IllustrationPOWER WINDOW CABLE ON A TWO YEAR OLD VEHICLE SNAPPED. *JB
2002 Chevrolet Silverado 1500
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2002 Chevrolet Silverado 1500 do not stand out strongly from the model-year median of 525.
About this comparison →How this year compares
Owner complaints by model year
Compare all Silverado 1500 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
340–25K
4925–50K
7950–75K
10275–100K
124100–150K
55150K+
443 reports with mileage · 66 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes. Review the 184 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 164 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
45 crash reports5 fire reports15 injury reports
What owners actually said
509 reportsMY SON'S 2002 CHEVROLET EXTENDED CAB PU TRUCK WAS STRUCK IN THE DRIVERS SIDE DOOR, FORCED OFF THE ROAD, WENT HEAD FIRST THROUGH AN IRON 6' FENCE, DOWN A 7' EMBANKMENT AND STRUCK A STONE PILLAR HEAD ON AND HIS AIR BAD DID NOT DEPLOY. *NM
VEHICLE HAD GRINDING NOISE FROM REAR WHEELS AND LOSS OF POWER. REAR BRAKES FAILED WITH 9, 975 MILES ON VEHICLE. DEALER FOUND RIGHT REAR BRAKE CALIPER RUSTED SOLID AND NOT OPERATING, CAUSING INNER RIGHT DISK BRAKE PAD TO WEAR OUT PREMATURELY. WAS ADVISED THAT THIS WAS A RESULT OF THE VEHICLE NOT BEING USED ENOUGH, ALLOWING COMPO…
Read full complaint
VEHICLE HAD GRINDING NOISE FROM REAR WHEELS AND LOSS OF POWER. REAR BRAKES FAILED WITH 9, 975 MILES ON VEHICLE. DEALER FOUND RIGHT REAR BRAKE CALIPER RUSTED SOLID AND NOT OPERATING, CAUSING INNER RIGHT DISK BRAKE PAD TO WEAR OUT PREMATURELY. WAS ADVISED THAT THIS WAS A RESULT OF THE VEHICLE NOT BEING USED ENOUGH, ALLOWING COMPONENTS INSIDE THE CALIPER TO RUST. DEALER REBUILT RIGHT REAR CALIPERS, TURNED DOWN BOTH EXCESSIVELY RUSTED REAR ROTORS AND REPLACED REAR DISC BRAKE PADS.
CHEVY TRUCK BEGAN A VIBRATION AND CHATTERING IN BRAKE PEDAL AT LOW SPEED . *BF THE ABS BRAKING SYSTEM WHEEL HAD LOCKED UP. *SC
1. NORMAL USE OF THE VEHICLE. 2.TRANSMISSION FAILED, LEAVING ME STRANDED. 3. TRANSMISSION WAS REBUILT AT MY COST. THERE ARE MANY PARTS JUST LIKE MINE AT THE AAMCO TRANSMISSION SHOP IN LAKE CHARLES, LA. *AK
WHILE TRAVELING UP I-65 NORTH ON AUGUST 17TH, 2004, I EXPERIENCED A TREAD SEPERATION ON MY TIRE. I WAS ABLE TO PULL OVER JUST BEFORE THE TIRE WAS ABLE TO SHRED TO PIECES.*AK
THE CONSUMER TOOK THE VEHICLE THROUGH INSPECTION AND IT WAS DETERMINED THAT THE ROTORS HAD RUSTED. THE ROTORS WERE TURNED INSTEAD OF BEING REPLACED BY THE DEALER. THE CONSUMER WAS DRIVING THE VEHICLE APPROXIMATELY 3 MONTHS LATER AND THE VEHICLE WAS HARD TO STOP WHEN THE BRAKES WERE APPLIED. THE CONSUMER TOOK THE VEHICLE TO TH…
Read full complaint
THE CONSUMER TOOK THE VEHICLE THROUGH INSPECTION AND IT WAS DETERMINED THAT THE ROTORS HAD RUSTED. THE ROTORS WERE TURNED INSTEAD OF BEING REPLACED BY THE DEALER. THE CONSUMER WAS DRIVING THE VEHICLE APPROXIMATELY 3 MONTHS LATER AND THE VEHICLE WAS HARD TO STOP WHEN THE BRAKES WERE APPLIED. THE CONSUMER TOOK THE VEHICLE TO THE DEALER AGAIN AND IT WAS DISCOVERED THAT THE BEARING AND HUB ASSEMBLY WAS DEFECTIVE AND IT WAS REPLACED ON THE LEFT SIDE. *JB
WHEN THE CONSUMER APPLIED THE BRAKE WHILE DRIVING 3 MPH TO PARK THE VEHICLE THE ABS ACTIVATED WHICH RESULTED IN EXTENDED STOPPINGDISTANCE. THE VEHICLE HIT A BARRIER WALL WHICH CAUSED $85 IN DAMAGE. *AK *NM
WHILE DRIVING TRANSMISSION MADE A NOISE, SLIPPED,AND THEN LOCKED. WHEN THIS OCCURRED VEHICLE STOPPED ACCELERATING. VEHICLE WAS TOWED TO A DEALERSHIP, WHO REPLACED THE SUN SEAL AND PINS THAT SHEARED OFF. THE FAILURE RECURRED 3 TIMES IN WHICH THE SAME PARTS WERE REPLACED. THE CAUSE OF THE FAILURES WAS UNDETERMINED.*AK
THE TAILGATE FELL OFF AT 70 MPH AND THE CONSUMER ALMOST HAD A COLLISION. THE CONSUMER HAD TAKEN THE VEHICLE TO THE DEALER AND THEY STATED THAT THE SAFETY CABLE DETERIORATED AND THE BRAKES WOULD BE REPLACED. *AK *SC *JB
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA04011 · Parking Brake Failure
Opened Apr 9, 2004 · Closed May 10, 2005
Status: closed (inferred from source dates) · Parking Brake; Parking Brake:conventional; Parking Brake:conventional:mechanical; Parking Brake:conventional:mechanical:linkage And Cable
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (4)
Parking Brake:conventional
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Parking Brake:conventional:mechanical
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Parking Brake:conventional:mechanical:linkage And Cable
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Parking Brake
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE03057 · Parking Brake Failure
Opened Dec 8, 2003 · Closed Apr 9, 2004
Status: closed (inferred from source dates) · Parking Brake
ODI OPENED PE03-057 TO ASSESS PARKING BRAKE INEFFECTIVENESS IN THE SUBJECT VEHICLES.THESE VEHICLES ARE EQUIPPED WITH FOUR WHEEL DISC BRAKES THAT INCORPORATE A SINGLE-SHOE DRUM-IN-HAT PARKING BRAKE INDEPENDENT OF THE SERVICE BRAKES.COMPLAINT AND WARRANTY DATA INDICATE THAT THE PARKING BRAKE LININGS TEND TO WEAR OUT EARLY IN THE LIFE OF THE VEHICLE (AT AN AVERAGE OF 24 MONTHS IN SERVICE), REDUCING THE PARKING BRAKE SYSTEM'S TORQUE BELOW THAT NEEDED TO IMMOBILIZE THE VEHICLE.GM HAS ATTRIBUTED THIS ACCELERATED WEAR TO FOREIGN MATERIAL INTRUSION AND A FAILURE OF THE BRAKE SHOE TO PROPERLY SELF-CENTER WITHIN ITS BRAKE DRUM.EFFECTIVE WITH THE START OF MY 2003 PRODUCTION, A NEWER REDUCED FORCE HOLD-DOWN CLIP WAS INTRODUCED TO FACILITATE BRAKE SHOE DISENGAGEMENT FROM THE DRUM SURFACE.THIS PART IS ALSO AVAILABLE AT THE SERVICE LEVEL FOR THE MY 1999-2002 VEHICLES.GM HAS INDICATED THAT THE PAKING BRAKE IS INTENDED TO OPERATE IN CONJUNCTION WITH THE TRANSMISSION TO IMMOBILZE PARKED VEHICLES, AND THAT IN MANY CASES, ACCELERATED PARKING BRAKE LINING WEAR IS CAUSED BY ROUGH USE, VEHICLE MODIFICATIONS, AND DRIVING WITH THE PARKING ENGAGED. ODI HAS UPGRADED THE PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING PARKING BRAKE USAGE FACTORS AND THE CIRCUMSTANCES SURROUNDING THE SEVENTEEN REPORTED VEHICLE CRASHES.