IllustrationMY SPEEDOMETER JUST STOPPED WORKING I HAVE 72,000 MILES ON IT. I WAS TOLD IT WILL COST 500 TO FIX . ALOT OF PEOPLE ARE HAVING PROBLEMS THIS SHOULD BE A RECALL. *TR
2004 Chevrolet Silverado 1500
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2004 Chevrolet Silverado 1500 do not stand out strongly from the model-year median of 525.
About this comparison →How this year compares
Owner complaints by model year
Compare all Silverado 1500 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
680–25K
15025–50K
17150–75K
14875–100K
118100–150K
45150K+
700 reports with mileage · 97 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 267 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 229 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 100 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
33 crash reports8 fire reports17 injury reports
Electrical System complaints
267 reportsTL*THE CONTACT OWNS A 2004 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE SPEEDOMETER DISPLAYS INACCURATE SPEEDS AND THE FUEL GAUGE DOES NOT DISPLAY THE CORRECT AMOUNT OF GASOLINE. THE FAILURES OCCUR INTERMITTENTLY. THE MANUFACTURER HAS AN EXTENDED WARRANTY REGARDING THESE FAILURES; HOWEVER, THE PARTS ARE UNAVAILABLE. …
Read full complaint
TL*THE CONTACT OWNS A 2004 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE SPEEDOMETER DISPLAYS INACCURATE SPEEDS AND THE FUEL GAUGE DOES NOT DISPLAY THE CORRECT AMOUNT OF GASOLINE. THE FAILURES OCCUR INTERMITTENTLY. THE MANUFACTURER HAS AN EXTENDED WARRANTY REGARDING THESE FAILURES; HOWEVER, THE PARTS ARE UNAVAILABLE. THE CURRENT MILEAGE WAS 67,250 AND FAILURE MILEAGE WAS 50,000.
SPEEDOMETER BEGAN "STICKING" ON ACCELERATION AND DECELERATION AT APPROXIMATELY 47000 MILES. EVENTUALLY, IT BEGAN TO REGISTER UP TO 70 MPH WHILE STOPPED AT STOP SIGNS. NOW, THE ONLY RELIABLE WAY TO TELL MY SPEED IS WITH HAND HELD GPS. I'M AT APPROXIMATELY 54,000 MILES AND SPEEDOMETER REGISTERS BETWEEN -10 MPH AND 120 MPH. ACC…
Read full complaint
SPEEDOMETER BEGAN "STICKING" ON ACCELERATION AND DECELERATION AT APPROXIMATELY 47000 MILES. EVENTUALLY, IT BEGAN TO REGISTER UP TO 70 MPH WHILE STOPPED AT STOP SIGNS. NOW, THE ONLY RELIABLE WAY TO TELL MY SPEED IS WITH HAND HELD GPS. I'M AT APPROXIMATELY 54,000 MILES AND SPEEDOMETER REGISTERS BETWEEN -10 MPH AND 120 MPH. ACCORDING TO THE SPEEDOMETER, I REGULARLY DO 100 MPH THROUGH SCHOOL ZONES. *TR
ELECTRICAL PANEL GAUGES (SPEEDOMETER) QUIT WORKING AT 68,000 MILES. I FILED A COMPLAINT. CHEVROLET NOTIFIED ME BY LETTER THEY WOULD REPLACE THE DEFECTIVE PART IF MY VEHICLE HAD LESS THAN 70,000 MILES. BY THE TIME I GOT THE LETTER MY VEHICLE HAD OVER 70,000 MILES. NOW CHEVROLET WILL NOT REPAIR THE DEFECTIVE PART. *TR
SPEEDOMETER AND OTHER GAUGES FAILURE ON 2004 CHEVROLET SILVERADO. STARTED APPROXIMATELY FALL LAST YEAR. NOW SPEEDOMETER IS INOPERABLE. CAUSING ME TO HAVE TO GUESS MY APPROXIMATE SPEED. G M FINALLY SENT NOTICES TO OWNERS OF AFFECTED VEHICLES BUT MINE IS OUT OF WARRANTY. THIS SEEMS TO BE A SERIOUS PROBLEM POSING POSSIBLE DANGER TO…
Read full complaint
SPEEDOMETER AND OTHER GAUGES FAILURE ON 2004 CHEVROLET SILVERADO. STARTED APPROXIMATELY FALL LAST YEAR. NOW SPEEDOMETER IS INOPERABLE. CAUSING ME TO HAVE TO GUESS MY APPROXIMATE SPEED. G M FINALLY SENT NOTICES TO OWNERS OF AFFECTED VEHICLES BUT MINE IS OUT OF WARRANTY. THIS SEEMS TO BE A SERIOUS PROBLEM POSING POSSIBLE DANGER TO THE OWNERS AND OTHER DRIVERS. A LOT OF FOLKS WILL PROBABLY NOT BE ABLE TO GET THIS REPAIRED SOON ENOUGH OR AT ALL DUE TO HIGH REPAIR COSTS. *TR
STARTED SUDDENLY.. SPEEDOMETER REGISTERING MUCH GREATER SPEED THAN ACTUAL SPEED. EVEN OFF/PARKED REGISTERING IN EXCESS OF 120 MPH. ALL OTHER GAUGES AS OF NOW SEEM TO BE FUNCTIONING PROPERLY. *TR
I HAVE HAD TROUBLE WITH MY SPEEDOMETER, HEAT, AND GAS GAUGES. THE SPEEDOMETER WILL SET AT 60MPH OR IT WILL NOT WORK AT ALL. THAN IT WILL START WORKING WHEN IT FEELS LIKE IT. MY TEMP. GAGE WILL GO TO THE RED LINE OR IT WON'T MOVE AT ALL. MY GAS GAGE WILL SET ON EMPTY WHEN IT FULL OR IT WILL WORK WHEN IT FEELS LIKE IT. THIS IS VER…
Read full complaint
I HAVE HAD TROUBLE WITH MY SPEEDOMETER, HEAT, AND GAS GAUGES. THE SPEEDOMETER WILL SET AT 60MPH OR IT WILL NOT WORK AT ALL. THAN IT WILL START WORKING WHEN IT FEELS LIKE IT. MY TEMP. GAGE WILL GO TO THE RED LINE OR IT WON'T MOVE AT ALL. MY GAS GAGE WILL SET ON EMPTY WHEN IT FULL OR IT WILL WORK WHEN IT FEELS LIKE IT. THIS IS VERY IMPORTANT TO ME AND CAN CAUSE PROBLEMS WITH ON HOW FAST YOUR GOING OR NOT GOING, AND WITH THE OTHER GAUGES YOU DON'T KNOW IF YOU HAVE GAS OR DON'T, AND WITH THE HEAD GAUGES THAT CAN SCARE YOU. *TR
INSTRUMENT PANEL GAUGE NEEDLES STICK, FLUTTER AND HAVE BECOME INOPERATIVE AT TIMES. THIS HAS CAUSED INACCURATE READINGS TO THE SPEEDOMETER AND FUEL GAUGE. *TR
BLOWER MOTOR WIRING HARNESS MELTED. *TR
BLOWER MOTOR UNDER THE DASH QUIT WORKING. A FELLOW WORKER HAS THE SAME TRUCK AND IT ALSO HAPPENED TO HIS TRUCK A COUPLE OF MONTHS AGO. G.M. DEALER SAID THE WIRING HARNESS AND RESISTOR WAS SHORTED AND NEEDED TO BE REPLACED. OVER $400 DOLLARS FOR REPAIRS. THE PERSON THAT FIXED MY FRIENDS TRUCK SAID HE WAS LUCKY HIS TRUCK DIDN'T…
Read full complaint
BLOWER MOTOR UNDER THE DASH QUIT WORKING. A FELLOW WORKER HAS THE SAME TRUCK AND IT ALSO HAPPENED TO HIS TRUCK A COUPLE OF MONTHS AGO. G.M. DEALER SAID THE WIRING HARNESS AND RESISTOR WAS SHORTED AND NEEDED TO BE REPLACED. OVER $400 DOLLARS FOR REPAIRS. THE PERSON THAT FIXED MY FRIENDS TRUCK SAID HE WAS LUCKY HIS TRUCK DIDN'T CATCH ON FIRE. *TR
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.