IllustrationWORKING DOOR FRAME-AWAY FROM ALL CABLES AND WIRES-TRUCK WAS PARKED IN DRIVEWAY-OFF-DRIVERS AIR BAG WENT OFF-ON ACCIDENT-TRUCK WAS PARKED--NO LUCK WITH GM--AN LUCK WITH DEALER--GM SAID-TRUCK OUT OF WARRANTY AND TO OLD--COST ME OVER $2000.00 TO REPLACE--I AM 70 YRS OLD AND RETIRED--STILL LIKE THE TRUCK--THESE $$$ HURT ME!
2004 Chevrolet Silverado 1500
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2004 Chevrolet Silverado 1500 do not stand out strongly from the model-year median of 525.
About this comparison →How this year compares
Owner complaints by model year
Compare all Silverado 1500 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
680–25K
15025–50K
17150–75K
14875–100K
118100–150K
45150K+
700 reports with mileage · 97 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 267 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 229 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 100 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
33 crash reports8 fire reports17 injury reports
What owners actually said
797 reportsTHE SPEEDOMETER DOESN'T WORK PROPERLY. I CAN BE AT A RED LIGHT AT COMPLETE STOP & IT STATES I AM DOING 60, WHEN I ACCELERATE IT GOES TO 100, WHEN I KNOW I AM ONLY DOING 10-15 MPH. I AM 70 YEARS OLD ON A FIXED INCOME. I NEVER RECEIVED ANYTHING ABOUT A RECALL AND I NOW HAVE AROUND 102,000 MILES ON MY TRUCK. I CAN NOT AFFORD TO REP…
Read full complaint
THE SPEEDOMETER DOESN'T WORK PROPERLY. I CAN BE AT A RED LIGHT AT COMPLETE STOP & IT STATES I AM DOING 60, WHEN I ACCELERATE IT GOES TO 100, WHEN I KNOW I AM ONLY DOING 10-15 MPH. I AM 70 YEARS OLD ON A FIXED INCOME. I NEVER RECEIVED ANYTHING ABOUT A RECALL AND I NOW HAVE AROUND 102,000 MILES ON MY TRUCK. I CAN NOT AFFORD TO REPLACE A DEFECTIVE PART FOR $500- $600. GM SHOULD HAVE TO REPLACE THESE AT FULL COST!
ENGINE LIGHT COMES ON WHILE DRIVING, ENGINE POWER DROPS IMMEDIATELY, NO POWER AT ALL. I GET A MESSAGE THAT SAYS ENGINE POWER FAILURE. I CAN STOP AND SHUT TRUCK OFF WAIT ABOUT 10-20 MINUTES, CRANK TRUCK, LIGHT GOES OUT AND ENGINE HAS POWER. THIS HAS HAPPENED 4 TIMES WITHIN THE LAST 2 MONTHS. TWICE THIS HAPPENED IN THE CITY LIMITS…
Read full complaint
ENGINE LIGHT COMES ON WHILE DRIVING, ENGINE POWER DROPS IMMEDIATELY, NO POWER AT ALL. I GET A MESSAGE THAT SAYS ENGINE POWER FAILURE. I CAN STOP AND SHUT TRUCK OFF WAIT ABOUT 10-20 MINUTES, CRANK TRUCK, LIGHT GOES OUT AND ENGINE HAS POWER. THIS HAS HAPPENED 4 TIMES WITHIN THE LAST 2 MONTHS. TWICE THIS HAPPENED IN THE CITY LIMITS AND TWICE ON THE HIGHWAY.
1 ISSUE IS THE AC RUNS HOT ON THE LEFT SIDE AND COLD ON THE RIGHT. SOMETIMES IT WILL RUN ALL HOT.. @. THE DASH BOARD LIGHTS GO OFF AFTER I HAVE STARTED DRIVING AND I CAN NOT SEE THE SPEED OR ANYTHING ON IT. WE HAD A RECALL ON THE HARNESS A FEW YEAR AGO, AROUND APRIL 2011 OR 2012 THE TRUCK WOULD NOT PASS STATE INSPECTION AT THE T…
Read full complaint
1 ISSUE IS THE AC RUNS HOT ON THE LEFT SIDE AND COLD ON THE RIGHT. SOMETIMES IT WILL RUN ALL HOT.. @. THE DASH BOARD LIGHTS GO OFF AFTER I HAVE STARTED DRIVING AND I CAN NOT SEE THE SPEED OR ANYTHING ON IT. WE HAD A RECALL ON THE HARNESS A FEW YEAR AGO, AROUND APRIL 2011 OR 2012 THE TRUCK WOULD NOT PASS STATE INSPECTION AT THE TIME. I HAVE REPLACED IT TWICE ALREADY. CHEVROLET MANUFACTURE REIMBURSED US.
THE AC/HEATER PASSENGER VENT DUCTS DO NOT RELAY HEATER AIR FLOW FUNCTION - ONLY DIRECTS COLD AIR, BOTH OVER AND UNDER DASHBOARD. THE DRIVER'S SIDE IS OK.
BRAKES FAILED ON HIGHWAY DUE TO RUSTED LINES. BRAKES COMPLETELY FAILED. BRAKE LINE WAS SO RUSTED IT HAD A HUGE HOLE IN IT DUE TO THE RUST.
SINCE IT WAS NEW MY TRUNK SURGES UNCONTROLLABLY AND VIOLENTLY AT TIMES. ITS NORMALLY WHEN I FIRST START IT IN MORNING AND FOR FIRST BLOCK OR TWO. ITS VERY DANGEROUS, IF IT EVER HAPPENS ON THE FREEWAY I WILL DIE. GM THREATENED TO BANKRUPT ME IF I SUED UNDER LEMON LAW.
I KNOW MY TRUCK IS 14 YEARS OLD. BUT MY BRAKE LINES RUST OUT NEAR THE ABS BLOCK AND NEAR THE FUEL TANK ON THE FRAME OF THE TRUCK. WHICH IS ODD TO HAPPEN AT THE SAME TIME. I HAVE HEARD OF PEOPLE HAVING PROBLEMS WITH THIS TRUCK LINE SOONER THEN ME. NOW I HAVE A 85 TRANS AM MADE BY GM AND HAVEN'T HAD THIS PROBLEM . I THINK THE NHT…
Read full complaint
I KNOW MY TRUCK IS 14 YEARS OLD. BUT MY BRAKE LINES RUST OUT NEAR THE ABS BLOCK AND NEAR THE FUEL TANK ON THE FRAME OF THE TRUCK. WHICH IS ODD TO HAPPEN AT THE SAME TIME. I HAVE HEARD OF PEOPLE HAVING PROBLEMS WITH THIS TRUCK LINE SOONER THEN ME. NOW I HAVE A 85 TRANS AM MADE BY GM AND HAVEN'T HAD THIS PROBLEM . I THINK THE NHTSA AND GM NEED TO LOOK AT THIS CLOSER. THIS HAPPEN TO ME THIS MORNING ON MY WAY OUT TO WORK AND IT SCARED THE HELL OUT ME LUCKY I WAS JUST IN MY DRIVE WAY. I TAKE VERY GOOD CARE OF MY TRUCK AND DON'T ABUSE IT. I TRY TO KEEP UP ON THE UNDER BODY AND FRAME AFTER SNOW STORMS BY RINSING OFF THE UNDER BODY AND FRAME. NOW I WAS INFORMED I WILL COST ME ANY WERE FROM $1500.00 TO$ 2000.00 TO REPAIR THIS PROBLEM. NOT A HAPPY CAMPER. JUST GLADE I WASN'T ON THE ROAD DOING 50. AS I TAKE LOCAL AND STATE HIGH WAYS TO WORK.
WHILE DRIVING AT HIGHWAY SPEED, TRAFFIC MOUNTED UP AND CARS VIGOROUSLY APPLIED BRAKED. BRAKED TRUCK, WHICH SLOWED AT FIRST, THEN PEDAL SANK TO FLOOR AND CEASED TO STOP. EMERGENCY BRAKE DEPLOYMENT PERFORMED REMAINING NECESSARY STOPPING (JUST BARELY). INSPECTION FOUND BADLY RUSTED BRAKE LINE RUPTURED NEAR THE PASSENGER REAR TIRE, …
Read full complaint
WHILE DRIVING AT HIGHWAY SPEED, TRAFFIC MOUNTED UP AND CARS VIGOROUSLY APPLIED BRAKED. BRAKED TRUCK, WHICH SLOWED AT FIRST, THEN PEDAL SANK TO FLOOR AND CEASED TO STOP. EMERGENCY BRAKE DEPLOYMENT PERFORMED REMAINING NECESSARY STOPPING (JUST BARELY). INSPECTION FOUND BADLY RUSTED BRAKE LINE RUPTURED NEAR THE PASSENGER REAR TIRE, AS THE METAL LINE MEETS RUBBER. ALL LINES BADLY RUSTED WHILE LITTLE OTHER UNDERCHASSIS SHOWS ANY RUST AT ALL.
YESTERDAY MY BRAKE PEDAL WENT TO THE FLOOR AND I COULD NOT STOP THE TRUCK. I PUT MY BLINKERS ON AND DROVE ABOUT TWO MILES AN HOUR TO MY REGULAR MECHANIC AND HE SAID ALL THE BRAKE LINES NEED TO BE REPLACED BECAUSE THE ARE RUSTED OUT AND LEAKING FLUID TO A COST OF $750.00. IT IS IN THE SHOP RIGHT NOW SO I WON'T HAVE THE INVOICE F…
Read full complaint
YESTERDAY MY BRAKE PEDAL WENT TO THE FLOOR AND I COULD NOT STOP THE TRUCK. I PUT MY BLINKERS ON AND DROVE ABOUT TWO MILES AN HOUR TO MY REGULAR MECHANIC AND HE SAID ALL THE BRAKE LINES NEED TO BE REPLACED BECAUSE THE ARE RUSTED OUT AND LEAKING FLUID TO A COST OF $750.00. IT IS IN THE SHOP RIGHT NOW SO I WON'T HAVE THE INVOICE FOR A FEW DAYS. HE ALSO SAID THE THE FUEL LINES LOOK RUSTED ALSO AND HOPES THEY WON'T BREAK WHILE FIXING THE BRAKE LINES.
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.