NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
122 reportsClear category filter75,000 miles · Mar 30, 2013
Service BrakesStructureCrash
I WAS DRIVING ALONG THE INTERSTATE AND TRAFFIC ABRUPTLY STOPPED IN FRONT OF ME. WHEN PRESSED ON THE BRAKE PEDAL, I SLOWED DOWN A LITTLE, BUT THEN THE PEDAL WENT TO THE FLOOR, AND I REAR-ENDED THE CAR IN FRONT OF ME. AFTER THE POLICE REPORT WAS FILED, I GOT IT TO A CHEVY DEALER AND THEY SAID THAT ONE OF THE STEEL BRAKE LINES FROM…
Read full complaint
I WAS DRIVING ALONG THE INTERSTATE AND TRAFFIC ABRUPTLY STOPPED IN FRONT OF ME. WHEN PRESSED ON THE BRAKE PEDAL, I SLOWED DOWN A LITTLE, BUT THEN THE PEDAL WENT TO THE FLOOR, AND I REAR-ENDED THE CAR IN FRONT OF ME. AFTER THE POLICE REPORT WAS FILED, I GOT IT TO A CHEVY DEALER AND THEY SAID THAT ONE OF THE STEEL BRAKE LINES FROM THE MASTER CYLINDER TO THE FRONT PASSENGER SIDE WAS RUSTED AND HAD BURST, SPILLING ALL OF THE BRAKE FLUID. THE WRECK DAMAGED THE FRONT PASSENGER SIDE BUMPER, AND BROKE THE GRILLE AND THE HEADLIGHT SUPPORT BRACKET. *TR
NHTSA ODI #10505026
Mileage unknown · Mar 22, 2013
Service Brakes
DRIVING 35 MPH WHEN I CAME TO NEXT RED LIGHT AND BRAKE PEDAL HIT THE FLOOR. TOOK VERY LONG TO COME TO A COMPLETE STOP. NOTICED LATER BRAKE LINES ARE CORRODED AND LEAKING DIRECTLY UNDERNEATH PASSENGER SIDE DOOR. APPEAR TO BE RUSTING ALL ALONG THE LENGTH OF THE TUBE. LUCKILY NO VEHICLES WERE IN FRONT OF ME AND WAS NOT TRAVELING AN…
Read full complaint
DRIVING 35 MPH WHEN I CAME TO NEXT RED LIGHT AND BRAKE PEDAL HIT THE FLOOR. TOOK VERY LONG TO COME TO A COMPLETE STOP. NOTICED LATER BRAKE LINES ARE CORRODED AND LEAKING DIRECTLY UNDERNEATH PASSENGER SIDE DOOR. APPEAR TO BE RUSTING ALL ALONG THE LENGTH OF THE TUBE. LUCKILY NO VEHICLES WERE IN FRONT OF ME AND WAS NOT TRAVELING ANY FASTER. *TR
NHTSA ODI #10504152
105,000 miles · Mar 7, 2013
Service Brakes
WHILE BACKING OUT AT A LITTLE LEAGUE PARKING LOT, THE BRAKE PEDAL WENT TO FLOOR AND I HAD TO USE THE EMERGENCY BRAKE TO STOP. ALL BRAKE LINES WERE RUSTED/RUPTURED. I DO NOT LIVE OR DRIVE IN THE "RUST BELT". THIS COULD HAVE BEEN MUCH WORSE TO INCLUDE PEDESTRIAN OR OCCUPANT FATALITIES. *TR
NHTSA ODI #10501932
100,000 miles · Mar 1, 2013
Service BrakesCrashInjury
TL* THE CONTACT OWNS A 2004 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT WHILE BRAKING FOR A TRAFFIC STOP, THE BRAKES ABNORMALLY TRAVELED TO THE FLOORBOARD AND THE VEHICLE DID NOT RESPOND. AS A RESULT, THE CONTACT CRASHED INTO A PEDESTRIAN. THE PEDESTRIAN WAS INJURED AND TRANSPORTED TO THE HOSPITAL. A POLICE REPORT WAS FILE…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT WHILE BRAKING FOR A TRAFFIC STOP, THE BRAKES ABNORMALLY TRAVELED TO THE FLOORBOARD AND THE VEHICLE DID NOT RESPOND. AS A RESULT, THE CONTACT CRASHED INTO A PEDESTRIAN. THE PEDESTRIAN WAS INJURED AND TRANSPORTED TO THE HOSPITAL. A POLICE REPORT WAS FILED OF THE INCIDENT. THE VEHICLE WAS TAKEN TO A MECHANIC, WHERE IT WAS DISCOVERED THAT THE ENTIRE BRAKE LINE WAS COMPLETELY RUSTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 100,000 AND THE CURRENT MILEAGE WAS 115,000.
NHTSA ODI #10500942
63,000 miles · Feb 25, 2013
Service Brakes
DRIVING DOWN A BUSY 4 LANE ROAD. APPROACHED A RED LIGHT AND ATTEMPTED TO STOP, WHEN PUSHING THE PEDAL IT GAVE FREE AND DEPRESSED ALL THE WAY TO THE FLOOR. I HAD TO SWITCH LANES QUICKLY TO AVOID A CAR AND BLEW THROUGH THE RED LIGHT. WHILE I WAS ABLE TO AVOID THE ACCIDENT IT WAS VERY SCARY. UPON INSPECTION OF MY BRAKE LINES 1 …
Read full complaint
DRIVING DOWN A BUSY 4 LANE ROAD. APPROACHED A RED LIGHT AND ATTEMPTED TO STOP, WHEN PUSHING THE PEDAL IT GAVE FREE AND DEPRESSED ALL THE WAY TO THE FLOOR. I HAD TO SWITCH LANES QUICKLY TO AVOID A CAR AND BLEW THROUGH THE RED LIGHT. WHILE I WAS ABLE TO AVOID THE ACCIDENT IT WAS VERY SCARY. UPON INSPECTION OF MY BRAKE LINES 1 HAD BURST AND THE REST WERE SO RUSTED IT WAS ONLY A MATTER OF TIME TILL THE REST BLEW. *TR ## VIN FAILED ##
NHTSA ODI #10500041
72,000 miles · Feb 21, 2013
Service Brakes
TODAY ON MY WAY HOME FROM A DOCTORS VISIT I WAS LEAVING ROUTE 509 OFF RAMP FROM HEADING NORTH BOUND IN SEATTLE WASHINGTON. I APPLIED THE BRAKES TO SLOW DOWN AND AS I APPROACHED THE STOP LIGHT SUDDENLY THE BRAKE PEDAL COLLAPSED TO THE FLOOR CORRESPONDING WITH THE SERVICE BRAKE LIGHT TURNING ON. LUCKILY THE LIGHT CHANGED TO GREEN …
Read full complaint
TODAY ON MY WAY HOME FROM A DOCTORS VISIT I WAS LEAVING ROUTE 509 OFF RAMP FROM HEADING NORTH BOUND IN SEATTLE WASHINGTON. I APPLIED THE BRAKES TO SLOW DOWN AND AS I APPROACHED THE STOP LIGHT SUDDENLY THE BRAKE PEDAL COLLAPSED TO THE FLOOR CORRESPONDING WITH THE SERVICE BRAKE LIGHT TURNING ON. LUCKILY THE LIGHT CHANGED TO GREEN SO I WAS ABLE TO AVOID AN ACCIDENT. AFTER MAKING THE TURN I DROVE SLOWLY UNTIL IT WAS SAFE TO STOP AS THIS IS A VERY INDUSTRIAL AREA WITH NO PLACE TO STOP. I HAD TO USE THE EMERGENCY BRAKE TO STOP THE VEHICLE, ONCE I WAS SAFE I EXAMINED THE BRAKE SYSTEM AND SAW FLUID DROPPING BELOW THE MASTER CYLINDER ONTO THE GROUND. WHEN I LOOKED CLOSER I FOUND A RUSTED BRAKE LINE RUPTURE ON THE FRONT PASSENGER BRAKE LINE DEPRESSURIZING THE SYSTEM. I LOOKED ONLINE TO SEE IF THERE WERE ANY ADDITIONAL COMPLAINTS AND HAVE FOUND A VERY COMMON ISSUE HERE AND REALIZED I SHOULD SHARE MY STORY. THE TRUCK IS NOT THAT OLD AND HAVING BEEN AN AUTOMOTIVE TECHNICIAN THERE IS NO EXCUSE FOR BRAKE LINES TO FAIL LIKE THIS REGARDLESS OF THE REGIONAL CLIMATES. THIS TRUCK RESIDED PROMINENTLY IN FLORIDA AND TEXAS AND ONLY RECENTLY HAS ARRIVED IN WASHINGTON. I HOPE THIS HELPS AND CHEVY REALLY DOES NEED TO TAKE RESPONSIBILITY FOR A MAJOR SAFETY PROBLEM LIKE THIS. I CANT TRUST ANY OF THE LINES IN THE TRUCK AFTER THIS AND INTEND TO REPLACE ALL OF THEM. HERE IS A BLOG FROM EDMONDS.COM WITH A LARGE COMPLAINT HISTORY I FOUND ONLINE THAT RAISED MY CONCERNS:HTTP://TOWNHALL-TALK.EDMUNDS.COM/DIRECT/VIEW/.F0D4FE5/281. *TR
NHTSA ODI #10499609
109,940 miles · Jan 19, 2013
Service Brakes
I WAS TRAVELING AT SLIGHTLY LESS THAN THE POSTED SPEED LIMIT WHEN I NOTICED THAT CARS AHEAD OF ME HAD STOPPED. I APPLIED MY BRAKES AND THE PEDAL IMMEDIATELY WENT TO THE FLOOR, THE BRAKE WARNING LIGHT ON THE DASH CAME ON AS DID A "SERVICE BRAKES" WHERE MY ODOMETER IS. THE BELL INSIDE THE CAB STARTED TO DING. I HAD TO SWERVE IN…
Read full complaint
I WAS TRAVELING AT SLIGHTLY LESS THAN THE POSTED SPEED LIMIT WHEN I NOTICED THAT CARS AHEAD OF ME HAD STOPPED. I APPLIED MY BRAKES AND THE PEDAL IMMEDIATELY WENT TO THE FLOOR, THE BRAKE WARNING LIGHT ON THE DASH CAME ON AS DID A "SERVICE BRAKES" WHERE MY ODOMETER IS. THE BELL INSIDE THE CAB STARTED TO DING. I HAD TO SWERVE INTO THE MIDDLE OF THE STREET TOWARD THE CENTERLINE TO AVOID HITTING THE CAR IN FRONT OF ME. I PUSHED THE PEDAL TO THE FLOOR HARD AND EVENTUALLY ROLLED TO A STOP. I PULLED TO THE SIDE OF THE ROAD AND MY HUSBAND (WHO WAS IN THE TRUCK WITH ME) HAD ME PUMP THE BRAKES AND BRAKE FLUID POURED DOWN FROM UNDER THE FRONT DRIVER SIDE OF THE TRUCK. I CALLED A TOW COMPANY AND THEY TOOK THE TRUCK TO THE NEAREST CHEVY DEALER. THE DEALER DIAGNOSED THAT ALL OF THE BRAKE LINES WHERE RUSTED AND SOME WERE LEAKING AND OTHERS WOULD SOON BE. THEY SAID ALL THE BRAKES LINES FROM FRONT TO REAR NEEDED TO BE REPLACED. THIS IS A VERY WELL CARED FOR TRUCK. I HAVE NEVER OWNED A VEHICLE THAT HAD BRAKE LINES CORRODE AND I HAVE ALWAYS LIVED IN NEW ENGLAND. *TR
NHTSA ODI #10493504
77,764 miles · Jan 18, 2013
Service Brakes
ON 7/7/09, DRIVING SLOWLY DOWN DRIVEWAY, BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR AND HAD TO USE EMERGENCY BRAKE TO STOP VEHICLE AFTER BOUNCING OVER CURB. TOOK THE CAR TO JEFF BARNES CHEVROLET AND THEY REPLACED BRAKE LINE THAT WAS COMPLETELY RUSTED THROUGH. ON 6/26/12, DRIVING ON A RURAL ROAD, BRAKES WENT OUT UNEXPECTEDLY. A…
Read full complaint
ON 7/7/09, DRIVING SLOWLY DOWN DRIVEWAY, BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR AND HAD TO USE EMERGENCY BRAKE TO STOP VEHICLE AFTER BOUNCING OVER CURB. TOOK THE CAR TO JEFF BARNES CHEVROLET AND THEY REPLACED BRAKE LINE THAT WAS COMPLETELY RUSTED THROUGH. ON 6/26/12, DRIVING ON A RURAL ROAD, BRAKES WENT OUT UNEXPECTEDLY. AGAIN, USED THE EMERGENCY BRAKE TO STOP VEHICLE. DROVE TO NEARBY MERCHANTS TIRE AND THEY REPLACED 20 FOOT OF BRAKE LINE AND COUPLINGS THAT HAD RUSTED THROUGH LEAKING ALL BRAKE FLUID. *TR
NHTSA ODI #10493462
86,600 miles · Jan 3, 2013
Service Brakes
I HAVE BEEN DEALING WITH RUSTING BRAKE COMPONENTS SINCE THE CALIPERS RUSTED AND FELL OFF AT 36,000 MILES. NOW MY GARAGE KEPT SILVERADO HAS BRAKE LINES FALLING OFF THAT NEARLY CAUSE AN ACCIDENT. *TR
NHTSA ODI #10490856
64,824 miles · Dec 18, 2012
Fuel System, GasolineService Brakes
I WAS NOTIFIED BY A GM SERVICE CENTER THAT THE BRAKE LINES WERE VERY RUSTY AND NEEDED REPLACING.. WHILE REPLACING THE BRAKE LINES, I WAS TOLD THAT THE FUEL LINES WERE LEAKING, NEEDING REPLACEMENT AND ALSO THE FUEL SENDER UNIT NEEDED REPLACING DUE TO CORROSION. THIS WAS A VERY COSTLY REPAIR AND SHOULD NOT HAPPEN ON A LOW MILEAG…
Read full complaint
I WAS NOTIFIED BY A GM SERVICE CENTER THAT THE BRAKE LINES WERE VERY RUSTY AND NEEDED REPLACING.. WHILE REPLACING THE BRAKE LINES, I WAS TOLD THAT THE FUEL LINES WERE LEAKING, NEEDING REPLACEMENT AND ALSO THE FUEL SENDER UNIT NEEDED REPLACING DUE TO CORROSION. THIS WAS A VERY COSTLY REPAIR AND SHOULD NOT HAPPEN ON A LOW MILEAGE VEHICLE. I WAS TOLD THAT THIS IS A BIG PROBLEM ON MANY GM TRUCKS. I THINK I SHOULD BE REIMBURSED FOR THESE REPAIRS. *TR
NHTSA ODI #10489125
Official recalls
8Oct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence & remedy
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Aug 3, 2006
ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Consequence & remedy
Consequence: IF THE DAMPER COMES LOOSE, A FUEL LEAK MAY RESULT. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC TRUCKS AT 1-866-996-9463.
Apr 22, 2005
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS AND BUILT WITH EITHER PBR PARKING BRAKE SYSTEMS OR TRW PARKING BRAKE SYSTEMS, THE PARKING BRAKE FRICTION LININGS MAY WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.
Consequence & remedy
Consequence: IF THE PARKING BRAKE DOES NOT HOLD, UNINTENDED VEHICLE MOVEMENT COULD OCCUR, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH A PBR PARKING BRAKE SYSTEM. ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM, DEALERS WILL INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY. THE RECALL BEGAN ON JULY 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Apr 22, 2005
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence & remedy
Consequence: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
Feb 8, 2005
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
May 11, 2004
CERTAIN EXTENDED AND REGULAR CAB PICKUP TRUCKS AND CARGO VANS CONVERTED TO COMPRESSED NATURAL GAS (CNG) FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RESTRAINT ANCHORAGE SYSTEMS.' THESE VEHICLES HAVE ONE SEATING POSITION, THE CENTER REAR SEAT, EQUIPPED WITH CHILD RESTRAINT LOWER ANCHORAGES.
Consequence & remedy
Consequence: THE STANDARD REQUIRES CHILD SEAT LOWER ANCHORAGES IN TWO SEATING POSITIONS FOR VEHICLES WITH THREE REAR SEATING POSITIONS. THE STANDARD CAB AND CARGO VAN VEHICLES, WHICH ONLY HAVE FRONT SEATING POSITIONS, HAVE AN AIR BAG OFF SWITCH TO DISABLE THE FRONT PASSENGER AIR BAG AND DO NOT HAVE CHILD RESTRAINT LOWER ANCHORAGES IN THE PASSENGER SEAT. THE STANDARD REQUIRES PASSENGER SEAT CHILD SEAT LOWER ANCHORAGES IN VEHICLES WITH AN AIR BAG OFF SWITCH. HOWEVER, THE STANDARD DOES NOT REQUIRE VEHICLES WITH ONLY FRONT SEATING POSITIONS TO HAVE LOWER ANCHORAGE PROVISIONS IF THE VEHICLE IS NOT EQUIPPED WITH AN AIR BAG OFF SWITCH.
Remedy: TO BRING THE STANDARD CAB AND CARGO VAN VEHICLES INTO COMPLIANCE, DEALERS WILL INJECT EPOXY INTO THE AIR BAG OFF SWITCH TO PREVENT AIR BAG ACTIVATION, RELOCATE THE SWITCH BEHIND THE INSTRUMENT PANEL AND THEN INSTALL A COVER OVER THE RESULTING OPENING. THE SUN VISOR LABEL AND OWNER'S MANUAL WILL ALSO BE CHANGED. THE CORRECTION FOR THE EXTENDED CAB VEHICLE WILL CONSIST OF CHANGING THE FRONT PASSENGER SEAT TO A SEAT THAT HAS CHILD RESTRAINT LOWER ANCHORAGES. THE RECALL BEGAN ON SEPTEMBER 9, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Mar 17, 2004
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE GALVANIZED STEEL TAILGATE SUPPORT CABLES THAT RETAIN THE TAILGATE IN THE FULL OPEN (HORIZONTAL) POSITION MAY CORRODE, WEAKEN, AND EVENTUALLY FRACTURE. IF BOTH CABLES FRACTURED, THE TAILGATE WOULD SUDDENLY DROP AND STRIKE THE TOP SURFACE OF THE REAR BUMPER.
Consequence & remedy
Consequence: ANYONE SITTING OR STANDING ON THE HORIZONTAL SURFACE OF THE TAILGATE WHEN BOTH CABLES FRACTURED COULD BE INJURED BY FALLING FROM THE TAILGATE. ON VEHICLES THAT HAVE HAD THE BUMPER REMOVED, THE TAILGATE MAY DROP EVEN LOWER. ADDITIONALLY, IF THERE IS CARGO ON THE TAILGATE THE CARGO MAY FALL OFF IF THE SUPPORT CABLES FRACTURE.
Remedy: DEALERS WILL REPLACE THE CABLES. INTERIM OWNER NOTIFICATION BEGAN ON APRIL 7, 20004. THE RECALL BEGAN ON SEPTEMBER 24, 2004, WHEN REPLACEMENT PARTS WERE AVAILABLE, AND WILL CONTINUE THROUGH OCTOBER 29, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463, OR VISIT WWW.MYGMLINK.COM, AND ENTER YOUR VEHICLE IDENTIFICATION NUMBER.
Feb 4, 2004
CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.
Consequence & remedy
Consequence: CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.
Remedy: DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration