← New search

2003 Chevrolet Silverado 1500

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2003 Chevrolet Silverado 1500 do not stand out strongly from the model-year median of 525.

About this comparison →

When problems were reported

Mileage at the reported incident

726 reports with mileage · 79 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Service Brakes. Review the 273 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 195 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Service Brakes, Hydraulic. Review the 151 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

26 crash reports7 fire reports8 injury reports

Electrical System complaints

195 reports
Clear category filter
51,000 miles · Dec 21, 2006
Electrical System

SPEEDOMETER ON 2003 SILVERADO FAILED WHILE DRIVING TO WORK. GLANCED DOWN AT THE INSTRUMENT PANEL AND NOTICED THAT I WAS TRAVELING 120 MPH IN A SCHOOL ZONE!!!!....OBVIOUSLY AN ERROR. THE SPEEDO NEEDLE IS GITTERY AND THE INSTRUMENT PANEL FLICKERS. I'M GRAVELY CONCERNED THAT I NO LONGER KNOW HOW FAST/SLOW I'M DRIVING. THIS IS A…

Read full complaint

SPEEDOMETER ON 2003 SILVERADO FAILED WHILE DRIVING TO WORK. GLANCED DOWN AT THE INSTRUMENT PANEL AND NOTICED THAT I WAS TRAVELING 120 MPH IN A SCHOOL ZONE!!!!....OBVIOUSLY AN ERROR. THE SPEEDO NEEDLE IS GITTERY AND THE INSTRUMENT PANEL FLICKERS. I'M GRAVELY CONCERNED THAT I NO LONGER KNOW HOW FAST/SLOW I'M DRIVING. THIS IS A SAFETY ISSUE AND MUST BE ADDRESSED/RESOLVED. *NM

NHTSA ODI #10176728

43,000 miles · Dec 14, 2006
Electrical System

THE SPEEDOMETER ON MY 2003 CHEVY SILVERADO HAS QUIT WORKING PROPERLY. THE SPEEDOMETER NEEDLE IS STUCK ON 120 MPH. *NM

NHTSA ODI #10176199

Mileage unknown · Nov 30, 2006
Electrical System

2003 CHEVY SILVERADO, 56,8000 MILES. SPEEDOMETER WAS TACKING AT 50 MPH. IS NOW WORKING BACKWARDS FROM 140 MPH GOING ONLY AS FAR AS 80 MPH. CALLED DEALER, SAID NO RECALL. SAID IT WOULD COST $600 TO REPLACE "BUNDLE". JUST WENT THROUGH MANY OF THE SAME COMPLAINTS AND I BELIEVE GM SHOULD STEP UP! *NM

NHTSA ODI #10174809

47,750 miles · Nov 29, 2006
Electrical System

THE SPEEDOMETER ON MY 03 CHEVROLET SILVERADO RANDOMLY STICKS. RIGHT NOW IT IS STUCK AT 80 MPH AND THE TRUCK IS STATIONARY AND IS NOT EVEN STARTED. THIS CAUSES MY SPEED TO DISPLAY WRONG AND I MUST USE SIMPLE ARITHMETIC TO FIGURE OUT HOW FAST I'M GOING. HOWEVER, AT THIS POINT, I CAN ONLY USE THAT ARITHMETIC TO DETERMINE UP TO 4…

Read full complaint

THE SPEEDOMETER ON MY 03 CHEVROLET SILVERADO RANDOMLY STICKS. RIGHT NOW IT IS STUCK AT 80 MPH AND THE TRUCK IS STATIONARY AND IS NOT EVEN STARTED. THIS CAUSES MY SPEED TO DISPLAY WRONG AND I MUST USE SIMPLE ARITHMETIC TO FIGURE OUT HOW FAST I'M GOING. HOWEVER, AT THIS POINT, I CAN ONLY USE THAT ARITHMETIC TO DETERMINE UP TO 40 MPH AS MY SPEEDOMETER ONLY MEASURES UP TO 120. AFTER THAT, I DON'T KNOW HOW FAST I'M GOING. THIS IS THE FOURTH TIME THIS HAS HAPPENED -- IT SEEMS TO EVENTUALLY FIX ITSELF ONLY TO HAPPEN AGAIN. IN CHECKING INTERNET CHAT ROOMS, THIS SEEMS TO BE A COMMON OCCURRENCE FOR CHEVY/GM VEHICLES IN THAT PRODUCTION YEAR. WHY HAS THIS BEEN ALLOWED TO CONTINUE WITHOUT A RECALL? MY CAR IS DUE FOR INSPECTION. I CAN ONLY HOPE THAT I GET THE SPEEDOMETER BACK TO 0 TO HAVE THIS INSPECTION DONE AS I DON'T HAVE TIME TO GET THE REPAIR DONE NOR DO I FEEL I SHOULD HAVE TO SPEND A DIME ON SOMETHING THAT IS OBVIOUSLY A MANUFACTURING PROBLEM. PLEASE DO YOUR JOB AND ISSUE A RECALL. OTHERWISE, IT'S BACK TO BUYING FOREIGN VEHICLES! *NM

NHTSA ODI #10174652

45,617 miles · Nov 24, 2006
Electrical System

ERRATIC AND INACCURATE SPEEDOMETER READINGS ON 2003 CHEVROLET SILVERADO 1500. *JB

NHTSA ODI #10174176

50,007 miles · Nov 14, 2006
Electrical System

2003 CHEVROLET Z-71 EXT. CAB, 4.8 LITER, AUTO TRANS. LS MODEL. JUST TURNED 50,000 MILES ON 11-13-2006 AND SPEEDOMETER IS ERRATIC AND INACCURATE! UNACCEPTABLE AND UNSAFE. I HAVE READ OVER 200 OF THE SAME CASES WITH THE SAME TYPE OF VEHICLE. SPEEDOMETER READS 100 WHEN TRAVELING AT 60 MPH. WHEN IN PARK SPEEDOMETER READS OVER 3…

Read full complaint

2003 CHEVROLET Z-71 EXT. CAB, 4.8 LITER, AUTO TRANS. LS MODEL. JUST TURNED 50,000 MILES ON 11-13-2006 AND SPEEDOMETER IS ERRATIC AND INACCURATE! UNACCEPTABLE AND UNSAFE. I HAVE READ OVER 200 OF THE SAME CASES WITH THE SAME TYPE OF VEHICLE. SPEEDOMETER READS 100 WHEN TRAVELING AT 60 MPH. WHEN IN PARK SPEEDOMETER READS OVER 35 MPH. THIS SAFETY ISSUE NEEDS TO BE RECALLED! *NM

NHTSA ODI #10173448

56,620 miles · Nov 12, 2006
Electrical System

2003 CHEVROLET SILVERADO SPEEDOMETER STICKS AT SPEEDS OVER 40 MPH. WHEN THE VEHICLE SLOWS DOWN, THE SPEEDOMETER DEVELOPS AN "OFFSET ZERO." I REALIZED THE PROBLEM HAD OCCURRED SLOWING TO A STOP LIGHT. THE MOST DIRE CONSEQUENCE WAS SLOWING TO TURN AFTER REALIZING THE PROBLEM HAD OCCURRED AND HAVING NO RELIABLE GAUGE AS TO MY T…

Read full complaint

2003 CHEVROLET SILVERADO SPEEDOMETER STICKS AT SPEEDS OVER 40 MPH. WHEN THE VEHICLE SLOWS DOWN, THE SPEEDOMETER DEVELOPS AN "OFFSET ZERO." I REALIZED THE PROBLEM HAD OCCURRED SLOWING TO A STOP LIGHT. THE MOST DIRE CONSEQUENCE WAS SLOWING TO TURN AFTER REALIZING THE PROBLEM HAD OCCURRED AND HAVING NO RELIABLE GAUGE AS TO MY TURNING SPEED. I NEVER REALIZED HOW MUCH I REFER TO MY SPEEDOMETER WHILE SLOWING UNTIL I ALMOST MISSED MY TURN ENTIRELY BECAUSE OF THIS FAILURE. I HAVE SINCE HAD THE DIGITAL INSTRUMENT PANEL CLUSTER REPAIRED AT A COST OF $200, BY A NON-GM TECHNICIAN. *JB

NHTSA ODI #10173297

38,000 miles · Oct 19, 2006
Electrical System

I WAS DRIVING DOWN THE ROAD AND STARTED SLOWING DOWN. WHILE I WAS SLOWING DOWN MY SPEEDOMETER WOULDN'T SHOW MY SPEED IT JUST STUCK AT 60 MPH. WHEN I WENT TO SPEED UP THE SPEEDOMETER WOULD SPEED UP ALSO SPEEDOMETER WOULD READ 65 WHEN REALLY I WAS ONLY GOING 5 MPH. PULLED THE TRUCK OVER AND SHUT THE ENGINE DOWN THE RESTARTED IT UN…

Read full complaint

I WAS DRIVING DOWN THE ROAD AND STARTED SLOWING DOWN. WHILE I WAS SLOWING DOWN MY SPEEDOMETER WOULDN'T SHOW MY SPEED IT JUST STUCK AT 60 MPH. WHEN I WENT TO SPEED UP THE SPEEDOMETER WOULD SPEED UP ALSO SPEEDOMETER WOULD READ 65 WHEN REALLY I WAS ONLY GOING 5 MPH. PULLED THE TRUCK OVER AND SHUT THE ENGINE DOWN THE RESTARTED IT UNTIL THE SPEEDOMETER WAS AT 0 MPH. THEN PULLED BACK ON THE HWY, WHILE SPEEDING UP TO THE TRAFFIC THE SPEEDOMETER WOULD READ 0 MPH. TOOK THE TRUCK TO THE DEALER I BOUGHT IT FROM AND THEY TOLD ME THAT THEY WERE HAVING PROBLEMS WHIT OTHER TRUCKS LIKE MINE. THE MECHANIC HOOKED UP A TESTER AND TOLD ME HE DIDN'T SEE ANY PROBLEM. AFTER LEAVING THE DEALERSHIP THE SPEEDOMETER WORKED PERFECTLY, FOR ABOUT 3 DAYS NOW SINCE THEN IT IS A GUESSING GAME WEATHER OR NOT THE SPEEDOMETER IS TELLING ME THE RIGHT SPEED OR IF IT IS WRONG. SO I HAVE BEEN USING MY GPS FOR THE PAST FEW MOTHS. I HAVE TALKED TO OTHER PEOPLE ABOUT THIS PROBLEM AND ALSO TO CHEVY. CHEVY HAS QUOTED ME ANYWHERE FROM 600-1000 DOLLARS TO FIX THIS PROBLEM. AND OTHERS I HAVE TALKED TO HAVE STATED THAT IT HAS COST THEM ABOUT THAT MUCH ALSO.

NHTSA ODI #10171296

36,000 miles · Oct 12, 2006
Electrical SystemVehicle Speed Control

SPEEDOMETER GAUGE IS NOT READING THE CORRECT SPEED AND JUMPS ALL OVER THE PLACE. THIS CAN CAUSE ME TO HAVE A ACCIDENT BECAUSE I AM UNABLE TO TELL WHAT SPEED I AM TRAVELING. *JB

NHTSA ODI #10170703

48,000 miles · Aug 23, 2006
Electrical SystemPower TrainSuspension

DT*: THE CONTACT STATED WHILE DRIVING 10 MPH ON DIRT ROAD AND ASPHALT, THE FRONT END OF THE VEHICLE SHOOK AND PULLED TO THE LEFT. THIS WAS ACCOMPANIED BY A CLUNKING SOUND FROM UNDER THE FRONT END. DURING THIS INCIDENT, THE INSTRUMENT PANEL DISPLAYED INCORRECT INFORMATION ON EVERY GAUGE. THE TRANSMISSION WOULD NOT SHIFT PROPER…

Read full complaint

DT*: THE CONTACT STATED WHILE DRIVING 10 MPH ON DIRT ROAD AND ASPHALT, THE FRONT END OF THE VEHICLE SHOOK AND PULLED TO THE LEFT. THIS WAS ACCOMPANIED BY A CLUNKING SOUND FROM UNDER THE FRONT END. DURING THIS INCIDENT, THE INSTRUMENT PANEL DISPLAYED INCORRECT INFORMATION ON EVERY GAUGE. THE TRANSMISSION WOULD NOT SHIFT PROPERLY,EITHER. THE VEHICLE BECAME LOCKED IN SECOND GEAR, AND WAS UNABLE TO BE SHIFTED OUT. FINALLY, THE BRAKES ON THE VEHICLE WERE SPONGY, CAUSING AN EXTENDED STOPPING DISTANCE FROM ANY SPEED. THE VEHICLE WAS TAKEN TO A SERVICE DEALER WHERE IT AWAITS A DIAGNOSIS.

NHTSA ODI #10166304

Official recalls

0

No recalls in this snapshot.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

EA11001 · Brake Line Corrosion Failure

Opened Jan 5, 2011 · Closed Apr 8, 2015

Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings

On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and 3500 series pick-up trucks; 2000-2006 Chevrolet Suburban, Chevrolet Tahoe and GMC Yukon sport utility vehicles; and 2002-2006 Cadillac Escalade and Chevrolet Avalanche sport-utility vehicles.General Motors produced a total of approximately 10,427,062 GMT800 vehicles for sales in the United States, including almost 5 million that were sold in salt states.Although there are over 60 different brake pipe routing configuration used in GMT800 vehicles, with the exception of the rear crossover pipes in MY 200x-2007 vehicles that changed from rear disc to drum brakes, all of the vehicles use brake pipes from the same supplier with a common double-wall, brazed steel pipe design with a combination of hot dip Zinc-Aluminum corrosion protection coating and Aluminum paint outer layer known in the industry as AlGal (ASTM-B750). ODI analysis of field data regarding GMT800 vehicles identified a total of 3,645 complaints of brake pipe corrosion failures, including 107 alleging crashes, and 40 injuries.Though only 20% of total GMT800 production, due to age and region the subject vehicles account for a disproportionate share of the failure experience; with 2,702 of the complaints (75%), 88 of the crashes (82%) and 20 of the injuries (50%) reported in those vehicles.Analysis of the complaints showed strong correlations to vehicle age and region.For vehicles with less than 8 years of service, the complaint rates were minimal for all regions.In the salt states the failure rates begin to climb as the vehicles advance in age, particularly in the Northeast corner of the United States.The complaint rates in the salt states go from less than 0.1 incident per thousand vehicles (IPTV) at 7 years in service to over 1.0 IPTV after the 12th year of service for the subject pickup trucks and utility vehicles.Most of the failures reported to ODI occurred in vehicles with more than 10 years in service.ODI?s investigation did not identify any specific defect conditions that were causing or contributing to the brake pipe failures.Nor did the analysis isolate the problem to any subject vehicle sub-populations when analyzed by vehicle type or production range.The investigation found that vehicles experiencing brake pipe corrosion failures were likely to have general patterns of excessive corrosion on the majority of the brake pipe assembly and appear to be occurring due to expected wear out for the brake pipe coating material used in the subject vehicles and the environmental conditions in severe corrosion states.A safety-related defect has not been identified at this time.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor t

Additional source detail variants (2)

Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings

On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and 3500 series pick-up trucks; 2000-2006 Chevrolet Suburban, Chevrolet Tahoe and GMC Yukon sport utility vehicles; and 2002-2006 Cadillac Escalade and Chevrolet Avalanche sport-utility vehicles.General Motors produced a total of approximately 10,427,062 GMT800 vehicles for sales in the United States, including almost 5 million that were sold in salt states.Although there are over 60 different brake pipe routing configuration used in GMT800 vehicles, with the exception of the rear crossover pipes in MY 200x-2007 vehicles that changed from rear disc to drum brakes, all of the vehicles use brake pipes from the same supplier with a common double-wall, brazed steel pipe design with a combination of hot dip Zinc-Aluminum corrosion protection coating and Aluminum paint outer layer known in the industry as AlGal (ASTM-B750). ODI analysis of field data regarding GMT800 vehicles identified a total of 3,645 complaints of brake pipe corrosion failures, including 107 alleging crashes, and 40 injuries.Though only 20% of total GMT800 production, due to age and region the subject vehicles account for a disproportionate share of the failure experience; with 2,702 of the complaints (75%), 88 of the crashes (82%) and 20 of the injuries (50%) reported in those vehicles.Analysis of the complaints showed strong correlations to vehicle age and region.For vehicles with less than 8 years of service, the complaint rates were minimal for all regions.In the salt states the failure rates begin to climb as the vehicles advance in age, particularly in the Northeast corner of the United States.The complaint rates in the salt states go from less than 0.1 incident per thousand vehicles (IPTV) at 7 years in service to over 1.0 IPTV after the 12th year of service for the subject pickup trucks and utility vehicles.Most of the failures reported to ODI occurred in vehicles with more than 10 years in service.ODI?s investigation did not identify any specific defect conditions that were causing or contributing to the brake pipe failures.Nor did the analysis isolate the problem to any subject vehicle sub-populations when analyzed by vehicle type or production range.The investigation found that vehicles experiencing brake pipe corrosion failures were likely to have general patterns of excessive corrosion on the majority of the brake pipe assembly and appear to be occurring due to expected wear out for the brake pipe coating material used in the subject vehicles and the environmental conditions in severe corrosion states.A safety-related defect has not been identified at this time.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor t

Service Brakes, Hydraulic

On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and 3500 series pick-up trucks; 2000-2006 Chevrolet Suburban, Chevrolet Tahoe and GMC Yukon sport utility vehicles; and 2002-2006 Cadillac Escalade and Chevrolet Avalanche sport-utility vehicles.General Motors produced a total of approximately 10,427,062 GMT800 vehicles for sales in the United States, including almost 5 million that were sold in salt states.Although there are over 60 different brake pipe routing configuration used in GMT800 vehicles, with the exception of the rear crossover pipes in MY 200x-2007 vehicles that changed from rear disc to drum brakes, all of the vehicles use brake pipes from the same supplier with a common double-wall, brazed steel pipe design with a combination of hot dip Zinc-Aluminum corrosion protection coating and Aluminum paint outer layer known in the industry as AlGal (ASTM-B750). ODI analysis of field data regarding GMT800 vehicles identified a total of 3,645 complaints of brake pipe corrosion failures, including 107 alleging crashes, and 40 injuries.Though only 20% of total GMT800 production, due to age and region the subject vehicles account for a disproportionate share of the failure experience; with 2,702 of the complaints (75%), 88 of the crashes (82%) and 20 of the injuries (50%) reported in those vehicles.Analysis of the complaints showed strong correlations to vehicle age and region.For vehicles with less than 8 years of service, the complaint rates were minimal for all regions.In the salt states the failure rates begin to climb as the vehicles advance in age, particularly in the Northeast corner of the United States.The complaint rates in the salt states go from less than 0.1 incident per thousand vehicles (IPTV) at 7 years in service to over 1.0 IPTV after the 12th year of service for the subject pickup trucks and utility vehicles.Most of the failures reported to ODI occurred in vehicles with more than 10 years in service.ODI?s investigation did not identify any specific defect conditions that were causing or contributing to the brake pipe failures.Nor did the analysis isolate the problem to any subject vehicle sub-populations when analyzed by vehicle type or production range.The investigation found that vehicles experiencing brake pipe corrosion failures were likely to have general patterns of excessive corrosion on the majority of the brake pipe assembly and appear to be occurring due to expected wear out for the brake pipe coating material used in the subject vehicles and the environmental conditions in severe corrosion states.A safety-related defect has not been identified at this time.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor t

EA04011 · Parking Brake Failure

Opened Apr 9, 2004 · Closed May 10, 2005

Status: closed (inferred from source dates) · Parking Brake; Parking Brake:conventional; Parking Brake:conventional:mechanical; Parking Brake:conventional:mechanical:linkage And Cable

IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.

Additional source detail variants (4)

Parking Brake:conventional

IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.

Parking Brake:conventional:mechanical

IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.

Parking Brake:conventional:mechanical:linkage And Cable

IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.

Parking Brake

IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.

PE03057 · Parking Brake Failure

Opened Dec 8, 2003 · Closed Apr 9, 2004

Status: closed (inferred from source dates) · Parking Brake

ODI OPENED PE03-057 TO ASSESS PARKING BRAKE INEFFECTIVENESS IN THE SUBJECT VEHICLES.THESE VEHICLES ARE EQUIPPED WITH FOUR WHEEL DISC BRAKES THAT INCORPORATE A SINGLE-SHOE DRUM-IN-HAT PARKING BRAKE INDEPENDENT OF THE SERVICE BRAKES.COMPLAINT AND WARRANTY DATA INDICATE THAT THE PARKING BRAKE LININGS TEND TO WEAR OUT EARLY IN THE LIFE OF THE VEHICLE (AT AN AVERAGE OF 24 MONTHS IN SERVICE), REDUCING THE PARKING BRAKE SYSTEM'S TORQUE BELOW THAT NEEDED TO IMMOBILIZE THE VEHICLE.GM HAS ATTRIBUTED THIS ACCELERATED WEAR TO FOREIGN MATERIAL INTRUSION AND A FAILURE OF THE BRAKE SHOE TO PROPERLY SELF-CENTER WITHIN ITS BRAKE DRUM.EFFECTIVE WITH THE START OF MY 2003 PRODUCTION, A NEWER REDUCED FORCE HOLD-DOWN CLIP WAS INTRODUCED TO FACILITATE BRAKE SHOE DISENGAGEMENT FROM THE DRUM SURFACE.THIS PART IS ALSO AVAILABLE AT THE SERVICE LEVEL FOR THE MY 1999-2002 VEHICLES.GM HAS INDICATED THAT THE PAKING BRAKE IS INTENDED TO OPERATE IN CONJUNCTION WITH THE TRANSMISSION TO IMMOBILZE PARKED VEHICLES, AND THAT IN MANY CASES, ACCELERATED PARKING BRAKE LINING WEAR IS CAUSED BY ROUGH USE, VEHICLE MODIFICATIONS, AND DRIVING WITH THE PARKING ENGAGED. ODI HAS UPGRADED THE PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING PARKING BRAKE USAGE FACTORS AND THE CIRCUMSTANCES SURROUNDING THE SEVENTEEN REPORTED VEHICLE CRASHES.