IllustrationWAS DRIVING AND BRAKE LINE "BURST" CAUSING BRAKE FAILURE AND WRECK INTO TREE. *TR
2002 Chevrolet Silverado 1500
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2002 Chevrolet Silverado 1500 do not stand out strongly from the model-year median of 525.
About this comparison →How this year compares
Owner complaints by model year
Compare all Silverado 1500 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
340–25K
4925–50K
7950–75K
10275–100K
124100–150K
55150K+
443 reports with mileage · 66 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes. Review the 184 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 164 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
45 crash reports5 fire reports15 injury reports
Service Brakes complaints
184 reportsCOMING HOME WITH A SMALL LOAD OF LUMBER FOR A WOODWORKING PROJECT, THE "CHANGE OIL LITE" CAME ON. UPON RETURNING HOME AND UNLOADED THE LUMBER, BACKED THE TRUCK INTO THE GARAGE TO CHANGE THE OIL-- THE PICKUP DIDN'T STOP. HE CRAWLED UNDER THE PICK UP TO FIND FLUID ON THE GARAGE FLOOR AND THE BRAKE LINES RUSTED, CORRODED AND ONE …
Read full complaint
COMING HOME WITH A SMALL LOAD OF LUMBER FOR A WOODWORKING PROJECT, THE "CHANGE OIL LITE" CAME ON. UPON RETURNING HOME AND UNLOADED THE LUMBER, BACKED THE TRUCK INTO THE GARAGE TO CHANGE THE OIL-- THE PICKUP DIDN'T STOP. HE CRAWLED UNDER THE PICK UP TO FIND FLUID ON THE GARAGE FLOOR AND THE BRAKE LINES RUSTED, CORRODED AND ONE BRAKE LINE SPLIT AND LEAKING. FORTUNATELY WE WERE NOT TRAVELING WHEN THE BRAKES MALFUNCTIONED. *TR
TL* THE CONTACT OWNS A 2002 CHEVROLET C1500 2WD. THE CONTACT WAS COASTING AND ATTEMPTED TO BRAKE BUT THE PEDAL ABNORMALLY TRAVELED TO THE FLOORBOARD AS THE BRAKES FAILED. THE CONTACT PLACED THE VEHICLE IN NEUTRAL AND APPLIED THE PARKING BRAKE TO STOP THE VEHICLE. THE VEHICLE WAS INSPECTED AND IT WAS DETERMINED ALL FOUR BRAKE LIN…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET C1500 2WD. THE CONTACT WAS COASTING AND ATTEMPTED TO BRAKE BUT THE PEDAL ABNORMALLY TRAVELED TO THE FLOORBOARD AS THE BRAKES FAILED. THE CONTACT PLACED THE VEHICLE IN NEUTRAL AND APPLIED THE PARKING BRAKE TO STOP THE VEHICLE. THE VEHICLE WAS INSPECTED AND IT WAS DETERMINED ALL FOUR BRAKE LINES WEE SEVERELY RUSTED AND CORRODED.. THE MANUFACTURER WAS MADE AWARE OF THE INCIDENT. THE APPROXIMATE FAILURE MILEAGE WAS 88,000...UPDATED 12-23-13 *BF
TL* THE CONTACT OWNS A 2002 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT WHILE INSPECTING THE VEHICLE, HE NOTICED THE BRAKE LINES WERE CORRODED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 16,233. UPDATED 12/24/13*LJ
I WAS TRAVELING AT 30 TO 35 MILES PER HOUR AND A SCHOOL BUS STOPPED TO DROP KIDS RED LIGHTS FLASHING. I APPLIED BRAKE PRESSURE ONLY TO HAVE THE BRAKE PEDAL GO ALL THE WAY TO THE FLOOR BOARD. LUCKY TIMING I WAS FIRST IN LINE AND RAN INTO GRASS ON THE SIDE OF THE ROAD BEFORE ANY CHILDREN HAD DISEMBARKED. INVESTIGATION REVEALED THA…
Read full complaint
I WAS TRAVELING AT 30 TO 35 MILES PER HOUR AND A SCHOOL BUS STOPPED TO DROP KIDS RED LIGHTS FLASHING. I APPLIED BRAKE PRESSURE ONLY TO HAVE THE BRAKE PEDAL GO ALL THE WAY TO THE FLOOR BOARD. LUCKY TIMING I WAS FIRST IN LINE AND RAN INTO GRASS ON THE SIDE OF THE ROAD BEFORE ANY CHILDREN HAD DISEMBARKED. INVESTIGATION REVEALED THAT THE BRAKE LINES HAD CORRODED AND CAUSED A FLUID LEAK. *TR
TOTAL BRAKE FAILURE- RUPTURED BRAKE LINE UNDER DRIVER DOOR SIDE. FORTUNATELY THIS HAPPENED WHEN I WAS BACKING OUT OF MY DRIVEWAY AND I WAS ABLE TO STOP MY TRUCK USING THE EMERGENCY BRAKE.THE WEEK BEFORE I HAD MY ABS SENSORS ON THE FRONT WHEELS REPLACED BECAUSE THE TRUCK WOULD SOMETIMES NOT STOP AT A SLOW SPEED. I AM HAPPY THAT T…
Read full complaint
TOTAL BRAKE FAILURE- RUPTURED BRAKE LINE UNDER DRIVER DOOR SIDE. FORTUNATELY THIS HAPPENED WHEN I WAS BACKING OUT OF MY DRIVEWAY AND I WAS ABLE TO STOP MY TRUCK USING THE EMERGENCY BRAKE.THE WEEK BEFORE I HAD MY ABS SENSORS ON THE FRONT WHEELS REPLACED BECAUSE THE TRUCK WOULD SOMETIMES NOT STOP AT A SLOW SPEED. I AM HAPPY THAT THIS DID NOT HAPPEN WHILE I WAS TOWING MY TRAILER. RUPTURE OF THIS LINE CAUSED A TOTAL BRAKE FAILURE WITH NO WARNING UNTIL AFTER THE INCIDENT( WHEN ALL THE FLUID WAS GONE}. *TR
NOTICED BRAKE FLUID WAS LOW. COULD NOT FIND ANY LEAKS, WHILE BACKING TRUCK UP, I APPLIED MY BRAKES AND THE BRAKE PEDAL WENT CLEAR TO THE FLOOR. I USED MY EMERGENCY BRAKE TO STOP MY TRUCK. I IMMEDIATELY LOOKED UNDERNEATH THE TRUCK AND BRAKE FLUID WAS DRIPPING FROM THE REAR AXLE. I INVESTIGATED THE BRAKE LINES AND FOUND THEM TO BE…
Read full complaint
NOTICED BRAKE FLUID WAS LOW. COULD NOT FIND ANY LEAKS, WHILE BACKING TRUCK UP, I APPLIED MY BRAKES AND THE BRAKE PEDAL WENT CLEAR TO THE FLOOR. I USED MY EMERGENCY BRAKE TO STOP MY TRUCK. I IMMEDIATELY LOOKED UNDERNEATH THE TRUCK AND BRAKE FLUID WAS DRIPPING FROM THE REAR AXLE. I INVESTIGATED THE BRAKE LINES AND FOUND THEM TO BE COMPLETELY RUSTED AND CORRODED. I WAS JUST LUCKY THAT THIS DID NOT HAPPEN ON THE HIGHWAY AS IT WOULD HAVE BEEN A CERTAIN COLLISION CAUSING INJURIES OR DEATH. *TR
LEFT REAR STEEL BRAKE LINE BLEW OUT. UPON INSPECTION, BRAKE LINE WAS FOUND RUSTED WITH A 1/16 INCH HOLE ON THE 3/16 INCH TUBING. *TR
BRAKES FAILED AS I WAS COMING TO A STOP SIGN. NO CROSS TRAFFIC AT TIME SO NO COLLISION OCCURRED. HAD VEHICLE TOWED TO REPAIR FACILITY. ALL BRAKE LINES HAD TO BE REPLACED. TOTAL BILL $750. *TR
WHILE DRIVING IN NORMAL TRAFFIC, I WAS PREPARING TO STOP AT A RED LIGHT WITH VEHICLES AHEAD OF ME. UPON APPLYING BRAKES FROM APPROX 30 MPH, I WAS ABLE TO BRAKE LIKE NORMAL, UNTIL APPROX 5-10 MPH, WHEN THE ABS KICKED ON FOR NO REASON, SENDING MY TRUCK WITHIN INCHES FROM STRIKING ANOTHER MOTORIST IN FRONT OF ME. IT CONTINUED TO …
Read full complaint
WHILE DRIVING IN NORMAL TRAFFIC, I WAS PREPARING TO STOP AT A RED LIGHT WITH VEHICLES AHEAD OF ME. UPON APPLYING BRAKES FROM APPROX 30 MPH, I WAS ABLE TO BRAKE LIKE NORMAL, UNTIL APPROX 5-10 MPH, WHEN THE ABS KICKED ON FOR NO REASON, SENDING MY TRUCK WITHIN INCHES FROM STRIKING ANOTHER MOTORIST IN FRONT OF ME. IT CONTINUED TO DO THIS FOR ABOUT 3 MILES UNTIL I ARRIVED HOME.
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA04011 · Parking Brake Failure
Opened Apr 9, 2004 · Closed May 10, 2005
Status: closed (inferred from source dates) · Parking Brake; Parking Brake:conventional; Parking Brake:conventional:mechanical; Parking Brake:conventional:mechanical:linkage And Cable
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (4)
Parking Brake:conventional
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Parking Brake:conventional:mechanical
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Parking Brake:conventional:mechanical:linkage And Cable
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Parking Brake
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE03057 · Parking Brake Failure
Opened Dec 8, 2003 · Closed Apr 9, 2004
Status: closed (inferred from source dates) · Parking Brake
ODI OPENED PE03-057 TO ASSESS PARKING BRAKE INEFFECTIVENESS IN THE SUBJECT VEHICLES.THESE VEHICLES ARE EQUIPPED WITH FOUR WHEEL DISC BRAKES THAT INCORPORATE A SINGLE-SHOE DRUM-IN-HAT PARKING BRAKE INDEPENDENT OF THE SERVICE BRAKES.COMPLAINT AND WARRANTY DATA INDICATE THAT THE PARKING BRAKE LININGS TEND TO WEAR OUT EARLY IN THE LIFE OF THE VEHICLE (AT AN AVERAGE OF 24 MONTHS IN SERVICE), REDUCING THE PARKING BRAKE SYSTEM'S TORQUE BELOW THAT NEEDED TO IMMOBILIZE THE VEHICLE.GM HAS ATTRIBUTED THIS ACCELERATED WEAR TO FOREIGN MATERIAL INTRUSION AND A FAILURE OF THE BRAKE SHOE TO PROPERLY SELF-CENTER WITHIN ITS BRAKE DRUM.EFFECTIVE WITH THE START OF MY 2003 PRODUCTION, A NEWER REDUCED FORCE HOLD-DOWN CLIP WAS INTRODUCED TO FACILITATE BRAKE SHOE DISENGAGEMENT FROM THE DRUM SURFACE.THIS PART IS ALSO AVAILABLE AT THE SERVICE LEVEL FOR THE MY 1999-2002 VEHICLES.GM HAS INDICATED THAT THE PAKING BRAKE IS INTENDED TO OPERATE IN CONJUNCTION WITH THE TRANSMISSION TO IMMOBILZE PARKED VEHICLES, AND THAT IN MANY CASES, ACCELERATED PARKING BRAKE LINING WEAR IS CAUSED BY ROUGH USE, VEHICLE MODIFICATIONS, AND DRIVING WITH THE PARKING ENGAGED. ODI HAS UPGRADED THE PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING PARKING BRAKE USAGE FACTORS AND THE CIRCUMSTANCES SURROUNDING THE SEVENTEEN REPORTED VEHICLE CRASHES.