUALLY SWITCHES BACK AND FORTH FROM ON TO OFF ON A TRIP. MY WIFE WILL TRY TO FIND A POSITION WHERE THE AIRBAG IS ON, ONLY TO NOTICE SEVER…

Read full complaint

THE SENSOR FOR THE PASSENGER SIDE AIRBAG ON OUR 2007 CHEVROLET SUBURBAN DOES NOT FUNCTION PROPERLY WITH A SMALL ADULT WEIGHING BETWEEN 105 AND 115 POUNDS SITTING IN THE SEAT. THE AIRBAG CONTINUALLY SWITCHES BACK AND FORTH FROM ON TO OFF ON A TRIP. MY WIFE WILL TRY TO FIND A POSITION WHERE THE AIRBAG IS ON, ONLY TO NOTICE SEVERAL MINUTES LATER IT IS AGAIN OFF. *JB

NHTSA ODI #10184596

Mileage unknown · Oct 17, 2006
Air BagsElectrical System

CAR IS 2007 CHEVROLET SUBURBAN - 2 MONTHS OLD. CHECK ENGINE AND CHECK AIR BAG LIGHTS CAME ON. THEN, NEXT DAY CAR WOULD NOT START AND WAS JUMPED EASILY. AFTER 2 DAYS AT DEALERSHIP SERVICE DEPT., DECIDED IT WAS THE CDM. 15 DAYS LATER CDM CAME IN BUT, SERVICE TECHS FOUND 4-5 WIRES "BURNT UP". WIRING HARNESS IS BROKEN. AFTER 6…

Read full complaint

CAR IS 2007 CHEVROLET SUBURBAN - 2 MONTHS OLD. CHECK ENGINE AND CHECK AIR BAG LIGHTS CAME ON. THEN, NEXT DAY CAR WOULD NOT START AND WAS JUMPED EASILY. AFTER 2 DAYS AT DEALERSHIP SERVICE DEPT., DECIDED IT WAS THE CDM. 15 DAYS LATER CDM CAME IN BUT, SERVICE TECHS FOUND 4-5 WIRES "BURNT UP". WIRING HARNESS IS BROKEN. AFTER 6 DAYS WIRING HARNESS IS IN AND BEING REPLACED CURRENTLY. DEALERSHIP IS NOT SURE THIS WILL SOLVE THE PROBLEM. *NM

NHTSA ODI #10171129

Official recalls

0

No recalls in this snapshot.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

EA08010 · NON-CRASH Engine Compartment Fires

Opened Jun 12, 2008 · Closed Sep 8, 2008

Status: closed (inferred from source dates) · Electrical System; Electrical SYSTEM:12V/24V/48V Battery; Electrical System:wiring; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers; Engine And Engine Cooling; Engine And Engine Cooling:engine; Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:switch/wiring

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

Additional source detail variants (9)

Electrical SYSTEM:12V/24V/48V Battery

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

Electrical System

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

Electrical System:wiring:front Underhood

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

Electrical System:wiring:fuses And Circuit Breakers

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

Electrical System:wiring

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

Engine And Engine Cooling:engine

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

Engine And Engine Cooling

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

Visibility:windshield Wiper/washer

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

Visibility:windshield Wiper/washer:switch/wiring

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

PE08010 · NON-CRASH Engine Compartment Fires

Opened Feb 4, 2008 · Closed Jun 12, 2008

Status: closed (inferred from source dates) · Electrical System; Electrical SYSTEM:12V/24V/48V Battery; Electrical SYSTEM:12V/24V/48V Battery:cables; Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine

IN RESPONSE TO AN INFORMATION REQUEST LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION(ODI) DURING PRELIMINARY EVALUATION PE08-010, GM PROVIDED ODI WITH 41 ALLEGATIONS OF NON-CRASH ENGINE COMPARTMENT FIRES INCLUDING 16 ALLEGATIONS OF FIRES ORIGINATING WITH THE IGNITION IN THE OFF POSITION.ONE OF THE FIRES WAS DETERMINED TO BE CAUSED BY AN ARSON EVENT.ODI HAS ALSO RECEIVED 5 REPORTS, 4 OF WHICH ARE OF DUPLICATIVE OF REPORTS PROVIDED BY GM, ALLEGING NON-CRASH ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.IN TOTAL, ODI IS AWARE OF 41 NON-CRASHENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES THAT ARE UNRELATED TO ARSON.EIGHT OF THE 41 FIRE ALLEGATIONS ALSO ALLEGE PROPERTY DAMAGE AS A RESULT OF THE FIRES.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-010) TO FURTHER ASSESS THE SCOPE, FREQUENCY, ORIGIN AND CAUSE OF THE ALLEGED NON-CRASH RELATED ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.

Additional source detail variants (7)

Electrical SYSTEM:12V/24V/48V Battery:cables

IN RESPONSE TO AN INFORMATION REQUEST LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION(ODI) DURING PRELIMINARY EVALUATION PE08-010, GM PROVIDED ODI WITH 41 ALLEGATIONS OF NON-CRASH ENGINE COMPARTMENT FIRES INCLUDING 16 ALLEGATIONS OF FIRES ORIGINATING WITH THE IGNITION IN THE OFF POSITION.ONE OF THE FIRES WAS DETERMINED TO BE CAUSED BY AN ARSON EVENT.ODI HAS ALSO RECEIVED 5 REPORTS, 4 OF WHICH ARE OF DUPLICATIVE OF REPORTS PROVIDED BY GM, ALLEGING NON-CRASH ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.IN TOTAL, ODI IS AWARE OF 41 NON-CRASHENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES THAT ARE UNRELATED TO ARSON.EIGHT OF THE 41 FIRE ALLEGATIONS ALSO ALLEGE PROPERTY DAMAGE AS A RESULT OF THE FIRES.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-010) TO FURTHER ASSESS THE SCOPE, FREQUENCY, ORIGIN AND CAUSE OF THE ALLEGED NON-CRASH RELATED ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.

Electrical SYSTEM:12V/24V/48V Battery

IN RESPONSE TO AN INFORMATION REQUEST LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION(ODI) DURING PRELIMINARY EVALUATION PE08-010, GM PROVIDED ODI WITH 41 ALLEGATIONS OF NON-CRASH ENGINE COMPARTMENT FIRES INCLUDING 16 ALLEGATIONS OF FIRES ORIGINATING WITH THE IGNITION IN THE OFF POSITION.ONE OF THE FIRES WAS DETERMINED TO BE CAUSED BY AN ARSON EVENT.ODI HAS ALSO RECEIVED 5 REPORTS, 4 OF WHICH ARE OF DUPLICATIVE OF REPORTS PROVIDED BY GM, ALLEGING NON-CRASH ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.IN TOTAL, ODI IS AWARE OF 41 NON-CRASHENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES THAT ARE UNRELATED TO ARSON.EIGHT OF THE 41 FIRE ALLEGATIONS ALSO ALLEGE PROPERTY DAMAGE AS A RESULT OF THE FIRES.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-010) TO FURTHER ASSESS THE SCOPE, FREQUENCY, ORIGIN AND CAUSE OF THE ALLEGED NON-CRASH RELATED ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.

Electrical System

IN RESPONSE TO AN INFORMATION REQUEST LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION(ODI) DURING PRELIMINARY EVALUATION PE08-010, GM PROVIDED ODI WITH 41 ALLEGATIONS OF NON-CRASH ENGINE COMPARTMENT FIRES INCLUDING 16 ALLEGATIONS OF FIRES ORIGINATING WITH THE IGNITION IN THE OFF POSITION.ONE OF THE FIRES WAS DETERMINED TO BE CAUSED BY AN ARSON EVENT.ODI HAS ALSO RECEIVED 5 REPORTS, 4 OF WHICH ARE OF DUPLICATIVE OF REPORTS PROVIDED BY GM, ALLEGING NON-CRASH ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.IN TOTAL, ODI IS AWARE OF 41 NON-CRASHENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES THAT ARE UNRELATED TO ARSON.EIGHT OF THE 41 FIRE ALLEGATIONS ALSO ALLEGE PROPERTY DAMAGE AS A RESULT OF THE FIRES.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-010) TO FURTHER ASSESS THE SCOPE, FREQUENCY, ORIGIN AND CAUSE OF THE ALLEGED NON-CRASH RELATED ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.

Electrical System:wiring:front Underhood

IN RESPONSE TO AN INFORMATION REQUEST LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION(ODI) DURING PRELIMINARY EVALUATION PE08-010, GM PROVIDED ODI WITH 41 ALLEGATIONS OF NON-CRASH ENGINE COMPARTMENT FIRES INCLUDING 16 ALLEGATIONS OF FIRES ORIGINATING WITH THE IGNITION IN THE OFF POSITION.ONE OF THE FIRES WAS DETERMINED TO BE CAUSED BY AN ARSON EVENT.ODI HAS ALSO RECEIVED 5 REPORTS, 4 OF WHICH ARE OF DUPLICATIVE OF REPORTS PROVIDED BY GM, ALLEGING NON-CRASH ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.IN TOTAL, ODI IS AWARE OF 41 NON-CRASHENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES THAT ARE UNRELATED TO ARSON.EIGHT OF THE 41 FIRE ALLEGATIONS ALSO ALLEGE PROPERTY DAMAGE AS A RESULT OF THE FIRES.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-010) TO FURTHER ASSESS THE SCOPE, FREQUENCY, ORIGIN AND CAUSE OF THE ALLEGED NON-CRASH RELATED ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.

Electrical System:wiring

IN RESPONSE TO AN INFORMATION REQUEST LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION(ODI) DURING PRELIMINARY EVALUATION PE08-010, GM PROVIDED ODI WITH 41 ALLEGATIONS OF NON-CRASH ENGINE COMPARTMENT FIRES INCLUDING 16 ALLEGATIONS OF FIRES ORIGINATING WITH THE IGNITION IN THE OFF POSITION.ONE OF THE FIRES WAS DETERMINED TO BE CAUSED BY AN ARSON EVENT.ODI HAS ALSO RECEIVED 5 REPORTS, 4 OF WHICH ARE OF DUPLICATIVE OF REPORTS PROVIDED BY GM, ALLEGING NON-CRASH ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.IN TOTAL, ODI IS AWARE OF 41 NON-CRASHENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES THAT ARE UNRELATED TO ARSON.EIGHT OF THE 41 FIRE ALLEGATIONS ALSO ALLEGE PROPERTY DAMAGE AS A RESULT OF THE FIRES.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-010) TO FURTHER ASSESS THE SCOPE, FREQUENCY, ORIGIN AND CAUSE OF THE ALLEGED NON-CRASH RELATED ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.

Engine And Engine Cooling:engine

IN RESPONSE TO AN INFORMATION REQUEST LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION(ODI) DURING PRELIMINARY EVALUATION PE08-010, GM PROVIDED ODI WITH 41 ALLEGATIONS OF NON-CRASH ENGINE COMPARTMENT FIRES INCLUDING 16 ALLEGATIONS OF FIRES ORIGINATING WITH THE IGNITION IN THE OFF POSITION.ONE OF THE FIRES WAS DETERMINED TO BE CAUSED BY AN ARSON EVENT.ODI HAS ALSO RECEIVED 5 REPORTS, 4 OF WHICH ARE OF DUPLICATIVE OF REPORTS PROVIDED BY GM, ALLEGING NON-CRASH ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.IN TOTAL, ODI IS AWARE OF 41 NON-CRASHENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES THAT ARE UNRELATED TO ARSON.EIGHT OF THE 41 FIRE ALLEGATIONS ALSO ALLEGE PROPERTY DAMAGE AS A RESULT OF THE FIRES.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-010) TO FURTHER ASSESS THE SCOPE, FREQUENCY, ORIGIN AND CAUSE OF THE ALLEGED NON-CRASH RELATED ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.

Engine And Engine Cooling

IN RESPONSE TO AN INFORMATION REQUEST LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION(ODI) DURING PRELIMINARY EVALUATION PE08-010, GM PROVIDED ODI WITH 41 ALLEGATIONS OF NON-CRASH ENGINE COMPARTMENT FIRES INCLUDING 16 ALLEGATIONS OF FIRES ORIGINATING WITH THE IGNITION IN THE OFF POSITION.ONE OF THE FIRES WAS DETERMINED TO BE CAUSED BY AN ARSON EVENT.ODI HAS ALSO RECEIVED 5 REPORTS, 4 OF WHICH ARE OF DUPLICATIVE OF REPORTS PROVIDED BY GM, ALLEGING NON-CRASH ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.IN TOTAL, ODI IS AWARE OF 41 NON-CRASHENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES THAT ARE UNRELATED TO ARSON.EIGHT OF THE 41 FIRE ALLEGATIONS ALSO ALLEGE PROPERTY DAMAGE AS A RESULT OF THE FIRES.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-010) TO FURTHER ASSESS THE SCOPE, FREQUENCY, ORIGIN AND CAUSE OF THE ALLEGED NON-CRASH RELATED ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.