← New search

2003 Chevrolet Silverado 1500

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2003 Chevrolet Silverado 1500 do not stand out strongly from the model-year median of 525.

About this comparison →

When problems were reported

Mileage at the reported incident

726 reports with mileage · 79 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Service Brakes. Review the 273 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 195 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Service Brakes, Hydraulic. Review the 151 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

26 crash reports7 fire reports8 injury reports

Engine complaints

15 reports
Clear category filter
Mileage unknown · May 18, 2021
EngineFuel/propulsion SystemSteering

My engine has been giving me lean condition codes p0171, p0174 and truck is lacking performance really bad and coolant problems too please message me back

NHTSA ODI #11417701

130,000 miles · Dec 5, 2016
Engine

TL* THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 1500. WHILE DRIVING 70 MPH, THE CHECK ENGINE AND REDUCE ENGINE POWER WARNING INDICATORS ILLUMINATED. THE CONTACT STATED THAT TURNING THE VEHICLE OFF AND BACK ON RESOLVED THE ISSUE. THE VEHICLE WAS TAKEN TO THE DEALER TO BE DIAGNOSED. THE MECHANIC WAS UNABLE TO DUPLICATE THE FAILURE…

Read full complaint

TL* THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 1500. WHILE DRIVING 70 MPH, THE CHECK ENGINE AND REDUCE ENGINE POWER WARNING INDICATORS ILLUMINATED. THE CONTACT STATED THAT TURNING THE VEHICLE OFF AND BACK ON RESOLVED THE ISSUE. THE VEHICLE WAS TAKEN TO THE DEALER TO BE DIAGNOSED. THE MECHANIC WAS UNABLE TO DUPLICATE THE FAILURE OR PRODUCE A FAULT CODE. THE CONTACT STATED THAT THE FAILURE RECURRED THREE TIMES. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

NHTSA ODI #10930045

128,000 miles · Dec 7, 2015
Electrical SystemEngine

AT RANDOM TIMES WHILE DRIVING OR TURNING, NO MATTER THE WEATHER OUR TRUCK RANDOMLY DIES. SHIFTING INTO NEUTRAL SHE ALWAYS STARTS BACK UP RIGHT AWAY.HOWEVER DUE TO NOT KNOWING WHEN IT WILL HAPPEN, IT DOES ON CITY STREETS AT 25MPH AND HAD ON THE HIGHWAY AT 75MPH. WE ARE UNSURE STILL AT THE MOMENT THE CAUSE OR SOLUTION. WE HAVE HAD…

Read full complaint

AT RANDOM TIMES WHILE DRIVING OR TURNING, NO MATTER THE WEATHER OUR TRUCK RANDOMLY DIES. SHIFTING INTO NEUTRAL SHE ALWAYS STARTS BACK UP RIGHT AWAY.HOWEVER DUE TO NOT KNOWING WHEN IT WILL HAPPEN, IT DOES ON CITY STREETS AT 25MPH AND HAD ON THE HIGHWAY AT 75MPH. WE ARE UNSURE STILL AT THE MOMENT THE CAUSE OR SOLUTION. WE HAVE HAD 4 EPISODES OF THIS DANGEROUS PROBLEM STARTING THIS YEAR ONLY, 2015 .

NHTSA ODI #10808829

120,000 miles · Apr 10, 2015
Electrical SystemEngineEquipment

TL* THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 1500. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE STALLED WITHOUT WARNING. AFTER RESTARTING, THE VEHICLE RESUMED NORMAL OPERATION. THE FAILURE RECURRED NUMEROUS TIMES AT VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THE THROTTLE BODY WAS…

Read full complaint

TL* THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 1500. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE STALLED WITHOUT WARNING. AFTER RESTARTING, THE VEHICLE RESUMED NORMAL OPERATION. THE FAILURE RECURRED NUMEROUS TIMES AT VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THE THROTTLE BODY WAS FAULTY. THE CONTACT WAS ABLE TO REPAIR THE VEHICLE HIMSELF. RECENTLY, THE VEHICLE EXHIBITED HESITATION ON DIFFERENT OCCASIONS WHEN THE ACCELERATOR PEDAL WAS BEING APPLIED. THE VEHICLE WAS NOT REPAIRED. IN ADDITION, THE AIR CONDITIONER CIRCULATED WARM AIR WHENEVER ACTIVATED. THE BLOWER MOTOR CONNECTOR WAS NOT REPLACED; HOWEVER, THE MOTOR RESISTOR WAS REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

NHTSA ODI #10704998

260,000 miles · Jan 3, 2015
Engine

I RECEIVED A REDUCED ENGINE POWER MESSAGE IN THE MIDDLE OF THE HIGHWAY I WAS TRAVELING AT 70 MPH AND WHEN IT CAME ON I COULDN'T TRAVEL MORE THAN 35 MPH. I WAS AFRAID FOR MY AND MY PASSENGERS LIFE AS WE WAS ON THE VERGE OF BEING HIT. I HAD THE CHECK ENGINE CODES CHECKED AND RECEIVED 7 DIFFERENT CODES. *TR

NHTSA ODI #10669892

45,000 miles · Jan 1, 2015
EngineFuel/propulsion System

ON MULTIPLE OCCASIONS THE VEHICLE HAS LOST POWER AT HIGHWAY SPEED AND THE ENGINE DIES. AFTER A FEW ATTEMPTS THE ENGINE RESTARTS AND OPERATES NORMALLY FOR AN UNPREDICTABLE INTERVAL. THIS HAS HAPPENED AT LEAST 10 TIMES. THE AUTHORIZED DEALER AND OTHER MECHANIC SHOPS HAVE NOT BEEN ABLE TO DIAGNOSE THE REASON FOR THE POWER FAILUR…

Read full complaint

ON MULTIPLE OCCASIONS THE VEHICLE HAS LOST POWER AT HIGHWAY SPEED AND THE ENGINE DIES. AFTER A FEW ATTEMPTS THE ENGINE RESTARTS AND OPERATES NORMALLY FOR AN UNPREDICTABLE INTERVAL. THIS HAS HAPPENED AT LEAST 10 TIMES. THE AUTHORIZED DEALER AND OTHER MECHANIC SHOPS HAVE NOT BEEN ABLE TO DIAGNOSE THE REASON FOR THE POWER FAILURE AS THEY HAVE NOT BEEN ABLE TO CAUSE IT TO DUPLICATE FAILURE WHEN THEY HAVE IT. THIS SUDDEN UNEXPECTED CONDITION IS VERY DANGEROUS WHEN IT OCCURS AND RENDERS THE VEHICLE UNUSABLE FOR ANYTHING OTHER THAN SHORT USAGE. *JS

NHTSA ODI #10669476

142,116 miles · Oct 29, 2014
Engine

WHILE DRIVING DOWN BUSY ROAD, FOR NO REASON ENGINE POWER WAS SUDDENLY REDUCED WHICH COULD HAVE RESULTED IN A SERIOUS ACCIDENT. THIS HAS HAPPENED NUMEROUS TIMES. CALLED GM. NO RECALLS. THIS APPEARS TO BE AN INHERENT PROBLEM, NOT WEAR AND TEAR. THIS NEEDS TO BE ADDRESSED ASAP. *TR

NHTSA ODI #10651034

180,000 miles · Sep 1, 2014
Electrical SystemEngineSteering

REDUCED ENGINE POWER. THIS HAS BEEN OCCURRING OFF AND ON FOR ABOUT 9 MONTHS, HAVE TAKEN IT TO DEALER MULTIPLE TIMES AND REPLACED EVERYTHING THAT WAS SAID WOULD FIX THE PROBLEM. THE PROBLEM STILL OCCURS EVEN AFTER REPLACING: ACCELERATOR AND RECEIVER ON THROTTLE BODY AS WELL AS CHECKING WIRING HARNESS FOR ISSUES. ESSENTIALLY, …

Read full complaint

REDUCED ENGINE POWER. THIS HAS BEEN OCCURRING OFF AND ON FOR ABOUT 9 MONTHS, HAVE TAKEN IT TO DEALER MULTIPLE TIMES AND REPLACED EVERYTHING THAT WAS SAID WOULD FIX THE PROBLEM. THE PROBLEM STILL OCCURS EVEN AFTER REPLACING: ACCELERATOR AND RECEIVER ON THROTTLE BODY AS WELL AS CHECKING WIRING HARNESS FOR ISSUES. ESSENTIALLY, THE VEHICLE WILL LOSE THE FUNCTION OF THE ACCELERATOR WITHOUT WARNING AT ANY GIVEN TIME DURING THE USE OF THE VEHICLE. THE DEALER HAS TOLD ME THAT THEY DON'T HAVE ANY IDEA WHY IT STILL IS HAVING THIS ISSUE...THE OTHER DAY THE VEHICLE WAS BEING DRIVEN AND REDUCED ENGINE POWER MODE SET IN AND AT THE SAME TIME THE POWER STEERING WENT OUT. THOUGHT THE POWER STEERING GOING OUT AT THE SAME TIME WAS A ONE TIME DEAL BUT IT HAPPENED AGAIN THE VERY NEXT DAY. THE VEHICLE HAD THIS ISSUE ON THE HIGHWAY THE OTHER DAY AND NEARLY CAUSED AN ACCIDENT. IT IS SHOCKING THAT THERE ARE NOT THOUSANDS OF COMPLAINTS WITH THIS SAME ISSUE, IF YOU LOOK UP FORUMS ON THIS TOPIC THERE ARE OVER 200,000 THREADS ON THIS VERY ISSUES. THERE ARE THOUSANDS OF FORUM COMPLAINTS ABOUT REDUCED ENGINE POWER AND HOW PEOPLE HAVE SPENT $1000 PLUS AT THE DEALER AND THE ISSUE STILL PERSISTS. THE DRIVE BY WIRE FUNCTIONALITY INSTEAD OF USING A THROTTLE CABLE SEEMS TO BE HAVING ISSUES THAT EVEN GM DOESN'T HAVE AN ANSWER FOR. WOULD APPRECIATE ANY LOOKING INTO ON THIS SUBJECT. *TR

NHTSA ODI #10629811

148,591 miles · Jul 18, 2014
Electrical SystemEngineVisibility

I WAS TRAVELING AT APPROXIMATELY 55MPH ON A SMOOTH PAVED COUNTY ROAD WITH MY A/C ON. IT WAS ABOUT 78 DEGREES OUTSIDE. I HAD THE A/C RUNNING ABOUT 15 MINUTES BEFORE THE AIR JUST TURNED WARM. I TRIED 3 TIMES TURNING OFF THE A/C AND BACK ON, AND THE AIR FAILED TO COOL. I STOPPED THE TRUCK, TURNED THE A/C ON, GOT OUT AND LOOKED AT T…

Read full complaint

I WAS TRAVELING AT APPROXIMATELY 55MPH ON A SMOOTH PAVED COUNTY ROAD WITH MY A/C ON. IT WAS ABOUT 78 DEGREES OUTSIDE. I HAD THE A/C RUNNING ABOUT 15 MINUTES BEFORE THE AIR JUST TURNED WARM. I TRIED 3 TIMES TURNING OFF THE A/C AND BACK ON, AND THE AIR FAILED TO COOL. I STOPPED THE TRUCK, TURNED THE A/C ON, GOT OUT AND LOOKED AT THE A/C COMPRESSOR. THE A/C COMPRESSOR WAS NOT ENGAGING. I TOOK IT TO A MECHANIC AND THE DIAGNOSIS WAS UNDETERMINED. 2 OTHER MECHANICS FAILED TO FIND THE PROBLEM AS WELL. THE SYSTEM WAS CHARGED CORRECTLY, NOT LEAKING, AND EVEN REPLACED THE HVAC CONTROL MODULE AND THE PROBLEM WAS NOT FIXED. THERE ARE MANY OTHER CASES JUST LIKE MINE AND I WOULD LIKE GM TO LOOK INTO THE PROBLEM. I AM PROUD TO BE A GM CUSTOMER AND HAVE ALWAYS LIKED MY GM PICKUPS. *TR

NHTSA ODI #10614631

119,856 miles · May 13, 2014
EngineFuel/propulsion System

THE BOLTS ARE BROKEN OFF IN THE MANIFOLD, AFTER CHECKING YOU-TUBE I FOUND THIS IS A PROBLEM THE GM HAS CHOSEN TO IGNORE. *TR

NHTSA ODI #10588040

Official recalls

0

No recalls in this snapshot.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

EA11001 · Brake Line Corrosion Failure

Opened Jan 5, 2011 · Closed Apr 8, 2015

Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings

On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and 3500 series pick-up trucks; 2000-2006 Chevrolet Suburban, Chevrolet Tahoe and GMC Yukon sport utility vehicles; and 2002-2006 Cadillac Escalade and Chevrolet Avalanche sport-utility vehicles.General Motors produced a total of approximately 10,427,062 GMT800 vehicles for sales in the United States, including almost 5 million that were sold in salt states.Although there are over 60 different brake pipe routing configuration used in GMT800 vehicles, with the exception of the rear crossover pipes in MY 200x-2007 vehicles that changed from rear disc to drum brakes, all of the vehicles use brake pipes from the same supplier with a common double-wall, brazed steel pipe design with a combination of hot dip Zinc-Aluminum corrosion protection coating and Aluminum paint outer layer known in the industry as AlGal (ASTM-B750). ODI analysis of field data regarding GMT800 vehicles identified a total of 3,645 complaints of brake pipe corrosion failures, including 107 alleging crashes, and 40 injuries.Though only 20% of total GMT800 production, due to age and region the subject vehicles account for a disproportionate share of the failure experience; with 2,702 of the complaints (75%), 88 of the crashes (82%) and 20 of the injuries (50%) reported in those vehicles.Analysis of the complaints showed strong correlations to vehicle age and region.For vehicles with less than 8 years of service, the complaint rates were minimal for all regions.In the salt states the failure rates begin to climb as the vehicles advance in age, particularly in the Northeast corner of the United States.The complaint rates in the salt states go from less than 0.1 incident per thousand vehicles (IPTV) at 7 years in service to over 1.0 IPTV after the 12th year of service for the subject pickup trucks and utility vehicles.Most of the failures reported to ODI occurred in vehicles with more than 10 years in service.ODI?s investigation did not identify any specific defect conditions that were causing or contributing to the brake pipe failures.Nor did the analysis isolate the problem to any subject vehicle sub-populations when analyzed by vehicle type or production range.The investigation found that vehicles experiencing brake pipe corrosion failures were likely to have general patterns of excessive corrosion on the majority of the brake pipe assembly and appear to be occurring due to expected wear out for the brake pipe coating material used in the subject vehicles and the environmental conditions in severe corrosion states.A safety-related defect has not been identified at this time.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor t

Additional source detail variants (2)

Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings

On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and 3500 series pick-up trucks; 2000-2006 Chevrolet Suburban, Chevrolet Tahoe and GMC Yukon sport utility vehicles; and 2002-2006 Cadillac Escalade and Chevrolet Avalanche sport-utility vehicles.General Motors produced a total of approximately 10,427,062 GMT800 vehicles for sales in the United States, including almost 5 million that were sold in salt states.Although there are over 60 different brake pipe routing configuration used in GMT800 vehicles, with the exception of the rear crossover pipes in MY 200x-2007 vehicles that changed from rear disc to drum brakes, all of the vehicles use brake pipes from the same supplier with a common double-wall, brazed steel pipe design with a combination of hot dip Zinc-Aluminum corrosion protection coating and Aluminum paint outer layer known in the industry as AlGal (ASTM-B750). ODI analysis of field data regarding GMT800 vehicles identified a total of 3,645 complaints of brake pipe corrosion failures, including 107 alleging crashes, and 40 injuries.Though only 20% of total GMT800 production, due to age and region the subject vehicles account for a disproportionate share of the failure experience; with 2,702 of the complaints (75%), 88 of the crashes (82%) and 20 of the injuries (50%) reported in those vehicles.Analysis of the complaints showed strong correlations to vehicle age and region.For vehicles with less than 8 years of service, the complaint rates were minimal for all regions.In the salt states the failure rates begin to climb as the vehicles advance in age, particularly in the Northeast corner of the United States.The complaint rates in the salt states go from less than 0.1 incident per thousand vehicles (IPTV) at 7 years in service to over 1.0 IPTV after the 12th year of service for the subject pickup trucks and utility vehicles.Most of the failures reported to ODI occurred in vehicles with more than 10 years in service.ODI?s investigation did not identify any specific defect conditions that were causing or contributing to the brake pipe failures.Nor did the analysis isolate the problem to any subject vehicle sub-populations when analyzed by vehicle type or production range.The investigation found that vehicles experiencing brake pipe corrosion failures were likely to have general patterns of excessive corrosion on the majority of the brake pipe assembly and appear to be occurring due to expected wear out for the brake pipe coating material used in the subject vehicles and the environmental conditions in severe corrosion states.A safety-related defect has not been identified at this time.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor t

Service Brakes, Hydraulic

On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and 3500 series pick-up trucks; 2000-2006 Chevrolet Suburban, Chevrolet Tahoe and GMC Yukon sport utility vehicles; and 2002-2006 Cadillac Escalade and Chevrolet Avalanche sport-utility vehicles.General Motors produced a total of approximately 10,427,062 GMT800 vehicles for sales in the United States, including almost 5 million that were sold in salt states.Although there are over 60 different brake pipe routing configuration used in GMT800 vehicles, with the exception of the rear crossover pipes in MY 200x-2007 vehicles that changed from rear disc to drum brakes, all of the vehicles use brake pipes from the same supplier with a common double-wall, brazed steel pipe design with a combination of hot dip Zinc-Aluminum corrosion protection coating and Aluminum paint outer layer known in the industry as AlGal (ASTM-B750). ODI analysis of field data regarding GMT800 vehicles identified a total of 3,645 complaints of brake pipe corrosion failures, including 107 alleging crashes, and 40 injuries.Though only 20% of total GMT800 production, due to age and region the subject vehicles account for a disproportionate share of the failure experience; with 2,702 of the complaints (75%), 88 of the crashes (82%) and 20 of the injuries (50%) reported in those vehicles.Analysis of the complaints showed strong correlations to vehicle age and region.For vehicles with less than 8 years of service, the complaint rates were minimal for all regions.In the salt states the failure rates begin to climb as the vehicles advance in age, particularly in the Northeast corner of the United States.The complaint rates in the salt states go from less than 0.1 incident per thousand vehicles (IPTV) at 7 years in service to over 1.0 IPTV after the 12th year of service for the subject pickup trucks and utility vehicles.Most of the failures reported to ODI occurred in vehicles with more than 10 years in service.ODI?s investigation did not identify any specific defect conditions that were causing or contributing to the brake pipe failures.Nor did the analysis isolate the problem to any subject vehicle sub-populations when analyzed by vehicle type or production range.The investigation found that vehicles experiencing brake pipe corrosion failures were likely to have general patterns of excessive corrosion on the majority of the brake pipe assembly and appear to be occurring due to expected wear out for the brake pipe coating material used in the subject vehicles and the environmental conditions in severe corrosion states.A safety-related defect has not been identified at this time.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor t

EA04011 · Parking Brake Failure

Opened Apr 9, 2004 · Closed May 10, 2005

Status: closed (inferred from source dates) · Parking Brake; Parking Brake:conventional; Parking Brake:conventional:mechanical; Parking Brake:conventional:mechanical:linkage And Cable

IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.

Additional source detail variants (4)

Parking Brake:conventional

IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.

Parking Brake:conventional:mechanical

IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.

Parking Brake:conventional:mechanical:linkage And Cable

IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.

Parking Brake

IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.

PE03057 · Parking Brake Failure

Opened Dec 8, 2003 · Closed Apr 9, 2004

Status: closed (inferred from source dates) · Parking Brake

ODI OPENED PE03-057 TO ASSESS PARKING BRAKE INEFFECTIVENESS IN THE SUBJECT VEHICLES.THESE VEHICLES ARE EQUIPPED WITH FOUR WHEEL DISC BRAKES THAT INCORPORATE A SINGLE-SHOE DRUM-IN-HAT PARKING BRAKE INDEPENDENT OF THE SERVICE BRAKES.COMPLAINT AND WARRANTY DATA INDICATE THAT THE PARKING BRAKE LININGS TEND TO WEAR OUT EARLY IN THE LIFE OF THE VEHICLE (AT AN AVERAGE OF 24 MONTHS IN SERVICE), REDUCING THE PARKING BRAKE SYSTEM'S TORQUE BELOW THAT NEEDED TO IMMOBILIZE THE VEHICLE.GM HAS ATTRIBUTED THIS ACCELERATED WEAR TO FOREIGN MATERIAL INTRUSION AND A FAILURE OF THE BRAKE SHOE TO PROPERLY SELF-CENTER WITHIN ITS BRAKE DRUM.EFFECTIVE WITH THE START OF MY 2003 PRODUCTION, A NEWER REDUCED FORCE HOLD-DOWN CLIP WAS INTRODUCED TO FACILITATE BRAKE SHOE DISENGAGEMENT FROM THE DRUM SURFACE.THIS PART IS ALSO AVAILABLE AT THE SERVICE LEVEL FOR THE MY 1999-2002 VEHICLES.GM HAS INDICATED THAT THE PAKING BRAKE IS INTENDED TO OPERATE IN CONJUNCTION WITH THE TRANSMISSION TO IMMOBILZE PARKED VEHICLES, AND THAT IN MANY CASES, ACCELERATED PARKING BRAKE LINING WEAR IS CAUSED BY ROUGH USE, VEHICLE MODIFICATIONS, AND DRIVING WITH THE PARKING ENGAGED. ODI HAS UPGRADED THE PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING PARKING BRAKE USAGE FACTORS AND THE CIRCUMSTANCES SURROUNDING THE SEVENTEEN REPORTED VEHICLE CRASHES.