← New search

2003 Chevrolet Silverado 1500

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2003 Chevrolet Silverado 1500 do not stand out strongly from the model-year median of 525.

About this comparison →

When problems were reported

Mileage at the reported incident

726 reports with mileage · 79 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Service Brakes. Review the 273 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 195 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Service Brakes, Hydraulic. Review the 151 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

26 crash reports7 fire reports8 injury reports

Steering complaints

56 reports
Clear category filter
18,000 miles · Mar 5, 2009
EquipmentSteering

4 TIMES IN 58,000 MILE THE FRONT STEERING SHAFT HAS NEEDED ATTENTION. TWICE UNDER WARRANTY, TWICE NOT. PAID FOR CORRECTION, 4TH TIME REFUSED TO PAY AS FEEL IT IS GM PROBLEM SINCE ALL 2003 CHEVY. SILVERADOS SUFFER FROM THIS. GM HAS DESIGNED A NEW PART BUT REFUSE TO INSTALL UNLESS CONSUMER PAYS FOR IT. THEY ADMITTED IT IS A PRO…

Read full complaint

4 TIMES IN 58,000 MILE THE FRONT STEERING SHAFT HAS NEEDED ATTENTION. TWICE UNDER WARRANTY, TWICE NOT. PAID FOR CORRECTION, 4TH TIME REFUSED TO PAY AS FEEL IT IS GM PROBLEM SINCE ALL 2003 CHEVY. SILVERADOS SUFFER FROM THIS. GM HAS DESIGNED A NEW PART BUT REFUSE TO INSTALL UNLESS CONSUMER PAYS FOR IT. THEY ADMITTED IT IS A PROBLEM. SETTLED ONCE, THEY SAID INSTALLED A NEW PART , FOUND OUT THEY DID NOT . HAVE REFERRED IT TO NY STATE ATTORNEY GENERALS OFFICE FOR ACTION, THEY ARE PRESENTLY TRYING TO MEDIATE. SINCE ALL SILVERADOS SUFFER FROM STEER SHAFT FAILURE SEEMS TO BE A MAJOR SAFETY PROBLEM AND SHOULD ALL BE RECALLED TO FIX. *TR

NHTSA ODI #10260781

27,500 miles · Feb 14, 2009
Steering

THERE IS A THUNKING SOUND THAT ORIGINATES SOMEWHERE IN THE STEERING MECHANISM. I TOOK IT TO THE DEALER WHILE THE VEHICLE WAS STILL UNDER WARRANTY AND WAS TOLD THAT IT WAS NOT A SAFETY ISSUE AND THAT THE STEERING BOX JUST NEEDED TO BE REPACKED WITH GREASE. IT FEELS AS IF IT IS A SAFETY ISSUE. IT FEELS AS IF THE WHOLE STEERING ME…

Read full complaint

THERE IS A THUNKING SOUND THAT ORIGINATES SOMEWHERE IN THE STEERING MECHANISM. I TOOK IT TO THE DEALER WHILE THE VEHICLE WAS STILL UNDER WARRANTY AND WAS TOLD THAT IT WAS NOT A SAFETY ISSUE AND THAT THE STEERING BOX JUST NEEDED TO BE REPACKED WITH GREASE. IT FEELS AS IF IT IS A SAFETY ISSUE. IT FEELS AS IF THE WHOLE STEERING MECHANISM IS GOING TO COME APART. I ORIGINALLY NOTICED THE PROBLEM AT 25000 MILES AND TOOK IT TO THE DEALER. THE NOISE CAME BACK IN ABOUT 12-15000 MILES. IT APPEARS FROM THE MESSAGE BOARDS AND TO PEOPLE THAT I HAVE TALKED TO THAT OWN THE SAME OR SIMILAR VEHICLE HAVE THE SAME PROBLEMS. *TR

NHTSA ODI #10258670

97,535 miles · Feb 2, 2009
Service Brakes, HydraulicSteering

I AM WRITING IN REGARDS TO MY ANTI LOCK BAKING SYSTEM (ABS) AND MY STEERING COLUMN. I WAS NEARLY INVOLVED IN AN AUTO ACCIDENT ON DRY PAVEMENT WHEN MY ABS SYSTEM ENGAGED AND THEN DIS-ENGAGED AT A SPEED OF LESS THAN 10 MPH. WHEN STEERING TO THE RIGHT TO AVOID THE ACCIDENT, MY STEERING COLUMN HAD A STRANGE VIBRATION/LOUD HUMMING N…

Read full complaint

I AM WRITING IN REGARDS TO MY ANTI LOCK BAKING SYSTEM (ABS) AND MY STEERING COLUMN. I WAS NEARLY INVOLVED IN AN AUTO ACCIDENT ON DRY PAVEMENT WHEN MY ABS SYSTEM ENGAGED AND THEN DIS-ENGAGED AT A SPEED OF LESS THAN 10 MPH. WHEN STEERING TO THE RIGHT TO AVOID THE ACCIDENT, MY STEERING COLUMN HAD A STRANGE VIBRATION/LOUD HUMMING NOISE. MY ANTILOCK BRAKES ENGAGED WHILE I WAS SLOWING TO SWERVE TO MISS THE ONCOMING VEHICLE AND THEN MY ABS STOPPED WORKING AND MY ABS WARNING LIGHT ALONG WITH MY PARKING BRAKE (P) WARNING LIGHT CAME ON. NOW, SINCE THAT DAY (2 DAYS AGO), MY STEERING COLUMN STILL MAKES NOISES WHEN I TURN TO THE RIGHT AND MY ABS SYSTEM CONTINUES TO ENGAGE AT SLOW SPEEDS WHEN STOPPING EVEN ON DRY PAVEMENT. I HAVE BEEN TOLD BY A GM DEALERSHIP THAT THE TWO ISSUES THAT I AM EXPERIENCING ARE NOT ON A RECALL LIST BUT ARE COMMON PROBLEMS WITH MY VEHICLE. THEY FURTHER ADVISED THAT SINCE MY VEHICLE IS NO LONGER UNDER WARRANTY, I WOULD HAVE TO PAY FOR THESE MALFUNCTIONS. I WAS TOLD BY AN INDEPENDENT MECHANIC THAT THE ABOVE ISSUES ARE SAFETY ISSUES AND GM IS AWARE OF THE PROBLEMS. WITH THE ABOVE BEING SAID, I FEEL THAT MY ISSUES WITH THE ABS SYSTEM AND THE STEERING COLUMN ARE SAFETY ISSUES AND GM SHOULD BE ADDRESSING THESE ISSUES BEFORE SOMEONE IS SERIOUSLY INJURED OR KILLED. I NEED TO GET THESE ISSUES CORRECTED ON MY VEHICLE, HOWEVER, I DO NOT FEEL THAT I SHOULD BE LIABLE FOR THESE REPAIRS WHEN GM IS AWARE OF THE ISSUES AND NOTHING HAS BEEN DONE TO REMEDY THE PROBLEM. *TR

NHTSA ODI #10257181

97,535 miles · Feb 2, 2009
Service Brakes, HydraulicSteering

I AM WRITING IN REGARDS TO MY ANTI LOCK BAKING SYSTEM (ABS) AND MY STEERING COLUMN. I WAS NEARLY INVOLVED IN AN AUTO ACCIDENT ON DRY PAVEMENT WHEN MY ABS SYSTEM ENGAGED AND THEN DIS-ENGAGED AT A SPEED OF LESS THAN 10 MPH. WHEN STEERING TO THE RIGHT TO AVOID THE ACCIDENT, MY STEERING COLUMN HAD A STRANGE VIBRATION/LOUD HUMMING N…

Read full complaint

I AM WRITING IN REGARDS TO MY ANTI LOCK BAKING SYSTEM (ABS) AND MY STEERING COLUMN. I WAS NEARLY INVOLVED IN AN AUTO ACCIDENT ON DRY PAVEMENT WHEN MY ABS SYSTEM ENGAGED AND THEN DIS-ENGAGED AT A SPEED OF LESS THAN 10 MPH. WHEN STEERING TO THE RIGHT TO AVOID THE ACCIDENT, MY STEERING COLUMN HAD A STRANGE VIBRATION/LOUD HUMMING NOISE. MY ANTILOCK BRAKES ENGAGED WHILE I WAS SLOWING TO SWERVE TO MISS THE ONCOMING VEHICLE AND THEN MY ABS STOPPED WORKING AND MY ABS WARNING LIGHT ALONG WITH MY PARKING BRAKE (P) WARNING LIGHT CAME ON. NOW, SINCE THAT DAY (2 DAYS AGO), MY STEERING COLUMN STILL MAKES NOISES WHEN I TURN TO THE RIGHT AND MY ABS SYSTEM CONTINUES TO ENGAGE AT SLOW SPEEDS WHEN STOPPING EVEN ON DRY PAVEMENT. I HAVE BEEN TOLD BY A GM DEALERSHIP THAT THE TWO ISSUES THAT I AM EXPERIENCING ARE NOT ON A RECALL LIST BUT ARE COMMON PROBLEMS WITH MY VEHICLE. THEY FURTHER ADVISED THAT SINCE MY VEHICLE IS NO LONGER UNDER WARRANTY, I WOULD HAVE TO PAY FOR THESE MALFUNCTIONS. I WAS TOLD BY AN INDEPENDENT MECHANIC THAT THE ABOVE ISSUES ARE SAFETY ISSUES AND GM IS AWARE OF THE PROBLEMS. WITH THE ABOVE BEING SAID, I FEEL THAT MY ISSUES WITH THE ABS SYSTEM AND THE STEERING COLUMN ARE SAFETY ISSUES AND GM SHOULD BE ADDRESSING THESE ISSUES BEFORE SOMEONE IS SERIOUSLY INJURED OR KILLED. I NEED TO GET THESE ISSUES CORRECTED ON MY VEHICLE, HOWEVER, I DO NOT FEEL THAT I SHOULD BE LIABLE FOR THESE REPAIRS WHEN GM IS AWARE OF THE ISSUES AND NOTHING HAS BEEN DONE TO REMEDY THE PROBLEM. *TR

NHTSA ODI #10257180

Mileage unknown · Oct 28, 2008
Steering

2003 CHEVY TAHOE AND SILVERADO EXCESSIVE VIBRATION, RATTLING AND PULLING IN STEERING. DEALER LUBES THE SHAFT WHICH ONLY TEMPORARILY FIXES THE PROBLEM AS THE PROBLEM ALWAYS COMES BACK. *TR

NHTSA ODI #10246960

40,000 miles · Oct 18, 2008
Steering

INTERMEDIATE STEERING SHAFT CLUNKING WHILE DRIVING. THIS HAS BEEN REPLACED BEFORE AND THE CLUNKING STOPPED FOR A WHILE, BUT IT NEEDS TO BE REPLACED AGAIN. *TR

NHTSA ODI #10245861

Mileage unknown · Sep 9, 2008
Steering

STEERING CONTINUES TO KNOCK. *TR

NHTSA ODI #10241571

25,000 miles · Sep 2, 2008
Steering

2003 CHEVROLET SILVERADO PICKUP STEERING DEFECT. INTERMEDIATE STEERING BECOMES LOOSE. POSSIBLE LOSS OF CONTROL. CURRENT REPAIR IS TO GREASE SHAFT TO DEADEN SOUND OF LOOSE SLIDING PARTS. STEERING PARTS IN QUESTION ARE CRUCIAL TO SAFE OPERATION. MULTIPLE OCCURRENCES WITH THIS VEHICLE. *TR

NHTSA ODI #10240655

15,000 miles · Mar 27, 2008
Steering

TL*THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THERE WAS A LOOSE, KNOCKING FEELING AS HE TURNED HIS STEERING WHEEL MULTIPLE TIMES. THE CONTACT TOOK THE VEHICLE TO A DEALER TWICE AND WAS INFORMED THAT IT WAS AN ONGOING FAILURE AND ALL THEY COULD DO WAS TO GREASE THE STEERING SHAFT. THE DEALER ALSO…

Read full complaint

TL*THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THERE WAS A LOOSE, KNOCKING FEELING AS HE TURNED HIS STEERING WHEEL MULTIPLE TIMES. THE CONTACT TOOK THE VEHICLE TO A DEALER TWICE AND WAS INFORMED THAT IT WAS AN ONGOING FAILURE AND ALL THEY COULD DO WAS TO GREASE THE STEERING SHAFT. THE DEALER ALSO STATED THAT IT WAS JUST A TEMPORARY REPAIR AND WOULD HAVE TO TAKE THE VEHICLE BACK PERIODICALLY FOR RELUBRICATION. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT MILEAGE WAS 81,000 AND FAILURE MILEAGE WAS 15,000.

NHTSA ODI #10222467

30,000 miles · Mar 18, 2008
Steering

POTENTIAL SAFETY PROBLEM WITH STEERING SHAFT ON 2000-2005 CHEVY TRUCKS. I HAVE HAD MY STEERING WORKED ON TWICE TO SOLVE A KNOCKING IN THE COLUMN. GM DEALERSHIPS SAY IF IT GOES UNREPAIRED THERE COULD BE A POTENTIAL FAILURE IN THE STEERING SHAFT. THERE ARE MANY COMPLAINTS ON THE INTERNET ABOUT THIS ALL YOU HAVE TO DO IS GOOGLE …

Read full complaint

POTENTIAL SAFETY PROBLEM WITH STEERING SHAFT ON 2000-2005 CHEVY TRUCKS. I HAVE HAD MY STEERING WORKED ON TWICE TO SOLVE A KNOCKING IN THE COLUMN. GM DEALERSHIPS SAY IF IT GOES UNREPAIRED THERE COULD BE A POTENTIAL FAILURE IN THE STEERING SHAFT. THERE ARE MANY COMPLAINTS ON THE INTERNET ABOUT THIS ALL YOU HAVE TO DO IS GOOGLE "CHEVY STEERING PROBLEMS". DEALER REPAIR SERVICE SAYS THERE IS NO FIX AND YOU HAVE TO BRING IT IN EVERY 20,000 TO 30,000 MILES AND HAVE IT REPAIRED AT A COST OF 100 DOLLARS TO 500 DOLLARS. SOMETHING NEEDS DONE ABOUT THIS BEFORE SOMEONE GETS HURT FROM THIS. THERE SHOULD BE A RECALL JUST FOR THE FACT THAT IT IS COSTING EVERYONE THAT HAS PURCHASED A CHEVY TRUCK TO FIX THE PROBLEM OVER AND OVER AGAIN. *TR

NHTSA ODI #10221609

Official recalls

0

No recalls in this snapshot.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

EA11001 · Brake Line Corrosion Failure

Opened Jan 5, 2011 · Closed Apr 8, 2015

Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings

On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and 3500 series pick-up trucks; 2000-2006 Chevrolet Suburban, Chevrolet Tahoe and GMC Yukon sport utility vehicles; and 2002-2006 Cadillac Escalade and Chevrolet Avalanche sport-utility vehicles.General Motors produced a total of approximately 10,427,062 GMT800 vehicles for sales in the United States, including almost 5 million that were sold in salt states.Although there are over 60 different brake pipe routing configuration used in GMT800 vehicles, with the exception of the rear crossover pipes in MY 200x-2007 vehicles that changed from rear disc to drum brakes, all of the vehicles use brake pipes from the same supplier with a common double-wall, brazed steel pipe design with a combination of hot dip Zinc-Aluminum corrosion protection coating and Aluminum paint outer layer known in the industry as AlGal (ASTM-B750). ODI analysis of field data regarding GMT800 vehicles identified a total of 3,645 complaints of brake pipe corrosion failures, including 107 alleging crashes, and 40 injuries.Though only 20% of total GMT800 production, due to age and region the subject vehicles account for a disproportionate share of the failure experience; with 2,702 of the complaints (75%), 88 of the crashes (82%) and 20 of the injuries (50%) reported in those vehicles.Analysis of the complaints showed strong correlations to vehicle age and region.For vehicles with less than 8 years of service, the complaint rates were minimal for all regions.In the salt states the failure rates begin to climb as the vehicles advance in age, particularly in the Northeast corner of the United States.The complaint rates in the salt states go from less than 0.1 incident per thousand vehicles (IPTV) at 7 years in service to over 1.0 IPTV after the 12th year of service for the subject pickup trucks and utility vehicles.Most of the failures reported to ODI occurred in vehicles with more than 10 years in service.ODI?s investigation did not identify any specific defect conditions that were causing or contributing to the brake pipe failures.Nor did the analysis isolate the problem to any subject vehicle sub-populations when analyzed by vehicle type or production range.The investigation found that vehicles experiencing brake pipe corrosion failures were likely to have general patterns of excessive corrosion on the majority of the brake pipe assembly and appear to be occurring due to expected wear out for the brake pipe coating material used in the subject vehicles and the environmental conditions in severe corrosion states.A safety-related defect has not been identified at this time.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor t

Additional source detail variants (2)

Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings

On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and 3500 series pick-up trucks; 2000-2006 Chevrolet Suburban, Chevrolet Tahoe and GMC Yukon sport utility vehicles; and 2002-2006 Cadillac Escalade and Chevrolet Avalanche sport-utility vehicles.General Motors produced a total of approximately 10,427,062 GMT800 vehicles for sales in the United States, including almost 5 million that were sold in salt states.Although there are over 60 different brake pipe routing configuration used in GMT800 vehicles, with the exception of the rear crossover pipes in MY 200x-2007 vehicles that changed from rear disc to drum brakes, all of the vehicles use brake pipes from the same supplier with a common double-wall, brazed steel pipe design with a combination of hot dip Zinc-Aluminum corrosion protection coating and Aluminum paint outer layer known in the industry as AlGal (ASTM-B750). ODI analysis of field data regarding GMT800 vehicles identified a total of 3,645 complaints of brake pipe corrosion failures, including 107 alleging crashes, and 40 injuries.Though only 20% of total GMT800 production, due to age and region the subject vehicles account for a disproportionate share of the failure experience; with 2,702 of the complaints (75%), 88 of the crashes (82%) and 20 of the injuries (50%) reported in those vehicles.Analysis of the complaints showed strong correlations to vehicle age and region.For vehicles with less than 8 years of service, the complaint rates were minimal for all regions.In the salt states the failure rates begin to climb as the vehicles advance in age, particularly in the Northeast corner of the United States.The complaint rates in the salt states go from less than 0.1 incident per thousand vehicles (IPTV) at 7 years in service to over 1.0 IPTV after the 12th year of service for the subject pickup trucks and utility vehicles.Most of the failures reported to ODI occurred in vehicles with more than 10 years in service.ODI?s investigation did not identify any specific defect conditions that were causing or contributing to the brake pipe failures.Nor did the analysis isolate the problem to any subject vehicle sub-populations when analyzed by vehicle type or production range.The investigation found that vehicles experiencing brake pipe corrosion failures were likely to have general patterns of excessive corrosion on the majority of the brake pipe assembly and appear to be occurring due to expected wear out for the brake pipe coating material used in the subject vehicles and the environmental conditions in severe corrosion states.A safety-related defect has not been identified at this time.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor t

Service Brakes, Hydraulic

On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and 3500 series pick-up trucks; 2000-2006 Chevrolet Suburban, Chevrolet Tahoe and GMC Yukon sport utility vehicles; and 2002-2006 Cadillac Escalade and Chevrolet Avalanche sport-utility vehicles.General Motors produced a total of approximately 10,427,062 GMT800 vehicles for sales in the United States, including almost 5 million that were sold in salt states.Although there are over 60 different brake pipe routing configuration used in GMT800 vehicles, with the exception of the rear crossover pipes in MY 200x-2007 vehicles that changed from rear disc to drum brakes, all of the vehicles use brake pipes from the same supplier with a common double-wall, brazed steel pipe design with a combination of hot dip Zinc-Aluminum corrosion protection coating and Aluminum paint outer layer known in the industry as AlGal (ASTM-B750). ODI analysis of field data regarding GMT800 vehicles identified a total of 3,645 complaints of brake pipe corrosion failures, including 107 alleging crashes, and 40 injuries.Though only 20% of total GMT800 production, due to age and region the subject vehicles account for a disproportionate share of the failure experience; with 2,702 of the complaints (75%), 88 of the crashes (82%) and 20 of the injuries (50%) reported in those vehicles.Analysis of the complaints showed strong correlations to vehicle age and region.For vehicles with less than 8 years of service, the complaint rates were minimal for all regions.In the salt states the failure rates begin to climb as the vehicles advance in age, particularly in the Northeast corner of the United States.The complaint rates in the salt states go from less than 0.1 incident per thousand vehicles (IPTV) at 7 years in service to over 1.0 IPTV after the 12th year of service for the subject pickup trucks and utility vehicles.Most of the failures reported to ODI occurred in vehicles with more than 10 years in service.ODI?s investigation did not identify any specific defect conditions that were causing or contributing to the brake pipe failures.Nor did the analysis isolate the problem to any subject vehicle sub-populations when analyzed by vehicle type or production range.The investigation found that vehicles experiencing brake pipe corrosion failures were likely to have general patterns of excessive corrosion on the majority of the brake pipe assembly and appear to be occurring due to expected wear out for the brake pipe coating material used in the subject vehicles and the environmental conditions in severe corrosion states.A safety-related defect has not been identified at this time.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor t

EA04011 · Parking Brake Failure

Opened Apr 9, 2004 · Closed May 10, 2005

Status: closed (inferred from source dates) · Parking Brake; Parking Brake:conventional; Parking Brake:conventional:mechanical; Parking Brake:conventional:mechanical:linkage And Cable

IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.

Additional source detail variants (4)

Parking Brake:conventional

IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.

Parking Brake:conventional:mechanical

IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.

Parking Brake:conventional:mechanical:linkage And Cable

IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.

Parking Brake

IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.

PE03057 · Parking Brake Failure

Opened Dec 8, 2003 · Closed Apr 9, 2004

Status: closed (inferred from source dates) · Parking Brake

ODI OPENED PE03-057 TO ASSESS PARKING BRAKE INEFFECTIVENESS IN THE SUBJECT VEHICLES.THESE VEHICLES ARE EQUIPPED WITH FOUR WHEEL DISC BRAKES THAT INCORPORATE A SINGLE-SHOE DRUM-IN-HAT PARKING BRAKE INDEPENDENT OF THE SERVICE BRAKES.COMPLAINT AND WARRANTY DATA INDICATE THAT THE PARKING BRAKE LININGS TEND TO WEAR OUT EARLY IN THE LIFE OF THE VEHICLE (AT AN AVERAGE OF 24 MONTHS IN SERVICE), REDUCING THE PARKING BRAKE SYSTEM'S TORQUE BELOW THAT NEEDED TO IMMOBILIZE THE VEHICLE.GM HAS ATTRIBUTED THIS ACCELERATED WEAR TO FOREIGN MATERIAL INTRUSION AND A FAILURE OF THE BRAKE SHOE TO PROPERLY SELF-CENTER WITHIN ITS BRAKE DRUM.EFFECTIVE WITH THE START OF MY 2003 PRODUCTION, A NEWER REDUCED FORCE HOLD-DOWN CLIP WAS INTRODUCED TO FACILITATE BRAKE SHOE DISENGAGEMENT FROM THE DRUM SURFACE.THIS PART IS ALSO AVAILABLE AT THE SERVICE LEVEL FOR THE MY 1999-2002 VEHICLES.GM HAS INDICATED THAT THE PAKING BRAKE IS INTENDED TO OPERATE IN CONJUNCTION WITH THE TRANSMISSION TO IMMOBILZE PARKED VEHICLES, AND THAT IN MANY CASES, ACCELERATED PARKING BRAKE LINING WEAR IS CAUSED BY ROUGH USE, VEHICLE MODIFICATIONS, AND DRIVING WITH THE PARKING ENGAGED. ODI HAS UPGRADED THE PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING PARKING BRAKE USAGE FACTORS AND THE CIRCUMSTANCES SURROUNDING THE SEVENTEEN REPORTED VEHICLE CRASHES.