← New search

2003 Chevrolet Silverado 1500

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2003 Chevrolet Silverado 1500 do not stand out strongly from the model-year median of 525.

About this comparison →

When problems were reported

Mileage at the reported incident

726 reports with mileage · 79 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Service Brakes. Review the 273 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 195 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Service Brakes, Hydraulic. Review the 151 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

26 crash reports7 fire reports8 injury reports

What owners actually said

805 reports
60,000 miles · Feb 16, 2006
Electrical System

SPEEDOMETER CLUSTER DOES NOT WORK. *NM

NHTSA ODI #10150433

41,135 miles · Feb 6, 2006
Electrical System

MY SPEEDOMETER GOES IN AND OUT. TYPICALLY DOESN'T WORK IN THE MORNING WHEN IT IS COLD. SOMETIMES WILL BE WORKING FINE THEN STOPS AND STAYS WHERE IT WAS WHEN IT STOPPED WORKING. I WAS TOLD IT IS THE GAUGE CLUSTER THAT NEEDS TO BE REPLACED. *NM

NHTSA ODI #10149498

72,000 miles · Jan 4, 2006
Steering

DT: THE CONTACT STATED A POPPING AND CRACKING NOISE FROM THE STEERING WHEN TURNING THE STEERING WHEEL AT LOW SPEEDS. THE CONTACTED TOOK THE VEHICLE TO THE DEALER. ALTHOUGH THE DEALER DID NOT INSPECT THE VEHICLE HE SUGGESTED REPLACING THE MID SHAFT OF THE STEERING. *AK

NHTSA ODI #10146909

1 miles · Sep 3, 2005
Service Brakes, Hydraulic

ANTI-LOCK BRAKES ON MY 2003 CHEVROLET SILVERADO PICKUP VIN # [XXX] DO NOT WORK AT LOW SPEED. I HAVE HAD THIS TRUCK BACK TO THE DEALER IN SOMERSET PA WHERE I BOUGH IT AND THEY HAVE FAILED TO REPAIR IT. THE FIRST TIME THEY SAID THAT WAS THE NATURE OF ANTI-LOCK BRAKES AND DID NOTHING. THE SECOND TIME AFTER I ALMOST WRECKED THE TRUC…

Read full complaint

ANTI-LOCK BRAKES ON MY 2003 CHEVROLET SILVERADO PICKUP VIN # [XXX] DO NOT WORK AT LOW SPEED. I HAVE HAD THIS TRUCK BACK TO THE DEALER IN SOMERSET PA WHERE I BOUGH IT AND THEY HAVE FAILED TO REPAIR IT. THE FIRST TIME THEY SAID THAT WAS THE NATURE OF ANTI-LOCK BRAKES AND DID NOTHING. THE SECOND TIME AFTER I ALMOST WRECKED THE TRUCK THEY CLEANED THE ABS SENSORS AND SAID THAT WAS ALL THEY COULD DO. THE PROBLEM IS STILL THERE. I WANTED THEM TO UNHOOK THE ANTI-LOCK BRAKES BUT THEY WOULD NOT DO THAT. THIS ALL TOOK PLACE OVER THE LAST TWO YEARS. NOW GM IS RECALLING 1998-2002 SILVERADO PICKUP FOR ANTI-LOCK BRAKE PROBLEMS BUT NOT MY 2003 TRUCK. MY TRUCK WAS BUILT IN 2002 AND I BOUGHT IT IN 2002 BUT IT IS A 2003 MODEL. I BELIEVE THIS TRUCK SHOULD BE RECALLED AND REPAIRED BEFORE I GET HURT. IF GM CAN'T REPAIR THIS TRUCK THEY SHOULD GIVE ME A NEW ONE. I ONLY HAVE 8,700 MILES ON THIS TRUCK AND I BOUGHT IT FOR BAD WINTER ROADS AND I AM AFRAID TO DRIVE IT BECAUSE YOU CAN'T STOP AT SLOW SPEED ON SNOW OR ICE ROADS.*JB UPDATED 07/19/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI #10135244

22,314 miles · Aug 30, 2005
Service Brakes, Hydraulic

DT: THE VEHICLE WENT THROUGH NY STATE INSPECTION ON MARCH 28, 2005 AND PASSED ALTHOUGH THE FRONT END OF THE VEHICLE WAS SHAKING. FOUR MONTHS LATER THE VEHICLE WAS TAKEN TO THE DEALER. THEY DETERMINED THAT THE REAR ROTORS WERE RUSTED AND PITTED. GM WILL ONLY REDUCE THE PRICE FROM $225 TO $79, ALTHOUGH IT WAS COVERED UNDER THE …

Read full complaint

DT: THE VEHICLE WENT THROUGH NY STATE INSPECTION ON MARCH 28, 2005 AND PASSED ALTHOUGH THE FRONT END OF THE VEHICLE WAS SHAKING. FOUR MONTHS LATER THE VEHICLE WAS TAKEN TO THE DEALER. THEY DETERMINED THAT THE REAR ROTORS WERE RUSTED AND PITTED. GM WILL ONLY REDUCE THE PRICE FROM $225 TO $79, ALTHOUGH IT WAS COVERED UNDER THE WARRANTY. THEY SAID IT WAS A WEAR OR RUST ISSUE. BUT THE FRONT BRAKE ROTORS AND CALIPERS WERE FINE. GM WAS NOT HONORING THE WARRANTY.*AK THE INTERMEDIATE SHAFT WAS REPLACED DUE TO NOISE. *NM

NHTSA ODI #10131041

50,000 miles · Aug 19, 2005
Service Brakes, Hydraulic

BRAKE PADS AND ROTORS HAD TO BE REPLACED ON 2003 CHEVROLET SILVERADO. ROTORS WERE CORRODED AND THE DEALERSHIP SAID THAT GM PUT ON "JUNK" PARTS AND WILL NOT ADMIT IT. TRIED TO WORK OUT THE SITUATION WITH GM BUT THEY REFUSED TO COOPERATE. HAD TO PAY FOR THE WORK MYSELF.

NHTSA ODI #10133493

20,000 miles · May 25, 2005
Service Brakes, Hydraulic

DT: CONSUMER STATES: VEHICLE HAD TERRIBLE STOPPING DISTANCE. HAD TO APPLY HARD PRESSURE TO GET THE VEHICLE TO STOP, TOOK IT TO BRAKE SPECIALIST, WHO SAID VEHICLE NEEDED A NEW BOOSTER.*AK *SB

NHTSA ODI #10122136

Mileage unknown · May 16, 2005
Vehicle Speed Control

SPEEDOMETER WAS JUMPING AROUND SPEEDS NOT INDICATED THE PROPER SPEED IF IT WORKED AT ALL.I FEEL IT IS A BIG SAFETY ISSUE NOT KNOWING THE SPEED YOUR GOING FOR THE ROAD CONDITIONS AND WHEN SEARCHING INTERNET FOUND THAT IT IS A CONTINUAL PROBLEM THAT GENERAL MOTORS STILL DOES NOTHING TO FIX FOR SEVERAL YEARS NOW AND CHARGES THE OWN…

Read full complaint

SPEEDOMETER WAS JUMPING AROUND SPEEDS NOT INDICATED THE PROPER SPEED IF IT WORKED AT ALL.I FEEL IT IS A BIG SAFETY ISSUE NOT KNOWING THE SPEED YOUR GOING FOR THE ROAD CONDITIONS AND WHEN SEARCHING INTERNET FOUND THAT IT IS A CONTINUAL PROBLEM THAT GENERAL MOTORS STILL DOES NOTHING TO FIX FOR SEVERAL YEARS NOW AND CHARGES THE OWNER A CHECK OUT FEE AND SEVERAL HUNDRED DOLLORS TO PUT A NEW DASH IN VEHICLE.

NHTSA ODI #10121105

17,686 miles · Apr 14, 2005
SteeringStructure

CONSUMER EXPERIENCING PROBLEMS GETTING RECALLED TAILGATE REPAIRS COMPLETED ON 2003 CHEVROLET LD 1500.*MR IN GM'S COMPUTER THE TAILGATE RECALL APPEARD TO HAVE ALREADY BEEN DONE. THE CONSUMER BELIEVES THAT A MIXUP OCCURED SINCE HE ALSO OWNS A 2002 PICKUP. THE TAILGATE WAS REPLACED ON THE 2002 TRUCK BUT THE CONSUMER BELIEVES TH…

Read full complaint

CONSUMER EXPERIENCING PROBLEMS GETTING RECALLED TAILGATE REPAIRS COMPLETED ON 2003 CHEVROLET LD 1500.*MR IN GM'S COMPUTER THE TAILGATE RECALL APPEARD TO HAVE ALREADY BEEN DONE. THE CONSUMER BELIEVES THAT A MIXUP OCCURED SINCE HE ALSO OWNS A 2002 PICKUP. THE TAILGATE WAS REPLACED ON THE 2002 TRUCK BUT THE CONSUMER BELIEVES THEY MARKED THAT THE TAILGATE ON THE 2003 TRUCK WAS REPLACED INSTEAD. THE STEERING SHAFT WAS ALSO REPLACED. *NM

NHTSA ODI #10119342

40,000 miles · Apr 5, 2005
Engine And Engine CoolingService Brakes, AirVisibility

MY COMPLAINT IS THE BRAKING SYSTEM ON MY 2003 CHEVROLET SILVERADO 1500 EXTENDED CAB, 4X4 TRUCK. THE BRAKES HAVE ALWAYS FELT SPONGY. AFTER COMPLAINING ABOUT THE "LOW" BRAKE PEDAL, MY DEALER ADVISED THAT I NEEDED TO HAVE MY REAR ROTORS REPAIRED & THE REAR BRAKE SHOES REPLACED., SO I HAD THE WORK DONE. ONE WEEK LATER, I AGAIN COMPL…

Read full complaint

MY COMPLAINT IS THE BRAKING SYSTEM ON MY 2003 CHEVROLET SILVERADO 1500 EXTENDED CAB, 4X4 TRUCK. THE BRAKES HAVE ALWAYS FELT SPONGY. AFTER COMPLAINING ABOUT THE "LOW" BRAKE PEDAL, MY DEALER ADVISED THAT I NEEDED TO HAVE MY REAR ROTORS REPAIRED & THE REAR BRAKE SHOES REPLACED., SO I HAD THE WORK DONE. ONE WEEK LATER, I AGAIN COMPLAINED THAT NOW WHEN I'M STOPPED AT A TRAFFIC LIGHT, THE BRAKE PEDAL WOULD GO EVEN LOWER. THE BRAKING SYSTEM WAS CHECKED OUT, THE MASTER CYLINDER WAS CHECKED, & I WAS TOLD EVERYTHING WAS OK, THERE WERE NO LEAKS. I WAS ALSO TOLD THAT THIS WAS THE BIGGEST COMPLAINT ABOUT THIS TRUCK. I HAVE HAD NOTHING BUT PROBLEMS WITH THIS VEHICLE. IN THE FIRST FEW MONTHS OF OWNING THE VEHICLE, THE WIPER BLADE WAS DEFECTIVE, THUS SCRATCHING THE WINDSHIELD. I HAD TO COMPLAIN TO GET THE WINDSHIELD REPLACED & THE WIPER REPAIRED. ALSO WITHING THE FIRST FEW MONTHS AFTER PURCHASING, THE 4X4 SWITCH HAD TO BE REPLACED. THE TRUCK WOULD NOT SHIFT OUT OF 4 WHEEL DRIVE LOW. ANOTHER COMPLAINT THAT THE DEALER WAS NOTIFIED WITHIN THE FIRST YEAR OF OWNERSHIP WAS THE WIND NOISE DUE TO A FAULTY DOOR GASKET ON THE DRIVER'S SIDE. THIS WAS NOT REPLACED, ONLY TEMPORARILY FIXED, WHICH ONLY CORRECTED THE PROBLEM FOR A SHORT WHILE. RECENTLY, THE ENGINE LIGHT CAME ON, THE O2 OXYGEN SENSOR HAD TO BE REPLACED. WITHIN A MONTH, THE ENGINE LIGHT CAME ON AGAIN, THIS TIME IT IS A STUCK OPEN VALVE SOLONOID DEALING WITH THE EMMISSION SYSTEM OF WHICH I WAS GIVEN AN ESTIMATE OF 364.00 TO REAPAIR, THIS WOULD NOT BE COVERED UNDER THE EXTENDED WARRANTY OF THE VEHICLE. THIS VEHICLE IS ONLY 2 YEARS OLD, & I'M TIRED OF HAVING TO TAKE THE TIME TO GET IT TO THE DEALER'S FOR REPAIRS. *AK

NHTSA ODI #10116382

Official recalls

0

No recalls in this snapshot.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

EA11001 · Brake Line Corrosion Failure

Opened Jan 5, 2011 · Closed Apr 8, 2015

Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings

On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and 3500 series pick-up trucks; 2000-2006 Chevrolet Suburban, Chevrolet Tahoe and GMC Yukon sport utility vehicles; and 2002-2006 Cadillac Escalade and Chevrolet Avalanche sport-utility vehicles.General Motors produced a total of approximately 10,427,062 GMT800 vehicles for sales in the United States, including almost 5 million that were sold in salt states.Although there are over 60 different brake pipe routing configuration used in GMT800 vehicles, with the exception of the rear crossover pipes in MY 200x-2007 vehicles that changed from rear disc to drum brakes, all of the vehicles use brake pipes from the same supplier with a common double-wall, brazed steel pipe design with a combination of hot dip Zinc-Aluminum corrosion protection coating and Aluminum paint outer layer known in the industry as AlGal (ASTM-B750). ODI analysis of field data regarding GMT800 vehicles identified a total of 3,645 complaints of brake pipe corrosion failures, including 107 alleging crashes, and 40 injuries.Though only 20% of total GMT800 production, due to age and region the subject vehicles account for a disproportionate share of the failure experience; with 2,702 of the complaints (75%), 88 of the crashes (82%) and 20 of the injuries (50%) reported in those vehicles.Analysis of the complaints showed strong correlations to vehicle age and region.For vehicles with less than 8 years of service, the complaint rates were minimal for all regions.In the salt states the failure rates begin to climb as the vehicles advance in age, particularly in the Northeast corner of the United States.The complaint rates in the salt states go from less than 0.1 incident per thousand vehicles (IPTV) at 7 years in service to over 1.0 IPTV after the 12th year of service for the subject pickup trucks and utility vehicles.Most of the failures reported to ODI occurred in vehicles with more than 10 years in service.ODI?s investigation did not identify any specific defect conditions that were causing or contributing to the brake pipe failures.Nor did the analysis isolate the problem to any subject vehicle sub-populations when analyzed by vehicle type or production range.The investigation found that vehicles experiencing brake pipe corrosion failures were likely to have general patterns of excessive corrosion on the majority of the brake pipe assembly and appear to be occurring due to expected wear out for the brake pipe coating material used in the subject vehicles and the environmental conditions in severe corrosion states.A safety-related defect has not been identified at this time.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor t

Additional source detail variants (2)

Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings

On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and 3500 series pick-up trucks; 2000-2006 Chevrolet Suburban, Chevrolet Tahoe and GMC Yukon sport utility vehicles; and 2002-2006 Cadillac Escalade and Chevrolet Avalanche sport-utility vehicles.General Motors produced a total of approximately 10,427,062 GMT800 vehicles for sales in the United States, including almost 5 million that were sold in salt states.Although there are over 60 different brake pipe routing configuration used in GMT800 vehicles, with the exception of the rear crossover pipes in MY 200x-2007 vehicles that changed from rear disc to drum brakes, all of the vehicles use brake pipes from the same supplier with a common double-wall, brazed steel pipe design with a combination of hot dip Zinc-Aluminum corrosion protection coating and Aluminum paint outer layer known in the industry as AlGal (ASTM-B750). ODI analysis of field data regarding GMT800 vehicles identified a total of 3,645 complaints of brake pipe corrosion failures, including 107 alleging crashes, and 40 injuries.Though only 20% of total GMT800 production, due to age and region the subject vehicles account for a disproportionate share of the failure experience; with 2,702 of the complaints (75%), 88 of the crashes (82%) and 20 of the injuries (50%) reported in those vehicles.Analysis of the complaints showed strong correlations to vehicle age and region.For vehicles with less than 8 years of service, the complaint rates were minimal for all regions.In the salt states the failure rates begin to climb as the vehicles advance in age, particularly in the Northeast corner of the United States.The complaint rates in the salt states go from less than 0.1 incident per thousand vehicles (IPTV) at 7 years in service to over 1.0 IPTV after the 12th year of service for the subject pickup trucks and utility vehicles.Most of the failures reported to ODI occurred in vehicles with more than 10 years in service.ODI?s investigation did not identify any specific defect conditions that were causing or contributing to the brake pipe failures.Nor did the analysis isolate the problem to any subject vehicle sub-populations when analyzed by vehicle type or production range.The investigation found that vehicles experiencing brake pipe corrosion failures were likely to have general patterns of excessive corrosion on the majority of the brake pipe assembly and appear to be occurring due to expected wear out for the brake pipe coating material used in the subject vehicles and the environmental conditions in severe corrosion states.A safety-related defect has not been identified at this time.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor t

Service Brakes, Hydraulic

On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and 3500 series pick-up trucks; 2000-2006 Chevrolet Suburban, Chevrolet Tahoe and GMC Yukon sport utility vehicles; and 2002-2006 Cadillac Escalade and Chevrolet Avalanche sport-utility vehicles.General Motors produced a total of approximately 10,427,062 GMT800 vehicles for sales in the United States, including almost 5 million that were sold in salt states.Although there are over 60 different brake pipe routing configuration used in GMT800 vehicles, with the exception of the rear crossover pipes in MY 200x-2007 vehicles that changed from rear disc to drum brakes, all of the vehicles use brake pipes from the same supplier with a common double-wall, brazed steel pipe design with a combination of hot dip Zinc-Aluminum corrosion protection coating and Aluminum paint outer layer known in the industry as AlGal (ASTM-B750). ODI analysis of field data regarding GMT800 vehicles identified a total of 3,645 complaints of brake pipe corrosion failures, including 107 alleging crashes, and 40 injuries.Though only 20% of total GMT800 production, due to age and region the subject vehicles account for a disproportionate share of the failure experience; with 2,702 of the complaints (75%), 88 of the crashes (82%) and 20 of the injuries (50%) reported in those vehicles.Analysis of the complaints showed strong correlations to vehicle age and region.For vehicles with less than 8 years of service, the complaint rates were minimal for all regions.In the salt states the failure rates begin to climb as the vehicles advance in age, particularly in the Northeast corner of the United States.The complaint rates in the salt states go from less than 0.1 incident per thousand vehicles (IPTV) at 7 years in service to over 1.0 IPTV after the 12th year of service for the subject pickup trucks and utility vehicles.Most of the failures reported to ODI occurred in vehicles with more than 10 years in service.ODI?s investigation did not identify any specific defect conditions that were causing or contributing to the brake pipe failures.Nor did the analysis isolate the problem to any subject vehicle sub-populations when analyzed by vehicle type or production range.The investigation found that vehicles experiencing brake pipe corrosion failures were likely to have general patterns of excessive corrosion on the majority of the brake pipe assembly and appear to be occurring due to expected wear out for the brake pipe coating material used in the subject vehicles and the environmental conditions in severe corrosion states.A safety-related defect has not been identified at this time.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor t

EA04011 · Parking Brake Failure

Opened Apr 9, 2004 · Closed May 10, 2005

Status: closed (inferred from source dates) · Parking Brake; Parking Brake:conventional; Parking Brake:conventional:mechanical; Parking Brake:conventional:mechanical:linkage And Cable

IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.

Additional source detail variants (4)

Parking Brake:conventional

IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.

Parking Brake:conventional:mechanical

IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.

Parking Brake:conventional:mechanical:linkage And Cable

IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.

Parking Brake

IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.

PE03057 · Parking Brake Failure

Opened Dec 8, 2003 · Closed Apr 9, 2004

Status: closed (inferred from source dates) · Parking Brake

ODI OPENED PE03-057 TO ASSESS PARKING BRAKE INEFFECTIVENESS IN THE SUBJECT VEHICLES.THESE VEHICLES ARE EQUIPPED WITH FOUR WHEEL DISC BRAKES THAT INCORPORATE A SINGLE-SHOE DRUM-IN-HAT PARKING BRAKE INDEPENDENT OF THE SERVICE BRAKES.COMPLAINT AND WARRANTY DATA INDICATE THAT THE PARKING BRAKE LININGS TEND TO WEAR OUT EARLY IN THE LIFE OF THE VEHICLE (AT AN AVERAGE OF 24 MONTHS IN SERVICE), REDUCING THE PARKING BRAKE SYSTEM'S TORQUE BELOW THAT NEEDED TO IMMOBILIZE THE VEHICLE.GM HAS ATTRIBUTED THIS ACCELERATED WEAR TO FOREIGN MATERIAL INTRUSION AND A FAILURE OF THE BRAKE SHOE TO PROPERLY SELF-CENTER WITHIN ITS BRAKE DRUM.EFFECTIVE WITH THE START OF MY 2003 PRODUCTION, A NEWER REDUCED FORCE HOLD-DOWN CLIP WAS INTRODUCED TO FACILITATE BRAKE SHOE DISENGAGEMENT FROM THE DRUM SURFACE.THIS PART IS ALSO AVAILABLE AT THE SERVICE LEVEL FOR THE MY 1999-2002 VEHICLES.GM HAS INDICATED THAT THE PAKING BRAKE IS INTENDED TO OPERATE IN CONJUNCTION WITH THE TRANSMISSION TO IMMOBILZE PARKED VEHICLES, AND THAT IN MANY CASES, ACCELERATED PARKING BRAKE LINING WEAR IS CAUSED BY ROUGH USE, VEHICLE MODIFICATIONS, AND DRIVING WITH THE PARKING ENGAGED. ODI HAS UPGRADED THE PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING PARKING BRAKE USAGE FACTORS AND THE CIRCUMSTANCES SURROUNDING THE SEVENTEEN REPORTED VEHICLE CRASHES.