2015 Chevrolet Spark

The contact owns a 2015 Chevrolet Spark. The vehicle was purchased from a private seller. The contact became nauseated after driving the vehicle for the second time. The contact’s throat, chest, and eyes hurt, and his head was pulsating; the contact was unable to think clearly. No medical attention was received. The contact used an air quality meter to test the inside of the vehicle, which showed "Seriously bad air quality,” but there was no odor inside the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact stated that the vehicle had not been driven since experiencing the symptoms. The manufacturer was not made aware of the failure. The failure mileage was approximately 59,392.

INCIDENT SUMMARY In February 2025, while driving on the freeway, my vehicle experienced a sudden and complete loss of power. The battery rapidly depleted without warning, causing the vehicle to decelerate dangerously in moving traffic. A Stabilitrak warning appeared on the display. I was fortunate to reach the shoulder safely, but this failure created an extremely hazardous situation that could have resulted in serious injury or death. Following this incident, the vehicle became completely inoperable and required towing to Stewart Chevrolet for diagnosis. DEALERSHIP DIAGNOSIS Stewart Chevrolet performed a diagnostic evaluation (cost: $700) and provided the following official findings: Problem Identified: Battery 1 with voltage variance beyond specifications Variance Measured: In excess of 0.07V discrepancy in battery cells GM Document Referenced: #17-NA-131 Recommended Repair: Labor operation 9102972 - Drive Motor Replacement and Shipping Preparation (high voltage battery replacement) Estimated Cost: $10,000-12,000

Vehicle: 2015 Chevrolet Spark, odometer <79,000 miles Component that failed: Continuously Variable Transmission (CVT) – pulley damage causing complete loss of propulsion.What happened: While driving, the vehicle suddenly lost all motive power with no ability to accelerate. The transmission would not engage in any gear and the car became inoperable in traffic. This is the exact failure described in GM Special Coverage Bulletin N192271110 (pulley damage in 2014–2015 Spark CVT). Safety risk: Complete and unexpected loss of propulsion created an immediate safety hazard. The vehicle could not accelerate from a stop or maintain speed, placing my 15-year-old son and other motorists at risk of rear-end collision or stranding in active traffic lanes.Dealer confirmation: RK Chevrolet in Virginia Beach, VA has inspected the vehicle and confirmed the failure matches N192271110 – full transmission replacement required (quote $6,637.19). Vehicle remains at the dealership and is available for inspection.Warning lamps/symptoms: Check-engine light and reduced-power message appeared at time of failure. No prior warnings before the sudden loss of power event. Failure occurred approximately October 2025 – only four months after GM’s 10-year/120,000-mile Special Coverage N192271110 expired on 06/11/2025.The failed transmission is still in the vehicle and available for inspection upon request.

This report concerns a known CVT defect and subsequent TCM failure that left the vehicle unsafe and inoperable. The vehicle suffered internal CVT failure consistent with GM Special Coverage N192271110. After the first transmission failed in May 2024 (and the second time October 5 2025), the TCM failed again shortly after the second failure—consistent with GM Preliminary Information Bulletin PIP5525A. Critical Safety Details: Both failures occurred while driving on highways with heavy traffic, where speed limits were 75 mph. On each occasion, the vehicle lost power and became unable to accelerate safely, presenting a serious safety risk to me and other drivers. GM is refusing coverage despite widely documented cases and their own bulletins describing this exact failure chain.

Vehicle began slipping out of gear between 1st & 2nd, then started losing power at 74,760 miles. Extended service coverage has been issued for model for CVT transmission pulley system, however only covers 10 years or 100,000 miles, whichever comes first. Mine apparently timed out in February, so they are trying to make me get a new transmission which basically totals out the car I spent a fortune on to buy & in repairs at under 75,000 miles. This is unacceptable.

My 2015 Chevy Spark has had repeated transmission failures related to GM Special Coverage N192271110. The first failure happened in May 2024, I was driving on 1-25 when the transmission went out and I lost all speed and my car was in the shop for five months before I finally got it back in October 2024. Unfortunately, on October 5, 2025, the transmission failed again. I was driving on I-76 speed limit of 75 MPH when my car transmission went out and I lost speed.

The contact owns a 2015 Chevrolet Spark. The contact received notification of NHTSA Campaign Number: 16V257000 (Equipment, Electrical Systems). The vehicle was taken to the dealer, and the contact was informed that the radio software needed to be updated. The dealer informed the contact that to complete the software upgrade, the dealer had to reprogram the radio USB portion to complete the upgrade. The vehicle was repaired. The contact stated that while driving at an undisclosed speed, the radio image was inoperable. The contact stated that the radio image appeared blank. Additionally, the Bluetooth feature failed to function properly. The dealer was contacted. The vehicle was not diagnosed or repaired. The contact was concerned about the failure of the vehicle and that it was related to the recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 129,173.

Transmission issue. During heavy traffic at stop lights car wouldn't shift into drive to move forward. Was stuck in the middle of the road with a passenger. Engine light came on but it's not an engine problem. Car was smoking under the hood. I burned my hand when popping the hood. When the car cooled the engine light went out and car would shift gears and it's drivable again. This has happened 3 times. Mechanic pulled up at P0700 Code on computer. It's the CVT transmission but not sure which part. I can't get the car to the dealership to inspect transmission. It won't drive that far.

Ever since I bought the vehicle in 2021, I have had problems with the car jerking and air conditioning problems, mostly during the colder months. I took the car in multiple times on different occasions throughout the years. They would "fix" the problems with the transmission, then a month or two down the line the issues would come back. This last time, the car started stalling on the and turned off completely. The air conditioner never worked because of the transmission as well.