NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
122 reportsClear category filter150,000 miles · Mar 18, 2016
Service Brakes
BRAKE FAILURE TODAY ON CHEVY SIVERADO. DRIVING 55 MPH ON HIGHWAY. THE CAR AHEAD OF ME SLOWED AND I BRAKED. PEDDLE WENT TO THE FLOOR WITHOUT STOPPING VEHICAL. WAS ABLE TO COME TO STOP AND COULD SEE RUSTED BRAKE LINES BY DRIVER DOOR. HAD WIFE PRESS BRAKE PEDDLE TO SEE FLUID SRAYING FROM RUSTED AREA. HAD ZERO BRAKING POWER WHEN FIR…
Read full complaint
BRAKE FAILURE TODAY ON CHEVY SIVERADO. DRIVING 55 MPH ON HIGHWAY. THE CAR AHEAD OF ME SLOWED AND I BRAKED. PEDDLE WENT TO THE FLOOR WITHOUT STOPPING VEHICAL. WAS ABLE TO COME TO STOP AND COULD SEE RUSTED BRAKE LINES BY DRIVER DOOR. HAD WIFE PRESS BRAKE PEDDLE TO SEE FLUID SRAYING FROM RUSTED AREA. HAD ZERO BRAKING POWER WHEN FIRST WENT OUT
NHTSA ODI #10850497
97,000 miles · Mar 17, 2016
Service Brakes
REAR BRAKE LINE BLEW WHEN TRYING TO APPLY BRAKES. NO INDICATOR LIGHTS OR ANYTHING PEDAL JUST WENT STRAIGHT TO THE FLOOR. HAD TO SWERVE OFF THE ROAD INTO AN EMBANKMENT TO AVOID A COLLISION AT A RED LIGHT! MECHANIC SAID THAT ALL MY BRAKE LINES WERE RUSTED AND IT WAS JUST A MATTER OF TIME BEFORE ANOTHER ONE WAS TO FAIL.
NHTSA ODI #10850145
113,000 miles · Jan 28, 2016
Service BrakesCrash
TL* THE CONTACT OWNS A 2004 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 30 MPH, THE BRAKES SUDDENLY FAILED AND THE DRIVER LOST CONTROL OF THE VEHICLE. AS A RESULT, THE CONTACT CRASHED INTO A DITCH. THE CONTACT INDICATED THAT WHEN DEPRESSING THE BRAKE PEDAL, IT EXTENDED TO THE FLOORBOARD. THE INDEP…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 30 MPH, THE BRAKES SUDDENLY FAILED AND THE DRIVER LOST CONTROL OF THE VEHICLE. AS A RESULT, THE CONTACT CRASHED INTO A DITCH. THE CONTACT INDICATED THAT WHEN DEPRESSING THE BRAKE PEDAL, IT EXTENDED TO THE FLOORBOARD. THE INDEPENDENT MECHANIC EXAMINED THE VEHICLE AND DISCOVERED THAT BRAKE LINES HAD RUSTED. THE CONTACT ALSO DISCOVERED THAT THE FRAME, THE ROCKER PANELS AND THE TAILGATE HINGES HAD ALSO RUSTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 113,000. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #10822851
130,000 miles · Jan 2, 2016
Service Brakes
I WAS DRIVING ON RT.7 IN SCHENECTADY NY, SPEED WAS AROUND 35MPH, TRAFFIC SIGNAL CHANGED TO RED, AS I WAS APPLING THE BRAKES THE PEDDAL SUDDENLY WENT TO THE FLOOR, LUCKY FOR ME THERE WERE NO CARS IN FRONT OF ME, OR IN THE INTERSECTION. MY TRUCK DID ENVETUALLY STOP, BUT IT WAS AFTER PASSING THRU THE INTERSECTION. THE RED LIGHT…
Read full complaint
I WAS DRIVING ON RT.7 IN SCHENECTADY NY, SPEED WAS AROUND 35MPH, TRAFFIC SIGNAL CHANGED TO RED, AS I WAS APPLING THE BRAKES THE PEDDAL SUDDENLY WENT TO THE FLOOR, LUCKY FOR ME THERE WERE NO CARS IN FRONT OF ME, OR IN THE INTERSECTION. MY TRUCK DID ENVETUALLY STOP, BUT IT WAS AFTER PASSING THRU THE INTERSECTION. THE RED LIGHT ON THE DASH DID NOT COME ON TILL THE BRAKES FAILED. FURTHER INSPECTION REVEALED MAIN BRAKE LINE TO THE REAR WHEELS BLEW DUE TO RUST.
NHTSA ODI #10817394
135,000 miles · Oct 12, 2015
Service Brakes
BRAKES FAILED SUDDENLY DUE TO SEVERELY CORRODED BRAKE LINES. BRAKE PEDAL WAS SLIGHTLY MUSHY AT STOP SIGN COMING OFF OF FREEWAY. AT THE NEXT STOP SIGN (3-WAY INTERSECTION ON 55-MPH COUNTY HIGHWAY) THE PEDAL WENT RIGHT TO THE FLOOR. FORTUNATELY THERE WAS NOBODY IN THE INTERSECTION OR A SERIOUS ACCIDENT MAY HAVE OCCURRED. APPAR…
Read full complaint
BRAKES FAILED SUDDENLY DUE TO SEVERELY CORRODED BRAKE LINES. BRAKE PEDAL WAS SLIGHTLY MUSHY AT STOP SIGN COMING OFF OF FREEWAY. AT THE NEXT STOP SIGN (3-WAY INTERSECTION ON 55-MPH COUNTY HIGHWAY) THE PEDAL WENT RIGHT TO THE FLOOR. FORTUNATELY THERE WAS NOBODY IN THE INTERSECTION OR A SERIOUS ACCIDENT MAY HAVE OCCURRED. APPARENTLY GM'S POSITION IS THAT BRAKE LINES ARE MAINTENANCE ITEM, AND THIS IS NORMAL WEAR AND TEAR, WHICH IS RIDICULOUS. I'VE OWNED OLDER VEHICLES (INCLUDING A NEARLY 50-YEAR OLD CHEVROLET TRUCK) IN SNOW COUNTRY AND HAVE NEVER SEEN BRAKE LINES THIS RUSTY. I AM VERY FORTUNATE THE RUPTURE DID NOT OCCUR IN AN EMERGENCY BRAKING SITUATION.
NHTSA ODI #10781497
120,000 miles · Oct 5, 2015
Service BrakesCrash
WHILE EXITING OF A HIGHWAY AND TRAVELING 25 MPH MY BRAKES COMPLETELY FAILED. I PUSHED THE PEDAL TO THE FLOOR SEVERAL TIMES BUT IT DID NOT SLOW THE TRUCK. AS A RESULT I REAR ENDED A VEHICLE IN FRONT OF ME. I HAD NOW WARNING OR CHECK LIGHT FOR THE BRAKES PREVIOUS OR SINCE. UPON INSPECTION I DISCOVERED CORRODED AND LEAKING BRAKE LI…
Read full complaint
WHILE EXITING OF A HIGHWAY AND TRAVELING 25 MPH MY BRAKES COMPLETELY FAILED. I PUSHED THE PEDAL TO THE FLOOR SEVERAL TIMES BUT IT DID NOT SLOW THE TRUCK. AS A RESULT I REAR ENDED A VEHICLE IN FRONT OF ME. I HAD NOW WARNING OR CHECK LIGHT FOR THE BRAKES PREVIOUS OR SINCE. UPON INSPECTION I DISCOVERED CORRODED AND LEAKING BRAKE LINES IN THE MIDDLE SECTION OF MY TRUCK.
NHTSA ODI #10779829
54,000 miles · Oct 2, 2015
Service Brakes
TL* THE CONTACT OWNS A 2004 CHEVROLET SILVERADO. WHILE DRIVING APPROXIMATELY 55 MPH, THE BRAKE PEDAL WAS DEPRESSED BUT FAILED TO RESPOND. THE BRAKE FLUID WARNING INDICATOR ILLUMINATED. THE FAILURE RECURRED ON TWO OTHER OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE BRAKE LINE WAS RUST…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET SILVERADO. WHILE DRIVING APPROXIMATELY 55 MPH, THE BRAKE PEDAL WAS DEPRESSED BUT FAILED TO RESPOND. THE BRAKE FLUID WARNING INDICATOR ILLUMINATED. THE FAILURE RECURRED ON TWO OTHER OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE BRAKE LINE WAS RUSTED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 54,000.
NHTSA ODI #10779361
108,000 miles · Sep 23, 2015
Service BrakesStructure
I WAS DRIVING ALONG AND HAD TO HIT THE BRAKES IMMEDIATELY. I ALMOST HIT THE CAR IN FRONT OF ME. I NOTICED I HAD TO START PUTTING THE BRAKES ALL THE WAY TO THE FLOOR IN ORDER TO STOP, ESPECIALLY ON AN INCLINE. THE BRAKE LIGHT WENT ON AND OFF A FEW TIMES SO I TOOK IT TO A SHOP TO HAVE IT LOOKED AT. THEY TOLD ME THAT MY BRAKE LINE …
Read full complaint
I WAS DRIVING ALONG AND HAD TO HIT THE BRAKES IMMEDIATELY. I ALMOST HIT THE CAR IN FRONT OF ME. I NOTICED I HAD TO START PUTTING THE BRAKES ALL THE WAY TO THE FLOOR IN ORDER TO STOP, ESPECIALLY ON AN INCLINE. THE BRAKE LIGHT WENT ON AND OFF A FEW TIMES SO I TOOK IT TO A SHOP TO HAVE IT LOOKED AT. THEY TOLD ME THAT MY BRAKE LINE BLEW AND ALL THE OTHER BRAKE LINES ARE RUSTED AND THE TRUCK IS NOT SAFE TO DRIVE. THIS TRUCK IS ONLY 11 YEARS OLD, THAT IS ABSOLUTELY UNACCEPTABLE THAT ALL THE BRAKE LINES ARE RUSTED. THE TRUCK ONLY HAS 108K MILES. I CALLED A LOCAL CHEVY DEALERSHIP AND THEY QUOTED ME 3K+ TO FIX IT. IT INVOLVED AT LEAST 20 HOURS OF LABOR AND THEY NEEDED TO LIFT THE FRAME OFF TO FIX. I CAN NOT BELIEVE THEIR ARE NO RECALLS FROM GM OR ATLEAST THEM OFFERING ANY HELP TO PAY FOR THIS. THE DEALER DID NOT OFFER ME ANY HELP OR REMEDY TO THE SITUATION, JUST WANTED ME TO FORK UP 3K.
NHTSA ODI #10775478
54,527 miles · Sep 21, 2015
Service Brakes
TL* THE CONTACT OWNS A 2004 CHEVROLET SILVERADO. WHILE DRIVING AT AN UNKNOWN SPEED, THE BRAKE PEDAL WAS DEPRESSED AND EXTENDED TO THE FLOORBOARD. THE CONTACT PLACED THE VEHICLE IN NEUTRAL AND WAS ABLE TO STOP THE VEHICLE. THE CONTACT THEN PLACED THE VEHICLE IN PARK, DEPRESSED THE BRAKE PEDAL ONCE MORE AND THE BRAKE PEDAL WENT TO…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET SILVERADO. WHILE DRIVING AT AN UNKNOWN SPEED, THE BRAKE PEDAL WAS DEPRESSED AND EXTENDED TO THE FLOORBOARD. THE CONTACT PLACED THE VEHICLE IN NEUTRAL AND WAS ABLE TO STOP THE VEHICLE. THE CONTACT THEN PLACED THE VEHICLE IN PARK, DEPRESSED THE BRAKE PEDAL ONCE MORE AND THE BRAKE PEDAL WENT TO THE FLOORBOARD AND THE BRAKE WARNING LIGHT ILLUMINATED. THE CONTACT STATED THAT UPON INSPECTION, THE BRAKE LINES UNDERNEATH OF THE VEHICLE WERE CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 54,527.
NHTSA ODI #10766427
65,500 miles · Aug 2, 2015
Service Brakes
MY BROTHER INLAW OWNS A 2003 GMC SIERRA AND EXPERIENCED TOTAL BRAKE FAILURE DUE TO CORRODED BRAKE LINES IN 2009. UPON INSPECTING MY BRAKE LINES ON MY 2004 SILVERADO I OBSERVED THE THE BRAKE LINES WERE CORRODED AND WOULD HAVE TO BE REPLACED BEFORE THEY FAILED AS WELL. MY TRUCK WAS ONLY 5 YEARS OLD AT THE TIME! AFTER MUCH DISCUSSI…
Read full complaint
MY BROTHER INLAW OWNS A 2003 GMC SIERRA AND EXPERIENCED TOTAL BRAKE FAILURE DUE TO CORRODED BRAKE LINES IN 2009. UPON INSPECTING MY BRAKE LINES ON MY 2004 SILVERADO I OBSERVED THE THE BRAKE LINES WERE CORRODED AND WOULD HAVE TO BE REPLACED BEFORE THEY FAILED AS WELL. MY TRUCK WAS ONLY 5 YEARS OLD AT THE TIME! AFTER MUCH DISCUSSION WITH THE DEALERSHIP WHERE I PURCHASED THIS VEHICLE I DETERMINED THAT THEY WOULD NOT STAND BEHIND THEIR PRODUCT AND HAD TO PAY OUT OF POCKET FOR THE REPAIRS. I STILL HAVE THE CORRODED BRAKE LINES, RECEIPT AND PICTURES OF LINES ON TRUCK BEFORE REPLACEMENT. KEEPING ALL EVIDENCE IN CASE OF RECALL. BY THE WAY, MY EXHAUST SYSTEM LOOKS LIKE BRAND NEW. WHY DIDN'T THEY USE THE SAME MATERIAL FOR THE BRAKE LINES? I DON'T EXPECT ANYTHING TO BE DONE ABOUT THIS UNTIL CNN STARTS RUNNING STORIES ABOUT PEOPLE GETTING KILLED BY THIS PROBLEM!
NHTSA ODI #10745660
Official recalls
8Oct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence & remedy
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Aug 3, 2006
ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Consequence & remedy
Consequence: IF THE DAMPER COMES LOOSE, A FUEL LEAK MAY RESULT. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC TRUCKS AT 1-866-996-9463.
Apr 22, 2005
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS AND BUILT WITH EITHER PBR PARKING BRAKE SYSTEMS OR TRW PARKING BRAKE SYSTEMS, THE PARKING BRAKE FRICTION LININGS MAY WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.
Consequence & remedy
Consequence: IF THE PARKING BRAKE DOES NOT HOLD, UNINTENDED VEHICLE MOVEMENT COULD OCCUR, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH A PBR PARKING BRAKE SYSTEM. ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM, DEALERS WILL INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY. THE RECALL BEGAN ON JULY 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Apr 22, 2005
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence & remedy
Consequence: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
Feb 8, 2005
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
May 11, 2004
CERTAIN EXTENDED AND REGULAR CAB PICKUP TRUCKS AND CARGO VANS CONVERTED TO COMPRESSED NATURAL GAS (CNG) FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RESTRAINT ANCHORAGE SYSTEMS.' THESE VEHICLES HAVE ONE SEATING POSITION, THE CENTER REAR SEAT, EQUIPPED WITH CHILD RESTRAINT LOWER ANCHORAGES.
Consequence & remedy
Consequence: THE STANDARD REQUIRES CHILD SEAT LOWER ANCHORAGES IN TWO SEATING POSITIONS FOR VEHICLES WITH THREE REAR SEATING POSITIONS. THE STANDARD CAB AND CARGO VAN VEHICLES, WHICH ONLY HAVE FRONT SEATING POSITIONS, HAVE AN AIR BAG OFF SWITCH TO DISABLE THE FRONT PASSENGER AIR BAG AND DO NOT HAVE CHILD RESTRAINT LOWER ANCHORAGES IN THE PASSENGER SEAT. THE STANDARD REQUIRES PASSENGER SEAT CHILD SEAT LOWER ANCHORAGES IN VEHICLES WITH AN AIR BAG OFF SWITCH. HOWEVER, THE STANDARD DOES NOT REQUIRE VEHICLES WITH ONLY FRONT SEATING POSITIONS TO HAVE LOWER ANCHORAGE PROVISIONS IF THE VEHICLE IS NOT EQUIPPED WITH AN AIR BAG OFF SWITCH.
Remedy: TO BRING THE STANDARD CAB AND CARGO VAN VEHICLES INTO COMPLIANCE, DEALERS WILL INJECT EPOXY INTO THE AIR BAG OFF SWITCH TO PREVENT AIR BAG ACTIVATION, RELOCATE THE SWITCH BEHIND THE INSTRUMENT PANEL AND THEN INSTALL A COVER OVER THE RESULTING OPENING. THE SUN VISOR LABEL AND OWNER'S MANUAL WILL ALSO BE CHANGED. THE CORRECTION FOR THE EXTENDED CAB VEHICLE WILL CONSIST OF CHANGING THE FRONT PASSENGER SEAT TO A SEAT THAT HAS CHILD RESTRAINT LOWER ANCHORAGES. THE RECALL BEGAN ON SEPTEMBER 9, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Mar 17, 2004
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE GALVANIZED STEEL TAILGATE SUPPORT CABLES THAT RETAIN THE TAILGATE IN THE FULL OPEN (HORIZONTAL) POSITION MAY CORRODE, WEAKEN, AND EVENTUALLY FRACTURE. IF BOTH CABLES FRACTURED, THE TAILGATE WOULD SUDDENLY DROP AND STRIKE THE TOP SURFACE OF THE REAR BUMPER.
Consequence & remedy
Consequence: ANYONE SITTING OR STANDING ON THE HORIZONTAL SURFACE OF THE TAILGATE WHEN BOTH CABLES FRACTURED COULD BE INJURED BY FALLING FROM THE TAILGATE. ON VEHICLES THAT HAVE HAD THE BUMPER REMOVED, THE TAILGATE MAY DROP EVEN LOWER. ADDITIONALLY, IF THERE IS CARGO ON THE TAILGATE THE CARGO MAY FALL OFF IF THE SUPPORT CABLES FRACTURE.
Remedy: DEALERS WILL REPLACE THE CABLES. INTERIM OWNER NOTIFICATION BEGAN ON APRIL 7, 20004. THE RECALL BEGAN ON SEPTEMBER 24, 2004, WHEN REPLACEMENT PARTS WERE AVAILABLE, AND WILL CONTINUE THROUGH OCTOBER 29, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463, OR VISIT WWW.MYGMLINK.COM, AND ENTER YOUR VEHICLE IDENTIFICATION NUMBER.
Feb 4, 2004
CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.
Consequence & remedy
Consequence: CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.
Remedy: DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration