SkipThatYearREAL DATA. SMARTER CAR DECISIONS.
← New search

2005 Chevrolet Silverado 2500

Owner reports · Recalls · Investigations

More warning signs than most Silverado 2500 years

Owner complaints for the 2005 Chevrolet Silverado 2500 are substantially higher than the model-year median of 81.

About this comparison →
269Owner complaints

Model-year median: 81

0Recall campaigns

View recall details →

0Investigations

View investigation details →

How this year compares

Owner complaints by model year

Other model years Selected year
351
2002449
2003368
2004269
2005177
2006204
2007191
2008
Compare all Silverado 2500 years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

Electrical System
98Service Brakes
45Steering
29Service Brakes, Hydraulic
26Power Train
21
All reported categories
Engine And Engine Cooling
16Tires
13Air Bags
11Fuel/propulsion System
11Fuel System, Diesel
8Suspension
7Visibility
6Engine
5Equipment
5Exterior Lighting
5Structure
5Vehicle Speed Control
5Fuel System, Gasoline
3Fuel System, Other
3Unknown Or Other
3Parking Brake
2Latches/locks/linkages
1Seat Belts
1Seats
1Service Brakes, Electric
1Wheels
1

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

242 reports with mileage · 27 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 98 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Service Brakes. Review the 45 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Steering. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

14 crash reports15 fire reports7 injury reports

Seats complaints

1 reports
Clear category filter
189,000 miles · Apr 23, 2018
Electrical SystemSeats

DRIVER SIDE SEAT HEATER TURNS ON BY ITSELF. THIS IS A DANGEROUS SITUATION BECAUSE THE DRIVER IS DISTRACTED WHILE DRIVING AND MUST LOOK DOWN TO FIND THE OFF SWITCH. OFTEN, THE SEAT HEAT COMES BACK ON AGAIN ALMOST RIGHT AWAY.. THIS SITUATION SEEMED TO OCCUR IN APPROX 2003 TO 2007 MODELS. INTERNET FORUMS SHOW THAT GM HAS SERVICE BU…

Read full complaint

DRIVER SIDE SEAT HEATER TURNS ON BY ITSELF. THIS IS A DANGEROUS SITUATION BECAUSE THE DRIVER IS DISTRACTED WHILE DRIVING AND MUST LOOK DOWN TO FIND THE OFF SWITCH. OFTEN, THE SEAT HEAT COMES BACK ON AGAIN ALMOST RIGHT AWAY.. THIS SITUATION SEEMED TO OCCUR IN APPROX 2003 TO 2007 MODELS. INTERNET FORUMS SHOW THAT GM HAS SERVICE BULLETINS THAT INSTRUCT TECHNICIANS TO DO A 'FIRMWARE FIX". THE ONLY WAY FOR ME TO STOP THIS CONDITION WAS TO LOCATE AND DISCONNECT A SMALL GREEN CONNECTOR UNDER THE SEAT THAT DISABLES THE SEAT HEATER. CHANGING THE CONTROL MODULE DIDN'T REMEDY THE SITUATION. IT HAPPENS WHILE DRIVING AND IS INTERMITTENT. SEEMS LIKE GM HAS REMEDIED THE SITUATION IN NEWER MODELS. SEEMS TO ME THEY SHOULD BE RECALLING OLDER MODELS TO INCORPORATE SOME SORT OF "FIX". THE DISTRACTION OF LOCATING AND TURNING OFF THE HEATER IS AS BAD AS "DRIVING WHILE TEXTING". I ALWAYS HAVE TO PULL OVER TO GET IT SHUT OFF. OFTEN, WHEN I RESUME DRIVING, THE HEATER WILL COME BACK ON. EVENTUALLY IT STOPS TURNING ITSELF ON.

NHTSA ODI #11089772

Official recalls

0

No recalls in this snapshot.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

0

No exact-year investigations in this snapshot.